DEM Simulations on the Heat Conduction in a Particle Mixer

2012 ◽  
Vol 549 ◽  
pp. 908-913 ◽  
Author(s):  
Yu Peng Xu ◽  
Li Jie Cui ◽  
Xin Xin Ren ◽  
Wei Ge ◽  
Wei Gang Lin

Understanding the heat transfer among particles with uneven temperature distribution is a key to powder processing. In this work, the discrete element method (DEM) is used to optimize the interior structure of a particle mixer with multiple baffles to achieve better heat transfer between two particulate materials. The simulation results show that optimal values exist for the number of baffles and their widths, slope angles and spacing to enhance heat transfer. The results are helpful to the design of a variety of process such as the ultra-fast pyrolysis in “coal topping”.

1976 ◽  
Vol 16 (74) ◽  
pp. 308-309
Author(s):  
S.S. Grigoryan ◽  
M.S. Krass ◽  
P.A. Shumskiy

Abstract In the case of a non-isothermal glacier it is necessary to integrate the equations of dynamics together with the equation of heat conduction, heat transfer, and heat generation because of the interdependence (1) of strain-rate of ice on its temperature, and (2) of ice temperature on the rate of heat transfer by moving ice and on the intensity of heat generation in its strain. In view of the complexity of the whole system of equations, simplified mathematical models have been constructed for dynamically different glaciers. The present model concerns land glaciers with thicknesses much less than their horizontal dimensions and radii of curvature of large bottom irregularities, so that the method of a thin boundary layer may be used. The principal assumption is the validity of averaging over a distance of the order of magnitude of ice thickness. Two component shear stresses parallel to the bottom in glaciers of this type considerably exceed the normal stresses and the third shear stress, so the dynamics are described by a statically determined system of equations. For the general case, expressions for the stresses have been obtained in dimensionless affine orthogonal curvilinear coordinates, parallel and normal to the glacier bottom, and taking into account the geometry of the lower and upper surfaces. The statically undetermined problem for ice divides is solved using the equations of continuity and rheology, so the result for stresses depends considerably on temperature distribution. In the case of a flat bottom the dynamics of an ice divide is determined by the curvature of the upper surface. The calculation of the interrelating velocity and temperature distributions is made by means of the iteration of solutions (1) for the components of velocity from the stress expressions using the rheological equations (a power law or the more precise hyberbolic one) with the assigned temperature distribution, and (2) for the temperature with the assigned velocity distribution. The temperature distribution in the coordinate system used is determined by a parabolic equation with a small parameter at the principal derivative. Its solution is reduced to the solution of a system of recurrent non-uniform differential equations of the first order by means of a series expansion of the small parameter: the right part for the largest term of the expansion contains a function of the heat sources, and for the other terms it contains the second derivative along the vertical coordinate from the previous expansion term. Thus advection makes the main contribution to the heat transfer, and temperature in a glacier is distributed along the particle paths, changing simultaneously under the influence of heat generation. A relatively thin conducting boundary layer adjoins the upper and lower surfaces of a glacier, playing the role of a temperature damper in the ablation area. The equation of heat conduction (at the free surface) or of heat conduction and heat transfer (at the bottom) with the boundary conditions, and with the condition of the connection with the solution of the problem for the internal temperature distribution, is being solved for the boundary layer because of its small thickness. Beyond the limits of the boundary layer, heat conduction makes a small change in the temperature distribution, which can be calculated with any degree of accuracy.


1976 ◽  
Vol 16 (74) ◽  
pp. 308-309
Author(s):  
S.S. Grigoryan ◽  
M.S. Krass ◽  
P.A. Shumskiy

