Thermal Inactivation of Salmonella and Escherichia coli O157:H7 on Alfalfa Seeds

2007 ◽  
Vol 70 (7) ◽  
pp. 1698-1703 ◽  
Author(s):  
GUOPING FENG ◽  
JOHN J. CHUREY ◽  
RANDY W. WOROBO
Keyword(s):  
Escherichia Coli ◽  
Heat Treatment ◽  
Thermal Inactivation ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Dry Heat ◽  
Sprouted Seeds ◽  
Alfalfa Sprouts ◽  
Alfalfa Seeds

Alfalfa seeds inoculated with five strains of Salmonella or Escherichia coli O157:H7 were subjected to dry heat at 55°C for up to 8 days. Five-log reductions in Salmonella or E. coli O157:H7 on seeds were observed. No pathogens were detected on the sprouted seeds, which were initially inoculated with ca. 2 log CFU/g of Salmonella or more than 8 log CFU/g of E. coli O157:H7. The percentages of germination of the alfalfa seeds did not significantly decrease after 6 days of heating at 55°C. These results showed that heat treatment of alfalfa seeds at 55°C for up to 6 days was effective in enhancing the safety of alfalfa sprouts without affecting germination significantly.

Chemical and Irradiation Treatments for Killing Escherichia coli O157:H7 on Alfalfa, Radish, and Mung Bean Seeds

2003 ◽  
Vol 66 (5) ◽  
pp. 767-774 ◽  
Author(s):  
M. L. BARI ◽  
E. NAZUKA ◽  
Y. SABINA ◽  
S. TODORIKI ◽  
K. ISSHIKI
Keyword(s):  
Escherichia Coli ◽  
Heat Treatment ◽  
Mung Bean ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Chemical Treatments ◽  
Dry Heat ◽  
Pathogen Populations ◽  
Dry Heat Treatment ◽  
Alfalfa Seeds

In this study, the effectiveness of dry-heat treatment in combination with chemical treatments (electrolyzed oxidizing [EO] water, califresh-S, 200 ppm of active chlorinated water) with and without sonication in eliminating Escherichia coli O157:H7 on laboratory-inoculated alfalfa, radish, and mung bean seeds was compared with that of dry-heat treatment in combination with irradiation treatment. The treatment of mung bean seeds with EO water in combination with sonication followed by a rinse with sterile distilled water resulted in reductions of approximately 4.0 log10 CFU of E. coli O157:H7 per g, whereas reductions of ca. 1.52 and 2.64 log10 CFU/g were obtained for radish and alfalfa seeds. The maximum reduction (3.70 log10 CFU/g) for mung bean seeds was achieved by treatment with califresh-S and chlorinated water (200 ppm) in combination with sonication and a rinse. The combination of dry heat, hot EO water treatment, and sonication was able to eliminate pathogen populations on mung bean seeds but was unable to eliminate the pathogen on radish and alfalfa seeds. Other chemical treatments used were effective in greatly reducing pathogen populations on radish and alfalfa seeds without compromising the quality of the sprouts, but these treatments did not result in the elimination of pathogens from radish and alfalfa seeds. Moreover, a combination of dry-heat and irradiation treatments was effective in eliminating E. coli O157:H7 on laboratory-inoculated alfalfa, radish, and mung bean seeds. An irradiation dose of 2.0 kGy in combination with dry heat eliminated E. coli O157:H7 completely from alfalfa and mung bean seeds, whereas a 2.5-kGy dose of irradiation was required to eliminate the pathogen completely from radish seeds. Dry heat in combination with irradiation doses of up to 2.0 kGy did not unacceptably decrease the germination percentage for alfalfa seeds or the length of alfalfa sprouts but did decrease the lengths of radish and mung bean sprouts.

Combination Treatments for Killing Escherichia coli O157:H7 on Alfalfa, Radish, Broccoli, and Mung Bean Seeds

2009 ◽  
Vol 72 (3) ◽  
pp. 631-636 ◽  
Author(s):  
M. L. BARI ◽  
D. NEI ◽  
K. ENOMOTO ◽  
S. TODORIKI ◽  
S. KAWAMOTO
Keyword(s):  
Escherichia Coli ◽  
Heat Treatment ◽  
Mung Bean ◽  
Germination Rate ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Dry Heat ◽  
Pathogen Populations ◽  
Dry Heat Treatment ◽  
Alfalfa Seeds

