Severe cartilage damage by broken poly–L–lactic acid (PLLA) interference screw after ACL reconstruction

2004 ◽  
Vol 13 (4) ◽  
pp. 283-286 ◽  
Author(s):  
Burkhard Lembeck ◽  
Nikolaus Wülker
Keyword(s):  
Lactic Acid ◽  
Acl Reconstruction ◽  
Cartilage Damage ◽  
Interference Screw

Stacked Biocomposite Screws in a Single-Stage Revision Anterior Cruciate Ligament Reconstruction Has Acceptable Fixation Strength in a Porcine Cadaveric Model

2021 ◽  
pp. 036354652110151
Author(s):  
Hasan Baydoun ◽  
Ian D. Engler ◽  
Ali Hosseini ◽  
Lance LeClere ◽  
Joeri Zoon ◽  
...  
Keyword(s):  
Bone Loss ◽  
Acl Reconstruction ◽  
Cruciate Ligament ◽  
Interference Screw ◽  
Single Stage ◽  
Fixation Strength ◽  
Revision Acl Reconstruction ◽  
Group 2 ◽  
Bone Tunnels ◽  
Primary Acl Reconstruction

Background: Stacked screws is a commonly used technique in single-stage revision anterior cruciate ligament (ACL) reconstruction in the setting of bone loss, but there are limited data to support its use. Hypothesis: Two configurations of a biocomposite stacked screws construct have similar fixation strength and linear stiffness as a primary ACL reconstruction construct in a biomechanical model. Study Design: Controlled laboratory study. Methods: A total of 30 porcine legs were divided into 3 groups. Group 1 underwent primary ACL reconstruction with a patellar tendon graft fixed into the femur, with an 8-mm biocomposite interference screw of beta-tricalcium phosphate and poly lactide-co-glycolide. For a revision ACL reconstruction model, groups 2 and 3 had bone tunnels created and subsequently filled with 12-mm biocomposite screws. New bone tunnels were drilled through the filler screw and the surrounding bone, and the patellar bone plug was inserted. Group 2 was fixed with 8-mm biocomposite screws on the side of the graft opposite the filler screw, while group 3 had the interference screw interposed between the graft and the filler screw. The construct was loaded at 1.5 mm/s in line with the tunnel until failure. Load to failure, linear stiffness, and mode of failure were recorded. Results: The mean pullout strength for groups 1, 2, and 3 was 626 ± 145 N, 653 ± 152 N, and 720 ± 125 N, respectively ( P = .328). The mean linear stiffness of the construct in groups 1, 2, and 3 was 71.4 ± 9.9 N/mm, 84.1 ± 11.1 N/mm, and 82.0 ± 10.8 N/mm, respectively. Group 2 was significantly stiffer than group 1 ( P = .037). Conclusion: Two configurations of a biocomposite stacked screws construct for a single-stage revision ACL reconstruction in the setting of bone loss show a similar fixation strength and linear stiffness to a primary ACL reconstruction at time zero in a porcine model. Clinical Relevance: In the setting of bone loss from tunnel malpositioning, a single-stage revision ACL reconstruction using a stacked screws construct may provide adequate fixation strength and linear stiffness.

scholarly journals Whether sutures reduce the graft laceration caused by interference screw in anterior cruciate ligament reconstruction? A biomechanical study in vitro

2021 ◽  
Vol 22 (1) ◽  
Author(s):  
Yuanjun Teng ◽  
Xiaohui Zhang ◽  
Lijun Da ◽  
Jie Hu ◽  
Hong Wang ◽  
...  
Keyword(s):  
Acl Reconstruction ◽  
Cruciate Ligament ◽  
Interference Screw ◽  
Biomechanical Study ◽  
Interference Screws ◽  
Suture Group ◽  
Anterior Cruciate ◽  
Biomechanical Tests ◽  
Single Insertion

Abstract Background Interference screw is commonly used for graft fixation in anterior cruciate ligament (ACL) reconstruction. However, previous studies had reported that the insertion of interference screws significantly caused graft laceration. The purposes of this study were to (1) quantitatively evaluate the graft laceration from one single insertion of PEEK interference screws; and (2) determine whether different types of sutures reduced the graft laceration after one single insertion of interference screws in ACL reconstruction. Methods The in-vitro ACL reconstruction model was created using porcine tibias and bovine extensor digitorum tendons of bovine hind limbs. The ends of grafts were sutured using three different sutures, including the bioabsorbable, Ethibond and ultra-high molecular weight polyethylene (UHMWPE) sutures. Poly-ether-ether-ketone (PEEK) interference screws were used for tibial fixation. This study was divided into five groups (n = 10 in each group): the non-fixed group, the non-sutured group, the absorbable suture group, the Ethibond suture group and the UHMWPE suture group. Biomechanical tests were performed using the mode of pull-to-failure loading tests at 10 mm/min. Tensile stiffness (newtons per millimeter), energy absorbed to failure (in joules) and ultimate load (newtons) were recorded for analysis. Results All prepared tendons and bone specimens showed similar characteristics (length, weight, and pre-tension of the tendons, tibial bone mineral density) among all groups (P > 0.05). The biomechanical tests demonstrated that PEEK interference screws significantly caused the graft laceration (P < 0.05). However, all sutures (the bioabsorbable, Ethibond and UHMWPE sutures) did not reduce the graft laceration in ACL reconstruction (P > 0.05). Conclusions Our biomechanical study suggested that the ultimate failure load of grafts was reduced of approximately 25 % after one single insertion of a PEEK interference screw in ACL reconstruction. Suturing the ends of the grafts using different sutures (absorbable, Ethibond and UHMWPE sutures) did not decrease the graft laceration caused by interference screws.

