Enhanced Hydrolysis of Cellulose to Reducing Sugars on Kaolinte Clay Activated by Mineral Acid

2021 ◽  
Author(s):  
Yuxiao Dong ◽  
Dongshen Tong ◽  
Laibin Ren ◽  
Xingtao Chen ◽  
Hao Zhang ◽  
...  
Keyword(s):  
Reducing Sugars ◽  
Mineral Acid ◽  
Hydrolysis Of Cellulose ◽  
Hydrolysis Of

Cellulose Hydrolysis by Acidic Ionic Liquids Enhanced with Microwave Heating

2018 ◽  
Vol 1145 ◽  
pp. 75-79 ◽  
Author(s):  
Hai Yun Ma ◽  
Zhi Ping Zhao ◽  
Peng Lu
Keyword(s):  
Ionic Liquids ◽  
Microwave Heating ◽  
Reducing Sugars ◽  
Cellulose Hydrolysis ◽  
Degree Of Polymerization ◽  
Deionized Water ◽  
Acidic Ionic Liquids ◽  
Hydrolysis Of Cellulose ◽  
Total Reducing Sugars ◽  
Hydrolysis Of

The hydrolysis of cellulose into platform compounds and chemicals fuels has gained much attention to relieve the global energy crisis and environmental pollution. The filter paper (FP) cellulose with average degree of polymerization (DP) of 1000-1300 was dissolved in 1-butyl-3-methylimidazolium chloride ([BMIM]Cl) firstly. And then acidic ionic liquids (ILs), ([(CH2)3SO3HVIm]HSO4) as the catalyst was applied to hydrolyze the FP cellulose by microwave heating. Compared with the oil bath heating method, microwave heating could effectively increase the total reducing sugars (TRS) yield about 10.7%. When the ratio of ILs catalyst to FP (w/w) was 0.167, and the ratio of deionized water to FP (w/w) was 0.833, the TRS yield was up to 60.8% within 20 min at 100°C.

Hydrolysis of cellulose into reducing sugars in ionic liquids

Fuel ◽  
2016 ◽  
Vol 164 ◽  
pp. 46-50 ◽  
Author(s):  
Xianxiang Liu ◽  
Qiong Xu ◽  
Junyi Liu ◽  
Dulin Yin ◽  
Shengpei Su ◽  
...  
Keyword(s):  
Ionic Liquids ◽  
Reducing Sugars ◽  
Hydrolysis Of Cellulose ◽  
Hydrolysis Of

scholarly journals The effect of beta-glucosidase supplementation on enzymatic hydrolysis of cellulose in hydrothermally pretreated sugar beet shreds

2018 ◽  
pp. 1-9
Author(s):  
Mirjana Antov ◽  
Aleksandar Fistes
Keyword(s):  
Enzymatic Hydrolysis ◽  
Sugar Beet ◽  
Reducing Sugars ◽  
Cellulose Hydrolysis ◽  
Enzymatic Hydrolysis Of Cellulose ◽  
Untreated Material ◽  
Hydrolysis Of Cellulose ◽  
Beta Glucosidase ◽  
Hydrolysis Of

Sugar beet shreds were pretreated by hydrothermal procedure to investigate the effect of beta-glucosidase supplementation at different substrate loading on the rate of cellulose hydrolysis. Cellulose in the hydrothermally pretreated substrate was more efficiently hydrolyzed by enzymes than in untreated material, resulting in more than two times higher release of reducing sugars. In the investigated range of solids load, supplementation of fungal cellulases cocktail by beta-glucosidase increased production of reducing sugars from substrates, while 0.25 U/g was sufficient to achieve the highest effect under applied conditions.

scholarly journals Semidry acid hydrolysis of cellulose sustained by autoclaving for production of reducing sugars for bacterial biohydrogen generation from various cellulose feedstock

PeerJ ◽  
2021 ◽  
Vol 9 ◽  
pp. e11244
Author(s):  
Fatthy Mohamed Morsy ◽  
Medhat Elbadry ◽  
Yasser Elbahloul
Keyword(s):  
Acid Hydrolysis ◽  
Reducing Sugars ◽  
Gas Production ◽  
Hydrogen Gas ◽  
Biohydrogen Production ◽  
Hydrogen Yield ◽  
E Coli ◽  
Dry Biomass ◽  
Hydrolysis Of Cellulose ◽  
Hydrolysis Of