In this study, the effectiveness of prolonged dry-heat treatment (50°C) alone or in combination with chemical treatments (1% oxalic acid, 0.03% phytic acid, 50% ethanol, electrolyzed acidic water, and electrolyzed alkaline water) in eliminating Escherichia coli O157:H7 on laboratory-inoculated alfalfa, radish, broccoli, and mung bean seeds was compared with that of dry-heat treatment in combination with irradiation treatment. Dry-heat treatment for 17 or 24 h alone could reduce E. coli O157:H7 numbers to below detectable levels in radish, broccoli, and alfalfa seeds, but was unable to reduce the pathogen numbers to below the detectable level in mung bean seeds. In addition, dry-heat treatment for 17 h plus sanitizer treatments were effective in greatly reducing pathogen populations on radish, broccoli, and alfalfa seeds, without compromising the quality of the sprouts, but these treatments did not eliminate the pathogen from radish and alfalfa seeds. Seventeen hours of dry heat followed by a 1.0-kGy dose of irradiation completely eliminated E. coli O157:H7 from radish and mung bean seeds, whereas only a minimum radiation dose of 0.25 kGy was required to completely eliminate the pathogen from broccoli and alfalfa seeds. Dry heat in combination with radiation doses of up to 1.0 kGy did not negatively impact the seed germination rate or length of alfalfa, broccoli, and radish seeds or the length of alfalfa, broccoli, and radish sprouts, but did decrease the length of mung bean sprouts.

Behavior of Enterohemorrhagic Escherichia coli O157:H7 on Alfalfa Sprouts during the Sprouting Process as Influenced by Treatments with Various Chemicals

1999 ◽  
Vol 62 (8) ◽  
pp. 850-856 ◽  
Author(s):  
PETER J. TAORMINA ◽  
LARRY R. BEUCHAT
Keyword(s):  
Escherichia Coli ◽  
Cold Storage ◽  
Treatment Method ◽  
Enterohemorrhagic Escherichia Coli ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Chemical Treatments ◽  
Alfalfa Sprouts ◽  
Germinated Seeds ◽  
Alfalfa Seeds

The behavior of Escherichia coli O157:H7 on alfalfa seeds subjected to conditions similar to those used commercially to grow and market sprouts as it is affected by applications of NaOCl, Ca(OCl)2, acidified NaClO2, acidified ClO2, Na3PO4, Vegi-Clean, Tsunami, Vortexx, or H2O2 at various stages of the sprouting process was determined. Application of 2,000 ppm of NaOCl, 200 and 2,000 ppm of Ca(OCl)2, 500 ppm of acidified ClO2, 10,000 ppm of Vegi-Clean, 80 ppm of Tsunami, or 40 and 80 ppm of Vortexx to germinated seeds significantly reduced the population of E. coli O157:H7. With the exception of acidified NaOCl2 at 1,200 ppm, spray applications of these chemicals did not significantly reduce populations or control the growth of E. coli O157:H7 on alfalfa sprouts during the sprouting process. Populations of E. coli on alfalfa sprouts peaked at 6 to 7 log10 CFU/g 48 h after initiation of the sprouting process and remained stable despite further spraying with chemicals. The population of E. coli O157:H7 on sprouts as they entered cold storage at 9 ± 2°C remained essentially unchanged for up to 6 days. None of the chemical treatments evaluated was able to eliminate or satisfactorily reduce E. coli O157:H7 on alfalfa seeds and sprouts. Observations on the ability of E. coli O157:H7 to grow during production of alfalfa sprouts not subjected to chemical treatments are similar to those from a previous study in our laboratory on the behavior of Salmonella Stanley. Our results do not reveal a chemical treatment method to eliminate the pathogen from alfalfa sprouts. We have demonstrated that currently recommended procedures for sanitizing alfalfa seeds fail to eliminate E. coli O157:H7 and that the pathogen can grow to populations exceeding 7 log10 CFU/g of sprouts produced using techniques not dissimilar to those used in the sprout industry.

