Application of IWA Anaerobic Digestion Model No. 1 to simulate butyric acid, propionic acid, mixed acid, and ethanol type fermentative systems using a variable acidogenic stoichiometric approach

2019 ◽  
Vol 161 ◽  
pp. 242-250 ◽  
Author(s):  
En Shi ◽  
Jianzheng Li ◽  
Miao Zhang
Keyword(s):  
Anaerobic Digestion ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Mixed Acid

Toxicity of pH, Ammonia and Volatile Fatty Acids on Hydrogenotrophic Methanogen-Enriched Sludge

2014 ◽  
Vol 955-959 ◽  
pp. 527-531
Author(s):  
Jian Zheng Li ◽  
Yu Peng Zhang ◽  
Chong Liu ◽  
Ze Yu Tang
Keyword(s):  
Fatty Acids ◽  
Acetic Acid ◽  
Anaerobic Digestion ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Volatile Fatty Acids ◽  
Batch Experiments ◽  
Inhibitory Effects ◽  
Hydrogenotrophic Methanogen ◽  
The Impact

The activities of methanogen are easily affected by inhibitory substances and lead to anaerobic digestion failure. To investigate inhibitory effects on methanogenesis of a methanogen-enriched sludge, pH, volatile fatty acids (such as acetic acid, propionic acid and butyric acid), and ammonia were used as inhibitory factors and a L16(45) orthogonal table was employed to design batch experiments. The result of variance analyses shows that pH has the greatest impact on the methanogenesis of the enriched culture. The impact of butyrate, NH3, acetate and propionate was decreased in order. DGGE finger-print shows that there was only one methanogen in the inoculum sludge.

Implementation of the IWA anaerobic digestion model No.1 (ADM1) for simulating digestion of blackwater from vacuum toilets

2006 ◽  
Vol 53 (9) ◽  
pp. 253-263 ◽  
Author(s):  
Y. Feng ◽  
J. Behrendt ◽  
C. Wendland ◽  
R. Otterpohl
Keyword(s):  
Acetic Acid ◽  
Anaerobic Digestion ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Reference Conditions ◽  
Batch Experiments ◽  
Organic Loading ◽  
Biochemical Kinetics ◽  
Uptake Rates ◽  
Mesophilic Conditions

The IWA anaerobic digestion model No.1 (ADM1) is applied to the blackwater anaerobic digestion (BWAD) plant in this work. In order to verify the biochemical kinetics, batch experiments were executed. According to the Monod type kinetics, the maximum uptake rates (km) of butyric acid (HBu), propionic acid (HPr) and acetic acid (HAc) are testified as 18, 14, 13 d−1, and their half saturation concentrations (KS) are 110, 120, 160 g COD/m3, respectively. Afterwards, the model was calibrated based on the performance of a laboratory scale BWAD plant (under mesophilic conditions) by three scenario studies, i.e. the reference conditions, different feeding frequencies and high NH4+ concentration. The model successfully simulated three scenarios. The further two virtual scenario studies were achieved based on the calibrated model. First, the performance of BWAD plant was predicted with different hydraulic retention times (HRT); second, the kitchen refuse (KR) was added into the BWAD plant as additional organic loading. The model predicted the perspective of BW plus KR digestion and generated valuable suggestions for the operation of the real BWAD plant.

Changes in amino acid compounds of wheat plants during ensiling and aerobic exposure: the influence of propionic acid and urea phosphate-calcium propionate

1984 ◽  
Vol 102 (3) ◽  
pp. 667-672 ◽  
Author(s):  
G. Ashbell ◽  
H. H. Theune ◽  
D. Sklan
Keyword(s):  
Amino Acids ◽  
Amino Acid ◽  
Glutamic Acid ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Total Amino Acid ◽  
Amino Butyric Acid ◽  
Urea Phosphate ◽  
Fresh Material ◽  
Calcium Propionate