AbstractIn the case of a non-isothermal glacier it is necessary to integrate the equations of dynamics together with the equation of heat conduction, heat transfer, and heat generation because of the interdependence (1) of strain-rate of ice on its temperature, and (2) of ice temperature on the rate of heat transfer by moving ice and on the intensity of heat generation in its strain. In view of the complexity of the whole system of equations, simplified mathematical models have been constructed for dynamically different glaciers. The present model concerns land glaciers with thicknesses much less than their horizontal dimensions and radii of curvature of large bottom irregularities, so that the method of a thin boundary layer may be used. The principal assumption is the validity of averaging over a distance of the order of magnitude of ice thickness.Two component shear stresses parallel to the bottom in glaciers of this type considerably exceed the normal stresses and the third shear stress, so the dynamics are described by a statically determined system of equations. For the general case, expressions for the stresses have been obtained in dimensionless affine orthogonal curvilinear coordinates, parallel and normal to the glacier bottom, and taking into account the geometry of the lower and upper surfaces. The statically undetermined problem for ice divides is solved using the equations of continuity and rheology, so the result for stresses depends considerably on temperature distribution. In the case of a flat bottom the dynamics of an ice divide is determined by the curvature of the upper surface.The calculation of the interrelating velocity and temperature distributions is made by means of the iteration of solutions (1) for the components of velocity from the stress expressions using the rheological equations (a power law or the more precise hyberbolic one) with the assigned temperature distribution, and (2) for the temperature with the assigned velocity distribution. The temperature distribution in the coordinate system used is determined by a parabolic equation with a small parameter at the principal derivative. Its solution is reduced to the solution of a system of recurrent non-uniform differential equations of the first order by means of a series expansion of the small parameter: the right part for the largest term of the expansion contains a function of the heat sources, and for the other terms it contains the second derivative along the vertical coordinate from the previous expansion term.Thus advection makes the main contribution to the heat transfer, and temperature in a glacier is distributed along the particle paths, changing simultaneously under the influence of heat generation. A relatively thin conducting boundary layer adjoins the upper and lower surfaces of a glacier, playing the role of a temperature damper in the ablation area. The equation of heat conduction (at the free surface) or of heat conduction and heat transfer (at the bottom) with the boundary conditions, and with the condition of the connection with the solution of the problem for the internal temperature distribution, is being solved for the boundary layer because of its small thickness. Beyond the limits of the boundary layer, heat conduction makes a small change in the temperature distribution, which can be calculated with any degree of accuracy.


Author(s):  
Eisa Ahmadi ◽  
M. M. Aghdam ◽  
Nasrin Sheikhy

In this study a new meshless method is presented for the analysis of heat transfer in heterogeneous solid structures. The presented meshless method is based on the integral form of energy equation for the sub-particles in the domain of the material. A micromechanical model based on the presented meshless method is presented for analysis of heat transfer, temperature distribution and steady-state effective thermal conductivities of fiber-matrix type of composite materials. Because the domain integration is eliminated in the presented meshless formulation, the computational efforts in presented method are decreased substantially. A small area of the composite system called the representative volume element (RVE) is considered as the solution domain. The fully bonded fiber-matrix interface is considered and contact thermal resistant is neglected in the fiber-matrix interface and so the continuity of temperature and reciprocity of heat flux is satisfied in the fiber-matrix interface. A direct interpolation method is employed for enforcement the appropriate boundary conditions to the RVE. Numerical results are presented for temperature distribution, heat flux and thermal conductivity. Numerical results show that presented meshless method is simple, effective, accurate and less costly method in micromechanical modeling of heat conduction in heterogeneous materials.


2014 ◽  
Vol 529 ◽  
pp. 655-659
Author(s):  
Li Zhang ◽  
Yi Ming Lei

Accurate descripting the temperature distribution of stator bars for the genaraors with big capacity is necessary. The stator bar of one 600MW generator was simulated for getting the temperature distribution. Several methods of dealing with the insulations were compared. How the heat conduction performance of insulations is good for the heat transfer of stator bars was discussed.


2014 ◽  
Vol 35 (2) ◽  
pp. 37-49
Author(s):  
Magda Joachimiak ◽  
Michał Ciałkowski ◽  
Jarosław Bartoszewicz

Abstract The paper presents the results of calculations related to determination of temperature distributions in a steel pipe of a heat exchanger taking into account inner mineral deposits. Calculations have been carried out for silicate-based scale being characterized by a low heat transfer coefficient. Deposits of the lowest values of heat conduction coefficient are particularly impactful on the strength of thermally loaded elements. In the analysis the location of the thermocouple and the imperfection of its installation were taken into account. The paper presents the influence of determination accuracy of the heat flux on the pipe external wall on temperature distribution. The influence of the heat flux disturbance value on the thickness of deposit has also been analyzed.


2012 ◽  
Vol 479-481 ◽  
pp. 586-589
Author(s):  
Dan Dan Hao ◽  
Wen Sheng Liu ◽  
Le Ping Dang ◽  
Hong Yuan Wei

At present, the CFD numerical simulation, combined with an experiments involving heat transfer has become an important approach to studying coal carbonization. The aim of this paper is to illustrate how a standard CFD package may be modified so it can be used to simulate temperature distribution, coking time and carbonization processes that occur in coke oven charge. Content of volatile matters and moisture have important influence on heating rate during carbonization. Further, heating rate have effects on char structure an inner coking condition, as well as the carbonization time. In addition, furnace wall temperature have important effects on carbonization, because they can change the coking time. Our simulation results for the coke oven model are in agreement with experimental and virtual data.


