Reaction Sintering of Tial Intermetallic Compound

2021 ◽  
Vol 1016 ◽  
pp. 744-748
Author(s):  
Yoshihiro Kohama ◽  
Masahiro Kimura ◽  
Toru Shimizu ◽  
Hisaki Watari

Improvement of fuel efficiency and reduction of carbon dioxide emission are important issues in the automotive and aviation industries. To achieve these issues, materials that are lightweight and have excellent heat resistance are required. For this reason, various alloys have been proposed. Among them, TiAl intermetallic compounds have excellent low specific gravity and high strength at high temperature. However, TiAl is difficult for machining and easily oxidized, so casting is difficult. For this reason, a method using reaction sintering has been studied, though it is difficult to obtain low oxygen concentration TiAl alloy powder. Therefore, the process to produce TiAl parts from Ti powder and Al powder is studied. However, in this method, when a mixed powder of Ti and Al is sintered, a phenomenon called ignition with a rapid temperature increasing may occurs, and ignited parts are swelling and becomes high porosity.

2012 ◽  
Vol 53 (6) ◽  
pp. 1075-1077 ◽  
Author(s):  
J.-M. Oh ◽  
B.-K. Lee ◽  
C.-Y. Suh ◽  
S.-W. Cho ◽  
J.-W. Lim

2021 ◽  
Vol 560 ◽  
pp. 179-185
Author(s):  
Adiza Abass ◽  
Tokuju Okano ◽  
Kotchakorn Boonyaleka ◽  
Ryo Kinoshita-Daitoku ◽  
Shoji Yamaoka ◽  
...  

1982 ◽  
Vol 92 (1) ◽  
pp. 172 ◽  
Author(s):  
J. H. Hendry ◽  
J. V. Moore ◽  
B. W. Hodgson ◽  
J. P. Keene

2013 ◽  
Vol 39 (1) ◽  
pp. 83-91 ◽  
Author(s):  
Katarzyna Bernat

Abstract In this study, the dependence between volumetric exchange rate (n) in an SBR (Sequencing Batch Reactor) with a modified cycle and simultaneous nitrification and denitrification (SND) efficiency during the treatment of anaerobic sludge digester supernatant was determined. In the SBR cycle alternating three aeration phases (with limited dissolved oxygen (DO) concentration up to 0.7 mg O2/L) and two mixing phases were applied. The lengths of each aeration and mixing phases were 4 and 5.5 h, respectively. Independently of n, a total removal of ammonium was achieved. However, at n = 0.1 d-1 and n = 0.3 d-1 nitrates were the main product of nitrification, while at n = 0.5 d-1, both nitrates and nitrites occurred in the effluent. Under these operational conditions, despite low COD/N (ca. 4) ratio in the influent, denitrification in activated sludge was observed. A higher denitrification efficiency at n = 0.5 d-1 (51.3%) than at n = 0.1 d-1 (7.8%) indicated that n was a crucial factor influencing SND via nitrite and nitrate in the SBR with a low oxygen concentration in aeration phases.


2009 ◽  
Vol 69 (1) ◽  
pp. 1-18 ◽  
Author(s):  
LP. Sartori ◽  
MG. Nogueira ◽  
R. Henry ◽  
EM. Moretto

During three consecutive years, monthly samples of zooplankton were taken in the lacustrine (dam) zone of Jurumirim (São Paulo, Brazil). The seasonal effect on basic limnological features (thermal regime, oxygen distribution, phytoplankton biomass, etc.) was also examined. The influence of the seasonality on the fluctuation of the zooplankton composition and abundance was not clearly detected (low degree of recurrent patterns). Rotifers (32 taxa) were the most abundant organisms during almost the entire study period with some seasonal alternations in the maximum abundance peaks of the main taxa (Conochilus unicornis, Keratella americana, K. cochlearis and Hexarthra spp.), except for Polyarthra (mainly P. vulgaris). Only occasionally copepods were numerically dominant. Higher copepod abundance was positively associated to periods of increase in the water retention time. Among the Copepoda (10 taxa) the calanoids (mainly Notodiaptomus iheringi) were more abundant, especially in warmer periods. Conversely, cyclopoids had higher abundance in autumn and winter. The species Thermocyclops minutus and T. decipiens co-occurred, but the first attained higher abundance. Some evidence of co-existence strategies between both species are considered. Cladocera (17 taxa) was never numerically dominant and the main taxa (Bosmina spp., Ceriodaphnia spp. and Diaphanosoma spp.) occurred almost the whole study period and did not present a seasonal pattern of fluctuation. Diaphanosoma (mainly D. birgei) attained the highest abundance among cladocerans. Most organisms were always found at the surface, but they also occupy the whole water column, even in periods of stratified conditions and low oxygen concentration in the bottom layers. Among the main zooplanktonic taxa, only Hexarthra avoids deep layers. An exceptionally high concentration of Copepoda nauplii on the surface was influenced by low transparency, high concentration of phytoplankton at this layer and low oxygen concentration at the bottom. In periods of higher retention timevariability there was a more heterogeneous distribution of the zooplankton in the water column. The increase in the retention time seems also to favor the copepod development. Finally, some inter-decade changes are considered on the basis of zooplankton assemblage structure observations.


2006 ◽  
Vol 87 (5) ◽  
pp. 1197-1201 ◽  
Author(s):  
Charlotte Servais ◽  
Perrine Caillet-Fauquet ◽  
Marie-Louise Draps ◽  
Thierry Velu ◽  
Yvan de Launoit ◽  
...  

Vectors derived from the autonomous parvovirus Minute virus of mice, MVM(p), are promising tools for the gene therapy of cancer. The validation of their in vivo anti-tumour effect is, however, hampered by the difficulty to produce high-titre stocks. In an attempt to increase vector titres, host cells were subjected to low oxygen tension (hypoxia). It has been shown that a number of viruses are produced at higher titres under these conditions. This is the case, among others, for another member of the family Parvoviridae, the erythrovirus B19 virus. Hypoxia stabilizes a hypoxia-inducible transcription factor (HIF-1α) that interacts with a ‘hypoxia-responsive element’ (HRE), the consensus sequence of which (A/GCGTG) is present in the B19 and MVM promoters. Whilst the native P4 promoter was induced weakly in hypoxia, vector production was reduced dramatically, and adding HRE elements to the P4 promoter of the vector did not alleviate this reduction. Hypoxia has many effects on cell metabolism. Therefore, even if the P4 promoter is activated, the cellular factors that are required for the completion of the parvoviral life cycle may not be expressed.


Sign in / Sign up

Export Citation Format

Share Document