SummaryChanges in distribution of amino acid nitrogen of chopped wheat plants ensiled at shooting and flowering when wilted, and at the milk and dough stages as fresh material, were determined as affected by addition of 0·8% propionic acid (PrA) or 2·2% urea phosphate-calcium propionate (UP-CaPr). Analyses were carried out after an ensiling period of 90 days and after a further aerobic exposure period (AE) of 7 days.Total amino acid (TAA) contents in the dry matter (D.M.) during the fermentation period and in the AE were stable in untreated material (UM) and treated material. Concentration of essential amino acids decreased during fermentation, this decrease being higher in the UM. The free amino acids were low in the fresh material (18·6% of TAA) but increased in the ensiled material to ca. 71 % of the TAA in the silage. In the AE this level was 63% in UM and 69% in treated material. The ammonia-N contents increased during fermentation in UM and especially in the UP-CaPr treatments, while the opposite occurred in the PrA treatments.The concentrations of and changes in 21 amino acids (AAs) are given. The highest AA concentrations recorded in the fresh material were those of arginine, lysine, glutamic acid, alanine, leucine, proline and glycine. The most marked increments in AAs as a result of fermentation were those of ornithine, γ-amino butyric acid, threonine and methionine. Marked decreases were observed in glutamine, arginine and glutamic acid. PrA increased mainly arginine, asparagine and glutamine, whereas γ-amino butyric acid decreased; UP-CaPr increased arginine, asparagine, lysine and glutamic acid (in silage only) and reduced γ-amino butyric acid and glutamine (in AE only).

scholarly journals Observations on the microbiology and biochemistry of the rumen in cattle given different quantities of a pelleted barley ration

1970 ◽  
Vol 24 (1) ◽  
pp. 157-177 ◽  
Author(s):  
J. Margaret Eadie ◽  
J. Hyldgaard-Jensen ◽  
S. O. Mann ◽  
R. S. Reid ◽  
F. G. Whitelaw
Keyword(s):  
Propionic Acid ◽  
Butyric Acid ◽  
Volatile Fatty Acid ◽  
Bacterial Population ◽  
Microbial Population ◽  
Rumen Fluid ◽  
Complete Loss ◽  
Rumen Bacteria ◽  
Diurnal Pattern ◽  
Rumen Ph

1. Three heifers were changed from a diet of equal parts of hay and barley cubes (50:50 diet) to one entirely of barley cubes given in three equal feeds throughout the day. Feed intake was restricted to 80% of calculated appetite at the time of change and this percentage progressively decreased as the live weights of the animals increased.2. The change of diet had no significant effect on the volume of rumen fluid but the rate of outflow from the rumen was significantly lower on the barley diet than on the 50:50 diet.3. Animals on the restricted barley diet developed an exceptionally high rumen ciliate population and the bacterial population was shown by Gram films to include a number of organisms typical of roughage-fed animals. In culture, organisms of the genusBacteroideswere predominant but these appeared largely as cocco-bacilli in the Gram films. This microbial population was associated with a higher proportion of butyric acid than of propionic acid in the rumen fluid.4. Occasional fluctuations in ciliate populations occurred in all three heifers. Decreases in ciliate number were paralleled by increases in propionic acid and decreases in butyric acid but not necessarily by a fall in pH. Under these conditions Gram films showed increases in bacteriodes-type rods and in certain curved Gram-negative rods.5. Rumen ammonia concentrations were on average lower and showed a different diurnal pattern when ciliate numbers were reduced. Lactic acid concentrations were low and were not affected by the size of the ciliate population.6. When the three heifers were given the barley dietad lib. there was a decrease in rumen pH and a complete loss of rumen ciliates. The rumen bacterial population and the volatile fatty acid proportions were similar to those seen during decreases in ciliate number at the restricted level of intake. These changes also occurred in a fourth heifer which was changed fairly rapidly from the 50:50 diet to a restricted amount of the barley diet.7. Two steers which had never had access to roughage were changed fromad lib. to restricted intake of the barley diet and were later given an inoculum of rumen ciliates. The rumen microbial population and the pattern of fermentation so produced were similar to those found in the heifers on the restricted barley diet.8. Anomalous values were noted for total counts of rumen bacteria when free starch grains were present in the rumen fluid.9. It is concluded that large ciliate populations and high proportions of butyric acid can be produced in animals fed exclusively on a barley diet by suitable adjustment of the intake and the method of feeding. It is postulated that the ciliate population may be largely responsible for the high butyric acid concentrations.

scholarly journals Synthetic Effect of EDTA and Ni2+ on Methane Production and Microbial Communities in Anaerobic Digestion Process of Kitchen Wastes

Processes ◽  
2019 ◽  
Vol 7 (9) ◽  
pp. 590
Author(s):  
Tingting Zhong ◽  
Yali Liu ◽  
Xiaorong Kang
Keyword(s):  
Anaerobic Digestion ◽  
Propionic Acid ◽  
Methane Production ◽  
High Throughput Sequencing ◽  
Ethylenediaminetetraacetic Acid ◽  
Speciation Analysis ◽  
Water Soluble ◽  
Sequencing Analysis ◽  
Biogas Yield ◽  
Ni Addition

