Gelation of casein-whey mixtures: effects of heating whey proteins alone or in the presence of casein micelles

2001 ◽  
Vol 68 (3) ◽  
pp. 471-481 ◽  
Author(s):  
CATHERINE SCHORSCH ◽  
DEBORAH K. WILKINS ◽  
MALCOLM G. JONES ◽  
IAN T. NORTON
Keyword(s):  
Heat Treatment ◽  
Whey Protein ◽  
Protein Denaturation ◽  
Whey Proteins ◽  
Treatment Sequence ◽  
Gel Properties ◽  
Casein Micelles ◽  
Gelation Kinetics ◽  
Milk Gelation

The aim of the present work was to investigate the role of whey protein denaturation on the acid induced gelation of casein. This was studied by determining the effect of whey protein denaturation both in the presence and absence of casein micelles. The study showed that milk gelation kinetics and gel properties are greatly influenced by the heat treatment sequence. When the whey proteins are denatured separately and subsequently added to casein micelles, acid-induced gelation occurs more rapidly and leads to gels with a more particulated microstructure than gels made from co-heated systems. The gels resulting from heat-treatment of a mixture of pre-denatured whey protein with casein micelles are heterogeneous in nature due to particulates formed from casein micelles which are complexed with denatured whey proteins and also from separate whey protein aggregates. Whey proteins thus offer an opportunity not only to control casein gelation but also to control the level of syneresis, which can occur.

Effects of heat treatment and acidification on the dissociation of bovine casein micelles

1996 ◽  
Vol 63 (1) ◽  
pp. 35-48 ◽  
Author(s):  
Andrew J. R. Law
Keyword(s):  
Heat Treatment ◽  
Whey Proteins ◽  
Raw Milk ◽  
Serum Concentrations ◽  
Casein Micelles ◽  
Heat Treated ◽  
Decreasing Ph ◽  
The Individual ◽  
Almost All

SummaryThe effects of heat treatment and subsequent acidification of milk on the distribution of proteins, Ca and Pi, between the serum and micellar phases were examined using ultracentrifugation. After heating milk at 85 °C for 10 min, and storing for 22 h at 4, 20 or 30 °C, there was a marked increase in the concentration of κ-casein in the serum. At 4 and 20 °C there was also slightly more β-casein in the serum from heat-treated milk than in that from the corresponding raw milk. The whey proteins were extensively denatured, and were almost equally distributed between the supernatants and micellar pellets. After storage for 22 h the distribution of Ca and Pi between soluble and colloidal phases in heat-treated milk was similar to that in raw milk. After acidifying heat-treated milk by the addition of glucono-δ-lactone and storing for 22 h at 4, 20 or 30 °C there was progressive solubilization of colloidal calcium phosphate with decreasing pH, and at pH 5·0 almost all of the Ca and Pi was present in the serum. At 20 °C, and even more so at 4 °C, serum concentrations of the individual caseins increased considerably with decreasing pH, reaching maximum levels of about 25 and 40% of the total casein at pH 5·7 and 5·5 respectively, and then decreasing rapidly at lower pH. Compared with raw milk, maximum dissociation in heat-treated milks stored at 4 and 20 °C occurred at higher pH, and the overall levels of dissociation of individual caseins from the micelles were lower. At 30 °C, the concentrations of individual caseins in the serum of heat-treated milk decreased steadily as the pH was reduced, and did not show the slight increase found previously for raw milk. The role of the denatured whey proteins in interacting with κ-casein and in promoting aggregation of the micelles on acidification is discussed.

Association of denatured whey proteins with casein micelles in heated reconstituted skim milk and its effect on casein micelle size

2003 ◽  
Vol 70 (1) ◽  
pp. 73-83 ◽  
Author(s):  
Skelte G Anema ◽  
Yuming Li
Keyword(s):  
Heat Treatment ◽  
Particle Size ◽  
Whey Protein ◽  
Volume Fraction ◽  
Whey Proteins ◽  
Skim Milk ◽  
Casein Micelle ◽  
Casein Micelles ◽  
Prolonged Heating ◽  
Micelle Size

