Anaerobic Thermophilic (55°C) Treatment of TMP Whitewater in Reactors Based on Biomass Attachment and Entrapment

1999 ◽  
Vol 40 (11-12) ◽  
pp. 67-75 ◽  
Author(s):  
Sigrun J. Jahren ◽  
Jukka A. Rintala ◽  
Hallvard Ødegaard
Keyword(s):  
Granular Sludge ◽  
Biofilm Reactor ◽  
Upflow Anaerobic Sludge Blanket ◽  
Hybrid Reactor ◽  
Anaerobic Sludge ◽  
Loading Rates ◽  
Anaerobic Reactors ◽  
Multi Stage ◽  
Degradation Rates ◽  
Thermomechanical Pulping

Thermomechanical pulping (TMP) whitewater was treated in thermophilic (55°C) anaerobic laboratory-scale reactors using three different reactor configurations. In all reactors up to 70% COD removals were achieved. The anaerobic hybrid reactor, composed of an upflow anaerobic sludge blanket (UASB) and a filter, gave degradation rates up to 10 kg COD/m3d at loading rates of 15 kg COD/m3d and hydraulic retention time (HRT) of 3.1 hours. The anaerobic multi-stage reactor, consisting of three compartments, each packed with granular sludge and carrier elements, gave degradation rates up to 9 kg COD/m3d at loading rates of 15-16 kg COD/m3d, and HRT down to 2.6 hours. Clogging and short circuiting eventually became a problem in the multi-stage reactor, probably caused by too high packing of the carriers. The anaerobic moving bed biofilm reactor performed similar to the other reactors at loading rates below 1.4 kg COD/m3d, which was the highest loading rate applied. The use of carriers in the anaerobic reactors allowed short HRT with good treatment efficiencies for TMP whitewater.

scholarly journals Bioenergy recovery from cattle wastewater in an UASB-AF hybrid reactor

2017 ◽  
Vol 76 (9) ◽  
pp. 2268-2279 ◽  
Author(s):  
Henrique Vieira de Mendonça ◽  
Jean Pierre Henry Balbaud Ometto ◽  
Marcelo Henrique Otenio ◽  
Alberto José Delgado dos Reis ◽  
Isabel Paula Ramos Marques
Keyword(s):  
Biogas Production ◽  
Upflow Anaerobic Sludge Blanket ◽  
Hybrid Reactor ◽  
Anaerobic Sludge ◽  
The Novel ◽  
Organic Loading ◽  
Loading Rates ◽  
Volatile Solids ◽  
Anaerobic Sludge Blanket

Abstract New data on biogas production and treatment of cattle wastewater were registered using an upflow anaerobic sludge blanket-anaerobic filter (UASB-AF) hybrid reactor under mesophilic temperature conditions (37 °C). The reactor was operated in semi-continuous mode with hydraulic retention times of 6, 5, 3 and 2 days and organic loading rates of 3.8, 4.6, 7.0 and 10.8 kg CODt m−3 d−1. Biogas volumes of 0.6–0.8 m3 m−3 d−1 (3.8–4.6 kg CODt m−3 d−1) and 1.2–1.4 m3 m−3 d−1 (7.0–10.8 kg CODt m−3 d−1), with methane concentrations between 69 and 75%, were attained. The removal of organic matter with values of 60–81% (CODt) and 51–75% (CODs) allowed methane yields of 0.155–0.183 m3 CH4 kg−1 CODt and 0.401–0.513 m3 CH4 kg−1 CODs to be obtained. Volatile solids were removed in 34 to 69%, with corresponding methane yields of 0.27 to 0.42 m3 CH4 kg−1 VSremoved. The good performance of the novel hybrid reactor was demonstrated by biogas outputs higher than reported previously in the literature, along with the quality of the gas obtained in the various experimental phases. The hybrid reactor investigated in this study presents comparative advantages, particularly in relation to conventional complete mixture units, considering economic factors such as energy consumption, reactor volume and installation area.

