Study on the Volumetric Behavior of Base Oils, Brines, and Drilling Fluids Under Extreme Temperatures and Pressures

2013 ◽  
Vol 28 (03) ◽  
pp. 278-288 ◽  
Author(s):  
Mario Zamora ◽  
Sanjit Roy ◽  
Kenneth S. Slater ◽  
John C. Troncoso
Author(s):  
Mario Zamora ◽  
Sanjit Roy ◽  
Kenneth Slater

The 1980’s introduction of costly non-aqueous drilling fluids finally sent the industry a wake-up call to seriously acknowledge the significant impacts of temperature and pressure on the downhole density and rheological properties of drilling fluids. Despite notable progress since then, key issues remain, mostly related to inherent complexities and uncertainties associated with quantifying these effects. Some issues are technical; others are procedural. Concerns are particularly critical on wells drilled under extreme HTHP (high-temperature/high pressure) conditions, in deepwater, and in Arctic and other ultra-cold locations. The primary objective of this paper is to discuss existing issues from well-integrity and wellbore-integrity perspectives, with focus on determining hydrostatic pressures and rheological properties under downhole conditions. Also included are new representative volumetric-behavior and viscometric data measured in the laboratory under extreme HTHP conditions.


Author(s):  
Gilles Numkam ◽  
Babak Akbari

Abstract Global energy demand continues to drive oil and gas exploration in increasingly challenging environments. The extreme temperatures and pressures drilling fluids are subjected to require optimum design of their rheology. Among the numerous components used in the design of drilling fluids are surfactants. Surfactants play an important role in the emulsification of immiscible liquids as well as the alteration of cuttings wettability to facilitate transport to the surface. Nonionic surfactants, depending on their chemical group allow the inversion of oil-in-water emulsions (O/W) to water-in-oil (W/O) and vice-versa depending on the direction of temperature change. In this study, emulsion-suspension samples were prepared with different nonionic surfactants at Oil:Water ratios of 50:50 and 60:40. The mechanical properties of the samples was assessed using a scientific rheometer at temperatures ranging from 0–90 °C. Phase inversion from oil-in-water to water-in-oil was observed for samples stabilized by polyoxyethylene oleyl ether surfactants. Build up in the apparent viscosity of the samples was observed following phase inversion, mainly resulting from the formation of nanosized dispersed water droplets. Findings in the study highlighted the possibility of obtaining different drilling fluid types during downhole circulation, thereby paving a path for the design optimization of drilling fluids used in offshore operations.


2009 ◽  
Vol 24 (02) ◽  
pp. 239-248 ◽  
Author(s):  
Barkim Demirdal ◽  
Jose C. Cunha

Author(s):  
S.f. Antonov ◽  
◽  
E.F. Kutsevich ◽  
A.I. Matveeva ◽  
R.V. Bartko ◽  
...  

Variants of the intensification of the solvent dewaxing process, which increase the yield of base oils, are described. One of the promising ways to improve the technical and economic indicators of the dewaxing process is the use of modifying additives. The work shows that the introduction of a polymer additive requires a decrease in the filtration rate and, accordingly, an increase in the performance of the dewaxing unit. This results in a petrolatum with a reduced oil content, which is a qualifying factor for the production of high-melting ceresins, protective-wax components, and lubricants for various purposes.


2019 ◽  
pp. 155-161 ◽  
Author(s):  
Ivan Beltran

Environmental temperature has fitness consequences on ectotherm development, ecology and behaviour. Amphibians are especially vulnerable because thermoregulation often trades with appropriate water balance. Although substantial research has evaluated the effect of temperature in amphibian locomotion and physiological limits, there is little information about amphibians living under extreme temperature conditions. Leptodactylus lithonaetes is a frog allegedly specialised to forage and breed on dark granitic outcrops and associated puddles, which reach environmental temperatures well above 40 ˚C. Adults can select thermally favourable microhabitats during the day while tadpoles are constrained to rock puddles and associated temperature fluctuations; we thus established microhabitat temperatures and tested whether the critical thermal maximum (CTmax) of L. lithonaetes is higher in tadpoles compared to adults. In addition, we evaluated the effect of water temperature on locomotor performance of tadpoles. Contrary to our expectations, puddle temperatures were comparable and even lower than those temperatures measured in the microhabitats used by adults in the daytime. Nonetheless, the CTmax was 42.3 ˚C for tadpoles and 39.7 ˚C for adults. Regarding locomotor performance, maximum speed and maximum distance travelled by tadpoles peaked around 34 ˚C, approximately 1 ˚C below the maximum puddle temperatures registered in the puddles. In conclusion, L. lithonaetes tadpoles have a higher CTmax compared to adults, suggesting a longer exposure to extreme temperatures that lead to maintain their physiological performance at high temperatures. We suggest that these conditions are adaptations to face the strong selection forces driven by this granitic habitat.


Sign in / Sign up

Export Citation Format

Share Document