Attachment of Escherichia coli O157:H7 in Ground Beef to Meat Grinders and Survival after Sanitation with Chlorine and Peroxyacetic Acid

1998 ◽  
Vol 61 (7) ◽  
pp. 817-822 ◽  
Author(s):  
BRIDGET L. FARRELL ◽  
AMY B. RONNER ◽  
AMY C. LEE WONG
Keyword(s):  
Escherichia Coli ◽  
Limit Of Detection ◽  
Ground Beef ◽  
Plate Count ◽  
Residual Soil ◽  
Escherichia Coli O157 ◽  
Peroxyacetic Acid ◽  
E Coli ◽  
Bioluminescence Assay ◽  
Atp Bioluminescence Assay

The potential for transfer of Escherichia coli O157:H7 from contaminated ground beef to grinding equipment and the inactivation of attached cells during cleaning and sanitizing was examined. Chub-packed ground beef with lean:fat ratios of 75:25, 80:20, or 90:10 was inoculated with 6 log CFU/g or 2 log CFU/g E. coli O157:H7 strain FRIK 910. Samples were consecutively ground in a Hobart meat grinder with stainless Steel (SS) chips (1 cm2) glued to the auger housing. Chips were harvested after grinding, detergent washing with or without manual scrubbing and rinsing, sanitizing in a chlorine or peroxyacetic acid sanitizer, and overnight storage. Survival of E. coli O157:H7 was evaluated both by plate count and enrichment in trypticase soy broth. Approximately 3 to 4 log CFU/cm2 were attached to the SS after grinding with all three fat contents. After washing and sanitizing in a chlorine or peroxyacetic acid sanitizer, viable bacteria were infrequently recovered by plate count. Enrichment of chips resulted in a higher survival rate with both sanitizing treatments, indicating that cell numbers below the limit of detection (5 CFU/cm2) or potentially injured organisms remained on the surface. Manual scrubbing during the washing step reduced the recovery rate. The scrubbing step also increased the number of passing scores assigned using an ATP bioluminescence assay of total residual soil on the chips sanitized in chlorine. The overall results indicate that plate counts alone may not be a reliable indicator of sanitation efficacy and may be validated by enrichment assay.

Low Prevalence of Salmonella and Shiga Toxin–Producing Escherichia coli in Lymph Nodes of Australian Beef Cattle

2017 ◽  
Vol 80 (12) ◽  
pp. 2105-2111 ◽  
Author(s):  
Gavin Bailey ◽  
Long Huynh ◽  
Lachlan Govenlock ◽  
David Jordan ◽  
Ian Jenson
Keyword(s):  
Escherichia Coli ◽  
Lymph Nodes ◽  
Shiga Toxin ◽  
Limit Of Detection ◽  
Ground Beef ◽  
Plate Count ◽  
Salmonella Spp ◽  
Live Animal ◽  
E Coli ◽  
Low Prevalence

ABSTRACT Salmonella contamination of ground beef has been viewed as originating from the surface of carcasses. Recent studies have identified lymph nodes as a potential source of Salmonella contamination because these tissues play an active role in containment of pathogens in the live animal and because some lymph nodes are unavoidably present in manufacturing beef trimmings or primal cuts that may be incorporated into ground beef. A survey was conducted of the microbiological status of lymph nodes from Australian cattle at the time of slaughter to determine the prevalence of microbiological contamination. Sets of lymph nodes (n = 197), consisting of the superficial cervical (prescapular), prepectoral, axillary, presternal, popliteal, ischiatic, subiliac (precrural), coxalis, and iliofemoralis (deep inguinal), were collected from five geographically separated Australian abattoirs over a period of 14 months. Samples were tested for the presence of Salmonella spp. and Shiga toxin–producing Escherichia coli by BAX PCR assay. Aerobic plate count, E. coli, and coliforms were enumerated with a lower limit of detection of 80 CFU per node. The observed prevalence of Salmonella within peripheral lymph nodes was 0.48% (7 of 1,464). Two of the seven lymph nodes in which Salmonella organisms were detected came from the same animal. Grass-fed, grain-fed, and cull dairy cattle were all found to have detectable Salmonella in lymph nodes. All Salmonella detections occurred during cooler months of the year. No Shiga toxin–producing E. coli were detected. Aerobic microorganisms were detected above the limit of quantification in 3.2% of nodes (median count 2.24 log per node), and E. coli was detected in 0.8% of nodes (median count 3.05 log per node). The low prevalence of Salmonella and low concentration of aerobic microorganisms in Salmonella-positive lymph nodes of Australian cattle at the time of slaughter suggest that the likelihood of lymph nodes contributing significantly to the presence of Salmonella in ground beef is low.

