Granulation and Biodegradation by Microbial Species in Granular Sequencing Batch Reactor for Soy Sauce Wastewater Treatment

2020 ◽  
pp. 287-308
Author(s):  
Hasnida Harun ◽  
Aznah Nor Anuar ◽  
Mohd Hakim Ab Halim ◽  
Inawati Othman ◽  
Noor Hasyimah Rosman ◽  
...  
Keyword(s):  
Wastewater Treatment ◽  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
Soy Sauce ◽  
Microbial Species

scholarly journals Methods of reconstruction and modification of the sequencing batch reactor at municipal wastewater treatment plants in Vietnam

Vestnik MGSU ◽  
2019 ◽  
pp. 589-602 ◽  
Author(s):  
Tran Ha Quan ◽  
Elena S. Gogina
Keyword(s):  
Wastewater Treatment ◽  
Sequencing Batch Reactor ◽  
Municipal Wastewater ◽  
Wastewater Treatment Plants ◽  
Batch Reactor ◽  
Municipal Wastewater Treatment ◽  
Wastewater Purification ◽  
Municipal Wastewater Treatment Plants ◽  
Operation Cycle

Introduction. Vietnamese urban municipal wastewater treatment plants are mainly of aeration-type facilities. Nowadays, an aeration-type plant, the Sequencing Batch Reactor (SBR), is widely applied and possesses a number of advantages over traditional systems with suspended activated sludge. Advantages of the SBR are mainly concluded in simplicity of operation, occupied area and cost. There is a number of problems at the wastewater treatment plants; they are connected with supplying only a half of wastewater design amount for the treatment as well as with quality of the purified water that must satisfy requirements of the Vietnamese discharge standard, the Standard A. Therefore, reconstruction and modification of the SBR is the major challenger to ensure the sustained development of large Vietnamese cities and maintenance of ecological balance. Materials and methods. To enhance the efficiency of wastewater purification in the SBR, the experiments were set on reactor reconstruction and modification by two directions: (1) Technological method, i.e. applying the Biochip 25 biocarrier, and (2) Operation method, i.e. adding the anoxic phase in reactor operation cycle. Laboratory tests were conducted for each of the directions, including comparison of a typical reactor with the modified one. Results. The study resulted in obtaining an optimal amount of the BioChip biocarrier material (10 to 20 %) that increased efficiency of wastewater purification by 10 to 20 %. In addition to this, when creating an anoxic phase of the operation cycle, efficiency of nitrogen removal increased by 20 %. When the denitrification occurs under the anoxic conditions, it contributes to stabilization of ammonium nitrogen removal for daily nitrogen loading in reactor of 0.3 to 0.8 TKN kg/sludge kg. Conclusions. The suggested technology provides the quality of treated water corresponding with the Vietnamese Standard A requirements. At the present, it is planned to proceed with the experiment on the base of Vietnamese semi-industrial plant for research and appraisal of the SBR reconstruction and modification method. Acknowledgements. The authors are grateful to AKVA Control company in Samara for granted biocarrier Mutag BioChip 25 and to Associate Professor Tran Van Quang and his students, Nguyen Ngoc Phuong and Truong Quoc Dai, of Environment Protect Research Center, Danang University for support of the experiment.

scholarly journals Study of COD Removal Rate on a Sequencing Batch Reactor (SBR) Treating Tapioca Wastewater

2019 ◽  
Vol 38 (3) ◽  
pp. 243
Author(s):  
Happy Mulyani ◽  
Gregorius Prima Indra Budianto ◽  
Margono Margono ◽  
Mujtahid Kaavessina
Keyword(s):  
Wastewater Treatment ◽  
Sequencing Batch Reactor ◽  
Removal Rate ◽  
Batch Reactor ◽  
Cod Removal ◽  
Operation Condition ◽  
Effluent Quality ◽  
Aeration Time ◽  
Standard Quality ◽  
Cod Removal Rate