DEGRADATION OF STARCH PARTICULATES IN A HYBRID REACTOR

1994 ◽  
Vol 30 (4) ◽  
pp. 97-104 ◽  
Author(s):  
Herbert H. P. Fang ◽  
Tin-Sang Kwong
Keyword(s):  
Loading Rate ◽  
Oxygen Demand ◽  
Upflow Anaerobic Sludge Blanket ◽  
Hybrid Reactor ◽  
Anaerobic Sludge ◽  
Methanogenic Activity ◽  
Loading Rates ◽  
Granular Biomass ◽  
Abundant Supply ◽  
Anaerobic Sludge Blanket

The study was conducted over 265 days to study the feasibility of removing starch particulates from wastewater using an 8.5 L reactor which was a hybrid between the upflow anaerobic sludge blanket (UASB) and the anaerobic filter reactors. At pH 7.2-7.5 and 37°C, the reactor was effective for the removal of chemical oxygen demand (COD) from wastewater containing starch particulates equivalent to 5000 mglL of COD with 12 hours of retention time, corresponding to a loading rate of 10 g-COD/L.d. Despite their insoluble nature, the starch particulates did not cause noticeable adverse effeels on the granulation of biomass, probably due to its easy-to-biodegrade nature and the cautious startup strategy. About 5.8% of COD in wastewater remained in the effluent, 82.5% was converted to methane, and the remaining 11.7% was converted to granular biomass with an average sludge yield of 0.09 g-VSS/g-COD. The granules exhibited a layered microstructure. The methanogenic activity of the granular biomass was 0.86 g-methane-COD/g-VSS.d in the reactor, which was considerably lower than the 1.96 g-methane-COD/ g-VSS.d measured in serum vials with an abundant supply of substrate, suggesting that further increase of loading rates was possible for the hybrid reactor.

Optimal process pattern for simultaneous sulfur, nitrogen and carbon removal

2009 ◽  
Vol 59 (4) ◽  
pp. 833-837 ◽  
Author(s):  
Chuan Chen ◽  
Aijie Wang ◽  
Nanqi Ren ◽  
Xuliang Deng ◽  
Duu-Jong Lee
Keyword(s):  
Elemental Sulfur ◽  
Removal Rate ◽  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Loading Rates ◽  
Process Pattern ◽  
High Removal Rate ◽  
Anaerobic Sludge Blanket

Denitrifying sulfide removal (DSR) process incorporates interactions between autotrophic and heterotrophic denitrifiers and reveals difficulty to achieve high removal rate of nitrogen and sulfur in practice. We compared the DSR performance of an expanded granular sludge bed (EGSB) reactor and an upflow anaerobic sludge blanket (UASB) reactor, both fed with wastewaters comprising sulfide, nitrate and acetate. The EGSB reactor can sustain at higher loading rates than UASB reactor, probably owing to the less elemental sulfur production rate for the latter in operation.

Anaerobic Treatment of an Apple Processing Wastewater

1987 ◽  
Vol 19 (1-2) ◽  
pp. 237-247 ◽  
Author(s):  
P. L. Dold ◽  
A. Sam-Soon ◽  
I. H. Palmer ◽  
G v. R. Marais
Keyword(s):  
Granular Sludge ◽  
Anaerobic Treatment ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Loading Rates ◽  
Medium Strength ◽  
Comparative Treatment ◽  
High Level ◽  
Anaerobic Sludge Blanket ◽  
New Generation

The new generation of anaerobic digestion systems provide a high level of performance under optimal conditions (~ 37°C). However, in practice many influents will be at lower temperatures - heating of digesters presents problems, particularly in developing countries where technical backup is limited. This paper reports on a study of the treatment of a low/medium strength apple juicing waste in an upflow anaerobic sludge blanket reactor (UASB) at temperatures Less than optimal (25°C and 30°C). Maximum loading rates of approximately 12 and 16 kg COD m−3 d−1 were attained at 25°C and 30°C, respectively, for Influent concentrations in the range 2500 to 5000 rag COD ℓ−1. The comparative treatment capacity is In accord with the reported temperature sensitivity of mesophilic anaerobic processes. Formation of pelletised (granular) sludge enabled high upflow velocities and low hydraulic retention times.