When skim milk at pH 6·55 was heated (75 to 100 °C for up to 60 min), the casein micelle size, as monitored by photon correlation spectroscopy, was found to increase during the initial stages of heating and tended to plateau on prolonged heating. At any particular temperature, the casein micelle size increased with longer holding times, and, at any particular holding time, the casein micelle size increased with increasing temperature. The maximum increase in casein micelle size was about 30–35 nm. The changes in casein micelle size were poorly correlated with the level of whey protein denaturation. However, the changes in casein micelle size were highly correlated with the levels of denatured whey proteins that were associated with the casein micelles. The rate of association of the denatured whey proteins with the casein micelles was considerably slower than the rate of denaturation of the whey proteins. Removal of the whey proteins from the skim milk resulted in only small changes in casein micelle size during heating. Re-addition of β-lactoglobulin to the whey-protein-depleted milk caused the casein micelle size to increase markedly on heat treatment. The changes in casein micelle size induced by the heat treatment of skim milk may be a consequence of the whey proteins associating with the casein micelles. However, these associated whey proteins would need to occlude a large amount of serum to account for the particle size changes. Separate experiments showed that the viscosity changes of heated milk and the estimated volume fraction changes were consistent with the particle size changes observed. Further studies are needed to determine whether the changes in size are due to the specific association of whey proteins with the micelles or whether a low level of aggregation of the casein micelles accompanies this association behaviour. Preliminary studies indicated lower levels of denatured whey proteins associated with the casein micelles and smaller changes in casein micelle size occurred as the pH of the milk was increased from pH 6·5 to pH 6·7.

Kinetics of heat-induced whey protein denaturation and aggregation in skim milks with adjusted whey protein concentration

2005 ◽  
Vol 72 (3) ◽  
pp. 369-378 ◽  
Author(s):  
David J Oldfield ◽  
Harjinder Singh ◽  
Mike W Taylor
Keyword(s):  
Whey Protein ◽  
Protein Concentration ◽  
Protein Denaturation ◽  
Polyacrylamide Gel Electrophoresis ◽  
Whey Proteins ◽  
Pilot Scale ◽  
Casein Micelles ◽  
Reaction Orders ◽  
Β Lactoglobulin ◽  
Kinetics Of

Microfiltration and ultrafiltration were used to manufacture skim milks with an increased or reduced concentration of whey proteins, while keeping the casein and milk salts concentrations constant. The skim milks were heated on a pilot-scale UHT plant at 80, 90 and 120 °C. The heat-induced denaturation and aggregation of β-lactoglobulin (β-lg), α-lactalbumin (α-la) and bovine serum albumin (BSA) were quantified by polyacrylamide gel electrophoresis. Apparent rate constants and reaction orders were calculated for β-lg, α-la and BSA denaturation. Rates of β-lg, α-la and BSA denaturation increased with increasing whey protein concentration. The rate of α-la and BSA denaturation was affected to a greater extent than β-lg by the change in whey protein concentration. After heating at 120 °C for 160 s, the concentration of β-lg and α-la associated with the casein micelles increased as the initial concentration of whey proteins increased.

Changes in milk on heating: viscosity measurements

1993 ◽  
Vol 60 (2) ◽  
pp. 139-150 ◽  
Author(s):  
Theo J. M. Jeurnink ◽  
Kees G. De Kruif
Keyword(s):  
Heat Treatment ◽  
Heat Exchangers ◽  
Hard Spheres ◽  
Whey Proteins ◽  
Skim Milk ◽  
Quantitative Model ◽  
Casein Micelles ◽  
Mutual Attraction ◽  
Viscosity Measurements ◽  
Quantitative Basis

SummarySkim milk was heated at 85 °C for different holding times. As a result of such heating, whey proteins, in particular β-lactoglobulin, denatured and associated with casein micelles. This led to an increase in size of the casein micelles but also to a different interaction between them. Both these changes could be described by using a quantitative model which was developed for the viscosity of so-called adhesive hard spheres. We applied the model successfully to skim milk and were able to describe on a quantitative basis the changes due to the heat treatment of milk. It was shown that after heating the casein micelles became larger and acquired a mutual attraction. The unfolding of the whey proteins and their subsequent association with the casein micelles appeared to be responsible for these changes. How this reaction influences the fouling of heat exchangers is discussed.

