scholarly journals Drying Characteristics and Physical and Nutritional Properties of Shrimp Meat as Affected by Different Traditional Drying Techniques

2016 ◽  
Vol 2016 ◽  
pp. 1-5 ◽  
Author(s):  
P. T. Akonor ◽  
H. Ofori ◽  
N. T. Dziedzoave ◽  
N. K. Kortei
Keyword(s):  
Ash Content ◽  
Moisture Loss ◽  
Drying Methods ◽  
Moisture Removal ◽  
Solar Drying ◽  
Nutritional Properties ◽  
Drying Characteristics ◽  
Red Color ◽  
Drying Techniques

The influence of different drying methods on physical and nutritional properties of shrimp meat was investigated in this study. Peeled shrimps were dried separately using an air-oven dryer and a tunnel solar dryer. The drying profile of shrimp meat was determined in the two drying systems by monitoring moisture loss over the drying period. Changes in color, proximate composition, and rehydration capacity were assessed. The rate of moisture removal during solar drying was faster than the air-oven drying. The development of red color during drying was comparable among the two methods, but solar-dried shrimps appeared darker (L⁎=47.4) than the air-oven-dried (L⁎=49.0). Chemical analysis indicated that protein and fat made up nearly 20% and 2% (wb) of the shrimp meat, respectively. Protein and ash content of shrimp meat dried under the two dryer types were comparable but fat was significantly (p<0.05) higher in oven-dried meat (2.1%), compared to solar-dried meat (1.5%). Although rehydration behavior of shrimp from the two drying systems followed a similar pattern, solar-dried shrimp absorbed moisture more rapidly. The results have demonstrated that different approaches to drying may affect the physical and nutritional quality of shrimp meat differently.

Effects of drying methods on color retention and chlorophyll of celery (ApiumgraveolensL.), spinach (Spinacia oleraceaL.), Malabar spinach (Basella albaL.)

2020 ◽  
pp. 53-61
Author(s):  
Dat Q Tran
Keyword(s):  
Microwave Drying ◽  
Drying Methods ◽  
Hot Air Drying ◽  
Drying Time ◽  
Air Drying ◽  
Color Retention ◽  
Hot Air ◽  
Drying Techniques ◽  
Dried Vegetables

Dried vegetables are considered convenient for storage, transportation and preservation. The different drying techniques could influence the quality of resulting products. This study aimed to evaluate the effects of three distinguish drying methods as hot-air drying, foam-mat drying and microwave drying on the color retention and chlorophyll of green vegetables powder. Fresh spinach(Spinacia oleraceaL.), celery (Apium graveolensL.), Malabar spinach (Basella albaL.) were dried by different methods: hot air at 60oC, foam-mat at 60oC and microwave at 270 W until the samples reached approximately 9% of moisture content (wb). The drying time of the dried samples by microwave, foam-mat and hot-air method were 60, 210 and 240 min, respectively. Foam-mat dried vegetables were found to have the best quality in terms of color and the residual chlorophyll content. The findings suggest that foam-mat drying is promising in dried vegetable processing

scholarly journals Rehydration Characteristics of Mushrooms using Different Drying Techniques

2021 ◽  
pp. 87-91
Author(s):  
Yesubabu Vinnakota ◽  
Nagalakshmi Yarlagadda
Keyword(s):  
Drying Methods ◽  
Expert Committee ◽  
Sensory Assessment ◽  
Rehydration Ratio ◽  
Organoleptic Evaluation ◽  
Sun Drying ◽  
Quality Retention ◽  
Drying Techniques ◽  
Tray Drying

Mushroom may be baked, fried, boiled, creamed, roasted, pickled and stuffed. In India, it is mainly consumed fresh and a negligible amount is used for processing. They can be processed as canned, dried and frozen mushrooms. The dried mushrooms are packed in hermetically sealed air tight tins for quality retention and stored in a cool dry place. The study’s main objective is to know the effect of different drying methods on the quality of mushrooms and its dehydration, rehydration characteristics. Sun-drying and Cabinet tray drying methods were selected in the study. The rehydration ratio and coefficient of rehydration were calculated and compared for both the drying methods. An expert Committee did an Organoleptic evaluation. The results showed that cabinet tray dried mushrooms were reconstituted better compared to the sundried ones. The values of coefficient of rehydration and the rehydration ratio for cabinet dried mushrooms were found as 0.498 and 1:3.3 which were higher than sundried mushrooms. Cabinet tray dried mushrooms showed it’s superiority in sensory assessment. The study concluded that mushrooms dehydrated by the cabinet tray drying have better rehydration characteristics than sun drying.