Cellulosic biowastes are one of the cheapest and most abundant renewable organic materials on earth that can be, subsequent to hydrolysis, utilized as an organic carbon source for several fermentation biotechnologies. This study was devoted to explore a semidry acid hydrolysis of cellulose for decreasing the cost and ionic strength of the hydrolysate. For semidry acid hydrolysis, cellulose was just wetted with HCl (0 to 7 M) and subjected to autoclaving. The optimum molar concentration of HCl and period of autoclaving for semidry acid hydrolysis of cellulose were 6 M and 50 min respectively. Subsequent to the semidry acid hydrolysis with a minimum volume of 6 M HCl sustained by autoclaving, the hydrolysate was diluted with distilled water and neutralized with NaOH (0.5 M). The reducing sugars produced from the semidry acid hydrolysis of cellulose was further used for dark fermentation biohydrogen production by Escherichia coli as a representative of most hydrogen producing eubacteria which cannot utilize non-hydrolyzed cellulose. An isolated E. coli TFYM was used where this bacterium was morphologically and biochemically characterized and further identified by phylogenetic 16S rRNA encoding gene sequence analysis. The reducing sugars produced by semidry acid hydrolysis could be efficiently utilized by E. coli producing 0.4 mol H2 mol−1 hexose with a maximum rate of hydrogen gas production of 23.3 ml H2 h−1 L−1 and an estimated hydrogen yield of 20.5 (L H2 kg−1 dry biomass). The cheap cellulosic biowastes of wheat bran, sawdust and sugarcane bagasse could be hydrolyzed by semidry acid hydrolysis where the estimated hydrogen yield per kg of its dry biomass were 36, 18 and 32 (L H2 kg−1 dry biomass) respectively indicating a good feasibility of hydrogen production from reducing sugars prepared by semidry acid hydrolysis of these cellulosic biowastes. Semidry acid hydrolysis could also be effectively used for hydrolyzing non-cellulosic polysaccharides of dry cyanobacterial biomass. The described semidry acid hydrolysis of cellulosic biowastes in this study might be applicable not only for bacterial biohydrogen production but also for various hydrolyzed cellulose-based fermentation biotechnologies.

scholarly journals Lignocellulosic Biomass Fractionation by Mineral Acids and Resulting Extract Purification Processes: Conditions, Yields, and Purities

Molecules ◽  
2019 ◽  
Vol 24 (23) ◽  
pp. 4273 ◽  
Author(s):  
Vincent Oriez ◽  
Jérôme Peydecastaing ◽  
Pierre-Yves Pontalier
Keyword(s):  
Degradation Products ◽  
Downstream Processing ◽  
Mineral Acid ◽  
Purification Step ◽  
Biomass Fractionation ◽  
Mineral Acids ◽  
Hydrolysis Of Cellulose ◽  
Sugar Degradation ◽  
Fuels And Chemicals ◽  
Hydrolysis Of

Fractionation of lignocellulose is a fundamental step in the valorization of cellulose, hemicelluloses, and lignin to produce various sustainable fuels and chemicals. Mineral acid fractionation is one of the most applied process and leads to the solubilization and hydrolysis of cellulose and hemicelluloses, whereas most of the lignin remains insoluble and can be separated from the extract. The obtained monomeric sugars in the acid extract are in solution with salts, sugar degradation products, and phenolic molecules. Downstream processing is required to purify the sugars and further valorize them into fuels or chemicals with the use of chemical or biochemical reactions. This purification step also allows the recycling of the mineral acid and the valorization of the sugar degradation products and the co-extracted phenolic molecules, adding value to the whole biorefinery scheme. Many purification techniques have been studied, providing several options in terms of yields, purities, and cost of the process. This review presents the conditions used for the mineral acid fractionation step and a wide variety of purification techniques applied on the obtained hydrolysate, with a focus on the associated yields and purities. Values from the literature are expressed in a standard way in order to simplify comparison between the different processes.

Optimization and hydrolysis of cellulose under subcritical water treatment for the production of total reducing sugars

RSC Advances ◽  
2015 ◽  
Vol 5 (125) ◽  
pp. 103265-103275 ◽  
Author(s):  
Mood Mohan ◽  
Robinson Timung ◽  
Narendra Naik Deshavath ◽  
Tamal Banerjee ◽  
Vaibhav V. Goud ◽  
...  
Keyword(s):  
Organic Matter ◽  
Water Treatment ◽  
Process Parameters ◽  
Reducing Sugars ◽  
Subcritical Water ◽  
Reaction Medium ◽  
Hydrolysis Of Cellulose ◽  
Total Reducing Sugars ◽  
Rsm Model ◽  
Hydrolysis Of

Subcritical water (SCW) treatment has gained enormous attention as an environmentally friendly technique for organic matter and an attractive reaction medium for a variety of applications. In the current work the process parameters were optimized by RSM model.

scholarly journals Eco-Friendly Ca-Montmorillonite Grafted by Non-Acidic Ionic Liquid Used as A Solid Acid Catalyst in Cellulose Hydrolysis to Reducing Sugars