Heat stability of milk: pH-dependent dissociation of micellar κ-casein on heating milk at ultra high temperatures

1985 ◽  
Vol 52 (4) ◽  
pp. 529-538 ◽  
Author(s):  
Harjinder Singh ◽  
Partick F. Fox
Keyword(s):  
Whey Protein ◽  
Whey Proteins ◽  
Heat Stability ◽  
Casein Micelle ◽  
Casein Micelles ◽  
Ph Profile ◽  
Ph Values ◽  
Maximum Stability ◽  
Β Lactoglobulin ◽  
Maximum Minimum

SUMMARYPreheating milk at 140 °C for 1 min at pH 6·6, 6·8, 7·0 or 7·2 shifted the heat coagulation time (HCT)/pH profile to acidic values without significantly affecting the maximum stability. Whey proteins (both β-lactoglobulin and α-lactalbumin) co-sedimented with the casein micelles after heating milk at pH < 6·9 and the whey protein-coated micelles, dispersed in milk ultrafiltrate, showed characteristic maxima–minima in their HCT/pH profile. Heating milk at higher pH values (> 6·9) resulted in the dissociation of whey proteins and κ-casein-rich protein from the micelles and the residual micelles were unstable, without a maximum–minimum in the HCT/pH profile. Preformed whey protein–casein micelle complexes formed by preheating (140 °C for 1 min) milk at pH 6·7 dissociated from the micelles on reheating (140 °C for 1 min) at pH > 6·9. The dissociation of micellar-κ-casein, perhaps complexed with whey proteins, may reduce the micellar zeta potential at pH ≃ 6·9 sufficiently to cause a minimum in the HCT/pH profile of milk.

Comparison of heat and pressure treatments of skim milk, fortified with whey protein concentrate, for set yogurt preparation: effects on milk proteins and gel structure

2000 ◽  
Vol 67 (3) ◽  
pp. 329-348 ◽  
Author(s):  
ERIC C. NEEDS ◽  
MARTA CAPELLAS ◽  
A. PATRICIA BLAND ◽  
PRETIMA MANOJ ◽  
DOUGLAS MACDOUGAL ◽  
...  
Keyword(s):  
Heat Treatment ◽  
Whey Protein ◽  
Skim Milk ◽  
Milk Proteins ◽  
Whey Protein Concentrate ◽  
Protein Concentrate ◽  
Casein Micelles ◽  
Micelle Structure ◽  
Dynamic Structures ◽  
Β Lactoglobulin

Heat (85 °C for 20 min) and pressure (600 MPa for 15 min) treatments were applied to skim milk fortified by addition of whey protein concentrate. Both treatments caused > 90% denaturation of β-lactoglobulin. During heat treatment this denaturation took place in the presence of intact casein micelles; during pressure treatment it occurred while the micelles were in a highly dissociated state. As a result micelle structure and the distribution of β-lactoglobulin were different in the two milks. Electron microscopy and immunolabelling techniques were used to examine the milks after processing and during their transition to yogurt gels. The disruption of micelles by high pressure caused a significant change in the appearance of the milk which was quantified by measurement of the colour values L*, a* and b*. Heat treatment also affected these characteristics. Casein micelles are dynamic structures, influenced by changes to their environment. This was clearly demonstrated by the transition from the clusters of small irregularly shaped micelle fragments present in cold pressure-treated milk to round, separate and compact micelles formed on warming the milk to 43 °C. The effect of this transition was observed as significant changes in the colour indicators. During yogurt gel formation, further changes in micelle structure, occurring in both pressure and heat-treated samples, resulted in a convergence of colour values. However, the microstructure of the gels and their rheological properties were very different. Pressure-treated milk yogurt had a much higher storage modulus but yielded more readily to large deformation than the heated milk yogurt. These changes in micelle structure during processing and yogurt preparation are discussed in terms of a recently published micelle model.

Comparative studies of loading lipophilic substances into casein micelles and investigating the influence of whey proteins and heat treatment on loading stability

2018 ◽  
Vol 71 (4) ◽  
pp. 954-965 ◽  
Author(s):  
Henrike Moeller ◽  
Dierk Martin ◽  
Katrin Schrader ◽  
Wolfgang Hoffmann ◽  
Stefanie Pargmann ◽  
...  
Keyword(s):  
Heat Treatment ◽  
Comparative Studies ◽  
Whey Proteins ◽  
Casein Micelles ◽  
Lipophilic Substances

scholarly journals Yoghurt-Type Gels from Skim Sheep Milk Base Enriched with Whey Protein Concentrate Hydrolysates and Processed by Heating or High Hydrostatic Pressure

Foods ◽  
2019 ◽  
Vol 8 (8) ◽  
pp. 342 ◽  
Author(s):  
Sakkas ◽  
Tzevdou ◽  
Zoidou ◽  
Gkotzia ◽  
Karvounis ◽  
...  
Keyword(s):  
Heat Treatment ◽  
Hydrostatic Pressure ◽  
Whey Protein ◽  
High Hydrostatic Pressure ◽  
Chelating Agent ◽  
Trisodium Citrate ◽  
Whey Protein Concentrate ◽  
Protein Concentrate ◽  
Gel Properties ◽  
Sheep Milk