Industrial wastewater treatment using Sequencing Batch Reactor (SBR) can improve effluent quality at lower cost than that obtained by other biological treatment methods. Further optimization is still required to enhance effluent quality until it meets standard quality and to reduce the operating cost of treatment of high strength organic wastewater. The purpose of this research was to determine the effect of pretreatment (pH adjustment and prechlorination) and aeration time on effluent quality and COD removal rate in tapioca wastewater treatment using SBR. Pretreatment was done by (1) adjustment of tapioca wastewater pH to control (4.92), 7, and 8, and (2) tapioca wastewater prechlorination at pH 8 during hour using calcium hypochlorite in variation dosages 0, 2, 4, 6 mg/L Cl2, SBR operation was conducted according to following steps: (1) Filling of pre-treated wastewater into a bioreactor during 1 hour, and (2) aeration of the mixture of tapioca wastewater and activated sludge during 8 hours. Effluent sample was collected at every 2-hours aeration for COD analysis. COD removal rate mathematical formula was got by first deriving the best fit function between aeration time and COD. Optimum aeration time resulting in no COD removal rate. The value of COD effluent and its removal rate in optimum aeration time was used to determine the recommended of operation condition of pretreatment. Research result shows that chosen pH operation condition is pH 8. Prechorination can make effluent quality which meets standard quality and highest COD removal rate. The chosen Cl2 dosage is 6 mg/L.

A comparison of continuous flow and sequencing batch reactor plants concerning integrated operation of sewer systems and wastewater treatment plants

2006 ◽  
Vol 54 (11-12) ◽  
pp. 241-248 ◽  
Author(s):  
J. Simon ◽  
J. Wiese ◽  
H. Steinmetz
Keyword(s):  
Wastewater Treatment ◽  
Continuous Flow ◽  
Sequencing Batch Reactor ◽  
Wastewater Treatment Plants ◽  
Batch Reactor ◽  
Sewer Systems ◽  
Combined Sewer ◽  
Integrated Operation

Integrated operation strategies for combined sewer and WWTP are becoming more and more popular because of numerous benefits. One can find many examples in literature, but many of these studies deal with partly fictitious systems and/or were accomplished within the planning. Hence most of these studies do not have to deal with the restrictions given by already built constructions. The authors, who worked on several integrated projects, will discuss the requirements of SBR and CFR plants concerning an implementation of integrated operation.

The impact of powdered keramsite on activated sludge and wastewater treatment in a sequencing batch reactor

2019 ◽  
Vol 237 ◽  
pp. 305-312 ◽  
Author(s):  
Adam Masłoń ◽  
Janusz A. Tomaszek ◽  
Justyna Zamorska ◽  
Monika Zdeb ◽  
Adam Piech ◽  
...  
Keyword(s):  
Wastewater Treatment ◽  
Activated Sludge ◽  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
The Impact

scholarly journals Municipal wastewater treatment by the bioaugmentation of Bacillus sp. K5 within a sequencing batch reactor

PLoS ONE ◽  
2017 ◽  
Vol 12 (6) ◽  
pp. e0178837 ◽  
Author(s):  
Yunlong Yang ◽  
Linxiang Xie ◽  
Xin Tao ◽  
Kaihui Hu ◽  
Shaobin Huang
Keyword(s):  
Wastewater Treatment ◽  
Sequencing Batch Reactor ◽  
Municipal Wastewater ◽  
Batch Reactor ◽  
Bacillus Sp ◽  
Municipal Wastewater Treatment

Efficient treatment of dairy processing wastewater in a laboratory scale Intermittently Aerated Sequencing Batch Reactor (IASBR)

2018 ◽  
Vol 85 (3) ◽  
pp. 379-383 ◽  
Author(s):  
Peter Leonard ◽  
Emma Tarpey ◽  
William Finnegan ◽  
Xinmin Zhan
Keyword(s):  
Wastewater Treatment ◽  
Retention Time ◽  
Wastewater Treatment Plant ◽  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
Treatment Plant ◽  
Laboratory Scale ◽  
Synthetic Wastewater ◽  
Operational Parameters ◽  
Dairy Processing

This Research Communication describes an investigation into the viability of an Intermittently Aerated Sequencing Batch Reactor (IASBR) for the treatment of dairy processing wastewater at laboratory-scale. A number of operational parameters have been varied and the effect has been monitored in order to determine optimal conditions for maximising removal efficiencies. These operational parameters include Hydraulic Retention Time (HRT), Solids Retention Time (SRT), aeration rate and cycle length. Real dairy processing wastewater and synthetic wastewater have been treated using three laboratory-scale IASBR units in a temperature controlled room. When the operational conditions were established, the units were seeded using sludge from a municipal wastewater treatment plant for the first experiment, and sludge from a dairy processing factory for the second and third experiment. In experiment three, the reactors were fed on real wastewater from the wastewater treatment plant at this dairy processing factory. These laboratory-scale systems will be used to demonstrate over time that the IASBR system is a consistent, viable option for treatment of dairy processing wastewater in this sector. In this study, the capacity of a biological system to remove both nitrogen and phosphorus within one reactor will be demonstrated. The initial operational parameters for a pilot-scale IASBR system will be derived from the results of the study.

Sign in / Sign up

Export Citation Format

Share Document