scholarly journals Long term results after transepiphysal ACL reconstruction in children and adolescent

2018 ◽  
Vol 6 (4_suppl2) ◽  
pp. 2325967118S0001
Author(s):  
Christian Eberle ◽  
Wolfgang Schopf ◽  
Andree Ellermann
Keyword(s):  
Acl Reconstruction ◽  
Cartilage Damage ◽  
Long Term Results ◽  
Angular Deformity ◽  
Leg Length ◽  
Growth Disturbance ◽  
Children And Adolescent ◽  
The Mean

The aim of our study was to review the long term clinical and radiological (MRI) outcomes of adult patients who underwent ACL reconstruction as children or adolescent with emphasize to the features of growth disturbance, angular deformity, meniscal and cartilage damage and revision rate We retrospectively evaluated patient who underwent ACL reconstruction in our clinic with arthroscopic transepiphyseal technique using hamstrings graft in childhood or adolescence between the years 1997 and 2009. A total of 43 Patients were assessed. 25 male and 18 female. The average age at time of surgery was 13,5 years (8 - 16 y.), at time of assessement 22,4 years (18 - 30 y.) . The mean follow up was 10 years (4 - 16 years). The physical development of the patients was assessed with the Lysholm score and the Cincinnati Knee score scale, their satisfaction was recorded on the basis of the IKDC subjective knee evaluation form and the Tegner activity score . Leg deformity or leg length discrepancy was evaluated clinically by the observers. The instrumented Lachman test using KT1000 and manual Pivot shift test was performed to assess knee stability. MRI was used to detect graft integrity, cartilage and meniscal damages. No significant leg deformities or leg length discrepancy had been detected. The average Lysholm score was 91 points (83 - 100), the Cincinnati Knee Score was 90,4 (79 - 100) points on average . The mean IKDC score was 92 points (82 -100). The Tegner-Activity-Score changed from preop 6,8 (2-10) to post op 5,8 (2-9). 2 Patient underwent revision ACL reconstruction due to rerupture (3 and 9 years post op). 2 Patients underwent meniscal surgery during follow up (1 resection and one refixation). KT1000 evaluation showed 67% excellent, 21% good and in 12% bad results. The MRI scan showed 42 intact grafts and one unverifiable graft. One patient with cartilage damage up to 3° (ICRS), 3 patients with meniscal degeneration up to grade 2. Each patient showed a free range of motion Our data underlines that transepiphyseal ACL reconstruction in children and adolescent with hamstrings is a save procedure leading to good long term results without causing angular deformity or growth disturbance

scholarly journals Testing of prototype interference screw for ACL reconstruction in porcine femurs

2011 ◽  
Author(s):  
József Kovács ◽  
Péter Nagy ◽  
Ákos Oroszlány ◽  
Attila Pavlik ◽  
Péter Hidas
Keyword(s):  
Acl Reconstruction ◽  
Interference Screw

scholarly journals Whether Sutures Reduce the Graft Laceration Caused by Interference Screw in Anterior Cruciate Ligament Reconstruction a Biomechanical Study in Vitro

2021 ◽  
Author(s):  
Yuanjun Teng ◽  
Lijun Da ◽  
Xiaohui Zhang ◽  
Hong Wang ◽  
Hua Han ◽  
...  
Keyword(s):  
Anterior Cruciate Ligament ◽  
Acl Reconstruction ◽  
Cruciate Ligament ◽  
Interference Screw ◽  
Biomechanical Study ◽  
Protective Effects ◽  
Mineral Density ◽  
Interference Screws ◽  
Anterior Cruciate

Abstract Background: Interference screw is commonly used for graft fixation in anterior cruciate ligament (ACL) reconstruction However, previous studies h a d reported that the insertion of interference screws significantly caused graft laceration . The purpose of this study was to determine whether sutures reduce d the graft laceration from the insertion of interference screws in ACL reconstruction. Methods: Porcine tibias and bovine extensor tendons were used for establishing a knee model of ACL reconstruction in vitro . The ends of grafts were sutured using three different sutures, including the bioabsorbable, Ethibond and ultra high molecular weight polyethylene (UHMWPE) sutures Poly ether ether ketone (PEEK) interference screw s w ere used fortibial fixation Biomechanical tests were performed to investigate the protective effects of different sutures on grafts Results : All prepared tendons and bone specimens showed similar characteristics (length, weight, and pre tension of the tendons, tibial bone mineral density) among all groups ( P 0.05). The biomechanical test s demonstrated that PEEK interference screw s significantly caused the graft laceration P 0.05). However, all sutures (the bioabsorbable, Ethibond and UHMWPE sutures) did not reduce the graft laceration in ACL reconstruction P 0.05). Conclusions : PEEK interference screw s significantly weakened the biomechanical properties of grafts during tibial fixation in ACL reconstruction. Absorbable Ethibond and UHMWPE sutures did not provide protective effects on grafts during ACL reconstruction.

