scholarly journals Dynamic model of supercritical Organic Rankine Cycle waste heat recovery system for internal combustion engine

2017 ◽  
Vol 18 (4) ◽  
pp. 589-601 ◽  
Author(s):  
Jahedul Islam Chowdhury ◽  
Bao Kha Nguyen ◽  
David Thornhill
Keyword(s):  
Internal Combustion Engine ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Combustion Engine ◽  
Organic Rankine Cycle ◽  
Rankine Cycle ◽  
Waste Heat Recovery System ◽  
Recovery System ◽  
Heat Recovery System

scholarly journals Economic and Exergo-Advance Analysis of a Waste Heat Recovery System Based on Regenerative Organic Rankine Cycle under Organic Fluids with Low Global Warming Potential

Energies ◽  
2020 ◽  
Vol 13 (6) ◽  
pp. 1317 ◽  
Author(s):  
Guillermo Valencia Ochoa ◽  
Cesar Isaza-Roldan ◽  
Jorge Duarte Forero
Keyword(s):  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Organic Rankine Cycle ◽  
Rankine Cycle ◽  
Working Fluid ◽  
Exhaust Gases ◽  
Waste Heat Recovery System ◽  
Recovery System ◽  
Heat Recovery System

The waste heat recovery system (WHRS) is a good alternative to provide a solution to the waste energy emanated in the exhaust gases of the internal combustion engine (ICE). Therefore, it is useful to carry out research to improve the thermal efficiency of the ICE through a WHRS based on the organic Rankine cycle (ORC), since this type of system takes advantage of the heat of the exhaust gases to generate electrical energy. The organic working fluid selection was developed according to environmental criteria, operational parameters, thermodynamic conditions of the gas engine, and investment costs. An economic analysis is presented for the systems operating with three selected working fluids: toluene, acetone, and heptane, considering the main costs involved in the design and operation of the thermal system. Furthermore, an exergo-advanced study is presented on the WHRS based on ORC integrated to the ICE, which is a Jenbacher JMS 612 GS-N of 2 MW power fueled with natural gas. This advanced exergetic analysis allowed us to know the opportunities for improvement of the equipment and the increase in the thermodynamic performance of the ICE. The results show that when using acetone as the organic working fluid, there is a greater tendency of improvement of endogenous character in Pump 2 of around 80%. When using heptane it was manifested that for the turbine there are near to 77% opportunities for improvement, and the use of toluene in the turbine gave a rate of improvement of 70%. Finally, some case studies are presented to study the effect of condensation temperature, the pinch point temperature in the evaporator, and the pressure ratio on the direct, indirect, and fixed investment costs, where the higher investment costs were presented with the acetone, and lower costs when using the toluene as working fluid.

Heat exchanger network design of an organic Rankine cycle integrated waste heat recovery system of a marine vessel using pinch point analysis

2020 ◽  
Vol 44 (15) ◽  
pp. 12312-12328 ◽  
Author(s):  
Olgun Konur ◽  
Omur Yasar Saatcioglu ◽  
Suleyman Aykut Korkmaz ◽  
Anil Erdogan ◽  
Can Ozgur Colpan
Keyword(s):  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Organic Rankine Cycle ◽  
Rankine Cycle ◽  
Pinch Point ◽  
Waste Heat Recovery System ◽  
Point Analysis ◽  
Recovery System ◽  
Heat Recovery System

scholarly journals Radial Expander Design for an Engine Organic Rankine Cycle Waste Heat Recovery System

2017 ◽  
Vol 129 ◽  
pp. 285-292 ◽  
Author(s):  
Fuhaid Alshammari ◽  
A. Karvountzis-Kontakiotis ◽  
A. Pesiridis ◽  
Timothy Minton
Keyword(s):  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Organic Rankine Cycle ◽  
Rankine Cycle ◽  
Waste Heat Recovery System ◽  
Recovery System ◽  
Heat Recovery System
Sign in / Sign up

Export Citation Format

Share Document