Molecules ◽  
2019 ◽  
Vol 24 (9) ◽  
pp. 1832 ◽  
Author(s):  
Yang Zhou ◽  
Miao Yang ◽  
Dongshen Tong ◽  
Haiyan Yang ◽  
Kai Fang
Keyword(s):  
Ionic Liquid ◽  
Reducing Sugars ◽  
Batch Reactor ◽  
Solid Acid Catalyst ◽  
Cellulose Hydrolysis ◽  
Solid Catalyst ◽  
Mass Ratio ◽  
Acidic Ionic Liquid ◽  
Hydrolysis Of Cellulose ◽  
Hydrolysis Of

An effective and friendly method was developed for the production of reducing sugars (RS) from the hydrolysis of cellulose over the solid catalyst of Ca-montmorillonite (Mt) grafted by non-acidic ionic liquid (Mt-IL) in water. The effect of mass ratio, water dosage, reaction temperature, and time were investigated in a batch reactor. Raw Mt showed only a 7.9% total reducing sugars (TRS) yield for the catalytic hydrolysis of cellulose in water. As the Mt was grafted by -SO3H and IL, the TRS yield greatly increased under the same reaction conditions. The highest TRS yield of 35.7% was obtained on the catalyst of Mt grafted by non-acidic IL at 200 °C with the mass ratio of catalyst to cellulose of 0.2 for 120 min. The high TRS yield for Mt-IL should be attributed to the synergistic effect of the dissolution of cellulose by IL and the exposed metal ions on the layer with water. Although the yield of TRS on Mt-IL decreased gradually with recycling runs, the decrease after the first run was not very serious compared to the fresh catalyst. This work provides a promising strategy for efficient cellulose hydrolysis into fine chemicals by Mt with non-acidic IL.

Immobilized Nanoparticles-Mediated Enzymatic Hydrolysis of Cellulose for Clean Sugar Production: A Novel Approach

2019 ◽  
Vol 15 (3) ◽  
pp. 296-303 ◽  
Author(s):  
Swapnil Gaikwad ◽  
Avinash P. Ingle ◽  
Silvio Silverio da Silva ◽  
Mahendra Rai
Keyword(s):  
Catalytic Activity ◽  
Enzymatic Hydrolysis ◽  
Immobilized Enzyme ◽  
Free Enzyme ◽  
Magnetic Nanomaterials ◽  
Sugar Production ◽  
Cellulase Enzyme ◽  
Enzymatic Hydrolysis Of Cellulose ◽  
Hydrolysis Of Cellulose ◽  
Hydrolysis Of

Background: Enzymatic hydrolysis of cellulose is an expensive approach due to the high cost of an enzyme involved in the process. The goal of the current study was to apply magnetic nanomaterials as a support for immobilization of enzyme, which helps in the repeated use of immobilized enzyme for hydrolysis to make the process cost-effective. In addition, it will also provide stability to enzyme and increase its catalytic activity. Objective: The main aim of the present study is to immobilize cellulase enzyme on Magnetic Nanoparticles (MNPs) in order to enable the enzyme to be re-used for clean sugar production from cellulose. Methods: MNPs were synthesized using chemical precipitation methods and characterized by different techniques. Further, cellulase enzyme was immobilized on MNPs and efficacy of free and immobilized cellulase for hydrolysis of cellulose was evaluated. Results: Enzymatic hydrolysis of cellulose by immobilized enzyme showed enhanced catalytic activity after 48 hours compared to free enzyme. In first cycle of hydrolysis, immobilized enzyme hydrolyzed the cellulose and produced 19.5 ± 0.15 gm/L of glucose after 48 hours. On the contrary, free enzyme produced only 13.7 ± 0.25 gm/L of glucose in 48 hours. Immobilized enzyme maintained its stability and produced 6.15 ± 0.15 and 3.03 ± 0.25 gm/L of glucose in second and third cycle, respectively after 48 hours. Conclusion: This study will be very useful for sugar production because of enzyme binding efficiency and admirable reusability of immobilized enzyme, which leads to the significant increase in production of sugar from cellulosic materials.

In Situ Microscopy for In-line Monitoring of the Enzymatic Hydrolysis of Cellulose

2013 ◽  
Vol 85 (17) ◽  
pp. 8121-8126 ◽  
Author(s):  
Britta Opitz ◽  
Andreas Prediger ◽  
Christian Lüder ◽  
Marrit Eckstein ◽  
Lutz Hilterhaus ◽  
...  
Keyword(s):  
Enzymatic Hydrolysis ◽  
Enzymatic Hydrolysis Of Cellulose ◽  
Hydrolysis Of Cellulose ◽  
Hydrolysis Of
Sign in / Sign up

Export Citation Format

Share Document