Evaluation of Two Upflow Anaerobic Digesters Purifying Industrial Wastewaters High in Organic Matter

1994 ◽  
Vol 29 (9) ◽  
pp. 225-229 ◽  
Author(s):  
Alan R. Howgrave-Graham ◽  
Helen A. Isherwood ◽  
F. Mike Wallis
Keyword(s):  
Pollutant Removal ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Feed Composition ◽  
Anaerobic Digesters ◽  
Start Up ◽  
Acetogenic Bacteria ◽  
Uasb Granules ◽  
Anaerobic Sludge Blanket ◽  
Microbial Morphotypes

Two full-scale anaerobic digesters, one a clarigester purifying a maize processing wastewater and the other with an upflow anaerobic sludge blanket (UASB) configuration treating brewery effluent, contained well settling, granular sludges efficient in pollutant removal. Due to differences in both digester design and feed composition, the sludges differed in activity and microbial population. The clarigester granules contained a diverse population with a multiformity of hydrolytic, acidogenic and acetogenic bacteria while the predominant methanogens, in order of significance, were Methanothrix and Methanosarcina. These granules did not reconstitute on re-start up following digester shutdown and possible reasons for this are discussed. The UASB granules contained a more uniform population with three major microbial morphotypes, the predominant methanogens being Methanothrix and, possibly, Methanobacterium. In this paper the differences in digester design, feed composition, sludge microbiology and process performance are discussed.

Toxicity and treatability of leachate: application of UASB reactor for leachate treatment from Okhla landfill, New Delhi

2012 ◽  
Vol 65 (10) ◽  
pp. 1887-1894 ◽  
Author(s):  
V. Singh ◽  
A. K. Mittal
Keyword(s):  
Oxygen Demand ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
New Delhi ◽  
Leachate Treatment ◽  
Feed Composition ◽  
Laboratory Scale Reactor ◽  
Anaerobic Sludge Blanket

This study reports applicability of upflow anaerobic sludge blanket (UASB) process to treat the leachate from a municipal landfill located in Delhi. A laboratory scale reactor was operated at an organic loading rate of 3.00 kg chemical oxygen demand (COD)/m3 d corresponding to a hydraulic retention time (HRT) of 12 h for over 8 months. The effect of toxicity of leachate, and feed composition on the treatability of leachate was evaluated. Average COD of the leachate, during the study period varied between 8,880 and 66,420 mg/l. Toxicity of the leachate used during a period of 8 months varied from LC50 1.22 to 12.35 for 96 h. The removal efficiency of soluble COD ranged between 91 and 67% for fresh leachate and decreased drastically from 90 to 35% for old leachate having high toxicity. The efficiency varied from 81 to 65%. The reactor performed more efficiently for the treatment of fresh leachate (less toxic, LC50 11.64, 12.35, and 12.15 for 96 h) as compared with old leachate (more toxic, LC50 1.22 for 96 h). Toxicity of the leachate affected its treatment potential by the UASB.

Start-Up Strategy to Achieve Excellent Efficiency of Degradation Acetate,Ethanol and Propionate in UASB

2011 ◽  
Vol 71-78 ◽  
pp. 2103-2106
Author(s):  
Ming Yue Zheng ◽  
Ming Xia Zheng ◽  
Kai Jun Wang ◽  
Hai Yan
Keyword(s):  
Loading Rate ◽  
Anaerobic Treatment ◽  
Upflow Anaerobic Sludge Blanket ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
Organic Loading ◽  
Metabolic Intermediate ◽  
Loading Rates ◽  
Start Up ◽  
Anaerobic Sludge Blanket

The performance of upflow anaerobic sludge blanket (UASB) fed with three metabolic intermediate (acetate, ethanol, and propionate) respectively was studied. The degradation of metabolic intermediate were investigated to discuss the reason for propionate inhibition problem in anaerobic treatment. The hydraulic retention time (HRT) in the reactors started with 8.0h.The yield rate of biogas were 237ml/gCOD, 242ml/gCOD, 218ml/gCOD for acetate, ethanol and propionate, respectively when finishing start-up under OLR of 5.0 kgCOD/(m3·d) (HRT=9.6h).The HRT remained constant 9.6h,and the substrate concentration was gradually increased from 1,000 to 16,000mg/L as COD,and the organic loading rates(OLR) was from 3.0 to 40.0 kgCOD/(m3·d).The maximum propionate concentration was 41.6 gHPr-COD/L at the organic loading rate of 43.9 kgCOD/(m3·d) (HRT, 9.6h) as well as acetate and ethanol.

A Modified UASB Process Treating Winery Wastewater

1990 ◽  
Vol 22 (9) ◽  
pp. 167-174 ◽  
Author(s):  
S. S. Cheng ◽  
J. J. Lay ◽  
Y. T. Wei ◽  
M. H. Wu ◽  
G. D. Roam ◽  
...  
Keyword(s):  
Gas Production ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Winery Wastewater ◽  
Start Up ◽  
Methane Potential ◽  
Bmp Test ◽  
Anaerobic Sludge Blanket ◽  
Different Characteristics

During the last two years,twenty-seven bioreactors of upflow anaerobic sludge blanket(UASB) process were constructed and operated well to treat 3,300 m3/day of winery wastewater in six winery plants in Taiwan. Each UASB reactor was installed with an internal filter and a side-armed sludge settler to separate gas-liquid-solid effectively in 127 m3 of reactor volume.These six plants established good performance of UASB process with different organic loadings depending on different characteristics of the winery wastewater. Start-up performance of the modified UASB process in four winery plants was investigated.Bioactivity of anaerobic sludge in each UASB was evaluated by means of Biochemical Methane Potential (BMP)test. Biokinetics of Monod and Haldane models were employed to interpret the different sludge characteristics in terms of gas production rate. Scanning electronic microscopy also showed different morphology of sludge granules in three UASB systems.

