Modeling of the Effect of Washing Solution Flow Conditions on Escherichia coli O157:H7 Population Reduction on Fruit Surfaces

2007 ◽  
Vol 70 (11) ◽  
pp. 2533-2540 ◽  
Author(s):  
HUA WANG ◽  
WEI LIANG ◽  
HAO FENG ◽  
YAGUANG LUO
Keyword(s):  
Escherichia Coli ◽  
Flow Velocity ◽  
Reduction Rate ◽  
Escherichia Coli O157 ◽  
Agitation Rate ◽  
Flow Conditions ◽  
Solution Flow ◽  
E Coli ◽  
Pathogen Reduction ◽  
Over The Top

Washing produce with sanitizing solutions is an important step in reducing microbial populations during postharvest handling. Little information exists regarding the effects of washing solution flow conditions on the efficacy of pathogen reduction during washing. This study was undertaken to investigate the effects of washing conditions such as flow velocity, agitation rate, and contact time on the reduction of Escherichia coli O157:H7 populations from the surfaces of cantaloupe rind and cut apples. Top surfaces of cylindrical samples were spot inoculated with E. coli O157:H7 and treated with peroxyacetic acid (POAA; 80 mg/liter) solution under different flow velocities and agitation rates and with different washing modes. Test results indicate that the reduction rate of E. coli O157:H7 increased with the increase in flow velocity and agitation rate under the testing conditions. In a 3-min treatment in the flow-through chamber, the E. coli O157:H7 count reduction on cantaloupe rind and cup apples reached 2.5 and 2.3 log CFU/cm2, respectively, when the flow velocity increased from 0.0 to 0.8 m/min. Agitation conducted at the bottom of the treatment chamber reduced the E. coli O157:H7 population on cut apples by 1.2 log CFU/cm2 in 3 min, whereas in the treatment with the agitation over the top of the chamber, the survival count of E. coli O157:H7 was reduced by only 0.8 log CFU/cm2. The experimental data were used to fit four microbial reduction kinetic models. It was found that E. coli O157:H7 reduction from the fruit surfaces was best described by the Weibull model. These findings may be useful in designing produce wash systems for achieving enhanced pathogen reduction and improved produce quality and safety.

scholarly journals Impact of Vacuum Cooling on Escherichia coli O157:H7 Infiltration into Lettuce Tissue

2008 ◽  
Vol 74 (10) ◽  
pp. 3138-3142 ◽  
Author(s):  
Haiping Li ◽  
Mehrdad Tajkarimi ◽  
Bennie I. Osburn
Keyword(s):  
Escherichia Coli ◽  
Risk Assessment ◽  
Reduction Rate ◽  
Escherichia Coli O157 ◽  
Surface Sterilization ◽  
E Coli ◽  
Green Industry ◽  
Vacuum Cooling ◽  
The Impact

ABSTRACT Vacuum cooling is a common practice in the California leafy green industry. This study addressed the impact of vacuum cooling on the infiltration of Escherichia coli O157:H7 into lettuce as part of the risk assessment responding to the E. coli O157:H7 outbreaks associated with leafy green produce from California. Vacuum cooling significantly increased the infiltration of E. coli O157:H7 into the lettuce tissue (2.65E+06 CFU/g) compared to the nonvacuumed condition (1.98E+05 CFU/g). A stringent surface sterilization and quadruple washing could not eliminate the internalized bacteria from lettuce. It appeared that vacuuming forcibly changed the structure of lettuce tissue such as the stomata, suggesting a possible mechanism of E. coli O157:H7 internalization. Vacuuming also caused a lower reduction rate of E. coli O157:H7 in stored lettuce leaves than that for the nonvacuumed condition.

scholarly journals Immunomagnetic separation and size-based detection of Escherichia coli O157 at the meniscus of a membrane strip

RSC Advances ◽  
2018 ◽  
Vol 8 (46) ◽  
pp. 26266-26270 ◽  
Author(s):  
Hyeonjeong Lee ◽  
Jeongin Hwang ◽  
Yunsung Park ◽  
Donghoon Kwon ◽  
Sanghee Lee ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Flow Velocity ◽  
Test Strip ◽  
Immunomagnetic Separation ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Membrane Strip

