A history of modern accelerated performance testing of pavement structures

Author(s):  
R Powell
Author(s):  
James P. King ◽  
Robert D. Hendrix

This paper describes the many features of a detailed investigation into the determination of a root cause for internal cracking found in the circumferential welds of radiant superheater crossover piping lines, in the Units No. 1 and 2 boilers at Big Cajun II Station in New Roads, Louisiana. The history of inside diameter, circumferential cracks dates back to 1992. The cracking had been recorded during several outages for both units. It was discovered by use of ultrasonic shear wave testing, and verified by ultrasonic time of flight diffraction methods. During each of the ensuing unit outages, the crack depths were recorded and mapped. Repairs were undertaken by machining out the complete girth weld followed by re-welding. During the interim years cracking did re-occur at many of the weld locations. In 2000, a detailed investigation into the cause of the cracking was initiated, which resulted in recommendations for resolving the ongoing problem. This detailed study included; nondestructive testing and metallurgy of removed metal samples, boiler performance testing and analysis and stress, fatigue and fracture mechanics evaluations. The detailed background, applications and results of the many and varied testing and analytical tasks are fully described herein. The main conclusion to the root cause of the cracking is identified as fatigue caused by the combined effects of thermal and pressure cycles. Recommendations are given which address the actions needed to limit or prevent re-occurrence of the cracking, including revised boiler operating procedures. In addition, a series of fatigue crack growth curves is presented, as a monitoring toot for evaluating existing cracks in the welds.


Blood ◽  
2014 ◽  
Vol 124 (21) ◽  
pp. 561-561 ◽  
Author(s):  
Francoise Bernaudin ◽  
Suzanne Verlhac ◽  
Regis Peffault Delatour ◽  
Jean-Hugues Dalle ◽  
Eleonore Petras ◽  
...  

Abstract Background : Evidence-based practices have shown that transfusion program (TP) is beneficial to SCA-patients with abnormally high velocities by Doppler; however, TP cannot be stopped safely, except following HSCT. No prospective trial has to date compared the extent of cerebral vasculopathy following TP or HSCT. The premise of the French National Trial “Drepagreffe” is that cerebral velocities will be reduced to a greater extent after HSCT than under TP. Patients and Methods : We present here preliminary results from this prospective trial with 2 arms (TP/HSCT), defined by the random-availability of a genoidentical donor. Inclusion criteria were SCA (SS/Sb0) children younger than 15 years with a history of abnormal cerebral arterial velocities (TAMMX ≥ 200 cm/sec), placed on long-term transfusion programs, with at least one non-SCA sibling and parents accepting HLA-typing and HSCT if a genoidentical donor was available. Transplanted patients received as conditioning regimen Busilvex-CY 200 mg/kg and 20 mg/kg rabbit Thymoglobulin with CSA and short MTX or MMF for GVHD prophylaxis. In the TP arm, HbS% was maintained at < 30% with Hb 9-11g/dL. At enrollment and 12 months post-enrollment, blood screening, Doppler, cerebral MRI/MRA were performed along with cognitive performance testing, the latter done in parallel in the control sibling. Primary endpoint was the significantly greater reduction of velocities in the HSCT than in the TP arm. Among the various secondary endpoints, Doppler normalization defined by velocities < 170 cm/s in all arteries was to occur more often after HSCT than on TP. Results: SCA-children (n=67; 36F-31M) from 10 French SCA-centers were enrolled between 12/2010 and 6/2013 at the mean (SD) age of 7.6 (3.1) years. History of stroke was present in 6 patients (4 in HSCT and 2 in TP) and 1 TIA in HSCT arm. At TP initiation, velocities≥200/cm/sec were found in middle (n=50), anterior (n=11) and internal carotid arteries (n=30) as abnormal velocities were observed in more than one artery in several patients. Mean (SD) maximum velocities were 219 (26) cm/s (range: 200-333). At enrollment all patients were on TP and paired analysis showed that mean(SD) maximum velocities had significantly decreased (p<0.001) under TP:169 (46) cm/s vs 219 (26) cm/s). Following HLA-typing, 35 without genoidentical donor were included in the transfusion arm and 32 with genoidentical donor were transplanted in 6 HSCT-centers. Mean (SD) maximum velocities were not significantly different in both arms at enrollment: 167 (41) in TP vs 170 (51) cm/s in HSCT. During the 12 months follow-up, no stroke was observed but one patient in the TP arm experienced a hyperammonemic reversible coma, without MRI/MRA alteration requiring transfer to intensive care. In the HSCT arm, all patients successfully engrafted, one grade II and two grade III acute GVHD, and no chronic GVHD were observed. Two patients required transfer to intensive care for seizures and pneumonia. Other complications were seizures (n=2), CMV (n=9) or EBV replications (n=1), hemorrhagic cystitis (n=3), aspergillosis (n=1), prolonged but reversible thrombopenia (n=2), transitory hemolytic anemia (n=1). At 12 months, data, available in 63/67 patients, showed that all patients were alive, mean (SD) Hb and HbS% in TP arm were 9.1 (0.9) and 27.5% (11.9), respectively, whereas in the HSCT arm, mean (SD) Hb and % donor chimerism were 12.0 (1.0) g/dL and 86.5% (12.2) respectively (range:60-100%). All transplanted patients had the same Hb electrophoresis than their donor. Mean (SD) maximum velocities were significantly lower post-HSCT (n=31) than under TP (n=32):128 (34) vs 174 (36) cm/s, respectively; (p<0.001), and were decreased more significantly following HSCT than on TP: mean(SD)Δ: -44 (24) vs +6 (3), respectively. The percentage of patients with normal velocities was significantly higher post-HSCT (27/31) than in the TP arm (16/32) (p=0.003). Conclusions: This prospective national trial comparing TP vs. HSCT in SCA-patients with a history of abnormal velocities shows for the first time that HSCT repeatedly and significantly results in a greater decrease in velocities than TP, and has very little toxicity. These preliminary results are encouraging and suggest that suppression of host SCA-erythropoiesis by HSCT is the treatment of choice for SCA-children with abnormal-TCD and genoidentical donor. Figure 1 Figure 1. Figure 2 Figure 2. Disclosures Bernaudin: Novartis: Research Funding.