Treatment of textile dyes in two-phase and single-phase anaerobic bio-treatment systems

2008 ◽  
Vol 57 (6) ◽  
pp. 863-868 ◽  
Author(s):  
D. Bhattacharyya ◽  
K. S. Singh
Keyword(s):  
Single Phase ◽  
Granular Sludge ◽  
Anaerobic Treatment ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Phase System ◽  
Two Phase ◽  
Anaerobic Reactors ◽  
Anaerobic Sludge Blanket

This research integrates two different concepts of anaerobic biotechnology- two-phase anaerobic treatment and anaerobic granular sludge bed technology, in treatment of colored wastewaters from textile industries. Four anaerobic reactors based on upflow anaerobic sludge blanket (UASB) technology were used as acid reactors and an expanded granular sludge bed (EGSB) reactor was used as a methane reactor. A conventional single-phase anaerobic reactor, working on EGSB technology was run in parallel to compare the performances of the two systems. Reactors were operated at different hydraulic retention times. The results from the study, which span over a period of 400 days, indicated that the two-phase system produces a higher quality of effluent in terms of color, COD and suspended solids than single-phase anaerobic treatment when operated under similar conditions. Alkalinity requirement of two-phase system was also observed to be lower than that of single-phase system which is important regarding design consideration.

Toxicity of Sulfite and Cadmium to Anaerobic Granular Sludge

1994 ◽  
Vol 29 (4) ◽  
pp. 581-598
Author(s):  
C.F. Shew ◽  
N. Kosaric
Keyword(s):  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Shock Load ◽  
Anaerobic Sludge ◽  
Anaerobic Granular Sludge ◽  
Scanning Electron Micrographs ◽  
Bacterial Growth Rate ◽  
Digestion Rate ◽  
Sulfate Reducing ◽  
Load Conditions

Abstract Toxicity of sulfite (Na2SO3) and cadmium (CdCl2) ions to anaerobic granular sludge was investigated in 1.2 litre bench-scale upflow anaerobic sludge blanket (UASB) reactors during process acclimation and shock load conditions. Minimal sulfite toxicity was observed under gradual and shock load conditions at sulfite concentrations of up to 1000 mg S/L if proper acclimation was allowed to occur. No long-term toxic effects were observed although the COD digestion rate was temporarily inhibited by shock load of sulfite. Scanning electron micrographs indicated that more sulfate-reducing bacteria were present in the granules developed in the reactors with sulfite supplement although rod-shaped Methanosaeta-like bacteria were still dominant. High bacterial growth rate was observed in the reactors which were supplied with the feed containing sulfite. The COD digestion rate was inhibited at a cadmium loading rate of 2.4 g Cd per day under both acclimation and shock load conditions. Acclimation did not seem to improve the bacteria to tolerate the toxicity of cadmium. The concentration of free cadmium was very low in the reactors under normal conditions, but increased rapidly when the COD digestion in the reactors ceased. The bacteria could not be reactivated after inhibited by cadmium. When reactors were operated at low specific COD loading rates, more inorganic precipitates were formed inside the granules which consequently settled faster.

Treatment of Different Wastewaters from Pulp and Paper Industry in Methane Reactors

1985 ◽  
Vol 17 (1) ◽  
pp. 223-230 ◽  
Author(s):  
P K Latola
Keyword(s):  
Power Plant ◽  
Paper Industry ◽  
Granular Sludge ◽  
Paper Mill ◽  
Pulp And Paper Industry ◽  
Pulp And Paper ◽  
Plastic Foam ◽  
Loading Rates ◽  
Multi Stage ◽  
Removal Efficiencies

A wastewater from an integrated paper mill with a COD of 1200 mg/dm3 was anaerobically treated in a multi-stage reactor. The BOD7 removal efficiencies of 60-75 % were achieved at maximal loading rates of 5-6 kg COD/m3d and HRT of 4-6 hours due to the granular sludge. Industrial sulphite evaporator condensates from Ca- and Na-processes were treated in anaerobic filters containing light gravel, plastic foam and power plant slag as filter media. The BOD7 removals of 78 % on average were achieved at loading rates of 1.8-3.3 kg COD/m3d with Ca-process evaporator condensates and 80 % BOD7 removals were achieved with Na-process condensates at loading rates of 3.5-4.1 kg COD/m3d.