Batch tests were carried out to study the effect of simultaneous addition of ethylenediaminetetraacetic acid and Ni2+ (EDTA-Ni) on anaerobic digestion (AD) performances of kitchen wastes (KWs). The results indicated that the cumulative biogas yield and methane content were enhanced to 563.82 mL/gVS and 63.7% by adding EDTA-Ni, respectively, which were almost 1.15 and 1.07-fold of that in the R2 with Ni2+ addition alone. At the same time, an obvious decrease of propionic acid was observed after EDTA-Ni addition. The speciation analysis of Ni showed that the percentages of water-soluble and exchangeable Ni were increased to 38.8% and 36.3% due to EDTA-Ni addition, respectively. Also, the high-throughput sequencing analysis revealed that the EDTA-Ni promoted the growth and metabolism of Methanosarcina and Methanobacterium, which might be the major reason for propionic acid degradation and methane production.

scholarly journals Enhanced lipid production by Yarrowia lipolytica cultured with synthetic and waste-derived high-content volatile fatty acids under alkaline conditions

2020 ◽  
Vol 13 (1) ◽  
Author(s):  
Ruiling Gao ◽  
Zifu Li ◽  
Xiaoqin Zhou ◽  
Wenjun Bao ◽  
Shikun Cheng ◽  
...  
Keyword(s):  
Fatty Acids ◽  
Acetic Acid ◽  
Propionic Acid ◽  
Yarrowia Lipolytica ◽  
Butyric Acid ◽  
Lipid Content ◽  
Volatile Fatty Acids ◽  
Lipid Production ◽  
Initial Ph ◽  
Alkaline Conditions

Abstract Background Volatile fatty acids (VFAs) can be effective and promising alternate carbon sources for microbial lipid production by a few oleaginous yeasts. However, the severe inhibitory effect of high-content (> 10 g/L) VFAs on these yeasts has impeded the production of high lipid yields and their large-scale application. Slightly acidic conditions have been commonly adopted because they have been considered favorable to oleaginous yeast cultivation. However, the acidic pH environment further aggravates this inhibition because VFAs appear largely in an undissociated form under this condition. Alkaline conditions likely alleviate the severe inhibition of high-content VFAs by significantly increasing the dissociation degree of VFAs. This hypothesis should be verified through a systematic research. Results The combined effects of high acetic acid concentrations and alkaline conditions on VFA utilization, cell growth, and lipid accumulation of Yarrowia lipolytica were systematically investigated through batch cultures of Y. lipolytica by using high concentrations (30–110 g/L) of acetic acid as a carbon source at an initial pH ranging from 6 to 10. An initial pH of 8 was determined as optimal. The highest biomass and lipid production (37.14 and 10.11 g/L) were obtained with 70 g/L acetic acid, whereas cultures with > 70 g/L acetic acid had decreased biomass and lipid yield due to excessive anion accumulation. Feasibilities on high-content propionic acid, butyric acid, and mixed VFAs were compared and evaluated. Results indicated that YX/S and YL/S of cultures on butyric acid (0.570, 0.144) were comparable with those on acetic acid (0.578, 0.160) under alkaline conditions. The performance on propionic acid was much inferior to that on other acids. Mixed VFAs were more beneficial to fast adaptation and lipid production than single types of VFA. Furthermore, cultures on food waste (FW) and fruit and vegetable waste (FVW) fermentate were carried out and lipid production was effectively improved under this alkaline condition. The highest biomass and lipid production on FW fermentate reached 14.65 g/L (YX/S: 0.414) and 3.20 g/L (YL/S: 0.091) with a lipid content of 21.86%, respectively. By comparison, the highest biomass and lipid production on FVW fermentate were 11.84 g/L (YX/S: 0.534) and 3.08 g/L (YL/S: 0.139), respectively, with a lipid content of 26.02%. Conclusions This study assumed and verified that alkaline conditions (optimal pH 8) could effectively alleviate the lethal effect of high-content VFA on Y. lipolytica and significantly improve biomass and lipid production. These results could provide a new cultivation strategy to achieve simple utilizations of high-content VFAs and increase lipid production. Feasibilities on FW and FVW-derived VFAs were evaluated, and meaningful information was provided for practical applications.

scholarly journals Impact of Alkaline Pretreatment to Enhance Volatile Fatty Acids (VFAs) Production from Rice Husk

2019 ◽  
Vol 2019 ◽  
pp. 1-8 ◽  
Author(s):  
Qian Fang ◽  
Sinmin Ji ◽  
Dingwu Huang ◽  
Zhouyue Huang ◽  
Zilong Huang ◽  
...  
Keyword(s):  
Fatty Acids ◽  
Acetic Acid ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Rice Husk ◽  
Volatile Fatty Acids ◽  
Alkaline Pretreatment ◽  
Rice Husks ◽  
Acid Fermentation ◽  
Study Results