Blood ◽  
2015 ◽  
Vol 126 (23) ◽  
pp. 544-544 ◽  
Author(s):  
Francoise Bernaudin ◽  
Suzanne Verlhac ◽  
Elisabeth Ducros-Miralles ◽  
Regis Peffault Delatour ◽  
Jean-Hugues Dalle ◽  
...  

Abstract Background: "Drepagreffe" is a French national prospective trial involving 67 sickle cell anemia (SCA)-children with a history of abnormal cerebral arterial velocities by TCD, and comparing for the first time the outcome of cerebral vasculopathy following transfusion program (TP) or transplantation (HSCT). Inclusion criteria at enrollment were children with SCA (SS/Sb0), younger than 15 years, with a history of abnormal cerebral arterial velocities (TAMMX ≥ 200 cm/sec) and placed on long-term TP, with at least one non-SCA sibling, and with parents accepting HLA-typing and HSCT if a genoidentical donor was available. The 2 arms (TP/HSCT) were defined by the random-availability of a genoidentical donor. Seven of the 67 patients had a history of stroke. Transplanted patients (n=32) received a conditioning regimen of Busilvex-CY 200 mg/kg and 20 mg/kg rabbit Thymoglobulin, with CSA and a short course of MTX or MMF for GvHD prophylaxis. In the TP arm (n=35), HbS% was maintained at < 30%, with an Hb at 9-11g/dL. At enrollment and 12 months post-enrollment, blood screening, Doppler, and cerebral MRI/MRA were performed along with cognitive performance testing, the latter being done in parallel in the non-SCA siblings. Preliminary findings on cerebral velocities as the primary endpoint were reported at the last ASH meeting (abstract 67237), and demonstrated that all patients were alive at one year and that the 32 transplanted patients had no chronic GVHD and the same hemoglobin profile as their donor. Velocities were significantly lower post-HSCT than under TP (p <0.001), and were normalized in a greater number of patients (p =0.003). Patients and Methods: We report here the cerebral imaging (MRI/MRA) and cognitive performance data performed at enrollment and after 12 months. The scoring applied for MRI was: 3 = territorial, 2 = borderzone (cortical and subcortical), 1 = white matter or basal ganglia infarcts, 0 to 3 = atrophia, and for MRA: 1 = mild stenosis (25-49%), 2 = moderate stenosis (50-74%), 3 = severe stenosis (75-99%), 4 = occlusion for each artery and 0 to 2 for Moya presence. Cognitive testing using the WPPSI-3 (3-6 yr), WISC-4 (7-16 yr) or WAIS-3 (>16 yr) scales, depending on the age, was performed in patients and in siblings when possible. Results: MRI/MRA data were available in 66/67 patients. At enrollment (M0), ischemic lesions and stenoses were present in 25 and 35/66 patients, respectively. Cognitive testing was obtained in 64 patients and 56 siblings. Paired analysis with siblings (Table 1) showed significant differences in Verbal Comprehension Index (VCI) with a mean difference of 7.6±14.5(p =0.0004), Processing Speed Index (PSI) 6.3±20.5 (p =0.04), and Full Scale IQ (FSIQ) 7.3±15.0 (p =0.01). After exclusion of the 7 patients with stroke history, significant differences were still observed in VCI (p =0.013) and FSIQ (p =0.019). Patient cognitive performance indexes were correlated negatively and significantly with the MRI and MRA scores (Table 2). At post-enrollment (M12),ischemic lesions and stenoses were present in 26/66 patients. The mean variation in MRI and MRA scores between M12 and M0 was not significantly different between the 2 arms (Table 3). The cognitive tests were performed at M12 in 60 patients (Table 4) and the performance indexes were improved in the TP compared to the HSCT arm, but only significantly for FSIQ. Conclusion This first prospective trial initially showed that HSCT reduces more significantly the cerebral velocities at M12 and in a higher proportion of patients than TP. Here, we show that patients with a history of abnormal cerebral velocities had significantly lower cognitive performances than their siblings, even in the absence of stroke history; however, there was no significant difference between the 2 arms for the outcomes of ischemic lesions and stenosis at M0 and M12. The fact that cognitive performances were improved in the TP compared to the HSCT arm might be explained by the stress of the HSCT procedure and the lack of schooling during this period. Despite the higher ability of HSCT to decrease velocities at M12 compared to TP, a longer follow-up will be required to demonstrate its effect on stenosis and cognitive performances; therefore, patients will be reassessed at 3 years post-HSCT. Disclosures Bernaudin: Novartis: Research Funding.


Sign in / Sign up

Export Citation Format

Share Document