Different organic loading rates on the biogas production during the anaerobic digestion of rice straw: A pilot study

2017 ◽  
Vol 244 ◽  
pp. 865-871 ◽  
Author(s):  
Jun Zhou ◽  
Jun Yang ◽  
Qing Yu ◽  
Xiaoyu Yong ◽  
Xinxin Xie ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Pilot Study ◽  
Rice Straw ◽  
Biogas Production ◽  
Organic Loading ◽  
Loading Rates

scholarly journals Performance of Anaerobic Digestion of Chicken Manure Under Gradually Elevated Organic Loading Rates

2019 ◽  
Vol 16 (12) ◽  
pp. 2239 ◽  
Author(s):  
Fei Wang ◽  
Mengfu Pei ◽  
Ling Qiu ◽  
Yiqing Yao ◽  
Congguang Zhang ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Poultry Manure ◽  
Ammonia Nitrogen ◽  
Methane Content ◽  
Chicken Manure ◽  
Continuous Stirred Tank Reactor ◽  
Organic Loading ◽  
Biogas Yield ◽  
Loading Rates

Poultry manure is the main source of agricultural and rural non-point source pollution, and its effective disposal through anaerobic digestion (AD) is of great significance; meanwhile, the high nitrogen content of chicken manure makes it a typical feedstock for anaerobic digestion. The performance of chicken-manure-based AD at gradient organic loading rates (OLRs) in a continuous stirred tank reactor (CSTR) was investigated herein. The whole AD process was divided into five stages according to different OLRs, and it lasted for 150 days. The results showed that the biogas yield increased with increasing OLR, which was based on the volatile solids (VS), before reaching up to 11.5 g VS/(L·d), while the methane content was kept relatively stable and maintained at approximately 60%. However, when the VS was further increased to 11.5 g VS/(L·d), the total ammonia nitrogen (TAN), pH, and alkalinity (CaCO3) rose to 2560 mg·L−1, 8.2, and 15,000 mg·L−1, respectively, while the volumetric biogas production rate (VBPR), methane content, and VS removal efficiency decreased to 0.30 L·(L·d)−1, 45%, and 40%, respectively. Therefore, the AD performance immediately deteriorated and ammonia inhibition occurred. Further analysis demonstrated that the microbial biomass yield and concentrations dropped dramatically in this period. These results indicated that the AD stayed steady when the OLR was lower than 11.5 g VS/(L·d); this also provides valuable information for improving the efficiency and stability of AD of a nitrogen-rich substrate.

Biogas Production and Microbial Community Dynamics during the Anaerobic Digestion of Rice Straw at 39–50 °C: A Pilot Study

2018 ◽  
Vol 32 (4) ◽  
pp. 5157-5163 ◽  
Author(s):  
Qing Yu ◽  
Zhenzhen Tian ◽  
Jingyuan Liu ◽  
Jun Zhou ◽  
Zhiying Yan ◽  
...  
Keyword(s):  
Microbial Community ◽  
Anaerobic Digestion ◽  
Pilot Study ◽  
Rice Straw ◽  
Community Dynamics ◽  
Biogas Production ◽  
Microbial Community Dynamics

Comparison of One-Phase and Two-Phase Anaerobic Digestion of Swine Manure

2013 ◽  
Vol 726-731 ◽  
pp. 2875-2880
Author(s):  
Wen Hao Liu ◽  
Shi Jie Tian ◽  
Shu Biao Wu ◽  
Xiao Qian Zhang ◽  
Chang Le Pang ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Swine Manure ◽  
Continuous Stirred Tank Reactor ◽  
Organic Loading ◽  
Two Phase ◽  
Biogas Yield ◽  
Loading Rates ◽  
Significant Difference ◽  
The One

The possible exploitation of two-phase anaerobic digestion for swine manure was investigated in this study. One-phase and two-phase anaerobic digestion process were investigated in continuous stirred-tank reactor with hydraulic retention times 15 days (hydrolysis and acidification for 3 days and methanogenic12 days in two-phase). When the organic loading rates were equal to or less than 4 g VS/L day, the biogas yield and volumetric production of two processes were no significant difference. However, in the case of organic loading rates being equal to or higher than 5.0 g VS/L day, two-phase biogas yield and volumetric biogas production averaged 0.294 L CH4/g VS added and 2.218 L/L day, compared with one-phase averaged 0.255L CH4/g VS added and 2.168 L/L day, respectively. Significant advantages in saving cost of biogas project were indicated by the comparison of biogas production and COD degradation in the one-phase and two-phase processes.

