scholarly journals Anisotropic and Pressure-Dependent Plasticity Modeling for Residual Stress Prediction

Author(s):  
Michael B. Prime
Author(s):  
Peter J. Bouchard ◽  
Lyndon Edwards ◽  
Anastasius G. Youtsos ◽  
Roger Dennis

Finite element weld residual stress modelling procedures involve complex non-linear analyses where many assumptions and approximations have to be made by the analyst. Weld modelling guidelines for inclusion in the R6 defect assessment procedure are in preparation and will be accompanied by a series of validation benchmarks that can be used to evaluate the accuracy of weld modelling procedures and assess their suitability for use in fracture assessments. It is intended to base one of the benchmarks on a stainless steel bead-on-plate weldment that has been extensively studied by members of Task Group 1 of the NeT European Network project. This paper uses round robin residual stress measurements from the NeT project to derive a statistically based ‘best estimate’ distribution of transverse stress passing through the wall-section at mid-length of the bead-on-plate weldment. The accuracy of a state-of-the-art residual stress prediction is benchmarked against the best estimate measurements using a root mean square error analysis and comparisons of decomposed components of stress. The appropriateness of using the predicted residual stresses in fracture assessments is assessed by comparing stress intensity factors based on the measured and predicted distributions of stress. The results from these studies will be used to help establish accuracy targets and acceptance criteria for the welding benchmark.


Author(s):  
Michael L. Benson ◽  
Patrick A. C. Raynaud ◽  
Frederick W. Brust

Residual stress prediction contributes to nuclear safety by enabling engineering estimates of component service lifetimes. Subcritical crack growth mechanisms, in particular, require residual stress assumptions in order to accurately model the degradation phenomena. In many cases encountered in nuclear power plant operations, the component geometry permits two-dimensional (i.e., axisymmetric) modeling. Two recent examples, however, required three-dimensional modeling for a complete understanding of the weld residual stress distribution in the component. This paper describes three-dimensional weld residual stress modeling for two cases: (1) branch connection welds off reactor coolant loop piping and (2) a mockup to demonstrate the effectiveness of the excavate and weld repair process.


2013 ◽  
Vol 768-769 ◽  
pp. 503-509 ◽  
Author(s):  
Jawad Badreddine ◽  
Emmanuelle Rouhaud ◽  
Matthieu Micoulaut ◽  
Sebastien Remy ◽  
Vincent Desfontaine ◽  
...  

This paper presents a 3D model that simulates an ultrasonic shot peening (USP) operation, using realistic process parameters and peening setups (part and chamber geometries). By simulating the shot dynamics (shot trajectories and impacts), statistical and spatial data are obtained for the peened component, i.e. surface coverage and coverage rate, impact speeds and angles, dissipated energy... This data can then be used for i) optimizing the design of peening chambers and process parameters and ii) predicting the residual stress and displacement fields induced by USP in the peened component. In fact, data from the 3D model can be used as initial data in existing residual stress prediction models. A chaining methodology was developed for this purpose and allows linking the choice of process parameters and USP setup to the induced residual stress displacement fields.


Sign in / Sign up

Export Citation Format

Share Document