scholarly journals Effects of low temperature drying processing on longan fruit

2018 ◽  
Vol 192 ◽  
pp. 03024
Author(s):  
Thadchapong Pongsuttiyakorn ◽  
Pachareeporn trusphimai ◽  
Pitikhate Sooraksa ◽  
Pimpen Pornchaloempong
Keyword(s):  
Drying Rate ◽  
Suitable Model ◽  
Moisture Removal ◽  
Browning Index ◽  
Air Temperatures ◽  
Constant Rate ◽  
Drying Techniques ◽  
Rate Period ◽  
Low Temperature Drying

In this study, the single-stage drying in tray dryer at air temperatures of 40, 50, 60, 70 and 80°C is modelled and investigated. The longan fruits, E-dor variety, are peeled and seeded before testing. The drying rate is significantly influenced by the drying techniques and temperatures. Drying rats are initialized adjustment constant rate periods at 60 70 and 80°C. The rate of moisture removal is rapidly changed drastically during the falling rate period. The Midilli model with high R2 and low χ2 and RMSE is the most suitable model for predictability of longan drying. Variation rates of quality of the water activity, the shrinkage, and the browning index are also reported.

scholarly journals Comparison of Traditional and Novel Drying Techniques and Its Effect on Quality of Fruits, Vegetables and Aromatic Herbs

Foods ◽  
2020 ◽  
Vol 9 (9) ◽  
pp. 1261
Author(s):  
Ángel Calín-Sánchez ◽  
Leontina Lipan ◽  
Marina Cano-Lamadrid ◽  
Abdolreza Kharaghani ◽  
Klaudia Masztalerz ◽  
...  
Keyword(s):  
Plant Material ◽  
Quality Parameters ◽  
Raw Material ◽  
Drying Methods ◽  
Drying Techniques ◽  
Material Volume ◽  
Review Reports ◽  
Combined Technique ◽  
Aromatic Herbs

Drying is known as the best method to preserve fruits, vegetables, and herbs, decreasing not only the raw material volume but also its weight. This results in cheaper transportation and increments the product shelf life, limiting the food waste. Drying involves the application of energy in order to vaporize and mobilize the moisture content within the porous products. During this process, the heat and mass transfer occurs simultaneously. The quality of dehydrated fruits, vegetables, and aromatic herbs is a key problem closely related to the development and optimization of novel drying techniques. This review reports the weaknesses of common drying methods applied for fruits, vegetables, and aromatic herbs and the possible options to improve the quality of dried products using different drying techniques or their combination. The quality parameters under study include color, bulk density, porosity, shrinkage, phytochemicals, antioxidant capacity, sugars, proteins, volatile compounds, and sensory attributes. In general, drying leads to reduction in all studied parameters. However, the behavior of each plant material is different. On the whole, the optimal drying technique is different for each of the materials studied and specific conditions must be recommended after a proper evaluation of the drying protocols. However, a novel or combined technique must assure a high quality of dried products. Furthermore, the term quality must englobe the energy efficiency and the environmental impact leading to production of sustainable dried products.

Comparison of Drying Characteristics and Quality of Shiitake Mushrooms (Lentinus edodes) Using Different Drying Methods

2014 ◽  
Vol 32 (15) ◽  
pp. 1751-1761 ◽  
Author(s):  
Lin-Lin Qi ◽  
Min Zhang ◽  
Arun S. Mujumdar ◽  
Xiang-Yong Meng ◽  
Hui-Zhi Chen
Keyword(s):  
Drying Methods ◽  
Lentinus Edodes ◽  
Drying Characteristics ◽  
Shiitake Mushrooms

Pre-Drying Effect and Quality Change of Rough Rice under Hot Air-Assisted Radio Frequency Disinfestation Treatment

2021 ◽  
Vol 37 (6) ◽  
pp. 1045-1054
Author(s):  
Windi Damayanti ◽  
Meiji Liao ◽  
Yuanrong Xu ◽  
Pu Jing ◽  
Shunshan Jiao
Keyword(s):  
Moisture Content ◽  
Radio Frequency ◽  
Moisture Loss ◽  
Total Phenolic ◽  
Moisture Removal ◽  
Drying Method ◽  
Quality Change ◽  
Hot Air ◽  
Rough Rice

HighlightsHA-RF disinfestation treatment had better pre-drying effect of rough rice than that of HA treatmentHighest moisture loss (8.7%) was obtained for samples with highest IMC (39.6% d.b.)Initial moisture content (IMC) correlated negatively with milling quality of rough riceHA-RF can be used as a pre-drying method to partially reduce the moisture contentAbstract.Hot air-assisted radio frequency (HA-RF) is an environmentally friendly disinfestation method, which can completely control the insects and meanwhile maintain quality of rough rice. In this study, the pre-drying effect of HA-RF disinfestation treatment of rough rice with different initial moisture contents (IMCs) (16.7%, 24.8%, 34.7%, and 39.6% d.b.) was investigated along with associated quality change. HA-RF treatments had better pre-drying effect of rough rice with various IMCs than that of hot air (HA) treatment and larger electrode gap obtained lower moisture removal. IMCs of rough rice also influenced the moisture removal for HA-RF treatments, and the corresponding moisture loss were 4.3%, 5.3%, 6.1%, and 8.7% for the treated rough rice with IMC of 16.7%, 24.8%, 34.7%, and 39.6%, respectively. More quality loss was observed for the rough rice with higher IMC, especially for broken rate, fissure, and water uptake ratio. HA-RF treatment had no influences on total phenolic acids, protein, and fat contents, but amylose and vitamin E contents were affected. Non-milled rice treated by HA-RF had an obvious decrease in the lightness (L*) except for the samples with highest IMC (39.6%). RF disinfestation treatment can be used as a pre-drying method to partially reduce the moisture content (MC) of rough rice. Keywords: Disinfestation, Moisture content, Pre-drying, Quality, Rough rice.