Survival of Escherichia coli O157:H7 in Ground-Beef Patties during Storage at 2, −2, 15 and then −2°C, and −20°C†

1999 ◽  
Vol 62 (11) ◽  
pp. 1243-1247 ◽  
Author(s):  
SUSAN E. ANSAY ◽  
KIM A. DARLING ◽  
CHARLES W. KASPAR
Keyword(s):  
Escherichia Coli ◽  
Frozen Storage ◽  
Ground Beef ◽  
Plate Count ◽  
Escherichia Coli O157 ◽  
Control Strain ◽  
Single Strain ◽  
E Coli ◽  
Beef Patties ◽  
Significant Difference

The survival of Escherichia coli O157:H7 and of a nonpathogenic control strain of E. coli was monitored in raw ground beef that was stored at 2°C for 4 weeks, −2°C for 4 weeks, 15°C for 4 h and then −2°C for 4 weeks, and −20°C. Irradiated ground beef was inoculated with one E. coli control strain or with a four-strain cocktail of E. coli O157:H7 (ca. 105 CFU/g), formed into patties (30 to 45 g), and stored at the appropriate temperature. The numbers of the E. coli control strain decreased by 1.4 log10 CFU/g, and pathogen numbers declined 1.9 log10 CFU/g when patties were stored for 4 weeks at 2°C. When patties were stored at −2°C for 4 weeks, the numbers of the E. coli control strain and the serotype O157:H7 strains decreased 2.8 and 1.5 log10 CFU/g, respectively. Patties stored at 15°C for 4 h prior to storage at −2°C for 4 weeks resulted in 1.6 and 2.7 log10–CFU/g reduction in the numbers of E. coli and E. coli O157:H7, respectively. Storage of retail ground beef at 15°C for 4 h (tempering) did not result in increased numbers of colony forming units per gram, as determined with violet red bile, MRS lactobacilli, and plate-count agars. Frozen storage (−20°C) of ground-beef patties that had been inoculated with a single strain of E. coli resulted in approximately a 1 to 2 log10–CFU/g reduction in the numbers of the control strain and individual serotype O157:H7 strains after 1 year. There was no significant difference between the survival of the control strain and the O157:H7 strains, nor was there a difference between O157:H7 strains. These data demonstrate that tempering of ground-beef patties prior to low-temperature storage accelerated the decline in the numbers of E. coli O157:H7.

Antibacterial Effect of Lactoferricin B on Escherichia coli O157:H7 in Ground Beef

1999 ◽  
Vol 62 (7) ◽  
pp. 747-750 ◽  
Author(s):  
KUMAR S. VENKITANARAYANAN ◽  
TONG ZHAO ◽  
MICHAEL P. DOYLE
Keyword(s):  
Escherichia Coli ◽  
Antibacterial Effect ◽  
Ground Beef ◽  
Enterohemorrhagic Escherichia Coli ◽  
Plate Count ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Significant Difference ◽  
Sufficient Magnitude ◽  
Peptone Medium