Inactivation of Escherichia coli O157:H7 on Inoculated Alfalfa Seeds with Ozonated Water and Heat Treatment

2002 ◽  
Vol 65 (3) ◽  
pp. 447-451 ◽  
Author(s):  
RATNA R. SHARMA ◽  
ALI DEMIRCI ◽  
LARRY R. BEUCHAT ◽  
WILLIAM F. FETT
Keyword(s):  
Escherichia Coli ◽  
Heat Treatment ◽  
Contact Time ◽  
Germination Percentage ◽  
Ozone Treatment ◽  
Escherichia Coli O157 ◽  
Alternative Mode ◽  
E Coli ◽  
Alfalfa Seeds ◽  
Ozonated Water

Alfalfa seeds inoculated with a five-strain mixture of Escherichia coli O157:H7 were immersed in water containing 4, 8, 10, and 21 ppm of ozone for 2, 4, 8, 16, 32, and 64 min at 4°C. Direct ozone sparging of seeds in water was used as an alternative mode of ozone treatment. Ozone-sparged seeds were also subsequently exposed to heat treatment at 40, 50, and 60°C for 3 h. Populations of E. coli O157:H7 on untreated and treated seeds were determined by spread plating diluted samples on tryptic soy agar supplemented with 50 μg/ml of nalidixic acid. Since E. coli O157:H7 was released from inoculated seeds during treatment with ozone, the rate of release of cells from inoculated seeds soaked in 0.1% peptone water for up to 64 min was also determined. The overall reduction of E. coli O157:H7 on seeds treated with ozonated water without continuous sparging ranged from 0.40 to 1.75 log10 CFU/g (59.6 to 98.2%), whereas reductions for control seeds were 0.32 to 1.03 log10 CFU/g (51.7 to 90.5%). Treatment with higher ozone concentrations enhanced inactivation, but contact time longer than 8 min did not result in significantly higher reductions (P > 0.05). For seeds treated by ozone sparging, a 1.12-log10 CFU/g (92.1%) reduction was achieved using a 2-min contact time, and a 2.21-log10 CFU/g (99.4%) reduction was achieved with a 64-min contact time. The corresponding reductions for control seeds were 0.71 log10 CFU/g (79.5%) and 2.21 log10 CFU/g (99.4%), respectively. Treatment of ozone-sparged seeds at 60°C for 3 h reduced the population to an undetectable level by direct plating (4 to 4.8 log10 CFU/g), although survivors were detected by enrichment. Ozone did not have a detrimental effect on seed germination percentage.

Thermal Inactivation of Escherichia coli O157: H7, Salmonella senftenberg, and Enzymes with Potential as Time-Temperature Indicators in Ground Beef

1997 ◽  
Vol 60 (5) ◽  
pp. 471-475 ◽  
Author(s):  
ALICIA ORTA-RAMIREZ ◽  
JAMES F. PRICE ◽  
YIH-CHIH HSU ◽  
GIRIDARAN J. VEERAMUTHU ◽  
JAMIE S. CHERRY-MERRITT ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Thermal Inactivation ◽  
Ground Beef ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Triose Phosphate ◽  
Beef Products ◽  
Z Value ◽  
D Values ◽  
Salmonella Senftenberg

The USDA has established processing schedules for beef products based on the destruction of pathogens. Several enzymes have been suggested as potential indicators of heat processing. However, no relationship between the inactivation rates of these enzymes and those of pathogenic microorganisms has been determined. Our objective was to compare the thermal inactivation of Escherichia coli O157:H7 and Salmonella senftenberg to those of endogenous muscle proteins. Inoculated and noninoculated ground beef samples were heated at four temperatures for predetermined intervals of time in thermal-death-time studies. Bacterial counts were determined and enzymes were assayed for residual activity. The D values for E. coli O157:H7 were 46.10, 6.44, 0.43, and 0.12 min at 53, 58, 63, and 68°C, respectively, with a z value of 5.60°C. The D values for S. senftenberg were 53.00, 15.17, 2.08, and 0.22 min at 53, 58, 63, and 68°C, respectively, with a z value of 6.24°C. Apparent D values at 53, 58, 63, and 68°C were 352.93, 26.31, 5.56, and 3.33 min for acid phosphatase; 6968.64, 543.48, 19.61, and 1.40 min for lactate dehydrogenase; and 3870.97, 2678.59, 769.23, and 42.92 min for peroxidase; with z values of 7.41,3.99, and 7.80°C, respectively. Apparent D values at 53, 58, 63, and 66°C were 325.03, 60.07, 3.07, and 1.34 min for phosphoglycerate mutase; 606.72, 89.86, 4.40, and 1.28 min for glyceraldehyde-3-phosphate dehydrogenase; and 153.06, 20.13, 2.25, and 0.74 min for triose phosphate isomerase; with z values of 5.18, 4.71, and 5.56°C, respectively. The temperature dependence of triose phosphate isomerase was similar to those of both E. coli O157 :H7 and S. senftenberg, suggesting that this enzyme could be used as an endogenous time-temperature indicator in beef products.

