scholarly journals Effect of Hydraulic Retention Time on the Performance of a Compact Moving Bed Biofilm Reactor for Effluent Polishing of Treated Sewage

Water ◽  
2022 ◽  
Vol 14 (1) ◽  
pp. 81
Author(s):  
Jamal Ali Kawan ◽  
Fatihah Suja’ ◽  
Sagor Kumar Pramanik ◽  
Arij Yusof ◽  
Rakmi Abdul Rahman ◽  
...  

Treated effluent from a wastewater treatment plant can be further reused as a water resource for a water supply treatment plant. In this case, the treated sewage gathered in the study of the Class V National Water Quality Standard (NWQS) of Malaysia would be treated for use as a water resource for a water treatment plant. In a moving bed biofilm reactor (MBBR) with a 500-L working volume, organic pollutants, undesirable nutrients, and bacteria were removed without disinfectant. At 24-h hydraulic retention time (HRT), the maximum removal efficiency of 5-day biological oxygen demand, ammonia–nitrogen (NH3-N), and total phosphorus were 71%, 48%, and 12%, respectively. The biofilm thickness, which was captured using scanning electron microscopy, increased from 102.6 μm (24-h HRT) to 297.1 μm (2-h HRT). A metagenomic analysis using 16S rRNA showed an abundance of anaerobic bacteria, especially from the Proteobacteria phylum, which made up almost 53% of the total microbes. MBBR operated at 24-h HRT could improve effluent quality, as its characteristics fell into Class IIA of the NWQS of Malaysia, with the exception of the NH3-N content, which indicated that the effluent needed conventional treatment prior to being reused as potable water.

2017 ◽  
Vol 77 (3) ◽  
pp. 714-720 ◽  
Author(s):  
J. C. Leyva-Díaz ◽  
A. Rodríguez-Sánchez ◽  
J. González-López ◽  
J. M. Poyatos

Abstract A membrane bioreactor (MBR) and a hybrid moving bed biofilm reactor-membrane bioreactor (hybrid MBBR-MBR) for municipal wastewater treatment were studied to determine the effect of salinity on nitrogen removal and autotrophic kinetics. The biological systems were analyzed during the start-up phase with a hydraulic retention time (HRT) of 6 h, total biomass concentration of 2,500 mg L−1 in the steady state, and electric conductivities of 1.05 mS cm−1 for MBR and hybrid MBBR-MBR working under regular salinity and conductivity variations of 1.2–6.5 mS cm−1 for MBR and hybrid MBBR-MBR operating at variable salinity. The variable salinity affected the autotrophic biomass, which caused a reduction of the nitrogen degradation rate, an increase of time to remove ammonium from municipal wastewater and longer duration of the start-up phase for the MBR and hybrid MBBR-MBR.


1994 ◽  
Vol 29 (12) ◽  
pp. 185-195 ◽  
Author(s):  
Bjørn Rusten ◽  
Jon G. Siljudalen ◽  
Bjørnar Nordeidet

A new moving bed biofilm reactor (MBBR) has been developed in Norway. The biomass is attached to carrier elements that move freely along with the water in the reactor. It has been demonstrated that existing, high loaded, activated sludge plants can easily be upgraded to nitrogen removing MBBR plants. With chemically enhanced mechanical treatment, full scale tests showed that 80-90% total nitrogen could be removed in a MBBR plant at a total empty bed hydraulic retention time (HRT) of 2.6 hours. The plant was operated in the post-denitrification mode, using methanol as an external carbon source.


2018 ◽  
Vol 7 (1) ◽  
Author(s):  
Nusa Idaman Said ◽  
Muhammad Rizki Syabani

The treatment process of wastewater contains organic pollutant which used in Indonesia especially in Jakarta is generaly activated sludge process. The problem is its treated water quality which frequently does not yet fulfilled to effluent standard of wastewater. Some affecting factors  are hydraulic retention time (HRT) too short, the fluctuation of wastewater flow rate, unfavorable function of aeration process and also which do not less important is operational mistake caused by insufficient knowledge of operator. To overcome the mentioned problems it is needed technological innovation to increase efficiency of wastewater treatment process especially activated sludge process. Moving Bed Biofilm Reactor (MBBR) technology is one of the  effective alternative for treating wastewater containing organic pollutants. In principle, MBBR is a modification of the activated sludge process is enhanced by adding the media into the aeration tank.This paper describes the study of domestic waste water treatment  using MBBR process which is filled with bioball plastic media which has specific surface 210 m2/m3 as much as 20 % of the volume of the aeration tank for attaching microorganism to increase efficiency and  keep stability of process.Result of the study shows that within 12 hours, 8 hours, 6 hours and 4 hours of hydraulic retention time (HRT) in aeration tank and sludge circulation ratio 0f R = 1.0 Q, the removal efficiency of ammonia were 94.05 %, 93.42 %, 89 %, and 79.6 % respectively. In ammonia loading 0.106 – 0.302 kg/m3.day, the removal efficiency of ammonia were 95.54 – 83.01 %. The greater ammonia loading,  removal efficiency of  ammonia  is getting smaller. Optimal residence time is 6 hours with ammonia removal efficiency reached 89 %, and the average concentration of ammonia in the effluent of 8.3 mg per litre.  Keyword : Domestic wastewater, ammonia, bioball, MBBR.


2000 ◽  
Vol 41 (1) ◽  
pp. 177-185 ◽  
Author(s):  
G. Andreottola ◽  
P. Foladori ◽  
M. Ragazzi

The aim of this study was to evaluate the performance of a full-scale upgrading of an existing RBC wastewater treatment plant with a MBBR (Moving Bed Biofilm Reactor) system, installed in a tank previously used for sludge aerobic digestion. The full-scale plant is located in a mountain resort in the North-East of Italy. Due to the fact that the people varied during the year's seasons (2000 resident people and 2000 tourists) the RBC system was insufficient to meet the effluent standards. The MBBR applied system consists of the FLOCOR-RMP®plastic media with a specific surface area of about 160 m2/m3 (internal surface only). Nitrogen and carbon removal from wastewater was investigated over a 1-year period, with two different plant lay-outs: one-stage (only MBBR) and two stage system (MBBR and rotating biological contactors in series). The systems have been operated at low temperature (5–15°C). 50% of the MBBR volume (V=79 m3) was filled. The organic and ammonium loads were in the average 7.9 gCOD m−2 d−1 and 0.9 g NH4−N m−2 d−1. Typical carbon and nitrogen removals in MBBR at temperature lower than 8°C were respectively 73% and 72%.


1993 ◽  
Vol 28 (10) ◽  
pp. 351-359 ◽  
Author(s):  
H. Ødegaard ◽  
B. Rusten ◽  
H. Badin

In 1988 the State Pollution Control Authority in Norway made recommendations regarding process designs for small wastewater treatment plants. Amongst these were recommendations for biological/chemical plants where biofilm reactors were used in combination with pretreatment in large septic tanks and chemical post treatment. At the same time the socalled “moving bed biofilm reactor” (MBBR) was developed by a Norwegian company. In this paper, experiences from a small wastewater treatment plant, based on the MBBR and on the recommendations mentioned, will be presented.


2020 ◽  
Vol 745 ◽  
pp. 141051
Author(s):  
Alessandro di Biase ◽  
Maciej S. Kowalski ◽  
Tanner R. Devlin ◽  
Jan A. Oleszkiewicz

Sign in / Sign up

Export Citation Format

Share Document