The antibacterial activity of lactoferricin B on enterohemorrhagic Escherichia coli O157:H7 in 1% peptone medium and ground beef was studied at 4 and 10°C. In 1% peptone medium, 50 and 100 μg of lactoferricin B per ml reduced E. coli O157:H7 populations by approximately 0.7 and 2.0 log CFU/ml, respectively. Studies comparing the antibacterial effect of lactoferricin B on E. coli O157:H7 in 1% peptone at pH 5.5 and 7.2 did not reveal any significant difference (P > 0.5) at the two pH values. Lactoferricin B (100 μg/g) reduced E. coli O157:H7 population in ground beef by about 0.8 log CFU/g (P < 0.05). No significant difference (P > 0.5) was observed in the total plate count between treatment and control ground beef samples stored at 4 and 10°C. The antibacterial effect of lactoferricin B on E. coli O157:H7 observed in this study is not of sufficient magnitude to merit its use in ground beef for controlling the pathogen.

Incidence of Escherichia coli O157:H7 in Frozen Beef Patties Produced over an 8-Hour Shift†

2002 ◽  
Vol 65 (9) ◽  
pp. 1363-1370 ◽  
Author(s):  
W. PAYTON PRUETT ◽  
TIMOTHY BIELA ◽  
CHARLES P. LATTUADA ◽  
PETER M. MROZINSKI ◽  
W. MARK BARBOUR ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Food Service ◽  
Ground Beef ◽  
Raw Material ◽  
Plate Count ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Beef Patties ◽  
Entry Points ◽  
Positive Results

A ground beef patty processor detected Escherichia coli O157:H7 in five production lots during routine testing with polymerase chain reaction (PCR) technology. This finding stimulated research to determine the incidence and potential entry points of the pathogen during processing. One of these lots (53,960 kg) was divided into 71 pallets (760 kg each) of food service ground beef patties. Ten cartons (19 kg each) were removed from each pallet, for a total of 710 cartons. Four patties were taken from each carton and subdivided to provide comparable samples for E. coli O157:H7 analyses by three different laboratories. Two laboratories employed different immunoassay tests, and one used PCR to screen samples. One sample set was analyzed for aerobic plate, coliform, and E. coli Biotype I counts to determine if any relationship existed between these microbial groups and the incidence of E. coli O157:H7. For 73 samples, presumptive positive results for E. coli O157:H7 were obtained by one or more methods. For 48 of these 73 samples, positive results for the pathogen were culture confirmed. The largest number (29) of culture-confirmed positive E. coli O157:H7 results were detected by PCR. Most positive results were obtained during a short segment of processing. All culture-confirmed E. coli O157:H7 strains were further characterized by two genetic subtyping techniques, resulting in two to four different patterns, depending on the subtyping procedure employed. For any sample tested, the aerobic plate count was <3.0 log CFU/g, and coliform and E. coli Biotype I counts were ≤1.00 log CFU/g. The results of this study suggest that most positive samples were associated with a contaminated batch of raw material introduced just before the 1725- to 1844-h processing segment. These results also indicate that more aggressive sampling plans and genetic screening technologies such as PCR may be used to better detect low levels of E. coli O157:H7 in ground beef products.

Surface and Internalized Escherichia coli O157:H7 on Field-Grown Spinach and Lettuce Treated with Spray-Contaminated Irrigation Water

2010 ◽  
Vol 73 (6) ◽  
pp. 1023-1029 ◽  
Author(s):  
MARILYN C. ERICKSON ◽  
CATHY C. WEBB ◽  
JUAN CARLOS DIAZ-PEREZ ◽  
SHARAD C. PHATAK ◽  
JOHN J. SILVOY ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Irrigation Water ◽  
Enrichment Culture ◽  
Field Studies ◽  
Plate Count ◽  
Escherichia Coli O157 ◽  
Adaxial Side ◽  
Abaxial Side ◽  
E Coli ◽  
Contaminated Irrigation Water