scholarly journals Investigation of Solar Drying of Ginger (Zingiber officinale): Emprical Modelling, Drying Characteristics, and Quality Study

2014 ◽  
Vol 2014 ◽  
pp. 1-7 ◽  
Author(s):  
A. Waheed Deshmukh ◽  
Mahesh N. Varma ◽  
Chang Kyoo Yoo ◽  
Kailas L. Wasewar
Keyword(s):  
Energy Requirement ◽  
Initial Moisture Content ◽  
Food Preservation ◽  
Convective Drying ◽  
Drying Methods ◽  
Solar Drying ◽  
Drying Time ◽  
Drying Characteristics ◽  
Solar Dryer ◽  
Thin Layer Drying

Drying is a simultaneous heat and mass transfer energy intensive operation, widely used as a food preservation technique. In view of improper postharvest methods, energy constraint, and environmental impact of conventional drying methods, solar drying could be a practical, economical, and environmentally reliable alternative. In the present paper applicability of mixed mode solar cabinet dryer was investigated for drying of commercially important and export oriented ginger. Freshly harvested ginger slices were successfully dried from initial moisture content of 621.50 to 12.19% (d.b.) and their drying characteristics, quality parameters, and kinetics were evaluated. The results showed that present solar dryer could be successfully applied for drying of ginger in view of quality, reduced drying time, and zero energy requirement as compared to conventional open sun drying and convective drying techniques, respectively. Drying curves showed that drying occurred in falling rate period and no constant period was observed. The effective moisture diffusivity was determined by using Fick’s second law and found to be 1.789×10-9 m2/s. The drying data was fitted to five thin layer drying models and compared using statistical criteria. Page model was found to be most suitable to describe the drying kinetics of ginger in solar dryer under natural convection among the tested models.

scholarly journals Effects of drying as a preservation technique on nutrient contents of beef

1970 ◽  
Vol 7 (1) ◽  
pp. 63-68 ◽  
Author(s):  
S Akhter ◽  
M Rahman ◽  
MM Hossain ◽  
MA Hashem
Keyword(s):  
Storage Time ◽  
Nutrient Content ◽  
Ash Content ◽  
Meat Sample ◽  
Drying Methods ◽  
Nutrient Contents ◽  
Physical And Chemical ◽  
Cooked Meat ◽  
Preservation Technique

Effects of different drying methods (sun drying, oven drying & rural cooker smoking) and meat size (block, flat & mince) on the nutrient content of beef was investigated with cooked cured (CC) or non-cooked cured (NC) beef. Both physical and chemical assessment were done to assess the quality of meat. Organoleptically all the samples were in acceptable condition upto 120 days of storage time. The initial (30 days) DM, CP, EE and ash content, of the samples (g/100 g DM) were ranged from 81.32-90.00, 69.00-80.16, 2.90-5.23 and 15.00-18.01, respectively. The DM, CP and EE decreased and ash content increased with increasing storage time. At the end of 120 days of storage the DM, CP, EE and ash content of the samples (g/100 g DM) ranged from 79.00-87.36, 67.24-77.92, 1.90 - 4.00 and 19.00 - 24.70, respectively. DM and CP content in cooked meat was higher than non-cooked meat. However, cooked meat contains less EE and ash value than non-cooked meat. At the end of storing time rural smoked cooked block contain highest protein (77.92%) and oven dried non-cooked mince meat (67.24%) contain lowest protein percent. Statistical analysis revealed that there was a significant (P<0.5 to 0.01) effect of drying methods and meat size on cooked or non-cooked meat. The nutrient contents of meat sample degraded significantly (P<0.05 to 0.01) with the elapse of storage time. The quality decreasing trend was lower in smoked, cooked, flat size meat sample. From this study it was observed that rural cooker smoking method of meat drying could be a useful technique of meat preservation. Keywords: Drying methods; Meat sizes; Beef preservation; Nutrient content DOI: 10.3329/jbau.v7i1.4800 J. Bangladesh Agril. Univ. 7(1): 63-68, 2009

Sign in / Sign up

Export Citation Format

Share Document