An objective of the present study was the enrichment of skim sheep yoghurt milk base with hydrolysates (WPHs) of whey protein concentrate (WP80) derived from Feta cheesemaking. Moreover, the use of high hydrostatic pressure (HP) treatment at 600 MPa/55 C/10 min as an alternative for heat treatment of milk bases, was studied. In brief, lyophilized trypsin and protamex hydrolysates of WP80 produced under laboratory conditions were added in skim sheep milk. The composition and heat treatment conditions were set after the assessment of the heat stability of various mixtures; trisodium citrate was used as a chelating agent, when needed. According to the results, the conditions of heat treatment were more important for the physical properties of the gel than the type of enrichment. High pressure treatment resulted in inferior gel properties, irrespective of the type of enrichment. Supplementation of skim sheep milk with whey protein hydrolysates at >0.5% had a detrimental effect on gel properties. Finally, skim sheep milk base inoculated with fresh traditional yoghurt, resulted in yoghurt-type gels with high counts of Lb. delbrueckii subsp. bulgaricus and Str. thermophilus -close to the ideal 1:1- and with a high ACE inhibitory activity >65% that were not essentially affected by the experimental factors.

Heat stability of milk: further studies on the pH-dependent dissociation of micellar κ-casein

1986 ◽  
Vol 53 (2) ◽  
pp. 237-248 ◽  
Author(s):  
Harjinder Singh ◽  
Patrick F. Fox
Keyword(s):  
Whey Protein ◽  
Cetyltrimethylammonium Bromide ◽  
Opposite Effect ◽  
Whey Proteins ◽  
Sodium Dodecyl ◽  
Skim Milk ◽  
Heat Stability ◽  
Casein Micelles ◽  
Acetylneuraminic Acid ◽  
Ph Dependent

SUMMARYWhey protein complexed and became co-sedimentable with casein micelles after heating milk at ≥ 90°C for 10 min at pH ≤ 6·9 while at higher pH values (7·3) whey proteins and κ-casein-rich protein dissociated from the micelles on heating. κ-Casein-deficient micelles were more sensitive to heat, Ca2+ or ethanol than whey protein-coated or native micelles and were readily coagulable by rennet. Isolated κ-casein added to skim milk before preheating (90°C for 10 min) did not associate with the micelles at pH ≥ 6·9. Sodium dodecyl sulphate increased the level of both non-sedimentable N (NSN) and N-acetylneuraminic acid (NANA) and shifted the NSN-pH and NANA-pH curves to more acidic values while cetyltrimethylammonium bromide had the opposite effect. It is suggested that the pH-dependent dissociation in micellar κ-casein, which appears to be reversible, depends on the surface charge on the micelles; at a certain negative charge, disruption of hydrophobic and electrostatic forces could result in the dissociation of κ-casein from the casein micelles.

The influence of pH and heat treatment on the colour and stability of ultra-high-temperature sterilized milk

1971 ◽  
Vol 38 (3) ◽  
pp. 393-401 ◽  
Author(s):  
J. G. Zadow
Keyword(s):  
Heat Treatment ◽  
Sodium Citrate ◽  
Whey Proteins ◽  
Raw Milk ◽  
Hydrogen Phosphate ◽  
Sediment Formation ◽  
Bacterial Action ◽  
Sterilized Milk ◽  
Influence Of Ph

SummaryWhen the pH of milk was varied within the range 7·1 to 6·3 by addition of acid or alkali or through bacterial action, the reflectance of the milk after subsequent ultra-heat-treatment (UHT) was at a maximum of about pH 6·70. Below this value the reflectance dropped rapidly with decrease in pH. The cause of this decrease was the development of increasing amounts of sediment in the product. At pH 6·4–6·5, at least 90% of the casein and 40% of the whey proteins had been precipitated. The addition of 0·1% sodium di-hydrogen phosphate or 0·1% sodium citrate to the raw milk prevented the formation of the sediment. The role of calcium appeared important as small additions of calcium chloride or EDTA altered the patterns of sediment formation and reflectance with changing pH. Addition of 0·3% EDTA prevented sediment formation as the pH dropped.

Sign in / Sign up

Export Citation Format

Share Document