Numerous field studies have revealed that irrigation water can contaminate the surface of plants; however, the occurrence of pathogen internalization is unclear. This study was conducted to determine the sites of Escherichia coli O157:H7 contamination and its survival when the bacteria were applied through spray irrigation water to either field-grown spinach or lettuce. To differentiate internalized and surface populations, leaves were treated with a surface disinfectant wash before the tissue was ground for analysis of E. coli O157:H7 by direct plate count or enrichment culture. Irrigation water containing E. coli O157:H7 at 102, 104, or 106 CFU/ml was applied to spinach 48 and 69 days after transplantation of seedlings into fields. E. coli O157:H7 was initially detected after application on the surface of plants dosed at 104 CFU/ml (4 of 20 samples) and both on the surface (17 of 20 samples) and internally (5 of 20 samples) of plants dosed at 106 CFU/ml. Seven days postspraying, all spinach leaves tested negative for surface or internal contamination. In a subsequent study, irrigation water containing E. coli O157:H7 at 108 CFU/ml was sprayed onto either the abaxial (lower) or adaxial (upper) side of leaves of field-grown lettuce under sunny or shaded conditions. E. coli O157:H7 was detectable on the leaf surface 27 days postspraying, but survival was higher on leaves sprayed on the abaxial side than on leaves sprayed on the adaxial side. Internalization of E. coli O157:H7 into lettuce leaves also occurred with greater persistence in leaves sprayed on the abaxial side (up to 14 days) than in leaves sprayed on the adaxial side (2 days).

Reduction of Escherichia coli O157:H7 Counts on Whole Fresh Apples by Treatment with Sanitizers

2000 ◽  
Vol 63 (6) ◽  
pp. 703-708 ◽  
Author(s):  
MARCY A. WISNIEWSKY ◽  
BONITA A. GLATZ ◽  
MARK L. GLEASON ◽  
CHERYLL A. REITMEIER
Keyword(s):  
Escherichia Coli ◽  
Chlorine Dioxide ◽  
Phosphate Buffer ◽  
Phosphate Buffer Solution ◽  
Escherichia Coli O157 ◽  
Peroxyacetic Acid ◽  
Water Control ◽  
Buffer Solution ◽  
E Coli ◽  
Log Reduction

The objectives of this study were to determine if washing of whole apples with solutions of three different sanitizers (peroxyacetic acid, chlorine dioxide, or a chlorine-phosphate buffer solution) could reduce a contaminating nonpathogenic Escherichia coli O157:H7 population by 5 logs and at what sanitizer concentration and wash time such a reduction could be achieved. Sanitizers were tested at 1, 2, 4, 8, and 16 times the manufacturer's recommended concentration at wash times of 5, 10, and 15 min. Whole, sound Braeburn apples were inoculated with approximately 1 × 108 or 7 × 106 CFU per apple, stored for 24 h, then washed with sterile water (control) or with sanitizers for the prescribed time. Recovered bacteria were enumerated on trypticase soy agar. Washing with water alone reduced the recoverable population by almost 2 logs from the starting population; this can be attributed to physical removal of organisms from the apple surface. No sanitizer, when used at the recommended concentration, reduced the recovered E. coli population by 5 logs under the test conditions. The most effective sanitizer, peroxyacetic acid, achieved a 5-log reduction when used at 2.1 to 14 times its recommended concentration, depending on the length of the wash time. The chlorine-phosphate buffer solution reduced the population by 5 logs when used at 3 to 15 times its recommended concentration, depending on wash time. At no concentration or wash time tested did chlorine dioxide achieve the 5-log reduction.