E. coli–Au/MNC complexes accumulate at the meniscus of the test strip where the flow velocity reaches a maximum.

Efficacy of Sanitizers To Inactivate Escherichia coli O157:H7 on Fresh-Cut Carrot Shreds under Simulated Process Water Conditions†

2004 ◽  
Vol 67 (11) ◽  
pp. 2375-2380 ◽  
Author(s):  
ROLANDO J. GONZALEZ ◽  
YAGUANG LUO ◽  
SAUL RUIZ-CRUZ ◽  
JAMES L. McEVOY
Keyword(s):  
Escherichia Coli ◽  
Tap Water ◽  
Process Water ◽  
Sodium Chlorite ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Water Conditions ◽  
Processing Water ◽  
Fresh Cut ◽  
Pathogen Reduction

Chlorine is widely used as a sanitizer to maintain the microbial quality and safety of fresh-cut produce; however, chlorine treatment lacks efficacy on pathogen reduction, especially when the fresh-cut processing water contains heavy organic loads. A more efficacious sanitizer that can tolerate the commercial processing conditions is needed to maintain microbial safety of fresh-cut produce. This study evaluated the efficacy of Escherichia coli O157:H7 reduction on fresh-cut carrots using new and traditional sanitizers with tap water and fresh-cut processing water scenarios. Fresh-cut carrot shreds inoculated with E. coli O157:H7 were washed in sanitizer solutions including 200 ppm chlorine, citric acid–based sanitizer (Pro-San), 80 ppm peroxyacetic acid-based sanitizer (Tsunami 100), and 1,000 ppm acidified sodium chlorite (SANOVA) prepared in fresh tap water or simulated processing water with a chemical oxygen demand level of approximately 3,500 mg/liter. Samples were packaged and stored at 5°C. Microbial analyses performed at days 0, 7, and 14 indicate that the organic load in the process water significantly affected the efficacy of chlorine on pathogen removal and was especially evident on samples tested during storage. Acidified sodium chlorite provided a strong pathogen reduction even under process water conditions with up to a 5.25-log reduction when compared with the no-wash control. E. coli O157:H7 was not recovered on acidified sodium chlorite–treated samples during the entire 14 days of storage, even following an enrichment step. These results suggest that acidified sodium chlorite holds considerable promise as an alternative sanitizer of fresh-cut produce.

Validation Comparing the Effectiveness of a Lactic Acid Dip with a Lactic Acid Spray for Reducing Escherichia coli O157:H7, Salmonella, and Non-O157 Shiga Toxigenic Escherichia coli on Beef Trim and Ground Beef

2012 ◽  
Vol 75 (11) ◽  
pp. 1968-1973 ◽  
Author(s):  
M. J. WOLF ◽  
M. F. MILLER ◽  
A. R. PARKS ◽  
G. H. LONERAGAN ◽  
A. J. GARMYN ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Lactic Acid ◽  
Untreated Control ◽  
Ground Beef ◽  
Escherichia Coli O157 ◽  
Water Spray ◽  
Intervention Effectiveness ◽  
E Coli ◽  
Application Methods ◽  
Pathogen Reduction

The objective of this research was to compare the effectiveness of two application methods (dip versus spray) of 4.4% lactic acid for reducing pathogens on inoculated beef trim and in ground beef. Beef trim inoculated with cocktail mixtures of E. coli O157:H7, non-O157 Shiga toxigenic E. coli (STEC), or Salmonella (105 to 106 CFU/g) at separate times was subjected to five treatments: lactic acid spray (LS), lactic acid dip (LD), water spray (WS), water dip (WD), and untreated control (CTL). Intervention effectiveness for pathogen reduction was measured at 1 and 20 h after treatment on beef trim. Trim was then ground and intervention effectiveness was measured 1 h, 24 h, 72 h, and 7 days after grinding. The LD treatment reduced all pathogens significantly (P < 0.05); E. coli O157:H7 was reduced by 0.91 to 1.41 log CFU/g on beef trim and ground beef, non-O157 STEC by 0.48 to 0.82 log CFU/g, and Salmonella by 0.51 to 0.81 log CFU/g. No other treatment significantly reduced any pathogen, although the WD treatment noticeably reduced (P > 0.05) both E. coli O157:H7 and non-O157 STEC populations compared with the CTL. The LS treatment reduced E. coli O157:H7 and Salmonella by up to 0.5 log CFU/g on beef trim, but these reduced counts did not significantly differ (P > 0.05) from the CTL counts. Overall, the LD treatment was most effective for reducing all pathogens and is the best of these options for improving the safety of beef trim and subsequently produced ground beef.

