Optimization of channel structure for proton exchange membrane fuel cells based on a three‐dimensional two‐phase flow model

2021 ◽  
Author(s):  
Zhuo Chen ◽  
Xiaolong Yang ◽  
Xiaobo Hu ◽  
Cheng Wang
Keyword(s):  
Fuel Cells ◽  
Proton Exchange Membrane ◽  
Flow Model ◽  
Two Phase Flow ◽  
Three Dimensional ◽  
Proton Exchange ◽  
Channel Structure ◽  
Phase Flow ◽  
Two Phase ◽  
Exchange Membrane

An ex-situ experiment to study the two-phase flow induced by water condensation into the channels of proton exchange membrane fuel cells (PEMFC)

2015 ◽  
Vol 40 (22) ◽  
pp. 7192-7203 ◽  
Author(s):  
Vincent Coeuriot ◽  
Jérôme Dillet ◽  
Gaël Maranzana ◽  
Olivier Lottin ◽  
Sophie Didierjean
Keyword(s):  
Fuel Cells ◽  
Proton Exchange Membrane ◽  
Two Phase Flow ◽  
Proton Exchange ◽  
Ex Situ ◽  
Phase Flow ◽  
Two Phase ◽  
Water Condensation ◽  
Exchange Membrane

An Analysis of Two-Phase Flow Pressure Drop in Operating Proton Exchange Membrane Fuel Cell Channels With the Lockhart-Martinelli Approach

2014 ◽  
Author(s):  
Ryan Anderson ◽  
Lifeng Zhang ◽  
David P. Wilkinson
Keyword(s):  
Fuel Cells ◽  
Pressure Drop ◽  
Proton Exchange Membrane ◽  
Two Phase Flow ◽  
Proton Exchange ◽  
Phase Flow ◽  
Two Phase ◽  
Current Densities ◽  
Flow Pressure ◽  
Exchange Membrane

Proton exchange membrane fuel cells (PEMFCs) are considered one of the most promising alternatives for the automotive industry owing to their high energy efficiency, zero emission at the vehicle use stage, and low temperature operation. Water as a byproduct plays a complex role in fuel cell operation. In particular, the inevitable occurrence of liquid water leads to gas-liquid two-phase flows in various components of PEMFCs including flow channels of which diameters range from micrometers to millimeters. In conventional minichannels and microchannels, the Lockhart-Martinelli (LM) approach has been employed to predict the two-phase pressure drop of gas-liquid systems. This approach has previously been updated by our group to more accurately reflect the introduction of liquid water into the flow channels of a PEMFC i.e. from a porous media perpendicular to the gas flow. Importantly, the LM method normalizes the data independent of the flow field design and operating conditions like temperature, pressure, and relative humidity. This paper analyzes the increasing amount of experimental data on two-phase flow pressure drops/two-phase flow multipliers in the literature with these approaches. The focus is the cathode side (therefore an air/water system), and data is collected from multiple research groups using active fuel cells (electrochemically produced water). The traditional LM approach greatly under-predicts the two-phase pressure drop at low current densities. However, the analysis is applied over a range of current densities, and it better predicts results at higher current densities (>600 mA cm−2). Literature correlations for the Chisholm parameter C, a flow regime dependent parameter in the LM equation, have been proposed for non-active (external water injection) fuel cells but do not match the results from operating fuel cells. C is shown here to vary with current density, flow stoichiometry (gas velocity), gas diffusion layer, and slightly with relative humidity.

scholarly journals Two-phase flow in the minichannels of proton exchange membrane fuel cells (PEMFC) flow field plates

2012 ◽  
Vol 395 ◽  
pp. 012168
Author(s):  
V Coeuriot ◽  
S Didierjean ◽  
J Dillet ◽  
G Maranzana ◽  
O Lottin
Keyword(s):  
Fuel Cells ◽  
Flow Field ◽  
Proton Exchange Membrane ◽  
Two Phase Flow ◽  
Proton Exchange ◽  
Phase Flow ◽  
Two Phase ◽  
Exchange Membrane

A one-dimensional and two-phase flow model of a proton exchange membrane fuel cell

2015 ◽  
Vol 90 (9) ◽  
pp. 1547-1551 ◽  
Author(s):  
Rui B Ferreira ◽  
Daniela S Falcão ◽  
Vânia B Oliveira ◽  
Alexandra Maria FR Pinto
Keyword(s):  
Fuel Cell ◽  
Proton Exchange Membrane ◽  
Flow Model ◽  
Two Phase Flow ◽  
Proton Exchange ◽  
Phase Flow ◽  
Two Phase ◽  
One Dimensional ◽  
Exchange Membrane

A critical review of two-phase flow in gas flow channels of proton exchange membrane fuel cells

2010 ◽  
Vol 195 (15) ◽  
pp. 4531-4553 ◽  
Author(s):  
Ryan Anderson ◽  
Lifeng Zhang ◽  
Yulong Ding ◽  
Mauricio Blanco ◽  
Xiaotao Bi ◽  
...  
Keyword(s):  
Fuel Cells ◽  
Critical Review ◽  
Gas Flow ◽  
Proton Exchange Membrane ◽  
Two Phase Flow ◽  
Proton Exchange ◽  
Phase Flow ◽  
Two Phase ◽  
Flow Channels ◽  
Exchange Membrane
Sign in / Sign up

Export Citation Format

Share Document