Reduction of adsorbable organically bound halogens (AOX) formation at near-neutral pH chlorine dioxide bleaching of softwood kraft pulp

Recently, a new type of bleaching sequence, Elemental Chlorine Free (ECF) light with one D stage, has been developed. It combines the efficiency and high selectivity of chlorine dioxide (ClO2) bleaching with more environmental friendly oxygen based bleaching chemicals. This work examines the effect of pH on the formation of adsorbable organically bound halogens (AOX) in an intermediate D stage – a single ClO2 stage at the middle of an ECF light bleaching sequence. Carbon dioxide (CO2) is used to generate a bicarbonate buffer in situ, stabilizing the pH during the bleaching. Near-neutral pH is hypothesized to decrease the formation of strongly chlorinating species, so that the AOX formation is reduced. The results indicate that a near-neutral pH D stage can reduce the AOX content in the effluents with up to 30%. The ISO brightness was unchanged to a lower ClO2 consumption. The pulp viscosity was slightly higher after near-neutral pH D stage, but to its disadvantage a lesser delignification and removal of HexA was obtained. The degradation of HexA correlated well with the AOX, affirming earlier theories that HexA has a major impact on the AOX formation. The higher amounts of residual HexA and lignin resulted in more thermal yellowing of the pulps bleached with a near-neutral pH D stage.

Performic acid for advanced wastewater disinfection

The disinfection efficiency of performic acid (PFA) against various microbial contaminants has been studied in municipal secondary effluent. The study demonstrated that PFA provides rapid, efficient and safe disinfection, degrading both bacteria and viruses even at low doses. The resistance order starting from the most resistant microorganism is as follows: MS2-coliphages > DNA-coliphages > enterococci and Escherichia coli. PFA is also efficient in the elimination of Salmonella spp., Clostridium perfringens spores and Giardia cysts. The results showed that a PFA dose as low as 0.5–1 mg L–1 with contact time of 10 min was efficient in achieving and maintaining for 72 h the disinfection level required for unrestricted agricultural water reuse (≤3 log units for faecal coliforms). However, the optimal dose will depend on the quality of wastewater. Regarding the formation of by-products during disinfection with PFA, very low amounts of hydrogen peroxide and organic per-acids were observed; active oxygen was not detected. The amounts of adsorbable organically bound halogens (AOX) compounds formed were significantly lower compared to the amounts generated during chlorine disinfection. This chlorine-free solution enables compliance with microbiological criteria for various water reuse applications and is already on the market for advanced disinfection.

Content changes of adsorbable organically bound halogens during sludge centrifugation and drying

A wastewater treatment plant in Brno may be one of the wastewater treatment plants in the Czech Republic using a dryer for dewatering the sludge. The results of an adsorbable organically bound halogens balance analysis measured on the sludge dryer at the waste water treatment plant in Brno are demonstrated in this work. The aim of this work was to calculate the material balance in the treatment process (centrifugation and drying). Control places were chosen and then samples of water and sludge (at the inlet and outlet of the system) were collected. The adsorbable organically bound halogens concentration was detected in these samples by the coulometric method.