Antimicrobial Effects of Zataria multiflora and Ocimum basilicum on Escherichia coli O157:H7 During Ripening of Traditional Lighvan Cheese

2020 ◽  
Vol 16 (3) ◽  
pp. 373-380
Author(s):  
Mohammad B. Zendeh ◽  
Vadood Razavilar ◽  
Hamid Mirzaei ◽  
Khosrow Mohammadi
Keyword(s):  
Escherichia Coli ◽  
Essential Oils ◽  
Dairy Products ◽  
Antimicrobial Agents ◽  
Escherichia Coli O157 ◽  
Zataria Multiflora ◽  
Antimicrobial Effects ◽  
E Coli ◽  
Common Causes ◽  
Lighvan Cheese

Background: Escherichia coli O157:H7 is one of the most common causes of contamination in Lighvan cheese processing. Using from natural antimicrobial essential oils is applied method to decrease the rate of microbial contamination of dairy products. The present investigation was done to study the antimicrobial effects of Z. multiflora and O. basilicum essential oils on survival of E. coli O157:H7 during ripening of traditional Lighvan cheese. Methods: Leaves of the Z. multiflora and O. basilicum plants were subjected to the Clevenger apparatus. Concentrations of 0, 100 and 200 ppm of the Z. multiflora and 0, 50 and 100 ppm of O. basilicum essential oils and also 103 and 105 cfu/ml numbers of E. coli O157:H7 were used. The numbers of the E. coli O157:H7 bacteria were analyzed during the days 0, 30, 60 and 90 of the ripening period. Results: Z. multiflora and O. basilicum essential oils had considerable antimicrobial effects against E. coli O157:H7. Using the essential oils caused decrease in the numbers of E. coli O157:H7 bacteria in 90th days of ripening (P <0.05). Using from Z. multiflora at concentration of 200 ppm can reduce the survival of E. coli O157:H7 in Lighvan cheese. Conclusion: Using Z. multiflora and O. basilicum essential oils as good antimicrobial agents can reduce the risk of foodborne bacteria and especially E. coli O157:H7 in food products.

An Aggregation-Induced Emission Material Labeling Antigen-Based Lateral Flow Immunoassay Strip for Rapid Detection of Escherichia coli O157:H7

2021 ◽  
pp. 247263032098193
Author(s):  
Cheng Liu ◽  
Shuiqin Fang ◽  
Yachen Tian ◽  
Youxue Wu ◽  
Meijiao Wu ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Rapid Detection ◽  
Foodborne Pathogen ◽  
Test Strip ◽  
Lateral Flow ◽  
Detection Sensitivity ◽  
Lateral Flow Immunoassay ◽  
Escherichia Coli O157 ◽  
Aggregation Induced Emission ◽  
E Coli

Escherichia coli O157:H7 ( E. coli O157:H7) is a dangerous foodborne pathogen, mainly found in beef, milk, fruits, and their products, causing harm to human health or even death. Therefore, the detection of E. coli O157:H7 in food is particularly important. In this paper, we report a lateral flow immunoassay strip (LFIS) based on aggregation-induced emission (AIE) material labeling antigen as a fluorescent probe for the rapid detection of E. coli O157:H7. The detection sensitivity of the strip is 105 CFU/mL, which is 10 times higher than that of the colloidal gold test strip. This method has good specificity and stability and can be used to detect about 250 CFU of E. coli O157:H7 successfully in 25 g or 25 mL of beef, jelly, and milk. AIE-LFIS might be valuable in monitoring food pathogens for rapid detection.

