The asymptotic strength distribution of a general fiber bundle

1973 ◽  
Vol 5 (2) ◽  
pp. 200-216 ◽  
Author(s):  
S. Leigh Phoenix ◽  
Howard M. Taylor

The asymptotic statistical distribution of tensile strength of a bundle of parallel fibers is determined in terms of the statistical characteristics of the individual fibers as the number of fibers in the bundle grows indefinitely large.

1973 ◽  
Vol 5 (02) ◽  
pp. 200-216 ◽  
Author(s):  
S. Leigh Phoenix ◽  
Howard M. Taylor

The asymptotic statistical distribution of tensile strength of a bundle of parallel fibers is determined in terms of the statistical characteristics of the individual fibers as the number of fibers in the bundle grows indefinitely large.


2007 ◽  
Vol 334-335 ◽  
pp. 805-808 ◽  
Author(s):  
Naveed A. Siddiqui ◽  
Jang Kyo Kim ◽  
Farjaad Muzaffar ◽  
Arshad Munir

This paper reports a study based on a novel concept of ‘self-healing’ coatings applied onto the brittle fibre surface to reduce the stress concentrations and thus to improve the reinforcing efficiency in a composite. The individual E-glass fibres as well as rovings were coated with a carbon nanotube (CNT) reinforced epoxy composite. The tensile strengths were measured for the individual and bundle fibres, which were treated statistically to determine the Weibull parameters and thus to evaluate the notch sensitivity of the fibres with and without coating. The results indicate that the tensile strength of the individual fibre increased by 10% after coating with neat epoxy. Coating with epoxy nanocomposite containing 0.3wt% MWNT further improved the tensile strength. However, increasing the nanotube content was not necessarily beneficial due to the formation of nanotube agglomerates within the matrix. The tensile tests on fibre roving also showed a clear trend of beneficial effect of nanocomposite impregnation on tensile strength. The rovings impregnated with nanocomposite exhibited a more uniform strength distribution and higher strengths than those impregnated with neat epoxy. Changes in prevailing failure mechanisms influenced by the epoxy and nanocomposite coatings are identified.


1992 ◽  
Vol 59 (4) ◽  
pp. 909-914 ◽  
Author(s):  
Per C. Hemmer ◽  
Alex Hansen

A bundle of many parallel fibers, with stochastically distributed thresholds for individual fibers, is loaded until complete failure. Equal load sharing is assumed. During the breakdown process, bursts of several fibers breaking simultaneously at a given load occur. We determine the expected number of such bursts before complete failure, as well as the frequency of bursts in which Δ fibers break simultaneously. This distribution follows asymptotically a universal power-law Δ−5/2, for any statistical distribution of the individual fiber strengths.


Author(s):  
W. Tillmann ◽  
L. Wojarski ◽  
T. Henning

AbstractEven though the buildup rate of laser powder bed fusion processes (LPBF) has steadily increased in recent years by using more and more powerful laser systems, the production of large-volume parts is still extremely cost-intensive. Joining of an additively manufactured complex part to a high-volume part made of conventional material is a promising technology to enhance economics. Today, constructors have to select the most economical joining process with respect to the individual field of application. The aim of this research was to investigate the hybrid joint properties of LBPF and conventionally casted 18MAR300 nickel maraging steel depending on the manufacturing process and the heat treatment condition. Therefore, the microstructure and the strength of the hybrid joints manufactured by LPBF or vacuum brazing were examined and compared to solid material and joints of similar material. It was found that the vacuum-brazed hybrid joints using a 50.8-μm-thick AuNi18 foil provide a high tensile strength of 904 MPa which is sufficient for a broad field of application. Furthermore, the additively manufactured hybrid samples offered with 1998 MPa a tensile strength more than twice as high but showed a considerable impact of buildup failures to the strength in general.


Author(s):  
R. SANTOSH KUMAR ◽  
ANNU KUMARI ◽  
B. KUSUMA LATHA ◽  
PRUDHVI RAJ

Objective: The aim of the current research is optimization, preparation and evaluation of starch tartrate (novel super disintegrant) and preparation of fast dissolving oral films of cetirizine dihydrochloride by employing starch tartrate. Methods: To check the drug excipient compatibility studies of the selected drug (Cetrizine dihydrochloride) and the prepared excipient i. e starch tartrate, different studies like FTIR (Fourier-transform infrared spectroscopy), DSC (Differential scanning calorimetry) and thin-layer chromatography (TLC) were carried out to find out whether there is any interaction between cetirizine dihydrochloride and starch tartrate. The solvent casting method was used for the preparation of fast dissolving films. The prepared films were then evaluated for thickness, folding endurance, content uniformity, tensile strength, percent elongation, in vitro disintegration time and in-vitro dissolution studies. Response surface plots and contour plots were also plotted to know the individual and combined effect of starch tartrate (A), croscarmellose sodium (B) and crospovidone (C) on disintegration time and drug dissolution efficiency in 10 min (dependent variables). Results: Films of all the formulations are of good quality, smooth and elegant by appearance. Drug content (100±5%), thickness (0.059 mm to 0.061 mm), the weight of films varies from 51.33 to 58.06 mg, folding endurance (52 to 67 times), tensile strength (10.25 to 12.08 N/mm2). Fast dissolving films were found to disintegrate between 34 to 69 sec. Percent dissolved in 5 min were found to be more in F1 formulation which confirms that starch tartrate was effective at 1%. Conclusion: From the research conducted, it was proved that starch tartrate can be used in the formulation of fast dissolving films of cetirizine dihydrochloride. The disintegration time of the films was increased with increase in concentration of super disintegrant.