Biogas production from chicken manure at different organic loading rates in a mesophilic full scale anaerobic digestion plant

2020 ◽  
Vol 141 ◽  
pp. 105693 ◽  
Author(s):  
Linas Jurgutis ◽  
Alvyra Slepetiene ◽  
Jonas Volungevicius ◽  
Kristina Amaleviciute-Volunge
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Full Scale ◽  
Chicken Manure ◽  
Organic Loading ◽  
Loading Rates

Insights into organic loading rates of anaerobic digestion for biogas production: a review

2021 ◽  
pp. 1-21
Author(s):  
Rosina Nkuna ◽  
Ashira Roopnarain ◽  
Charles Rashama ◽  
Rasheed Adeleke
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Organic Loading ◽  
Loading Rates

Anaerobic co-digestion of winery waste and waste activated sludge: assessment of process feasibility

2013 ◽  
Vol 69 (2) ◽  
pp. 269-277 ◽  
Author(s):  
C. Da Ros ◽  
C. Cavinato ◽  
F. Cecchi ◽  
D. Bolzonella
Keyword(s):  
Activated Sludge ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Pilot Scale ◽  
Waste Activated Sludge ◽  
Organic Loading ◽  
Operational Conditions ◽  
Loading Rates ◽  
Thermophilic Conditions ◽  
Soluble Chemical Oxygen Demand

In this study the anaerobic co-digestion of wine lees together with waste activated sludge in mesophilic and thermophilic conditions was tested at pilot scale. Three organic loading rates (OLRs 2.8, 3.3 and 4.5 kgCOD/m3d) and hydraulic retention times (HRTs 21, 19 and 16 days) were applied to the reactors, in order to evaluate the best operational conditions for the maximization of the biogas yields. The addition of lee to sludge determined a higher biogas production: the best yield obtained was 0.40 Nm3biogas/kgCODfed. Because of the high presence of soluble chemical oxygen demand (COD) and polyphenols in wine lees, the best results in terms of yields and process stability were obtained when applying the lowest of the three organic loading rates tested together with mesophilic conditions.

scholarly journals Bioenergy recovery from cattle wastewater in an UASB-AF hybrid reactor

2017 ◽  
Vol 76 (9) ◽  
pp. 2268-2279 ◽  
Author(s):  
Henrique Vieira de Mendonça ◽  
Jean Pierre Henry Balbaud Ometto ◽  
Marcelo Henrique Otenio ◽  
Alberto José Delgado dos Reis ◽  
Isabel Paula Ramos Marques
Keyword(s):  
Biogas Production ◽  
Upflow Anaerobic Sludge Blanket ◽  
Hybrid Reactor ◽  
Anaerobic Sludge ◽  
The Novel ◽  
Organic Loading ◽  
Loading Rates ◽  
Volatile Solids ◽  
Anaerobic Sludge Blanket

Abstract New data on biogas production and treatment of cattle wastewater were registered using an upflow anaerobic sludge blanket-anaerobic filter (UASB-AF) hybrid reactor under mesophilic temperature conditions (37 °C). The reactor was operated in semi-continuous mode with hydraulic retention times of 6, 5, 3 and 2 days and organic loading rates of 3.8, 4.6, 7.0 and 10.8 kg CODt m−3 d−1. Biogas volumes of 0.6–0.8 m3 m−3 d−1 (3.8–4.6 kg CODt m−3 d−1) and 1.2–1.4 m3 m−3 d−1 (7.0–10.8 kg CODt m−3 d−1), with methane concentrations between 69 and 75%, were attained. The removal of organic matter with values of 60–81% (CODt) and 51–75% (CODs) allowed methane yields of 0.155–0.183 m3 CH4 kg−1 CODt and 0.401–0.513 m3 CH4 kg−1 CODs to be obtained. Volatile solids were removed in 34 to 69%, with corresponding methane yields of 0.27 to 0.42 m3 CH4 kg−1 VSremoved. The good performance of the novel hybrid reactor was demonstrated by biogas outputs higher than reported previously in the literature, along with the quality of the gas obtained in the various experimental phases. The hybrid reactor investigated in this study presents comparative advantages, particularly in relation to conventional complete mixture units, considering economic factors such as energy consumption, reactor volume and installation area.

Sign in / Sign up

Export Citation Format

Share Document