An experimental investigation of micro-machinability of aluminum alloy 2024 using Ti(C7N3)-based cermet micro end-mill tools

2016 ◽  
Vol 235 ◽  
pp. 13-27 ◽  
Author(s):  
Kaitao Xu ◽  
Bin Zou ◽  
Yishun Wang ◽  
Peng Guo ◽  
Chuanzhen Huang ◽  
...  
2016 ◽  
Vol 1136 ◽  
pp. 143-148 ◽  
Author(s):  
Zhi Qiang Liang ◽  
Li Ping Ma ◽  
Xi Bin Wang ◽  
Wen Xiang Zhao ◽  
Tian Feng Zhou ◽  
...  

This study is carried out to investigate the influence of pulsed magnetic treatment on wear of carbide micro-end-mill. To analyze the friction behavior of micro-end-mill with workpiece, the special micro-end-mill with a chisel is fabricated and used in micro-milling experiments. A paramagnetic material aluminum alloy is employed as workpiece material. The experimental results indicated 17% and 27 % reductions in maximum minor flank wear width and chisel edge wear area of micro-end-mill after pulsed magnetic treatment, respectively. However, the surface roughness and morphology of machined aluminum alloy have no obvious changes with or without pulsed magnetic treatment. Consequently, the reduction of tool wear during milling aluminum alloy can be mainly attributed to the improvement of mechanical properties of carbide tool materials after pulsed magnetic treatment.


2011 ◽  
Vol 325 ◽  
pp. 588-593 ◽  
Author(s):  
Koji Tsuda ◽  
Koichi Okuda ◽  
Hiroo Shizuka ◽  
Masayuki Nunobiki

This study deals with the cutting characteristics of titanium materials when milled by a small-diameter end mill, or a micro end mill. It is well known that titanium is difficult to cut by conventional means. However, its cutting characteristics have not yet been made sufficiently clear in cases where a micro end mill less than 1 mm in diameter is used. This study chiefly involves the experimental investigation of tool wear and surface roughness of micro-end milling of Ti-6Al-4V. The findings were that tool wear did not increase much when the cutting speed was increased from 50 m/min to 200 m/min. Furthermore, the cutting force required to cut decreased at high speeds and during wet cutting. In wet cutting, the surface had a roughness (Rz) of only 0.3 μm at 200 m/min in contrast to 0.6 μm at 50 m/min.


Author(s):  
Ankit Thakur ◽  
Gurmeet Singh ◽  
Navdeep Minhas ◽  
Varun Sharma ◽  
Anuj Bansal

2012 ◽  
Vol 83 (3) ◽  
pp. 230-237 ◽  
Author(s):  
Lihui Lang ◽  
Baosheng Liu ◽  
Tao Li ◽  
Xiangni Zhao ◽  
Yuansong Zeng

1986 ◽  
Vol 108 (4) ◽  
pp. 313-320 ◽  
Author(s):  
D. E. Helling ◽  
A. K. Miller ◽  
M. G. Stout

The multiaxial yield behaviors of 1100-0 aluminum, 70:30 brass, and an overaged 2024 aluminum alloy (2024-T7) have been investigated for a variety of prestress histories involving combinations of normal and shear stresses. Von Mises effective prestrains were in the range of 1.2–32%. Prestress paths were chosen in order to investigate the roles of prestress and prestrain direction on the nature of small-strain offset (ε = 5 × 10−6) yield loci. Particular attention was paid to the directionality, i.e., translation and distortion, of the yield locus. A key result, which was observed in all three materials, was that the final direction of the prestrain path strongly influences the distortions of the yield loci. Differences in the yield locus behavior of the three materials were also observed: brass and the 2024-T7 alloy showed more severe distortions of the yield locus and a longer memory of their entire prestrain history than the 1100-0 aluminum. In addition, more “kinematic” translation of the subsequent yield loci was observed in brass and 2024-T7 than in 1100-0 aluminum. The 2024-T7 differed from the other materials, showing a yield locus which decreased in size subsequent to plastic straining. Finally, the implications of these observations for the constitutive modeling of multiaxial material behavior are discussed.


Sign in / Sign up

Export Citation Format

Share Document