Detection of Early Stage of Fatigue Changes in Non-Alloy Steel Using Residual Magnetic Field Method

2020 ◽  
Vol 405 ◽  
pp. 277-281
Author(s):  
Patrycja Antonik-Popiołek ◽  
Jacek Głód ◽  
Zbigniew Jurasz ◽  
Janusz Juraszek

In this work, the fatigue of P265GH steel acc. to EN 10216-2 has been evaluated by measuring a residual magnetic field (RMF). During experiment the notched-specimen has been loaded with a servo-hydraulic uniaxial MTS test machine and a special magnetic sensor was applied. The measurement distribution of the residual magnetic field was performed in two axes. In the first stage of experiment the specimen was gradually loaded with quasi-static force in range of 0 to 16 kN (~ 0.7 Rm). The increase of strength of residual magnetic field was observed only from 0 to 8 kN, whereas in range 8 to 16 kN this effect was not noticed. In the second stage the controlled tensile fatigue test was performed (R = 0, Fmax = 16 kN). Up to 21k load cycles no changes to residual magnetic field were noticed. At 31k cycles the significant increase of amplitude of strength of residual magnetic field change was observed but visual inspection does not show any visible crack, while at 35k cycles crack was visible. It means that applied methodology allow to find the initiation of crack. The performed observation on SEM showed ductile fatigue of fracture.

2020 ◽  
Vol 6 (4) ◽  
pp. 3-9
Author(s):  
Victor Grigoryev ◽  
Lyudmila Ermakova ◽  
Anna Khlystova

We study the evolution of the photospheric magnetic field at the early stage of active region development. We use data on longitudinal component of the magnetic field and line-of-sight velocities from SOHO/MDI and SDO/HMI. The visual inspection of 48 cases of birth of active regions and the detailed analysis of the magnetic flux dynamics in 4 active regions have shown that at the time of emergence of a new magnetic field, the field of the following polarity is the first to be detected in the photosphere. The flux asymmetry of the leading and following polarities persists for several tens of minutes. The observed asymmetry of magnetic fluxes supports the results of the numerical simulation of emergence of the active region magnetic field in the upper layers of the convective zone, which has been carried out by Rempel and Cheung [2014].


Author(s):  
Yi Liu ◽  
Xiwang Lan ◽  
Bo Hu

To demonstrate the feasibility of the passive magnetic NDT method for damage assessment of 304 austenitic stainless steel, the residual magnetic field change of the 304 stainless steel specimens under fatigue loads was investigated. The measurement was carried out using a fluxgate sensor and the magnetic characteristics were extracted for analysis of fatigue state. Then, the XRD test was carried out to investigate the mechanism of magnetic field changes and verify the reliability of the proposed method. The results show that the variation of the maximum gradient is consistent with the process of fatigue crack growth, which indicates that the fatigue damage can be estimated by residual magnetic field measuring. In future stage, how to distinguish the magnetic field changes derived from martensite transformation or stress magnetization effect will be investigated.


2020 ◽  
Vol 6 (4) ◽  
pp. 3-9
Author(s):  
Victor Grigoryev ◽  
Lyudmila Ermakova ◽  
Anna Khlystova

We study the evolution of the photospheric magnetic field at the early stage of active region development. We use data on longitudinal component of the magnetic field and line-of-sight velocities from SOHO/MDI and SDO/HMI. The visual inspection of 48 cases of birth of active regions and the detailed analysis of the magnetic flux dynamics in 4 active regions have shown that at the time of emergence of a new magnetic field, the field of the following polarity is the first to be detected in the photosphere. The flux asymmetry of the leading and following polarities persists for several tens of minutes. The observed asymmetry of magnetic fluxes supports the results of the numerical simulation of emergence of the active region magnetic field in the upper layers of the convective zone, which has been carried out by Rempel and Cheung [2014].


2021 ◽  
Vol 9 (3) ◽  
pp. 30
Author(s):  
Mai Thi Giang Thanh ◽  
Ngo Van Toan ◽  
Do Thi Thanh Toan ◽  
Nguyen Phu Thang ◽  
Ngoc Quang Dong ◽  
...  

This systematic review and meta-analysis aimed to investigate the efficacy of fluorescence-based methods, visual inspections, and photographic visual examinations in initial caries detection. A literature search was undertaken in the PubMed and Cochrane databases. Preferred Reporting Items for Systematic Review and Meta-Analyses (PRISMA) guidelines were followed, and eligible articles published from 1 January 2009 to 30 October 2019 were included if they met the following criteria: they (1) assessed the accuracy of methods of detecting initial tooth caries lesions on occlusal, proximal, or smooth surfaces in both primary and permanent teeth (in clinical); (2) used a reference standard; (3) reported data regarding the sample size, prevalence of initial tooth caries, and accuracy of the methods. Data collection and extraction, quality assessment, and data analysis were conducted according to Cochrane standards Quality Assessment of Diagnostic Accuracy Studies-2. Statistical analyses were performed using Review Manager 5.3 and STATA 14.0. A total of 12 eligible articles were included in the meta-analysis. The results showed that the sensitivity and specificity of fluorescence-based methods were 80% and 80%, respectively; visual inspection was measured at 80% and 75%, respectively; photographic visual examination was measured at 67% and 79%, respectively. We found that the visual method and the fluorescence method were reliable for laboratory use to detect early-stage caries with equivalent accuracy.