2014 ◽  
Vol 49 (25) ◽  
pp. 3157-3168 ◽  
Author(s):  
Jian Song ◽  
Weidong Wen ◽  
Haitao Cui ◽  
Sibo Zhao

2012 ◽  
Vol 57 (4) ◽  
pp. 1201-1210 ◽  
Author(s):  
M. Prażmowski ◽  
H. Paul

This study focuses on the effect of the stand-off distance between the bonded plates on the properties of zirconium (Zr700) - steel (P355NL2) bimetal produced by explosion welding. Bonding trials were carried out in parallel arrangement at constant detonation velocity. The analyses of microstructural transformations occurring in the bond zone and mechanical properties of the clad were performed for as-bonded welds, i.e. immediately following explosion welding. A general description of the obtained welds was made (height and length of the wave was determined) and the quantitative fraction of the melt zones was calculated along the bond’s length. Using optical microscopy and scanning electron microscopy (SEM) enabled the assessment of the quality of the formed bonds, initial identification of phases and quantitative analysis of the individual phases on the longitudinal section. The microhardness results were used in the analysis of hardening changes at the interface area. The completed research proves the potential to obtain a proper bond for zirconium/carbon steel sheets. A strong effect of the stand-off distance on the strength properties of the fabricated plates was observed, and the ’direction’ of these transformations was pointed out. Optical microscopy and SEM examinations allowed determining the characteristic of the bond interface for diverse stand-off distances. It was established that increasing the stand-off distance between the plates causes the reduction of the melt area along the length of the bond, which improves strength properties of the bimetal. The analysis of the strength distribution performed based on the microhardness measurements showed that the changes occur within the distances up to 500µm from the bond interface and the highest hardening, for both zirconium and steel, is directly at the interface and then successively decreases.


Solid Earth ◽  
2019 ◽  
Vol 10 (5) ◽  
pp. 1519-1540
Author(s):  
Marisol Monterrubio-Velasco ◽  
F. Ramón Zúñiga ◽  
José Carlos Carrasco-Jiménez ◽  
Víctor Márquez-Ramírez ◽  
Josep de la Puente

Abstract. Earthquake aftershocks display spatiotemporal correlations arising from their self-organized critical behavior. Dynamic deterministic modeling of aftershock series is challenging to carry out due to both the physical complexity and uncertainties related to the different parameters which govern the system. Nevertheless, numerical simulations with the help of stochastic models such as the fiber bundle model (FBM) allow the use of an analog of the physical model that produces a statistical behavior with many similarities to real series. FBMs are simple discrete element models that can be characterized by using few parameters. In this work, the aim is to present a new model based on FBM that includes geometrical characteristics of fault systems. In our model, the faults are not described with typical geometric measures such as dip, strike, and slip, but they are incorporated as weak regions in the model domain that could increase the likelihood to generate earthquakes. In order to analyze the sensitivity of the model to input parameters, a parametric study is carried out. Our analysis focuses on aftershock statistics in space, time, and magnitude domains. Moreover, we analyzed the synthetic aftershock sequences properties assuming initial load configurations and suitable conditions to propagate the rupture. As an example case, we have modeled a set of real active faults related to the Northridge, California, earthquake sequence. We compare the simulation results to statistical characteristics from the Northridge sequence determining which range of parameters in our FBM version reproduces the main features observed in real aftershock series. From the results obtained, we observe that two parameters related to the initial load configuration are determinant in obtaining realistic seismicity characteristics: (1) parameter P, which represents the initial probability order, and (2) parameter π, which is the percentage of load distributed to the neighboring cells. The results show that in order to reproduce statistical characteristics of the real sequence, larger πfrac values (0.85<πfrac<0.95) and very low values of P (0.0<P≤0.08) are needed. This implies the important corollary that a very small departure from an initial random load configuration (computed by P), and also a large difference between the load transfer from on-fault segments than by off-faults (computed by πfrac), is required to initiate a rupture sequence which conforms to observed statistical properties such as the Gutenberg–Richter law, Omori law, and fractal dimension.


Sign in / Sign up

Export Citation Format

Share Document