OBJECTIVEPosterior-based thoracolumbar 3-column osteotomy (3CO) is a formidable surgical procedure. Surgeon experience and case volume are known factors that influence surgical complication rates, but these factors have not been studied well in cases of adult spinal deformity (ASD). This study examines how surgeon experience affects perioperative complications and operative measures following thoracolumbar 3CO in ASD.METHODSA retrospective study was performed of a consecutive cohort of thoracolumbar ASD patients who underwent 3CO performed by the senior authors from 2006 to 2018. Multivariate analysis was used to assess whether experience (years of experience and/or number of procedures) is associated with perioperative complications, operative duration, and blood loss.RESULTSA total of 362 patients underwent 66 vertebral column resections (VCRs) and 296 pedicle subtraction osteotomies (PSOs). The overall complication rate was 29.4%, and the surgical complication rate was 8.0%. The rate of postoperative neurological deficits was 6.2%. There was a trend toward lower overall complication rates with greater operative years of experience (from 44.4% to 28.0%) (p = 0.115). Years of operative experience was associated with a significantly lower rate of neurological deficits (p = 0.027); the incidence dropped from 22.2% to 4.0%. The mean operative time was 310.7 minutes overall. Both increased years of experience and higher case numbers were significantly associated with shorter operative times (p < 0.001 and p = 0.001, respectively). Only operative years of experience was independently associated with operative times (p < 0.001): 358.3 minutes from 2006 to 2008 to 275.5 minutes in 2018 (82.8 minutes shorter). Over time, there was less deviation and more consistency in operative times, despite the implementation of various interventions to promote fusion and prevent construct failure: utilization of multiple-rod constructs (standard, satellite, and nested rods), bone morphogenetic protein, vertebroplasty, and ligament augmentation. Of note, the use of tranexamic acid did not significantly lower blood loss.CONCLUSIONSSurgeon years of experience, rather than number of 3COs performed, was a significant factor in mitigating neurological complications and improving quality measures following thoracolumbar 3CO for ASD. The 3- to 5-year experience mark was when the senior surgeon overcame a learning curve and was able to minimize neurological complication rates. There was a continuous decrease in operative time as the surgeon’s experience increased; this was in concurrence with the implementation of additional preventative surgical interventions. Ongoing practice changes should be implemented and can be done safely, but it is imperative to self-assess the risks and benefits of those practice changes.
