Wastewater Reuse in Textile Industry

2011 ◽  
pp. 131-139
Author(s):  
Fatoş Germirli Babuna
Keyword(s):  
Textile Industry ◽  
Wastewater Reuse

Textile Wastewater Reuse: Ozonation of Membrane Concentrated Secondary Effluent

1999 ◽  
Vol 40 (4-5) ◽  
pp. 99-105 ◽  
Author(s):  
A. Lopez ◽  
G. Ricco ◽  
R. Ciannarella ◽  
A. Rozzi ◽  
A. C. Di Pinto ◽  
...  
Keyword(s):  
Wastewater Treatment ◽  
Acute Toxicity ◽  
Wastewater Treatment Plant ◽  
Textile Industry ◽  
Nonionic Surfactants ◽  
Wastewater Reuse ◽  
Treatment Plant ◽  
Textile Wastewater ◽  
Secondary Effluent ◽  
Complete Disappearance

Among the activities appointed by the EC research-project “Integrated water recycling and emission abatement in the textile industry” (Contract: ENV4-CT95-0064), the effectiveness of ozone for improving the biotreatability of recalcitrant effluents as well as for removing from them toxic and/or inhibitory pollutants has been evaluated at lab-scale. Real membrane concentrates (pH=7.9; TOC=190 ppm; CDO=595 ppm; BOD5=0 ppm; Conductivity=5,000 μS/cm; Microtox-EC20=34%) produced at Bulgarograsso (Italy) Wastewater Treatment Plant by nanofiltering biologically treated secondary textile effluents, have been treated with ozonated air (O3conc.=12 ppm) over 120 min. The results have indicated that during ozonation, BOD5 increases from 0 to 75 ppm, whereas COD and TOC both decrease by about 50% and 30 % respectively. As for potentially toxic and/or inhibitory pollutants such as dyes, nonionic surfactants and halogenated organics, all measured as sum parameters, removals higher than 90% were achieved as confirmed by the complete disappearance of acute toxicity in the treated streams. The only ozonation byproducts searched for and found were aldehydes whose total amount continuously increased in the first hour from 1.2 up to 11.8 ppm. Among them, formaldehyde, acetaldehyde, glyoxal, propionaldehyde, and butyraldehyde were identified by HPLC.

Nanofiltration of secondary effluent for wastewater reuse in the textile industry

Desalination ◽  
2008 ◽  
Vol 222 (1-3) ◽  
pp. 272-279 ◽  
Author(s):  
J.M. Gozálvez-Zafrilla ◽  
D. Sanz-Escribano ◽  
J. Lora-García ◽  
M.C. León Hidalgo
Keyword(s):  
Textile Industry ◽  
Wastewater Reuse ◽  
Secondary Effluent

Membrane separation for wastewater reuse in the textile industry

2001 ◽  
Vol 31 (2) ◽  
pp. 189-197 ◽  
Author(s):  
G Ciardelli ◽  
L Corsi ◽  
M Marcucci
Keyword(s):  
Textile Industry ◽  
Membrane Separation ◽  
Wastewater Reuse

Wastewater Reuse in Textile Industry: Case of Bandung, Indonesia

2019 ◽  
Vol 5 (1) ◽  
pp. 18-24
Author(s):  
Youngkun Chung ◽  
Mi-Young Lee ◽  
Shi Chun Yang ◽  
Seoktae Kang
Keyword(s):  
Textile Industry ◽  
Wastewater Reuse

scholarly journals Recovery of Biologically Treated Textile Wastewater by Ozonation and Subsequent Bipolar Membrane Electrodialysis Process

Membranes ◽  
2021 ◽  
Vol 11 (11) ◽  
pp. 900
Author(s):  
Burak Yuzer ◽  
Huseyin Selcuk
Keyword(s):  
Textile Industry ◽  
Wastewater Reuse ◽  
Oxygen Demand ◽  
Textile Wastewater ◽  
Quality Parameters ◽  
Bipolar Membrane ◽  
Acid Base ◽  
Operational Conditions ◽  
Bipolar Membrane Electrodialysis ◽  
Pre Treatment