This study explores the use of alkaline pretreatments to improve the hydrolyzation of rice husks to produce volatile fatty acids (VFAs). The study investigated the effects of reagent concentration and pretreatment time on protein, carbohydrates, and dissolved chemical oxygen demand (SCOD) dissolution after the pretreatment. The optimum alkaline pretreatment conditions were 0.30 g NaOH (g VS)−1, with a reaction time of 48 h. The experimental results show that when comparing the total VFA (TVFA) yields from the alkaline-pretreated risk husk with those from the untreated rice husk, over 14 d and 2 d, the maximum value reached 1237.7 and 716.0 mg·L−1 with acetic acid and propionic acid and with acetic acid and butyric acid, respectively. After the alkaline pretreatment, TVFAs increased by 72.9%; VFA accumulation grew over time. The study found that alkaline pretreatment can improve VFA yields from rice husks and transform butyric acid fermentation into propionic acid fermentation. The study results can provide guidelines to support the comprehensive utilization of rice husk and waste treatment.

scholarly journals Fermentation and bulking capacity of indigestible carbohydrates: the case of inulin and oligofructose

2002 ◽  
Vol 87 (S2) ◽  
pp. S163-S168 ◽  
Author(s):  
M. Nyman
Keyword(s):  
Fatty Acids ◽  
Molecular Weight ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Colonic Mucosa ◽  
Short Chain Fatty Acids ◽  
Short Chain ◽  
Acid Formation ◽  
Fresh Weight ◽  
Chain Fatty Acids

The bulking index (i.e. the increase in faecal fresh weight in gram per gram indigestible carbohydrate ingested) with oligofructose and inulin is similar to that produced with other easily fermented fibres such as pectins and gums. Most studies in man have been performed at a level of 15 g/d and more investigations on lower intakes are needed to appoint the least intake for an effect. Concerning short-chain fatty acids (SCFA) most studies have been using oligofructose and points at an increased butyric acid formation in the caecum of rats. In one study on rats with inulin high caecal proportions of propionic acid were obtained. As inulin has a higher molecular weight than oligofructose it might be speculated if this could be a reason to the different SCFA-profile formed. No effects on faecal concentrations of SCFA in humans have been revealed with inulin and oligofructose, which neither is expected as most of the SCFA formed during the fermentation already has been absorbed or utilized by the colonic mucosa.

Effect of diet on individual volatile fatty acids in the rumen of sheep, with particular reference to the effect of low rumen pH and adaptation on high-starch diets

1957 ◽  
Vol 8 (6) ◽  
pp. 691 ◽  
Author(s):  
RL Reid ◽  
JP Hogan ◽  
PK Briggs
Keyword(s):  
Fatty Acids ◽  
Propionic Acid ◽  
Butyric Acid ◽  
Acid Production ◽  
Volatile Fatty Acids ◽  
Maximum Level ◽  
Fatty Acid Production ◽  
Rumen Ph ◽  
Term Change ◽  
Effects Of Ph

Detailed data are presented on changes in the proportions of acetic, propionic, and butyric acids in the rumen after feeding on various diets. Pre-feeding proportions were constant on each diet but varied from a mixture of 72-76 per cent. acetic, 14-16 per cent. propionic, and 10-12 per cent. butyric acid on all-roughage diets to one of 63-65 per cent. acetic, 18-20 per cent. propionic, and 16-18 per cent. butyric acid on a diet containing 70 per cent. wheat grain. On all diets the proportion of propionic acid increased after feeding and reached a peak which coincided with the maximum level of total volatile fatty acids. The response of butyric acid was variable, low levels being recorded on a diet of lucerne chaff and on one containing a high proportion of cracked maize. The proportion of acetic acid always declined after feeding. These responses were modified in experiments on rations containing high proportions of wheaten starch, in which rumen pH fell below 5.0 as a result of lactic acid accumulation. When animals were first fed on such diets, a decline in rumen pH below 5.0-5.5 after feeding was always associated with a pronounced decline in the proportions of propionic and butyric acids, to levels as low as 8 and 5 per cent. respectively. Continued feeding of such diets did not affect the response of butyric acid, but there was evidence of a change in propionic acid production in response to low pH conditions, both in respect to short-term change during experiments in which low rumen pH levels were maintained for considerable periods and to long-term change when such diets were fed intermittently over considerable periods. The implications of these findings are discussed with respect to the effects of pH on individual volatile fatty acid production in the rumen, and on the qualitative nature of the microbial population and on their metabolic patterns.

Sign in / Sign up

Export Citation Format

Share Document