Validation of Time and Temperature Values as Critical Limits for the Control of Escherichia coli O157:H7 during the Production of Fresh Ground Beef

2006 ◽  
Vol 69 (8) ◽  
pp. 1978-1982 ◽  
Author(s):  
J. E. MANN ◽  
M. M. BRASHEARS
Keyword(s):  
Escherichia Coli ◽  
Room Temperature ◽  
Hazard Analysis ◽  
Control Point ◽  
Ground Beef ◽  
Escherichia Coli O157 ◽  
Meat Processing ◽  
E Coli ◽  
Critical Control Point ◽  
Critical Limits

In order to provide beef processors with valuable data to validate critical limits set for temperature during grinding, a study was conducted to determine Escherichia coli O157:H7 growth at various temperatures in raw ground beef. Fresh ground beef samples were inoculated with a cocktail mixture of streptomycin-resistant E. coli O157:H7 to facilitate recovery in the presence of background flora. Samples were held at 4.4, 7.2, and 10°C, and at room temperature (22.2 to 23.3°C) to mimic typical processing and holding temperatures observed in meat processing environments. E. coli O157:H7 counts were determined by direct plating onto tryptic soy agar with streptomycin (1,000 μg/ml), at 2-h intervals over 12 h for samples held at room temperature. Samples held under refrigeration temperatures were sampled at 4, 8, 12, 24, 48, and 72 h. Less than one log of E. coli O157:H7 growth was observed at 48 h for samples held at 10°C. Samples held at 4.4 and 7.2°C showed less than one log of E. coli O157:H7 growth at 72 h. Samples held at room temperature showed no significant increase in E. coli O157:H7 counts for the first 6 h, but increased significantly afterwards. These results illustrate that meat processors can utilize a variety of time and temperature combinations as critical limits in their hazard analysis critical control point plans to minimize E. coli O157:H7 growth during the production and storage of ground beef.

Bioluminescence: A Rapid Indicator of Escherichia Coli O157:H7 in Selected Yogurt and Cheese Varieties

1997 ◽  
Vol 60 (8) ◽  
pp. 891-897 ◽  
Author(s):  
L. M. HUDSON ◽  
J. CHEN ◽  
A. R. HILL ◽  
M. W. GRIFFITHS
Keyword(s):  
Escherichia Coli ◽  
Enterohemorrhagic Escherichia Coli ◽  
Cottage Cheese ◽  
Plate Count ◽  
Escherichia Coli O157 ◽  
Potential Hazard ◽  
Growth And Survival ◽  
E Coli ◽  
Standard Plate Count ◽  
Standard Plate

Outbreaks of enterohemorrhagic Escherichia coli O157:H7 have been commonly associated with products derived from ground beef, but recently the organism has been implicated as the causative agent in outbreaks involving yogurt and cheese. This finding has raised concern about the potential for its growth and survival in fermented dairy products. A bioluminescent strain of E. coli O157:H7 was used to determine postprocessing survival in yogurt with live cultures at pH 4.17, 4.39, and 4.47 stored at 4 and 10°C. In addition, survival of E. coli O157:H7 was monitored during the manufacture of Cottage, Colby, Romano, and Feta cheeses. Results indicated survival for 8 and 5 days at 4 and 10°C respectively in yogurt at pH 4.17, 17 and 15 days at 4 and 10°C respectively in yogurt at pH 4.39, and 17days at both 4 and 10°C in yogurt at pH 4.47. E. coli O157:H7 did not survive cooking procedures at 56°C in Cottage cheese. However, the pathogen survived for 27, 30, and 27 days in Colby, Romano, and Feta cheeses respectively. A high correlation of r2 > 0.89 was obtained between counts of bioluminescenct colonies and standard plate count for all yogurt and cheese varieties, indicating that bioluminescence was a sensitive and rapid indicator of cellular viability for E. coli O157:H7. Survival of the pathogen, as indicated by this method, is possible in highly acidic environments even at refrigeration temperatures. This poses a potential hazard should postprocessing contamination occur.

