scholarly journals Experimental Study on a Ceramic Membrane Condenser with Air Medium for Water and Waste Heat Recovery from Flue Gas

Membranes ◽  
2021 ◽  
Vol 11 (9) ◽  
pp. 701
Author(s):  
Da Teng ◽  
Liansuo An ◽  
Guoqing Shen ◽  
Shiping Zhang ◽  
Heng Zhang
Keyword(s):  
Flue Gas ◽  
Negative Pressure ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Ceramic Membrane ◽  
Waste Heat ◽  
Outlet Temperature ◽  
Water Recovery ◽  
Cooling Medium ◽  
Transfer Characteristics

Ceramic membrane condensers that are used for water and waste heat recovery from flue gas have the dual effects of saving water resources and improving energy efficiency. However, most ceramic membrane condensers use water as the cooling medium, which can obtain a higher water recovery flux, but the waste heat temperature is lower, which is difficult to use. This paper proposes to use the secondary boiler air as the cooling medium, build a ceramic membrane condenser with negative pressure air to recover water and waste heat from the flue gas, and analyze the transfer characteristics of flue gas water and waste heat in the membrane condenser. Based on the experimental results, it is technically feasible for the ceramic membrane condenser to use negative pressure air as the cooling medium. The flue gas temperature has the most obvious influence on the water and heat transfer characteristics. The waste heat recovery is dominated by latent heat of water vapor, accounting for 80% or above. The negative pressure air outlet temperature of the ceramic membrane condenser can reach 50.5 °C, and it is in a supersaturated state. The research content of this article provides a new idea for the water and waste heat recovery from flue gas.

A novel lignite pre-drying system integrated with flue gas waste heat recovery at lignite-fired power plants

2019 ◽  
Vol 150 ◽  
pp. 200-209 ◽  
Author(s):  
Min Yan ◽  
Chunyuan Ma ◽  
Qiuwan Shen ◽  
Zhanlong Song ◽  
Jingcai Chang
Keyword(s):  
Flue Gas ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Power Plants ◽  
Waste Heat ◽  
Drying System

A study on air-cooling waste heat recovery from molten slag of slag-tap boilers

2017 ◽  
Vol 231 (5) ◽  
pp. 371-381
Author(s):  
Lei Deng ◽  
Chunli Tang ◽  
Xiaowen Tan ◽  
Ke Sun ◽  
Song Wu ◽  
...  
Keyword(s):  
Flue Gas ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Molten Slag ◽  
Waste Heat ◽  
Ash Content ◽  
Air Cooling ◽  
Air Preheater ◽  
Hot Air ◽  
Secondary Air

For a better utilization of Zhundong coals which have high fouling and slagging tendency, the slag-tap boiler has attracted much attention. To avoid the high sensible heat loss of discharged molten slag, an air-cooling waste heat recovery system is proposed. Energy and economic analyses are conducted to investigate the effectiveness of heating the desulfurized flue gas by hot air and the influences of partially substituting the secondary air by hot air on heat transfer of air preheater and thermal efficiency of boiler. A case study is performed by referring to a typical 50 MW cyclone boiler with nine types of low fusion temperature coals. The results show that for coals with low ash content, the temperature increment of desulfurized flue gas can be over 7 ℃. While for coals with high ash content, the flue gas temperature can be heated to more than 70 ℃, and the surplus hot air can be sent to the furnace. When the hot air is introduced to partially substitute the secondary air, an instantaneous impact on the air preheater will give rise to a decrement of quantity of heat transferred and increments of temperatures of exit flue gas and hot secondary air. The variations of these thermodynamic parameters become smaller with increasing hot air temperature. After introduction of hot air, the thermal efficiency of boiler can increase, resulting in a decrease of fuel consumption rate. In addition, the heating surface area of air preheater can be reduced.

Novel flue gas waste heat recovery system equipped with enthalpy wheel

2019 ◽  
Vol 196 ◽  
pp. 649-663 ◽  
Author(s):  
Yiyu Men ◽  
Xiaohua Liu ◽  
Tao Zhang ◽  
Xi Xu ◽  
Yi Jiang
Keyword(s):  
Flue Gas ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Waste Heat Recovery System ◽  
Recovery System ◽  
Heat Recovery System

Application of a low pressure economizer for waste heat recovery from the exhaust flue gas in a 600 MW power plant

Energy ◽  
2012 ◽  
Vol 48 (1) ◽  
pp. 196-202 ◽  
Author(s):  
Chaojun Wang ◽  
Boshu He ◽  
Shaoyang Sun ◽  
Ying Wu ◽  
Na Yan ◽  
...  
Keyword(s):  
Power Plant ◽  
Flue Gas ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Low Pressure

The Comparison and Analysis of the System Utilizing the General Boiler Flue Gas Waste Heat

2014 ◽  
Vol 926-930 ◽  
pp. 829-832
Author(s):  
Yan Feng Liu ◽  
Peng Cheng Wang ◽  
Shao Shan Zhang
Keyword(s):  
Low Temperature ◽  
Flue Gas ◽  
Heat Recovery ◽  
Waste Heat Recovery ◽  
Waste Heat ◽  
Waste Heat Recovery System ◽  
Recovery System ◽  
Heat Recovery System ◽  
Comparison And Analysis ◽  
Gas Recycling

Flue gas recycling system is an effective way of saving energy and improving efficiency for coal-fired power plant. In this paper, the general low-temperature economizer, heat pipe type low temperature economizer, composite phase change heat recovery system are introduced. Combined with a 600MW unit parameters, the economies of various waste heat recovery system are compared.

Sign in / Sign up

Export Citation Format

Share Document