Inactivation of Escherichia coli O157:H7 in Nonintact Beefsteaks of Different Thicknesses Cooked by Pan Broiling, Double Pan Broiling,or Roasting by Using Five Types of Cooking Appliances

2010 ◽  
Vol 73 (3) ◽  
pp. 461-469 ◽  
Author(s):  
CANGLIANG SHEN ◽  
JEREMY M. ADLER ◽  
IFIGENIA GEORNARAS ◽  
KEITH E. BELK ◽  
GARY C. SMITH ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Thermal Inactivation ◽  
Sodium Tripolyphosphate ◽  
Cooking Methods ◽  
Escherichia Coli O157 ◽  
Target Temperature ◽  
Pathogen Inactivation ◽  
Total Water ◽  
E Coli ◽  
George Foreman

This study compared thermal inactivation of Escherichia coli O157:H7 in nonintact beefsteaks of different thicknesses by different cooking methods and appliances. Coarsely ground beef was inoculated with rifampin-resistant E. coli O157:H7 (eight-strain composite, 6 to 7 log CFU/g) and then mixed with sodium chloride (0.45%) plus sodium tripolyphosphate (0.23%); the total water added was 10%. The meat was stuffed into bags (10-cm diameter), semifrozen (−20°C, 6 h), and cut into 1.5-, 2.5-, and 4.0-cm-thick steaks. Samples were then individually vacuum packaged, frozen (−20°C, 42 h), and tempered (4°C, 2.5 h) before cooking. Partially thawed (−2 ± 1°C) steaks were pan broiled (Presto electric skillet and Sanyo grill), double pan broiled (George Foreman grill), or roasted (Oster toaster oven and Magic Chef standard kitchen oven) to a geometric center temperature of 65°C. Extent of pathogen inactivation decreased in order of roasting (2.0 to 4.2 log CFU/g) > pan broiling (1.6 to 2.8 log CFU/g) ≥ double pan broiling (1.1 to 2.3 log CFU/g). Cooking of 4.0-cm-thick steaks required a longer time (19.8 to 65.0 min; variation was due to different cooking appliances), and caused greater reductions in counts (2.3 to 4.2 log CFU/g) than it did in thinner samples (1.1 to 2.9 log CFU/g). The time to reach the target temperature increased in order of George Foreman grill (3.9 to 19.8 min) < Oster toaster oven (11.3 to 45.0 min) < Presto electric skillet (16.3 to 55.0 min) < Sanyo grill (14.3 to 65.0 min) < standard kitchen oven (20.0 to 63.0 min); variation was due to steak thickness. Results indicated that increased steak thickness allowed greater inactivation of E. coli O157:H7, as time to reach the target internal temperature increased. Roasting in a kitchen oven was most effective for pathogen inactivation.

scholarly journals Effects of Acid Adaptation, Product pH, and Heating on Survival of Escherichia coli O157:H7 in Pepperoni

2000 ◽  
Vol 66 (4) ◽  
pp. 1726-1729 ◽  
Author(s):  
Denise C. R. Riordan ◽  
Geraldine Duffy ◽  
James J. Sheridan ◽  
Richard C. Whiting ◽  
Ian S. Blair ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Thermal Inactivation ◽  
Escherichia Coli O157 ◽  
Acid Adaptation ◽  
E Coli

ABSTRACT The thermotolerance of E. coli O157:H7 cells (strain 380-94) heated in pepperoni is reported. Information on the pattern of thermal inactivation of E. coli O157:H7 in pepperoni was applied in the development of heating processes designed to reduceE. coli O157:H7 numbers therein by 5 log10units.

Efficacy of Chemical Treatments in Eliminating Salmonella and Escherichia coli O157:H7 on Scarified and Polished Alfalfa Seeds

2001 ◽  
Vol 64 (10) ◽  
pp. 1489-1495 ◽  
Author(s):  
SARAH L. HOLLIDAY ◽  
ALAN J. SCOUTEN ◽  
LARRY R. BEUCHAT
Keyword(s):  
Escherichia Coli ◽  
Chemical Treatment ◽  
Organic Material ◽  
Pathogenic Bacteria ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Mechanical Abrasion ◽  
Chemical Treatments ◽  
The Impact ◽  
Alfalfa Seeds