Thermal Inactivation of Escherichia coli O157: H7, Salmonella senftenberg, and Enzymes with Potential as Time-Temperature Indicators in Ground Beef

1997 ◽  
Vol 60 (5) ◽  
pp. 471-475 ◽  
Author(s):  
ALICIA ORTA-RAMIREZ ◽  
JAMES F. PRICE ◽  
YIH-CHIH HSU ◽  
GIRIDARAN J. VEERAMUTHU ◽  
JAMIE S. CHERRY-MERRITT ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Thermal Inactivation ◽  
Ground Beef ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Triose Phosphate ◽  
Beef Products ◽  
Z Value ◽  
D Values ◽  
Salmonella Senftenberg

The USDA has established processing schedules for beef products based on the destruction of pathogens. Several enzymes have been suggested as potential indicators of heat processing. However, no relationship between the inactivation rates of these enzymes and those of pathogenic microorganisms has been determined. Our objective was to compare the thermal inactivation of Escherichia coli O157:H7 and Salmonella senftenberg to those of endogenous muscle proteins. Inoculated and noninoculated ground beef samples were heated at four temperatures for predetermined intervals of time in thermal-death-time studies. Bacterial counts were determined and enzymes were assayed for residual activity. The D values for E. coli O157:H7 were 46.10, 6.44, 0.43, and 0.12 min at 53, 58, 63, and 68°C, respectively, with a z value of 5.60°C. The D values for S. senftenberg were 53.00, 15.17, 2.08, and 0.22 min at 53, 58, 63, and 68°C, respectively, with a z value of 6.24°C. Apparent D values at 53, 58, 63, and 68°C were 352.93, 26.31, 5.56, and 3.33 min for acid phosphatase; 6968.64, 543.48, 19.61, and 1.40 min for lactate dehydrogenase; and 3870.97, 2678.59, 769.23, and 42.92 min for peroxidase; with z values of 7.41,3.99, and 7.80°C, respectively. Apparent D values at 53, 58, 63, and 66°C were 325.03, 60.07, 3.07, and 1.34 min for phosphoglycerate mutase; 606.72, 89.86, 4.40, and 1.28 min for glyceraldehyde-3-phosphate dehydrogenase; and 153.06, 20.13, 2.25, and 0.74 min for triose phosphate isomerase; with z values of 5.18, 4.71, and 5.56°C, respectively. The temperature dependence of triose phosphate isomerase was similar to those of both E. coli O157 :H7 and S. senftenberg, suggesting that this enzyme could be used as an endogenous time-temperature indicator in beef products.

Viability of Acid-Adapted Escherichia coli O157:H7 in Ground Beef Treated with Acidic Calcium Sulfate

2004 ◽  
Vol 67 (3) ◽  
pp. 591-595 ◽  
Author(s):  
LARRY R. BEUCHAT ◽  
ALAN J. SCOUTEN
Keyword(s):  
Escherichia Coli ◽  
Acetic Acid ◽  
Calcium Sulfate ◽  
Ground Beef ◽  
Storage Period ◽  
Acid Tolerance ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Acidic Environments ◽  
Subsequent Acid

The effects of lactic acid, acetic acid, and acidic calcium sulfate (ACS) on viability and subsequent acid tolerance of three strains of Escherichia coli O157:H7 were determined. Differences in tolerance to acidic environments were observed among strains, but the level of tolerance was not affected by the acidulant to which cells had been exposed. Cells of E. coli O157:H7 adapted to grow on tryptic soy agar acidified to pH 4.5 with ACS were compared to cells grown at pH 7.2 in the absence of ACS for their ability to survive after inoculation into ground beef treated with ACS, as well as untreated beef. The number of ACS-adapted cells recovered from ACS-treated beef was significantly (α = 0.05) higher than the number of control cells recovered from ACS-treated beef during the first 3 days of a 10-day storage period at 4°C, suggesting that ACS-adapted cells might be initially more tolerant than unadapted cells to reduced pH in ACS-treated beef. Regardless of treatment of ground beef with ACS or adaptation of E. coli O157:H7 to ACS before inoculating ground beef, the pathogen survived in high numbers.

Sign in / Sign up

Export Citation Format

Share Document