Bacteriophages reduce Escherichia coli O157:H7 levels in experimentally inoculated sheep

2009 ◽  
Vol 89 (2) ◽  
pp. 285-293 ◽  
Author(s):  
S J Bach ◽  
R P Johnson ◽  
K. Stanford ◽  
T A McAllister
Keyword(s):  
Escherichia Coli ◽  
Oral Administration ◽  
Coliform Bacteria ◽  
Escherichia Coli O157 ◽  
Fecal Shedding ◽  
Total Coliforms ◽  
E Coli ◽  
Oral Inoculation ◽  
Experimental Treatments ◽  
And Control

Bacteriophage biocontrol has potential as a means of mitigating the prevalence of Escherichia coli O157:H7 in ruminants. The efficacy of oral administration of bacteriophages for reducing fecal shedding of E. coli O157:H7 by sheep was evaluated using 20 Canadian Arcott rams (50.0 ± 3.0) housed in four rooms (n = 5) in a contained facility. The rams had ad libitum access to drinking water and a pelleted barley-based total mixed ration, delivered once daily. Experimental treatments consisted of administration of E. coli O157:H7 (O157), E. coli O157:H7+bacteriophages (O157+phage), bacteriophages (phage), and control (CON). Oral inoculation of the rams with 109 CFU of a mixture of four nalidixic acid-resistant strains of E. coli O157:H7 was performed on day 0. A mixture of 1010 PFU of bacteriophages P5, P8 and P11 was administered on days -2, -1, 0, 6 and 7. Fecal samples collected on 14 occasions over 21 d were analyzed for E. coli O157:H7, total E. coli, total coliforms and bacteriophages. Sheep in treatment O157+phage shed fewer (P < 0.05) E. coli O157:H7 than did sheep in treatment O157. Populations of total coliforms and total E. coli were similar (P < 0.05) among treatments, implying that bacteriophage lysis of non-target E. coli and coliform bacteria in the gastrointestinal tract did not occur. Bacteriophage numbers declined rapidly over 21 d, which likely reduced the chance of collision between bacteria and bacteriophage. Oral administration of bacteriophages reduced shedding of E. coli O157:H7 by sheep, but a delivery system that would protect bacteriophages during passage through the intestine may increase the effectiveness of this strategy as well as allow phage to be administered in the feed.Key words: Escherichia coli O157:H7, bacteriophage, sheep, environment, coliforms

Surface and Internalized Escherichia coli O157:H7 on Field-Grown Spinach and Lettuce Treated with Spray-Contaminated Irrigation Water

2010 ◽  
Vol 73 (6) ◽  
pp. 1023-1029 ◽  
Author(s):  
MARILYN C. ERICKSON ◽  
CATHY C. WEBB ◽  
JUAN CARLOS DIAZ-PEREZ ◽  
SHARAD C. PHATAK ◽  
JOHN J. SILVOY ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Irrigation Water ◽  
Enrichment Culture ◽  
Field Studies ◽  
Plate Count ◽  
Escherichia Coli O157 ◽  
Adaxial Side ◽  
Abaxial Side ◽  
E Coli ◽  
Contaminated Irrigation Water

Numerous field studies have revealed that irrigation water can contaminate the surface of plants; however, the occurrence of pathogen internalization is unclear. This study was conducted to determine the sites of Escherichia coli O157:H7 contamination and its survival when the bacteria were applied through spray irrigation water to either field-grown spinach or lettuce. To differentiate internalized and surface populations, leaves were treated with a surface disinfectant wash before the tissue was ground for analysis of E. coli O157:H7 by direct plate count or enrichment culture. Irrigation water containing E. coli O157:H7 at 102, 104, or 106 CFU/ml was applied to spinach 48 and 69 days after transplantation of seedlings into fields. E. coli O157:H7 was initially detected after application on the surface of plants dosed at 104 CFU/ml (4 of 20 samples) and both on the surface (17 of 20 samples) and internally (5 of 20 samples) of plants dosed at 106 CFU/ml. Seven days postspraying, all spinach leaves tested negative for surface or internal contamination. In a subsequent study, irrigation water containing E. coli O157:H7 at 108 CFU/ml was sprayed onto either the abaxial (lower) or adaxial (upper) side of leaves of field-grown lettuce under sunny or shaded conditions. E. coli O157:H7 was detectable on the leaf surface 27 days postspraying, but survival was higher on leaves sprayed on the abaxial side than on leaves sprayed on the adaxial side. Internalization of E. coli O157:H7 into lettuce leaves also occurred with greater persistence in leaves sprayed on the abaxial side (up to 14 days) than in leaves sprayed on the adaxial side (2 days).

