Effects of Radiation sterilization Dose on the Molecular Weight and Gelling Properties of Commercial Alginate Samples

To estimate the molecular weight (Mw) and gelling properties, a total of 26 alginate samples consisting of control (n = 13) and 15 kGy γ-irradiated (n = 13) samples were characterized through viscometric and gel permeation chromatography (GPC-MALLS) methods. Based on the observations, a remarkable decrease in the intrinsic viscosity of all samples of alginates was evident due to the effects of radiation, with a linear relationship between viscosity and concentration in 0.01 M NaCl solution. The correlation among the Mw, percentage mass recovery, radii of gyration (Rz/Rg), and percentage reduction of Mw assessed by GPC was significant. The Mw decreased dramatically (from 3.1 × 105 to 0.49 × 105 mole/g in sample no. 12) by the effect of radiation with momentous relation to the % reduction of the molecular weight. The highest molecular weight reduction (84%), which is the most sensitive to γ-radiation, and the average reduction rate was ≥50%. The mass recovery was 100% obtained from samples no. 1,3,4,5,7,12, and 13, while the rest of the samples’ recovery rate was significantly higher. The reduction rate of mass molecular weight (Mw) is higher than the average molecular weight (Mv), but they showed a sensitivity towards radiation, consequently their performance are different from each other. The stability test was performed as a critical behaviour in the control, recurrently same as in the irradiated samples. Thus, the sterilization dose of 15 kGy for the Mw distribution, and subsequently for the characterization, was significantly effective.

Radiation Sterilization: Dose Is Dose

In the radiation sterilization arena, the question often arises as to whether radiation resistance of microorganisms might be affected by the energy level of the radiation source and the rate of the dose delivered (kGy/time). The basis for the question is if the microbial lethality is affected by the radiation energy level and/or the rate the dose is delivered, then the ability to transfer dose among different radiation sources could be challenged. This study addressed that question by performing a microbial inactivation study using two radiation sources (gamma and electron beam [E-beam]), two microbial challenges (natural product bioburden and biological indicators), and four dose rates delivered by three energy levels (1.17 MeV [gamma], 1.33 MeV [gamma], and 10 MeV [high-energy E-beam]). Based on analysis of the data, no significant differences were seen in the rate of microbial lethality across the range of radiation energies evaluated. In summary, as long as proof exists that the specified dose is delivered, dose is dose.

Radiation Dose Audit Failures: Truth and Consequences

The validation of a radiation sterilization dose involves an initial sterilization dose determination as well as maintenance of that sterilization dose. The procedures for maintenance of the sterilization dose typically include the periodic use of two types of tests: bioburden and dose audits. The details for the procedures are outlined in the ISO radiation sterilization standards. These documents also provide guidelines for recommended actions in response to the results of the two tests. The results for the dose audit are based on the number of positive tests of sterility (TOS) for products that have been irradiated at a verification or experimental dose. When the dose audit yields TOS positives, it is often thought that they indicate a sterilization failure and nonsterile product. The belief that any TOS positive is a failure is an incorrect assumption because of the statistical basis used for the determination of the sterilization dose. This article will outline the truth of what dose audit TOS positives mean in terms of the sterility assurance of product, as well as the consequences of TOS positives.

Gamma Radiation Sterilization Dose of Adult Males in Asian Tiger Mosquito Pupae

The pathogen-carrying tiger mosquito, Aedes albopictus, has spread from the Western Pacific and Southeast Asia to Europe, Africa, the Middle East, North and South America, and the Caribbean. This species of mosquito transmits arboviral infections, such as yellow fever, chikungunya, dengue, zika, and several encephalitides. The objective of this research was to provide a radiation dose inducing sterilization in adult male Ae. albopictus in the pupal stage. A cobalt-60 source of gamma radiation at a dose rate of 381 Gy/h was used. The pupae were irradiated with doses of 0 (control), 20, 30, 40, 50, and 60 Gy. Each treatment had a total of five replications using 60 pupae. After irradiation, the different phases of Ae. albopictus development (egg, larva, pupa, and adult) in the F1 generation were observed daily. Parameters such as viability, fertility, longevity, and mortality were recorded. The results from these studies showed that a dose of 60 Gy was necessary to sterilize 100% of the male Ae. albopictus pupae.