Improving Gypsum Slurry Filtration in the Production of Phosphoric Acid by Adding Cationic Amphiphilic Copolymer

2012 ◽  
Vol 550-553 ◽  
pp. 919-926 ◽  
Author(s):  
Yong Liu ◽  
De Jun Fei ◽  
Ya Gu Dang ◽  
Jian Xun Wu ◽  
Guang Chao Du

A cationic amphiphilic copolymer was synthesized with acrylamide (AM), dimethyl diallyl ammonium chloride (DMDAAC), monomer B by solution copolymerization. Through the orthogonal test, the optimum synthesis condition was obtained as follow: the solid content of the polymerization system is 10%, the pH value is 4.0, the polymerization temperature is 60°C, the concentration of the initiator is 0.06%, and the monomer ratio of m (AM): m (DMDAAC): m (monomer B) is 70:10:20. The copolymer was used for the filtration aiding in the wet process phosphoric acid. The filtration rate of the gypsum slurry is increased by 4.8 times, and the filter cake moisture is reduced by 11.79%, with the addition of PADB. The mechanism of filtration aiding was also researched, which shows that PADB can change the mean diameter of crystals and agglomerate the tiny crystals; PADB can decrease the surface tension of the filter liquor and enhance the hydrophobicity of the gypsum.

1984 ◽  
Vol 28 ◽  
pp. 221-226
Author(s):  
Wendell D. Wilhide ◽  
Doris H. Ash

AbstractRapid X-ray fluorescence (XRF) analytical methods have been developed for analyzing wet-process phosphoric acid liquid samples and by-product calcium sulfate filter-cake solids. Liquid acid samples are neutralized by lithium carbonate and pressed-pellet, dry sample wafers are prepared for a nine-element analysis. Filter-cake solids are dehydrated to anhydrous calcium sulfate for a ten-element analysis. Hovel sample preparation techniques are described which permit maximum use of the automated XRF system for process control. Precision obtained for typical materials is compared with results of conventional chemical analyses.


2012 ◽  
Vol 557-559 ◽  
pp. 961-967 ◽  
Author(s):  
Guang Chao Du ◽  
De Jun Fei ◽  
Jian Xun Wu ◽  
Ya Gu Dang ◽  
Yong Liu ◽  
...  

A novel copolymer PADA which has two functions of flocculation and surface activity was synthesized in aqueous solution. The copolymer was applied to filtration aiding on wet-process phosphoric acid (WPA). The results show that PADA can increase the filtration rate of the phosphoric acid slurry and decrease the moisture of the filter cake. The mechanism of filtration aiding was studied. PADA neutralizes the surface potential of the phosphogypsum and makes the microcrystal particles flocculate to conglobation, which indicate that electrostatic neutralization and flocculation might be the action modes in the process of filtration aiding. The shortest flocculation time and largest average diameter of floccules can be obtained with the addition of 10 ppm PADA. The average pore size and porosity of the filter cake are enlarged by 0.22 μm and 15.38% respectively with the addition of PADA. The surface contact angle of the phosphogypsum is increased by 3.4° with PADA presence.


1954 ◽  
Vol 26 (6) ◽  
pp. 1060-1061 ◽  
Author(s):  
J. A. Brabson ◽  
W. D. Wilhide

2009 ◽  
Vol 9 (5) ◽  
pp. 1579-1595 ◽  
Author(s):  
C. Galy-Lacaux ◽  
D. Laouali ◽  
L. Descroix ◽  
N. Gobron ◽  
C. Liousse

Abstract. Long-term precipitation chemistry have been recorded in the rural area of Banizoumbou (Niger), representative of a semi-arid savanna ecosystem. A total of 305 rainfall samples ~90% of the total annual rainfall) were collected from June 1994 to September 2005. From ionic chromatography, pH major inorganic and organic ions were detected. Rainwater chemistry is controlled by soil/dust emissions associated with terrigeneous elements represented by SO42−, Ca2+, Carbonates, K+ and Mg2+. It is found that calcium and carbonates represent ~40% of the total ionic charge. The second highest contribution is nitrogenous, with annual Volume Weighed Mean (VWM) for NO3− and NH4+ concentrations of 11.6 and 18.1 μeq.l−1, respectively. This is the signature of ammonia sources from animals and NOx emissions from savannas soil-particles rain-induced. The mean annual NH3 and NO2 air concentration are of 6 ppbv and 2.6 ppbv, respectively. The annual VWM precipitation concentration of sodium and chloride are both of 8.7 μeq.l−1 which reflects the marine signature of monsoonal and humid air masses. The median pH value is of 6.05. Acidity is neutralized by mineral dust, mainly carbonates, and/or dissolved gases such NH3. High level of organic acidity with 8μeq.l−1 and 5.2 μeq.l−1 of formate and acetate were also found. The analysis of monthly Black Carbon emissions and Fraction of Absorbed Photosynthetically Active Radiation (FAPAR) values show that both biogenic emission from vegetation and biomass burning could explain the rainfall organic acidity content. The interannual variability of the VWM concentrations around the mean (1994–2005) is between ±5% and ±30% and mainly due to variations of sources strength and rainfall spatio-temporal distribution. From 1994 to 2005, the total mean wet deposition flux in the Sahelian region is of 60.1 mmol.m−2.yr−1 ±25%. Finally, Banizoumbou measurements are compared to other long-term measurements of precipitation chemistry in the wet savanna of Lamto (Côte d'Ivoire) and in the forested zone of Zoétélé (Cameroon). The total chemical loading presents a maximum in the dry savanna and a minimum in the forest (from 143.7, 100.2 to 86.6 μeq.l−1), associated with the gradient of terrigeneous sources. The wet deposition fluxes present an opposite trend, with 60.0 mmol.m−2.yr−1 in Banizoumbou, 108.6 mmol.m−2.yr−1 in Lamto and 162.9 mmol.m−2.yr−1 in Zoétélé, controlled by rainfall gradient along the ecosystems transect.


2013 ◽  
Vol 20 (0) ◽  
pp. 183-195 ◽  
Author(s):  
Xuhong JIA ◽  
Jun LI ◽  
Yang JIN ◽  
Jianhong LUO ◽  
Baoming WANG ◽  
...  

1960 ◽  
Vol 199 (4) ◽  
pp. 731-732 ◽  
Author(s):  
Jack R. Luick ◽  
Harold R. Parker ◽  
A. C. Andersen

A statistical study has been made of the composition of the major C-containing compounds taken from beagle dog milk during the 3rd through 5th week of lactation. The mean values are as follows: 26% total solids, 13% fat, 3.3% lactose and 9.8% protein. Total solid content was found to vary with fat content according to the equation: % total solids = 15.6 + 0.85 % fat.


2018 ◽  
Vol 57 (20) ◽  
pp. 6968-6979
Author(s):  
Hang Ma ◽  
Xiao Feng ◽  
Chun Deng

Sign in / Sign up

Export Citation Format

Share Document