scholarly journals A pilot-scale test on the treatment of biological pretreated leachate by the synergy of ozonation-biological treatment-catalytic ozonation

2020 ◽  
Vol 26 (4) ◽  
pp. 200349-0
Author(s):  
Yuanmei Chen ◽  
Yutang Xiao ◽  
Guanping Wang ◽  
Wei Shi ◽  
Linquan Sun ◽  
...  
Keyword(s):  
Biological Treatment ◽  
Removal Rate ◽  
Oxygen Demand ◽  
Pilot Scale ◽  
Catalytic Ozonation ◽  
Test Results ◽  
Scale Test ◽  
Pre Treatment ◽  
Discharge Criteria ◽  
Pilot Scale Test

In this pilot-scale test, the ozonation-biological treatment-catalytic ozonation system was performed to treat complex organics and highly-concentrated total nitrogen (TN) in biological pretreated incineration leachate. The test results showed that the ratio of five-day biochemical oxygen demand (BOD5) / chemical oxygen demand (COD) increased from 0.059 to 0.237, which indicated that the concentration of biodegradable COD (CODbio) increased by ozonation pre-treatment process. In addition, the TN removal mainly occurred in anaerobic zone due to direct denitrification by the activated bacteria, which were domesticated through different influent ratio. Moreover, it was necessary to add catalytic ozonation process to reach higher direct effluent discharge criteria. After 60 days repeated debugging, the removal rate of COD and TN reached 88.5% and 98.2%, respectively. Finally, the total cost of this system was ￥ 6.65 /m<sup>3</sup> ($ 0.95 /m<sup>3</sup>), which was acceptable for the treatment of biological pretreated leachate. This pilot-scale test could provide some guiding information for the treatment of leachate containing highly-concentrated TN with low CODbio/N by the composite system.

Removal of nitrogen from coal gasification wastewater by nitrosofication and denitrosofication

1998 ◽  
Vol 38 (1) ◽  
pp. 39-46 ◽  
Author(s):  
Junxin Liu ◽  
Weiguang Li ◽  
Xiuheng Wang ◽  
Hongyuan Liu ◽  
Baozhen Wang
Keyword(s):  
Nitrogen Removal ◽  
Coal Gasification ◽  
Oxygen Demand ◽  
Test Results ◽  
New Process ◽  
Scale Test ◽  
Coal Gasification Wastewater ◽  
Total Nitrogen Removal ◽  
Biological Nitrogen ◽  
Bench Scale Test

In this paper, a study of a new process with nitrosofication and denitrosofication for nitrogen removal from coal gasification wastewater is reported. In the process, fibrous carriers were packed in an anoxic tank and an aerobic tank for the attached growth of the denitrifying bacteria and Nitrobacter respectively, and the suspended growth activated sludge was used in an aerobic tank for the growth of Nitrosomonas. A bench scale test has been carried out on the process, and the test results showed that using the process, 25% of the oxygen demand and 40% of the carbon source demand can be saved, and the efficiency of total nitrogen removal can increase over 10% as compared with a traditional process for biological nitrogen removal.

Treatment of local scrubber wastewater for semiconductor by using photo-catalytic ozonation

2009 ◽  
Vol 59 (11) ◽  
pp. 2281-2286 ◽  
Author(s):  
Chung-Yi Chou ◽  
Chien-Pin Huang ◽  
Neng-Chou Shang ◽  
Yue-Hwa Yu
Keyword(s):  
Ion Exchange ◽  
Removal Efficiency ◽  
Removal Rate ◽  
Catalytic Ozonation ◽  
Acidic Condition ◽  
Buffer Solution ◽  
Toc Removal ◽  
Pre Treatment ◽  
Alkaline Buffer Solution

This study investigates the oxidation of local scrubber wastewater (LSW) from semiconductor manufacture by using ozonation, catalytic ozonation (ozone/Al2O3 and ozone/TiO2–Al2O3), and photo-catalytic ozonation (UV/TiO2–Al2O3, ozone/UV and ozone/UV/TiO2–Al2O3). The results show that catalyst Al2O3 and TiO2–Al2O3 promotes the TOC removal under the condition of neutral or alkaline buffer solution during catalytic ozonation of LSW. The Al2O3 induces highest promotion in TOC removal efficiency, which is higher than ozone alone by 26% TOC removal under alkaline buffer solution. However, TiO2–Al2O3 and Al2O3 cannot display the promotion in TOC removal under acidic condition. In addition, a pre-treatment of anion ion-exchange is employed and the result indicates that decreasing the anion ions concentration before AOPs can imply higher TOC removal during AOPs of LSW. In this study, ozone/UV under raw LSW acidic condition and ozone/Al2O3 under alkaline buffer solution present 95% and 88% TOC removal rate respectively and show the higher TOC removal efficiency than other AOPs. Therefore, these two kinds of AOP can serve as the very viable AOP methods in the LSW reclamation for semiconductor.

Sign in / Sign up

Export Citation Format

Share Document