scholarly journals Acetone–butanol–ethanol production from Kraft paper mill sludge by simultaneous saccharification and fermentation

2016 ◽  
Vol 200 ◽  
pp. 713-721 ◽  
Author(s):  
Wenjian Guan ◽  
Suan Shi ◽  
Maobing Tu ◽  
Yoon Y. Lee
Keyword(s):  
Ethanol Production ◽  
Simultaneous Saccharification And Fermentation ◽  
Paper Mill ◽  
Paper Mill Sludge ◽  
Kraft Paper ◽  
Acetone Butanol Ethanol ◽  
Simultaneous Saccharification

Ethanol Production from Corn Stover Using Soaking Pretreatment

2010 ◽  
Vol 171-172 ◽  
pp. 261-265
Author(s):  
Zhuang Zuo ◽  
Xiu Shan Yang
Keyword(s):  
Ethanol Production ◽  
Corn Stover ◽  
Simultaneous Saccharification And Fermentation ◽  
Pichia Stipitis ◽  
Liquid Ratio ◽  
Mild Conditions ◽  
Whole Process ◽  
Conversion Rates ◽  
Mild Temperature ◽  
Simultaneous Saccharification

Corn stover was pretreated using different soaking conditions at mild temperature. Among the tested conditions, the best was 1% NaOH+8% NH4OH，50°C，48 h, Solid-to-liquid ratio 1:10. The results showed that soaking pretreatment achieved 63.6% delignification, retained the xylan and glucan. After enzymatic hydrolysis, conversion rates of xylan and glucan were 70.9% and 78.5%, respectively. The pretreated filtration re-soaking cause 52.7% xylan and 65.0% glucan conversion. NaOH+NH4OH treatment can be performed under mild conditions, gives a good buffering effect, low carbohydates degradation and extensive removal of lignin. Additionally, simultaneous saccharification and fermentation was conducted with pretreated corn stover to assess the ethanol production. For the whole process, 0.15g ethanol /g corn stover was achieved using Saccharomyces cerevisiae Y5, and 0.19g ethanol /g corn stover when using Pichia stipitis.

Fuel Ethanol Production from Wet Oxidised Corn Stover by S. Cerevisiae

2011 ◽  
Vol 343-344 ◽  
pp. 963-967 ◽  
Author(s):  
Zhang Qiang ◽  
Anne Belinda Thomsen
Keyword(s):  
Ethanol Production ◽  
Corn Stover ◽  
Simultaneous Saccharification And Fermentation ◽  
Ethanol Concentration ◽  
Ethanol Yield ◽  
Liquid Fraction ◽  
Raw Material ◽  
Wet Oxidation ◽  
Inhibition Effect ◽  
Simultaneous Saccharification

In order to find out appropriate process for ethanol production from corn stover, wet oxidation（195°C，15 minutes）and simultaneous saccharification and fermentation (SSF) was carried out to produce ethanol. The results showed that the cellulose recovery of 92.9% and the hemicellulose recovery of 74.6% were obtained after pretreatment. 86.5% of cellulose was remained in the solid cake . After 24h hydrolysis at 50°C using cellulase（Cellubrix L）,the achieved conversion of cellulose to glucose was 64.8%. Ethanol production was evaluated from dried solid cake and the hydrolysate was employed as liquid fraction . After 142 h of SSF with substrate concentration of 8% (W/V), ethanol yield of 73.1 % of the theoretical based on glucose in the raw material was obtained by S. cerevisiae(ordinary baker’ yeast) . The corresponding ethanol concentration and volumetric productivity were 17.2g/L and 0.121g/L.h respectively. The estimated total ethanol production was 257.7 kg/ton raw material by assuming consumption of both C-6 and C-5. No obvious inhibition effect occurred during SSF. These instructions give you the basic guidelines for preparing papers for WCICA/IEEE conference proceedings.

Enhanced ethanol production by simultaneous saccharification and fermentation of pretreated olive stones

2015 ◽  
Vol 74 ◽  
pp. 839-847 ◽  
Author(s):  
Manuel Cuevas ◽  
Sebastián Sánchez ◽  
Juan F. García ◽  
Jaime Baeza ◽  
Carolina Parra ◽  
...  
Keyword(s):  
Ethanol Production ◽  
Simultaneous Saccharification And Fermentation ◽  
Olive Stones ◽  
Simultaneous Saccharification
Sign in / Sign up

Export Citation Format

Share Document