2021 ◽  
Vol 7 (5) ◽  
pp. 60
Author(s):  
Luis M. Moreno-Ramírez ◽  
Victorino Franco

The applicability of magnetocaloric materials is limited by irreversibility. In this work, we evaluate the reversible magnetocaloric response associated with magnetoelastic transitions in the framework of the Bean-Rodbell model. This model allows the description of both second- and first-order magnetoelastic transitions by the modification of the η parameter (η<1 for second-order and η>1 for first-order ones). The response is quantified via the Temperature-averaged Entropy Change (TEC), which has been shown to be an easy and effective figure of merit for magnetocaloric materials. A strong magnetic field dependence of TEC is found for first-order transitions, having a significant increase when the magnetic field is large enough to overcome the thermal hysteresis of the material observed at zero field. This field value, as well as the magnetic field evolution of the transition temperature, strongly depend on the atomic magnetic moment of the material. For a moderate magnetic field change of 2 T, first-order transitions with η≈1.3−1.8 have better TEC than those corresponding to stronger first-order transitions and even second-order ones.


Author(s):  
Т.А. Богумил

В статье предлагается концепция жизни и творческого роста В.М. Шукшина сквозь призму тезаурусного и кластерного подходов. Объяснительными «персональными моделями» для интерпретации биографического текста писателя являются кластеры Мартина Идена, Гамлета и Степана Разина. Ранее биографы и литературоведы указывали на важность этих персон для Шукшина, но разрозненно. Впервые предпринята попытка свести указанные персональные модели воедино, в целостный сюжет становления писателя в пространстве культуры. На разных этапах эволюции автора доминирует одна из указанных моделей, последовательно сменяя друг друга, но не вытесняя, а «внахлест». Ранний этап творчества, ориентированный на стратегию Мартина Идена, является попыткой «вписаться» в наличный культурный мейнстрим. Выражено это в следовании поэтике соцреализма. Второй этап подспудно начинается с реабилитации отца Шукшина в 1956 года, когда актуализируется «гамлетовский комплекс», проявляющийся в чувстве вины перед отцом, через стратегию утаивания подлинного «я», мотивы чудаковатости. Третий этап связан с личностью реального исторического лица, Степана Разина, и выражается в открытом протесте против власти. Все важные для В.М. Шукшина поведенческие модели объединены мотивом одинокого противостояния враждебному социуму и имеют трагический финал, что обусловило ранний уход писателя и порождение мифов о насильственном характере его смерти. В.М. Шукшин одновременно был фигурой неординарной и типичной, что позволило его биографии стать «персональной моделью» для последующих авторов, выходцев из сельской глубинки. The article proposes the concept of life and creative growth of V.M. Shukshin through the prism of the thesaurus and cluster approach. The explanatory "personal models" for interpreting the biographical text of the writer are clusters of Martin Eden, Hamlet and Stepan Razin. Earlier, biographers and literary critics pointed out the importance of these people for Shukshin, but it was scattered. For the first time, an attempt was made to bring these personal models together into an integral plot of the formation of the writer in the space of culture. At different stages of the writer’s evolution, one of these models dominates, successively replacing each other, but not crowding out, but “overlapping”. The early stage of creativity, focused on Martin Eden’s strategy, is an attempt to “fit in” the current cultural mainstream. This is expressed in following the poetics of socialist realism. The second stage implicitly begins with the rehabilitation of Shukshin’s father in 1956, when the “Hamletian complex” is actualized. It is manifested in a sense of guilt towards his father, the strategy of concealing the true “I”, eccentricities. The third stage is connected with the personality of a real historical person, Stepan Razin, and is expressed in an open protest against the authorities. All important for V.M. Shukshin's behavioral models are united by the motive of a lonely confrontation with a hostile society and have a tragic ending, which led to the early departure of the writer and the generation of myths about the violent nature of his death. V.M. Shukshin was an extraordinary and typical figure at the same time. That allowed his biography to become a “personal model” for subsequent authors who came from the rural outback.


2004 ◽  
Vol 126 (5) ◽  
pp. 925-931 ◽  
Author(s):  
Yanyao Jiang ◽  
Ming Zhang ◽  
Tae-Won Park ◽  
Chu-Hwa Lee

The self-loosening process of a bolted joint consists of two distinct stages. The early stage of self-loosening is due to the cyclic plastic deformation of the materials. The second stage of self-loosening is characterized by the backing off of the nut. The current work is concentrated on an experimental investigation of the second stage self-loosening. Over one hundred bolted joints with M12×1.75 bolts and nuts were experimentally tested using a specially designed testing apparatus. The experiments mimicked two plates jointed by a bolt and a nut and were subjected to cyclic transverse shear loading. During an experiment, the relative displacement between the two clamped plates, denoted by δ, was a controlling parameter. For a given preload, the relationship between, Δδ/2, the amplitude of the relative displacement between the two clamped plates, and, NL, the number of loading cycles to loosening followed a pattern similar to a fatigue curve. There existed an endurance limit below which self-loosening would not persist. A larger preload resulted in a larger endurance limit. However, a large preload increased the possibility for the bolt to fail in fatigue. The results suggest that the use of a regular nut is superior to the use of a flange nut in terms of self-loosening resistance.


Sign in / Sign up

Export Citation Format

Share Document