The effect of extreme temperatures (70–80°C) on the effluent quality and sludge characteristics of UASB reactors

1997 ◽  
Vol 36 (6-7) ◽  
pp. 325-332 ◽  
Author(s):  
Raghida Lepistö ◽  
Jukka Rintala
Keyword(s):  
Volatile Fatty Acids ◽  
Granular Sludge ◽  
Anaerobic Sludge ◽  
Methanogenic Activity ◽  
Sludge Characteristics ◽  
Effluent Quality ◽  
Start Up ◽  
Thermomechanical Pulping ◽  
Increasing Temperature ◽  
Uasb Reactors

The study focused on the effluent quality and sludge characteristics during the start-up and operation of extreme thermophilic (70 to 80°C) upflow anaerobic sludge bed (UASB) reactors, inoculated with mesophilic and thermophilic granular sludge and fed with acetate, volatile fatty acids (VFA), and thermomechanical pulping (TMP) whitewater. Low effluent quality and long start-up periods were observed during the start-up of the 70 to 76°C, VFA-fed UASB reactors inoculated with mesophilic granulae, while better effluent quality and considerably shorter start-up periods were observed when thermophilic (55/70°C) inocula were used. With VFA feed, a significant amount of acetate was removed at 70°C and even at 80°C, while propionate removal was negligible. With TMP whitewater feed, low VFA effluent concentration was obtained at 70°C. The volatile solids (VS) and the VS/total solids (TS) content of the sludge decreased significantly during the first 2–3 months of operation when mesophilic inocula were used. The initial specific methanogenic activity (ISMA) of the extreme thermophilic sludge decreased with increasing temperature and was slightly higher on glucose than on acetate. At 70 to 80°C, various rod-like bacteria were dispersed through the granulae in either individual or in low density micro colonies surrounded with a varying degree of precipitates.

scholarly journals Microbial Diversity Dynamics in a Methanogenic-Sulfidogenic UASB Reactor

2021 ◽  
Vol 18 (3) ◽  
pp. 1305
Author(s):  
E. Fernández-Palacios ◽  
Xudong Zhou ◽  
Mabel Mora ◽  
David Gabriel
Keyword(s):  
Paper Industry ◽  
Chemical Species ◽  
Methanogenic Archaea ◽  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Rrna Gene ◽  
Sulfate Reducing ◽  
Long Run

In this study, the long-term performance and microbial dynamics of an Upflow Anaerobic Sludge Blanket (UASB) reactor targeting sulfate reduction in a SOx emissions treatment system were assessed using crude glycerol as organic carbon source and electron donor under constant S and C loading rates. The reactor was inoculated with granular sludge obtained from a pulp and paper industry and fed at a constant inlet sulfate concentration of 250 mg S-SO42−L−1 and a constant C/S ratio of 1.5 ± 0.3 g Cg−1 S for over 500 days. Apart from the regular analysis of chemical species, Illumina analyses of the 16S rRNA gene were used to study the dynamics of the bacterial community along with the whole operation. The reactor was sampled along the operation to monitor its diversity and the changes in targeted species to gain insight into the performance of the sulfidogenic UASB. Moreover, studies on the stratification of the sludge bed were performed by sampling at different reactor heights. Shifts in the UASB performance correlated well with the main shifts in microbial communities of interest. A progressive loss of the methanogenic capacity towards a fully sulfidogenic UASB was explained by a progressive wash-out of methanogenic Archaea, which were outcompeted by sulfate-reducing bacteria. Desulfovibrio was found as the main sulfate-reducing genus in the reactor along time. A progressive reduction in the sulfidogenic capacity of the UASB was found in the long run due to the accumulation of a slime-like substance in the UASB.

Sign in / Sign up

Export Citation Format

Share Document