Effect of Magnetite on Anaerobic Digester Biogas, Hydrogen Sulfide Gas, Digester Effluent, and Related Processes

2021 ◽  
Vol 147 (12) ◽  
pp. 05021005
Author(s):  
Patricia Ayaa ◽  
Michael McFarland
1984 ◽  
Vol 11 (3) ◽  
pp. 167-179 ◽  
Author(s):  
Parameshwaran Ravishanker ◽  
David Hills

2006 ◽  
Vol 53 (6) ◽  
pp. 203-211 ◽  
Author(s):  
W. Charles ◽  
R. Cord-Ruwisch ◽  
G. Ho ◽  
M. Costa ◽  
P. Spencer

The Woodman Point Wastewater Treatment Plant (WWTP) in Western Australia has experienced two separate problems causing avoidable maintenance costs: the build-up of massive struvite (MgNH4PO4· 6H2O) scaling downstream of the anaerobic digester and the formation of hydrogen sulfide (H2S) levels in the digester gas to levels that compromised gas engine operation and caused high operating costs on the gas scrubber. As both problems hang together with a chemical imbalance in the anaerobic digester, we decided to investigate whether both problems could be (feasibly and economically) addressed by a common solution (such as dosing of iron solutions to precipitate both sulfide and phosphate), or by using separate approaches. Laboratory results showed that, the hydrogen sulfide emission in digesters could be effectively and economically controlled by the addition of iron dosing. Slightly higher than the theoretical value of 1.5 mol of FeCl3 was required to precipitate 1 mol of dissolved sulfide inside the digester. Due to the high concentration of PO43− in the digested sludge liquor, significantly higher iron is required for struvite precipitation. Iron dosing did not appear an economic solution for struvite control via iron phosphate formation. By taking advantage of the natural tendency of struvite formation in the digester liquid, it is possible to reduce the risk of struvite precipitation in and around the sludge-dewatering centrifuge by increasing the pH to precipitate struvite out before passing through the centrifuge. However, as the Mg2+ /PO43− molar ratio in digested sludge was low, by increasing the pH alone (using NaOH) the precipitation of PO43− was limited by the amount of cations (Ca2+  and Mg2+ ) available in the sludge. Although this would reduce struvite precipitation in the centrifuge, it could not significantly reduce PO43− recycling back to the plant. For long-term operation, maximum PO43− reduction should be the ultimate aim to minimise PO43− accumulation in the plant. Magnesium hydroxide liquid (MHL) was found to be the most cost-effective chemical to achieve this goal. It enhanced struvite precipitation from both, digested sludge and centrate to the point where more than 95% PO43− reduction in the digested sludge was achieved.


2009 ◽  
Vol 65 (2) ◽  
pp. 104-113 ◽  
Author(s):  
Takuro KOBAYASHI ◽  
Yu-You LI ◽  
Kengo KUBOTA ◽  
Hideki HARADA ◽  
Takeki MAEDA ◽  
...  

2017 ◽  
Vol 5 (32) ◽  
Author(s):  
Xiangdong Wei ◽  
Xumen Ge ◽  
Yebo Li ◽  
Zhongtang Yu

ABSTRACT The draft genome sequence of Methylocaldum sp. SAD2, a methanotrophic strain isolated from a hydrogen sulfide-rich anaerobic digester, is reported here. Strain SAD2 possesses genes for methane oxidation in the presence of H2S.


2016 ◽  
Vol 51 (7) ◽  
pp. 838-844 ◽  
Author(s):  
Wenxian Zhang ◽  
Xumeng Ge ◽  
Yueh-Fen Li ◽  
Zhongtang Yu ◽  
Yebo Li

2017 ◽  
Vol 6 (2) ◽  
pp. 111 ◽  
Author(s):  
Agus Haryanto ◽  
Fadli Marotin ◽  
Sugeng Triyono ◽  
Udin Hasanudin