Author(s):  
Yasser Shafiei-alamooti ◽  
Ali Ashrafizadeh

Heat leakage mechanisms need to be addressed in the thermal analysis of multi-stream heat exchangers due to their effects on the intended heat transfer between the streams. In this paper, multi-dimensional heat transfers between various fluid streams and also between the fluid and solid parts of a three-stream plate-fin heat exchanger is numerically modeled considering the variation of thermo-physical properties of both solid and fluid parts. All internal heat leak mechanisms, i.e. longitudinal heat conduction, transverse bypass through fins, and heat transfer reversal in a stream are taken into consideration. The distribution of longitudinal heat conduction along the stream’s separating plates (plates) is also explored. It is shown that the longitudinal heat conduction depends strongly on the variation of properties in some flow arrangements. For such cases, the plates experience areas with relatively low temperature, and a new longitudinal heat conduction, mainly induced by property variation, is identified and presented. This induced longitudinal conduction is close to 1% of the maximum heat exchange between the streams in this study. Another interesting result is that the longitudinal temperature distribution in the plates does not necessarily follow the temperature distribution along the nearby streams due to the entrance effects and unbalanced heat capacity rates. Numerical results show that property variations affect all of the thermal leakage phenomena and, therefore, need to be considered in the modeling and thermal analysis of multi-stream heat exchangers.


2011 ◽  
Vol 704-705 ◽  
pp. 412-418 ◽  
Author(s):  
Chao Chen ◽  
Cui Jiao Ding ◽  
De Gang Ouyang ◽  
Zhan Zeng Liu ◽  
Zhong Hua Song ◽  
...  

This paper presents a study of the temperature fields of steel slab in a walking beam furnace. To simulate the temperature distribution in the slab of heating-up process in heating furnace, a two-dimensional mathematical model was developed. The heat transfer in the furnace was very complex, so the model was developed on the assumptions that the temperature of each section of the furnace was unchangeable, the slab moved in the furnace in even velocity, the heat transfer between the slab and the walking beam was out of consideration, the longitudinal heat conduction of the slab and the effect of the scale on the heat conduction were neglected. The equations were calculated by the finite difference method. A black box experiment research was carried out to measure the temperature history of the slab as it passed through the furnace. The comparison of the calculated results with the measured results showed that the model worked well for simulating the temperature distribution of the slab in walking beam furnace. With this developed model, the optimizing of hot rolling and heating processes of steel slab can be investigated in the future.


2011 ◽  
Vol 704-705 ◽  
pp. 462-467
Author(s):  
Liang Jing Jing ◽  
Rui Li ◽  
Yu Yu Li

Heat transfer in wood particle controls the process of the pyrolysis. This paper makes a 2-D transient heat transfer model in cylindrical to predict the thermal behavior of wood particle in the process of fast pyrolysis. Wood anisotropy and thermophysical properties are considered in this model, as well as the influence of heat reaction on temperature distribution in wood particle. Based on the calculation of transient temperature in wood particle, and analysis of the temperature distribution during the process of wood fast pyrolysis at different time, this paper preliminarily discusses the optimization of parameters in wood particle fast pyrolysis. Keywords: pyrolysis, heat transfer, particle, wood


2020 ◽  
Vol 5 ◽  
Author(s):  
Collins O. Akeremale ◽  
Olusegun A Olaiju ◽  
Yeak Su Hoe

In the diagnosis and control of various thermal systems, the philosophy of heat fluxes, and temperatures are very crucial. Temperature as an integral property of any thermal system is understood and also, has well-developed measurement approaches. Though finite difference (FD) had been used to ascertain the distribution of temperature, however, this current article investigates the impact of finite element method (FEM) on temperature distribution in a square plate geometry to compare with finite difference approach. Most times, in industries, cold and hot fluids run through rectangular channels, even in many technical types of equipment. Hence, the distribution of temperature of the plate with different boundary conditions is studied. In this work, let’s develop a finite element method (code) for the solution of a closed squared aluminum plate in a two-dimensional (2D) mixed boundary heat transfer problem at different boundary conditions. To analyze the heat conduction problems, let’s solve the two smooth mixed boundary heat conduction problems using the finite element method and compare the temperature distribution of the plate obtained using the finite difference to that of the plate obtained using the finite element method. The temperature distribution of heat conduction in the 2D heated plate using a finite element method was used to justify the effectiveness of the heat conduction compared with the analytical and finite difference methods


Sign in / Sign up

Export Citation Format

Share Document