The Bipolar Membrane Electrodialysis process (BPMED) can produce valuable chemicals such as acid (HCl, H2SO4, etc.) and base (NaOH) from saline and brackish waters under the influence of an electrical field. In this study, BPMED was used to recover wastewater and salt in biologically treated textile wastewater (BTTWW). BPMED process, with and without pre-treatment (softening and ozonation), was evaluated under different operational conditions. Water quality parameters (color, remaining total organic carbon, hardness, etc.) in the acid, base and filtrated effluents of the BPMED process were evaluated for acid, base, and wastewater reuse purposes. Ozone oxidation decreased 90% of color and 37% of chemical oxygen demand (COD) in BTTWW. As a result, dye fouling on the anion exchange membrane of the BPMED process was reduced. Subsequently, over 90% desalination efficiency was achieved in a shorter period. Generated acid, base, and effluent wastewater of the BPMED process were found to be reusable in wet textile processes. Results indicated that pre-ozonation and subsequent BPMED membrane systems might be a promising solution in converging to a zero discharge approach in the textile industry.

Membrane filtration and sonication for industrial wastewater reuse

2011 ◽  
Vol 64 (12) ◽  
pp. 2500-2507 ◽  
Author(s):  
C. Caretti ◽  
E. Coppini ◽  
E. Fatarella ◽  
C. Lubello
Keyword(s):  
Textile Industry ◽  
Membrane Filtration ◽  
Formation Rate ◽  
Combined Treatment ◽  
Wastewater Reuse ◽  
Treatment Plant ◽  
Pilot Scale ◽  
Secondary Effluent ◽  
Treated Effluent ◽  
Target Values

This paper presents an experimental study aimed at estimating the efficiency of the innovative process of ultrafiltration (UF) combined with sonication (Son.) for the refinement of treated effluent to be reused in wet textile processes. Such a novel approach, which has not yet been employed on a full industrial scale, has been experienced at pilot scale on the secondary effluent of the Baciacavallo wastewater treatment plant (WWTP), which treats part of the effluent from one of the largest textile industry districts in Italy. The combined treatment efficiency was assessed both on ozonated and non-ozonated Baciacavallo secondary effluent. The membrane filtration process was optimized in terms of running time, backwash, chemical addition and cleaning procedures. The sonication treatment was optimized on laboratory-scale with synthetic solutions (demineralized water added with dyestuffs) in terms of hydroxyl radicals formation rate, frequency, acoustic power, hydrogen peroxide addition, contact time and pH. The optimal conditions have been applied on the pilot-scale sonicator which was used in combination with the UF treatment. According to the experimental results, the best configuration within the Baciacavallo WWTP was the sonication of non-ozonated wastewater followed by the UF. The combined treatment guaranteed the compliance with the target values for wastewater reuse in wet textile industries. This study is part of the Research Project PURIFAST (Purification of industrial and mixed wastewater by combined membrane filtration and sonochemical technologies) LIFE + ENV/IT/000439.

Novel Stage Decorations-A New Branch of Textile Industry

1910 ◽  
Vol 103 (19) ◽  
pp. 358-358
Author(s):  
Arthur H. J. Keane
Keyword(s):  
Textile Industry

Collective Resource Mobilisation for Economic Survival within the Kurdish and Turkish Communities in London

2016 ◽  
Vol 6 (2) ◽  
pp. 219-239
Author(s):  
Olgu Karan
Keyword(s):  
Small Business ◽  
Textile Industry ◽  
Economic Capital ◽  
Small Business Owners ◽  
Coffee Shop ◽  
Business Ownership ◽  
Economic Survival ◽  
Collective Resource ◽  
Resource Mobilisation ◽  
Depth Interviews

This paper proposes a new conceptual framework in understanding the dynamics within the Kurdish and Turkish (KT) owned firms in London by utilising Charles Tilly’s work concerning collective resource mobilisation. Drawing on 60 in-depth interviews with restaurant, off-licence, kebab-shop, coffee-shop, supermarket, wholesaler owners and various community organisations, the paper sheds light upon the questions of why and how the KT communities in London moved into, and are over represented and why Turkish Cypriots are absent in small business ownership. The re-search illustrates that members of the KT communities aligned in their interests to become small business owners after the demise of textile industry in the midst of 1990s in London. The interest alignment in small business ownership required activation of various forms of capital and transposition of social, cultural and economic capital into one another.

Sign in / Sign up

Export Citation Format

Share Document