The purpose of this study is to develop a family-size biogas-fueled electricity generating system consisting of anaerobic digester, bio-filter scrubber, and power generating engine. Biogas was produced from a pilot scale wet anaerobic digester (5-m3 capacity). The biogas was filtered using bio-scrubber column filled with locally made compost to reduce hydrogen sulfide (H2S) content. Biogas composition was analysed using a gas chromatograph and its H2S level was measured using a H2S detector. A 750-W four stroke power generating engine was used with 100% biogas. Biogas consumed by the generator engine was measured at different load from 100 to 700 W (13.3 to 93.3% of the rated power). Three replications for each load experiment were taken. Results showed that the total biogas yield was 1.91 m3/day with methane content of 56.48% by volume. Bio-filter successfully reduced H2S content in the biogas by 98% (from 400 ppm to 9 ppm). Generator engine showed good performance during the test with average biogas consumption of 415.3 L/h. Specific biogas consumption decreased from 5.05 L/Wh to 1.15 L/Wh at loads of 100 W to 700 W, respectively. Thermal efficiency increased with loads from 6.4% at 100 W to 28.1 at 700 W. The highest thermal efficiency of 30% was achieved at a load of 600 W (80% of the rated power) with specific biogas consumption of 1.07 L/Wh. Keywords: biogas; family size; generator; electricity; bio-filter. Article History: Received Janury 16th 2017; Received in revised form 2nd June 2017; Accepted 18th June 2017; Available onlineHow to Cite This Article: Haryanto, A., Marotin, F., Triyono, S., Hasanudin, U. (2017), Developing A Family-Size Biogas-Fueled Electricity Generating System. International Journal of Renewable Energy Develeopment, 6(2), 111-118.https://doi.org/10.14710/ijred.6.2.111-118


2007 ◽  
Vol 2007 (16) ◽  
pp. 2761-2772
Author(s):  
Ian Watson ◽  
Paris Neofotistos ◽  
Chris Collins ◽  
Vaughan Harshman ◽  
David Morano

2019 ◽  
Vol 133 (20) ◽  
pp. 2045-2059 ◽  
Author(s):  
Da Zhang ◽  
Xiuli Wang ◽  
Siyao Chen ◽  
Selena Chen ◽  
Wen Yu ◽  
...  

Abstract Background: Pulmonary artery endothelial cell (PAEC) inflammation is a critical event in the development of pulmonary arterial hypertension (PAH). However, the pathogenesis of PAEC inflammation remains unclear. Methods: Purified recombinant human inhibitor of κB kinase subunit β (IKKβ) protein, human PAECs and monocrotaline-induced pulmonary hypertensive rats were employed in the study. Site-directed mutagenesis, gene knockdown or overexpression were conducted to manipulate the expression or activity of a target protein. Results: We showed that hydrogen sulfide (H2S) inhibited IKKβ activation in the cell model of human PAEC inflammation induced by monocrotaline pyrrole-stimulation or knockdown of cystathionine γ-lyase (CSE), an H2S generating enzyme. Mechanistically, H2S was proved to inhibit IKKβ activity directly via sulfhydrating IKKβ at cysteinyl residue 179 (C179) in purified recombinant IKKβ protein in vitro, whereas thiol reductant dithiothreitol (DTT) reversed H2S-induced IKKβ inactivation. Furthermore, to demonstrate the significance of IKKβ sulfhydration by H2S in the development of PAEC inflammation, we mutated C179 to serine (C179S) in IKKβ. In purified IKKβ protein, C179S mutation of IKKβ abolished H2S-induced IKKβ sulfhydration and the subsequent IKKβ inactivation. In human PAECs, C179S mutation of IKKβ blocked H2S-inhibited IKKβ activation and PAEC inflammatory response. In pulmonary hypertensive rats, C179S mutation of IKKβ abolished the inhibitory effect of H2S on IKKβ activation and pulmonary vascular inflammation and remodeling. Conclusion: Collectively, our in vivo and in vitro findings demonstrated, for the first time, that endogenous H2S directly inactivated IKKβ via sulfhydrating IKKβ at Cys179 to inhibit nuclear factor-κB (NF-κB) pathway activation and thereby control PAEC inflammation in PAH.


Sign in / Sign up

Export Citation Format

Share Document