Frequency dispersion of strain-induced crystallization coefficient of natural rubber vulcanizates in sub-sonic range

1974 ◽  
Vol 13 (2) ◽  
pp. 252-259
Author(s):  
H. Hiratsuka ◽  
M. Hashiyama ◽  
S. Tomita ◽  
H. Kawai
Keyword(s):  
Natural Rubber ◽  
Frequency Dispersion ◽  
Strain Induced Crystallization ◽  
Natural Rubber Vulcanizates ◽  
Induced Crystallization

Influence of Crosslink Characteristics Induced by Aromatic-Based Antioxidants on the Swelling and Stress-Strain Behavior of Natural Rubber Vulcanizates

2003 ◽  
Vol 76 (2) ◽  
pp. 334-347 ◽  
Author(s):  
Tarek M. Madkour ◽  
Rasha A. Azzam
Keyword(s):  
Natural Rubber ◽  
Crosslinking Agent ◽  
Oxidative Degradation ◽  
Thermal Oxidative Degradation ◽  
Stress Strain ◽  
Strain Behavior ◽  
Strain Induced Crystallization ◽  
Elastomeric Chains ◽  
Natural Rubber Vulcanizates ◽  
Induced Crystallization

Abstract Stress-strain measurements were performed on dry and swollen natural rubber vulcanizates prepared using both sulfur as the crosslinking agent and aromatic-based bound antioxidants acting as a second crosslinking agent. The aromatic-based antioxidants were synthesized and analyzed spectroscopically in order to relate the final behavior of the vulcanizates to the nature of the crosslink characteristics. The anomalous upturn in the modulus values of these networks in response to the imposed stress was shown to persist in the dry as well as the swollen state. Since the swollen elastomeric chains cannot undergo a strain-induced crystallization, the abnormal upturns in the modulus values in an absence of a filler were explained on the basis of the limited extensibility of the short chains of networks prepared using two different crosslinking agents in line with earlier modeling predictions. Remarkably, the swelling experiments revealed the increase in the crosslink density of the networks in the early stages of the thermal oxidative degradation procedure indicating a post-cure of the chemically bound antioxidants to the elastomeric chains, which incidentally corresponds to a maximum in the modulus values of the networks. The rheological and other mechanical properties such as the hardness were shown not to have been affected as a result of the incorporation of the chemically bound antioxidants.

scholarly journals Mechanism of strain-induced crystallization in filled and unfilled natural rubber vulcanizates

2005 ◽  
Vol 97 (10) ◽  
pp. 103529 ◽  
Author(s):  
Sirilux Poompradub ◽  
Masatoshi Tosaka ◽  
Shinzo Kohjiya ◽  
Yuko Ikeda ◽  
Shigeyuki Toki ◽  
...  
Keyword(s):  
Natural Rubber ◽  
Strain Induced Crystallization ◽  
Natural Rubber Vulcanizates ◽  
Induced Crystallization

scholarly journals Mullins Effect and Crack Growth in Natural Rubber Vulcanizates during Heat Aging and Cyclic Loading

2021 ◽  
Vol 31 (4) ◽  
pp. 61-67
Keyword(s):  
Cyclic Loading ◽  
Natural Rubber ◽  
Crack Growth ◽  
Fatigue Resistance ◽  
Mullins Effect ◽  
Strain Induced Crystallization ◽  
Unmodified Silica ◽  
Natural Rubber Vulcanizates ◽  
Induced Crystallization ◽  
Dynamic Fatigue

The effect of thermal aging and cyclic loading on mechanical properties and development of cracks in natural rubber vulcanizates was studied. After aging at 70oC and 110oC vulcanizates were subjected to cyclic loading. At a certain number of loading cycles, the samples were conducted in a tension test. At the aging condition of 70oC, the static tensile properties of material stay almost unchanged even after 88 aged hours and 8000 loading cycles. On the contrary, the dynamic fatigue resistance of vulcanizates decreases with increasing aging time. These results are attributed to the post-curing and the development of microcracks that might be caused by Mullins effect: in the case of static loading, the strain-induced crystallization may prevent cracks growth, but in the case of cyclic loading the strain-induced crystallization does not occur, so cracks develop without hindrance. However, at 110oC both static properties and dynamic fatigue resistance of material reduced dramatically because at high temperature the heat degradation exceeds both post-curing and strain-induced crystallization. Crack formation and propagation were examined by a digital optical microscope in the progress of cyclic loading. Results showed that natural rubber vulcanizate filled with carbon black has the best crack growth resistance (CGR) while the addition of modified and unmodified silica reduces CGR of materials. Moreover, the vulcanizate with unmodified silica has the lowest CGR.

scholarly journals Strain induced crystallization in vulcanized natural rubber containing ground tire rubber particles with reinforcement and nucleation abilities

2021 ◽  
pp. 107313
Author(s):  
Nicolas Candau ◽  
Oguzhan Oguz ◽  
Carlos Eloy Federico ◽  
Gregory Stoclet ◽  
Jean-François Tahon ◽  
...  
Keyword(s):  
Natural Rubber ◽  
Tire Rubber ◽  
Ground Tire Rubber ◽  
Rubber Particles ◽  
Strain Induced Crystallization ◽  
Induced Crystallization

Strain-induced crystallization behaviour of natural rubbers from guayule and rubber dandelion revealed by simultaneous time-resolved WAXD/tensile measurements: indispensable function for sustainable resources

RSC Advances ◽  
2016 ◽  
Vol 6 (98) ◽  
pp. 95601-95610 ◽  
Author(s):  
Yuko Ikeda ◽  
Preeyanuch Junkong ◽  
Takumi Ohashi ◽  
Treethip Phakkeeree ◽  
Yuta Sakaki ◽  
...  
Keyword(s):  
Natural Rubber ◽  
Crystallization Behaviour ◽  
Time Resolved ◽  
Sustainable Resources ◽  
Strain Induced Crystallization ◽  
Induced Crystallization

Guayule and rubber dandelion natural rubbers are useful alternatives forHeveanatural rubber in terms of their strain-induced crystallization behaviours.

Sign in / Sign up

Export Citation Format

Share Document