Anaerobic treatment of Wastewater from a fish-canning factory in a full-scale Upflow Anaerobic Sludge Blanket (UASB) reactor

1999 ◽  
Vol 40 (8) ◽  
pp. 57-62 ◽  
Author(s):  
A. Pun˜al ◽  
J. M. Lema
Keyword(s):  
Anaerobic Treatment ◽  
Upflow Anaerobic Sludge Blanket ◽  
Total Alkalinity ◽  
Uasb Reactor ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
Stable Operation ◽  
Start Up ◽  
Upward Velocity ◽  
Anaerobic Sludge Blanket

The start-up and optimisation of a 380 m3 UASB reactor (Up-flow Anaerobic Sludge Blanket) treating wastewater from a fish-canning factory was carried out. At the beginning of the operation the Organic Loading Rate (OLR) was 1 kg COD/m3·d. Then, the load was gradually increased in steps of 50% OLR until the final capacity of the system (4 kg COD/m3·d) was achieved. Wastewater characteristics were highly dependent on the canned product (mussel, tuna, sardines, etc.). In spite of that, a stable operation working at a hydraulic retention time (HRT) of 2 days was maintained. Total Alkalinity (TA) always presented values higher than 3 g CaCO3/l, while the IA/TA ratio (Intermediate Alalinity/Total Alkalinity) was always maintained lower than 0.3. In order to improve granulation conditions, upward velocities from 0.5 to 0.8 m/h were applied. The highest values caused the washout of non-granulated biomass from the reactor, optimum operation being achieved at an upward velocity of 0.7 m/h.

Startup of thermophilic (55°C) UASB reactors using different mesophilic seed sludges

1996 ◽  
Vol 34 (5-6) ◽  
pp. 445-452 ◽  
Author(s):  
Herbert H. P. Fang ◽  
Ivan W. C. Lau
Keyword(s):  
Oxygen Demand ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Methanogenic Activity ◽  
The Third ◽  
Uasb Granules ◽  
Thermophilic Condition ◽  
Anaerobic Sludge Blanket ◽  
The Impact ◽  
Uasb Reactors

Performances during startup of three 2.8-litre UASB (upflow anaerobic sludge blanket) reactors operated under thermophilic condition were investigated. All reactors were seeded with mesophilic sludges: one with flocculent digester sludge (Reactor-F), another with UASB granules (Reactor-G), and the third with disintegrated granules (Reactor-D). The reactors were operated in parallel at 55°C and 24 hours of retention time, using sucrose and milk as substrate at COD (chemical oxygen demand) loadings up to 10 g-COD/l·day. Immediately after temperature was step-increased from 37°C to 55°C, all reactors encountered sludge washout and deterioration of COD removal efficiency; however, the impact of temperature increase was more severe on Reactor-F. Sludge granulation took place in all reactors; first granules became noticeable after 45 days in Reactor-D, and after 90 days in Reactor-F. Reactor-G and Reactor-D were capable of removing 95% of soluble COD after 75 days, while Reactor-F after 110 days. Throughout this study, there was little difference in performance between Reactors G and D. The thermophilic granule were estimated to have a yield of 0.099 g-VSS/g-COD, and a methanogenic activity of 0.71-1.55 g-methane-COD/g-VSS·day, comparable to that of mesophilic granules.

scholarly journals Microbial and Physicochemical Characteristics of Compact Anaerobic Ammonium-Oxidizing Granules in an Upflow Anaerobic Sludge Blanket Reactor

2010 ◽  
Vol 76 (8) ◽  
pp. 2652-2656 ◽  
Author(s):  
Bing-Jie Ni ◽  
Bao-Lan Hu ◽  
Fang Fang ◽  
Wen-Ming Xie ◽  
Boran Kartal ◽  
...  
Keyword(s):  
Upflow Anaerobic Sludge Blanket ◽  
16S Rrna Genes ◽  
Rrna Genes ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Stable Operation ◽  
Ammonium Oxidation ◽  
N Removal ◽  
Start Up ◽  
Anaerobic Sludge Blanket

ABSTRACT Anaerobic ammonium oxidation (anammox) is a promising new process to treat high-strength nitrogenous wastewater. Due to the low growth rate of anaerobic ammonium-oxidizing bacteria, efficient biomass retention is essential for reactor operation. Therefore, we studied the settling ability and community composition of the anaerobic ammonium-oxidizing granules, which were cultivated in an upflow anaerobic sludge blanket (UASB) reactor seeded with aerobic granules. With this seed, the start-up period was less than 160 days at a NH4 +-N removal efficiency of 94% and a loading rate of 0.064 kg N per kg volatile suspended solids per day. The formed granules were bright red and had a high settling velocity (41 to 79 m h−1). Cells and extracellular polymeric substances were evenly distributed over the anaerobic ammonium-oxidizing granules. The high percentage of anaerobic ammonium-oxidizing bacteria in the granules could be visualized by fluorescent in situ hybridization and electron microscopy. The copy numbers of 16S rRNA genes of anaerobic ammonium-oxidizing bacteria in the granules were determined to be 4.6 � 108 copies ml−1. The results of this study could be used for a better design, shorter start-up time, and more stable operation of anammox systems for the treatment of nitrogen-rich wastewaters.

Sign in / Sign up

Export Citation Format

Share Document