Origin of the synchronous pressure fluctuations in the draft tube of Francis turbines operating at part load conditions

2019 ◽  
Vol 86 ◽  
pp. 13-33 ◽  
Author(s):  
Simon Pasche ◽  
François Gallaire ◽  
François Avellan
Energies ◽  
2021 ◽  
Vol 14 (13) ◽  
pp. 3894
Author(s):  
Arthur Favrel ◽  
Nak-Joong Lee ◽  
Tatsuya Irie ◽  
Kazuyoshi Miyagawa

This paper proposes an original approach to investigate the influence of the geometry of Francis turbines draft tube on pressure fluctuations and energy losses in off-design conditions. It is based on Design of Experiments (DOE) of the draft tube geometry and steady/unsteady Computational Fluid Dynamics (CFD) simulations of the draft tube internal flow. The test case is a Francis turbine unit of specific speed Ns=120 m-kW which is required to operate continuously in off-design conditions, either with 45% (part-load) or 110% (full-load) of the design flow rate. Nine different draft tube geometries featuring a different set of geometrical parameters are first defined by an orthogonal array-based DOE approach. For each of them, unsteady and steady CFD simulations of the internal flow from guide vane to draft tube outlet are performed at part-load and full-load conditions, respectively. The influence of each geometrical parameter on both the flow instability and resulting pressure pulsations, as well as on energy losses in the draft tube, are investigated by applying an Analysis of Means (ANOM) to the numerical results. The whole methodology enables the identification of a set of geometrical parameters minimizing the pressure fluctuations occurring in part-load conditions as well as the energy losses in both full-load and part-load conditions while maintaining the requested pressure recovery. Finally, the results of the CFD simulations with the final draft tube geometry are compared with the results estimated by the ANOM, which demonstrates that the proposed methodology also enables a rough preliminary estimation of the draft tube losses and pressure fluctuations amplitude.


Author(s):  
Mohammad Hossein Khozaei ◽  
Arthur Favrel ◽  
Toshitake Masuko ◽  
Naoki Yamaguchi ◽  
Kazuyoshi Miyagawa

Abstract This paper focuses on the generation of twin vortex rope in the draft-tube elbow of a Francis turbine at deep part-load operation through analyzing the results of model tests along with numerical simulations. Model tests, including pressure fluctuations measurements, are conducted over 10 speed factors. By considering the frequency of the pressure fluctuations with respect to the swirl intensity at the runner outlet, the part-load operating range is divided into three regimes, with two clear transitions between each occurring at swirl numbers 0.4 and 1.7. For operating conditions with a swirl number S>0.4, a linear correlation between the frequency of the precessing vortex core and the swirl number is established. During deep part-load regime (S>1.7), low-frequency pressure fluctuations appear. Their frequency feature another linear correlation with the swirl number. Unsteady CFD simulation of the full domain is performed to elucidate the generation mechanisms of the low-frequency fluctuations. By tracking the center of the vortical structures along the draft-tube, generation of three vortices in the elbow responsible for the pressure fluctuations at the lowest frequency is highlighted: the main PVC hits the draft-tube wall in the elbow resulting in its break down into three vortices rotating with half the rotational speed of the PVC. Two of the vortices rotate with opposite angular position, constituting a structure of twin vortices. The periodic rotation of these three vortices in the elbow induces the low-frequency pressure fluctuations.


2006 ◽  
Vol 128 (4) ◽  
pp. 649-655 ◽  
Author(s):  
Zhengwei Wang ◽  
Lingjiu Zhou

Pressure oscillations caused by vortex rope were measured in the draft tube of a prototype Francis turbine. The three-dimensional, unsteady Reynolds-averaged Navier-Stokes equations with the RNG κ−ϵ turbulence model were solved to model the flow within the entire flow path of the prototype hydraulic unit including the guide vanes, the runner, and the draft tube. The model was able to predict the pressure fluctuations that occur when operating at 67–83% of the optimum opening. The calculated frequencies and amplitudes of the oscillation show reasonable agreement with the experiment data. However, the results at 50% opening were not satisfactory. Pressure oscillations on the runner blades were found to be related to the precession of vortex ropes which caused pressure on the blades to fluctuate with frequencies of −fn+fd (fn is the rotational frequency and fd is vortex procession frequency). The peak-to-peak amplitudes of the pressure oscillations on the blades at the lower load conditions (67% opening) were higher than at higher load conditions (83% opening). Fluctuations on the suction side tended to be stronger than on the pressure side.


Water ◽  
2019 ◽  
Vol 11 (7) ◽  
pp. 1332 ◽  
Author(s):  
An Yu ◽  
Qinghong Tang ◽  
Xincheng Wang ◽  
Daqing Zhou ◽  
Jintao Liu

Cavitation and system instability are the most common problems occurring in hydraulic power systems, especially operated under part-load conditions. Previous research show that when the hydraulic turbine operates apart from designed conditions, such as part-load conditions, a helical vortex rope occurs from the runner exit, and usually generates severe pressure oscillations. Cavitation usually appears and turns the rope to become a two-phase cavitation rope. The occurrence of cavitation rope is believed to be the main reason of the severe pressure oscillations. Based on a new multiphase flow simulation method re-developed in ANSYS CFX, this paper did the runner modification by using grooves and made the investigation of pressure fluctuation alleviation in a hydraulic turbine at different cavitation numbers. The behavior of cavitation rope and the pressure fluctuations induced by cavitation under typical part load conditions with modified runner were analyzed in present research. The results show that besides the pressure fluctuation induced by the rope rotating, cavitation induced a new pressure fluctuation with a lower frequency. For the embedded analysis the results show that the modified runner can decrease the vortex rope eccentricity and increase the vortex core pressure and finally alleviate the two types of pressure fluctuations. Also, the turbine efficiency has a little rise when equipped with the modified runner.


2018 ◽  
Vol 30 (1) ◽  
pp. 131-139 ◽  
Author(s):  
Ting Chen ◽  
Xianghao Zheng ◽  
Yu-ning Zhang ◽  
Shengcai Li

Processes ◽  
2021 ◽  
Vol 9 (7) ◽  
pp. 1182
Author(s):  
Seung-Jun Kim ◽  
Yong Cho ◽  
Jin-Hyuk Kim

Under low flow-rate conditions, a Francis turbine exhibits precession of a vortex rope with pressure fluctuations in the draft tube. These undesirable flow phenomena can lead to deterioration of the turbine performance as manifested by torque and power output fluctuations. In order to suppress the rope with precession and a swirl component in the tube, the use of anti-swirl fins was investigated in a previous study. However, vortex rope generation still occurred near the cone of the tube. In this study, unsteady-state Reynolds-averaged Navier–Stokes analyses were conducted with a scale-adaptive simulation shear stress transport turbulence model. This model was used to observe the effects of the injection in the draft tube on the unsteady internal flow and pressure phenomena considering both active and passive suppression methods. The air injection affected the generation and suppression of the vortex rope and swirl component depending on the flow rate of the air. In addition, an injection level of 0.5%Q led to a reduction in the maximum unsteady pressure characteristics.


Sign in / Sign up

Export Citation Format

Share Document