Risk factors for progression of articular cartilage damage after anatomical anterior cruciate ligament reconstruction

2018 ◽  
Vol 100-B (3) ◽  
pp. 285-293 ◽  
Author(s):  
A. Nakamae ◽  
N. Adachi ◽  
M. Deie ◽  
M. Ishikawa ◽  
T. Nakasa ◽  
...  
Keyword(s):  
Risk Factors ◽  
Anterior Cruciate Ligament ◽  
Articular Cartilage ◽  
Acl Reconstruction ◽  
Cruciate Ligament ◽  
Cartilage Damage ◽  
Significant Risk ◽  
Articular Cartilage Damage ◽  
Anterior Cruciate

Aims To investigate the risk factors for progression of articular cartilage damage after anatomical anterior cruciate ligament (ACL) reconstruction. Patients and Methods A total of 174 patients who underwent second-look arthroscopic evaluation after anatomical ACL reconstruction were enrolled in this study. The graded condition of the articular cartilage at the time of ACL reconstruction was compared with that at second-look arthroscopy. Age, gender, body mass index (BMI), ACL reconstruction technique, meniscal conditions, and other variables were assessed by regression analysis as risk factors for progression of damage to the articular cartilage. Results In the medial compartment, multivariable logistic regression analysis indicated that partial medial meniscectomy (odds ratio (OR) 6.82, 95% confidence interval (CI) 2.11 to 22.04, p = 0.001), pivot-shift test grade at the final follow-up (OR 3.53, CI 1.39 to 8.96, p = 0.008), BMI (OR 1.15, CI 1.03 to 1.28, p = 0.015) and medial meniscal repair (OR 3.19, CI 1.24 to 8.21, p = 0.016) were significant risk factors for progression of cartilage damage. In the lateral compartment, partial lateral meniscectomy (OR 10.94, CI 4.14 to 28.92, p < 0.001) and side-to-side differences in anterior knee laxity at follow-up (OR 0.63, p = 0.001) were significant risk factors. Conclusion Partial meniscectomy was found to be strongly associated with the progression of articular cartilage damage despite r anatomical ACL reconstruction. Cite this article: Bone Joint J 2018;100-B:285–93.

Miniplate Suture Button Augmentation for Soft Tissue Graft Tibial Fixation in Anterior Cruciate Ligament Reconstruction

2021 ◽  
Vol 104 (2) ◽  
pp. 277-285
Keyword(s):  
Anterior Cruciate Ligament ◽  
Acl Reconstruction ◽  
Cruciate Ligament ◽  
Interference Screw ◽  
Tibial Fixation ◽  
Suture Button ◽  
Soft Tissue Graft ◽  
Anterior Cruciate ◽  
Supplemental Fixation

Background: Anterior cruciate ligament (ACL) reconstruction requires reliable and rigid graft fixation. Tibial-sided fixation is frequently cited as the “weak point” of the femur-graft-tibia construct. Some authors have recommended supplemental fixation with a staple or screw suture to post improve the strength and stiffness of the fixation. However, with these fixations, there is a risk for symptomatic hardware. Miniplate is flatter than screw or staple and does not penetrate the bone when attached. It is used as a button for suspensory fixation to enhance interference screw tibial fixation. Objective: To evaluate the clinical outcomes of the miniplate suture button for supplemental soft tissue graft tibial fixation in ACL reconstruction. Materials and Methods: A retrospective study was carried out between August 2016 and December 2019. A total of 40 patients had undergone primary ACL reconstruction, performed with hamstring tendon grafts that were secured using a miniplate suture button for supplemental interference screw tibial fixation. A total of 18 patients were excluded, leaving 22 patients at 1-year follow-up. Results: At least 1-year follow-up, the remaining 22 patients had significant difference between preoperative and postoperative outcome of anterior drawer test, Lachman test and pivot shift test (p<0.05). Lysholm knee scores improved significantly from 54.0±12.53 to 90.04±5.38. However, 3 patients (13.6%) experienced symptomatic hardware pain and 3 patients (13.6%) tendered around the miniplate site. There were no radiographic changes in miniplate displacement, deformed or broken plate, and bony reaction around miniplate. Conclusion: The use of a miniplate suture button as a supplemental fixation showed adequate fixation strength and showed good results in postoperative manual ligament laxity test and functional scores at minimum 1-year follow-up. However, there is still symptomatic pain at the hardware site. Keywords: Anterior cruciate ligament reconstruction, Supplemental fixation, Suture button

Sign in / Sign up

Export Citation Format

Share Document