Tracking an Escherichia coli O157:H7–Contaminated Batch of Leafy Greens through a Pilot-Scale Fresh-Cut Processing Line

2014 ◽  
Vol 77 (9) ◽  
pp. 1487-1494 ◽  
Author(s):  
ANNEMARIE L. BUCHHOLZ ◽  
GORDON R. DAVIDSON ◽  
BRADLEY P. MARKS ◽  
EWEN C. D. TODD ◽  
ELLIOT T. RYSER
Keyword(s):  
Escherichia Coli ◽  
Membrane Filtration ◽  
Fluorescent Protein ◽  
Pilot Scale ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Leafy Greens ◽  
Iceberg Lettuce ◽  
Processing Line ◽  
Fresh Cut

Cross-contamination of fresh-cut leafy greens with residual Escherichia coli O157:H7–contaminated product during commercial processing was likely a contributing factor in several recent multistate outbreaks. Consequently, radicchio was used as a visual marker to track the spread of the contaminated product to iceberg lettuce in a pilot-scale processing line that included a commercial shredder, step conveyor, flume tank, shaker table, and centrifugal dryer. Uninoculated iceberg lettuce (45 kg) was processed, followed by 9.1 kg of radicchio (dip inoculated to contain a four-strain, green fluorescent protein–labeled nontoxigenic E. coli O157:H7 cocktail at 106 CFU/g) and 907 kg (2,000 lb) of uninoculated iceberg lettuce. After collecting the lettuce and radicchio in about 40 bags (~22.7 kg per bag) along with water and equipment surface samples, all visible shreds of radicchio were retrieved from the bags of shredded product, the equipment, and the floor. E. coli O157:H7 populations were quantified in the lettuce, water, and equipment samples by direct plating with or without prior membrane filtration on Trypticase soy agar containing 0.6% yeast extract and 100 ppm of ampicillin. Based on triplicate experiments, the weight of radicchio in the shredded lettuce averaged 614.9 g (93.6%), 6.9 g (1.3%), 5.0 g (0.8%), and 2.8 g (0.5%) for bags 1 to 10, 11 to 20, 21 to 30, and 31 to 40, respectively, with mean E. coli O157:H7 populations of 1.7, 1.2, 1.1, and 1.1 log CFU/g in radicchio-free lettuce. After processing, more radicchio remained on the conveyor (9.8 g; P &lt; 0.05), compared with the shredder (8.3 g), flume tank (3.5 g), and shaker table (0.1 g), with similar E. coli O157:H7 populations (P &gt; 0.05) recovered from all equipment surfaces after processing. These findings clearly demonstrate both the potential for the continuous spread of contaminated lettuce to multiple batches of product during processing and the need for improved equipment designs that minimize the buildup of residual product during processing.

PCR for the Specific Detection of an Escherichia coli O157:H7 Laboratory Control Strain

2015 ◽  
Vol 78 (9) ◽  
pp. 1738-1744 ◽  
Author(s):  
MICHAEL KNOWLES ◽  
DOMINIC LAMBERT ◽  
GEORGE HUSZCZYNSKI ◽  
MARTINE GAUTHIER ◽  
BURTON W. BLAIS
Keyword(s):  
Escherichia Coli ◽  
Pathogenic Bacteria ◽  
Control Measure ◽  
Positive Control ◽  
Food Microbiology ◽  
Escherichia Coli O157 ◽  
Control Strain ◽  
E Coli ◽  
Signature Sequences ◽  
Materials Used

Control strains of bacterial pathogens such as Escherichia coli O157:H7 are commonly processed in parallel with test samples in food microbiology laboratories as a quality control measure to assure the satisfactory performance of materials used in the analytical procedure. Before positive findings can be reported for risk management purposes, analysts must have a means of verifying that pathogenic bacteria (e.g., E. coli O157:H7) recovered from test samples are not due to inadvertent contamination with the control strain routinely handled in the laboratory environment. Here, we report on the application of an in-house bioinformatic pipeline for the identification of unique genomic signature sequences in the development of specific oligonucleotide primers enabling the identification of a common positive control strain, E. coli O157:H7 (ATCC 35150), using a simple PCR procedure.

Sign in / Sign up

Export Citation Format

Share Document