Alfalfa seeds are sometimes subjected to a scarification treatment to enhance water uptake, which results in more rapid and uniform germination during sprout production. It has been hypothesized that this mechanical abrasion treatment diminishes the efficacy of chemical treatments used to kill or remove pathogenic bacteria from seeds. A study was done to compare the effectiveness of chlorine (20,000 ppm), H2O2 (8%), Ca(OH)2 (1%), Ca(OH)2 (1%) plus Tween 80 (1%), and Ca(OH)2 (1%) plus Span 20 (1%) treatments in killing Salmonella and Escherichia coli O157:H7 inoculated onto control, scarified, and polished alfalfa seeds obtained from two suppliers. The influence of the presence of organic material in the inoculum carrier on the efficacy of sanitizers was investigated. Overall, treatment with 1% Ca(OH)2 was the most effective in reducing populations of the pathogens. Reduction in populations of pathogens on seeds obtained from supplier 1 indicate that chemical treatments are less efficacious in eliminating the pathogens on scarified seeds compared to control seeds. However, the effectiveness of chemical treatment in removing Salmonella and E. coli O157:H7 from seeds obtained from supplier 2 was not markedly affected by scarification or polishing. The presence of organic material in the inoculum carrier did not have a marked influence on the efficacy of chemicals in reducing populations of test pathogens. Additional lots of control, scarified, and polished alfalfa seeds of additional varieties need to be tested before conclusions can be drawn concerning the impact of mechanical abrasion on the efficacy of chemical treatment in removing or killing Salmonella and E. coli O157:H7.

scholarly journals Differences in Growth of Salmonella enterica and Escherichia coli O157:H7 on Alfalfa Sprouts

2002 ◽  
Vol 68 (6) ◽  
pp. 3114-3120 ◽  
Author(s):  
A. O. Charkowski ◽  
J. D. Barak ◽  
C. Z. Sarreal ◽  
R. E. Mandrell
Keyword(s):  
Escherichia Coli ◽  
Irrigation Water ◽  
Salmonella Enterica ◽  
Fluorescent Protein ◽  
Human Pathogens ◽  
E Coli ◽  
Inoculum Dose ◽  
Alfalfa Sprouts ◽  
Green Fluorescent ◽  
Alfalfa Seeds

ABSTRACT Sprout producers have recently been faced with several Salmonella enterica and Escherichia coli O157:H7 outbreaks. Many of the outbreaks have been traced to sprout seeds contaminated with low levels of human pathogens. Alfalfa seeds were inoculated with S. enterica and E. coli O157:H7 strains isolated from alfalfa seeds or other environmental sources and sprouted to examine growth of these human pathogens in association with sprouting seeds. S. enterica strains grew an average of 3.7 log10 on sprouting seeds over 2 days, while E. coli O157:H7 strains grew significantly less, an average of 2.3 log10. The initial S. enterica or E. coli O157:H7 inoculum dose and seed-sprouting temperature significantly affected the levels of both S. enterica and E. coli O157:H7 on the sprouts and in the irrigation water, while the frequency of irrigation water replacement affected only the levels of E. coli O157:H7. Colonization of sprouting alfalfa seeds by S. enterica serovar Newport and E. coli O157:H7 strains transformed with a plasmid encoding the green fluorescent protein was examined with fluorescence microscopy. Salmonella serovar Newport colonized both seed coats and sprout roots as aggregates, while E. coli O157:H7 colonized only sprout roots.

Inactivation of Escherichia coli O157:H7, Salmonella Typhimurium DT104, and Listeria monocytogenes on Inoculated Alfalfa Seeds with a Fatty Acid–Based Sanitizer

2006 ◽  
Vol 69 (3) ◽  
pp. 582-590 ◽  
Author(s):  
PASCALE M. PIERRE ◽  
ELLIOT T. RYSER
Keyword(s):  
Escherichia Coli ◽  
Lactic Acid ◽  
Fatty Acid ◽  
Listeria Monocytogenes ◽  
Salmonella Typhimurium ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Reference Concentration ◽  
Glycerol Monolaurate ◽  
Alfalfa Seeds

Alfalfa seeds were inoculated with a three-strain cocktail of Escherichia coli O157:H7, Salmonella enterica subsp. enterica serovar Typhimurium DT104, or Listeria monocytogenes by immersion to contain ∼6 to 8 log CFU/g and then treated with a fatty acid–based sanitizer containing 250 ppm of peroxyacid, 1,000 ppm of caprylic and capric acids (Emery 658), 1,000 ppm of lactic acid, and 500 ppm of glycerol monolaurate at a reference concentration of 1×. Inoculated seeds were immersed at sanitizer concentrations of 5×, 10×, and 15× for 1, 3, 5, and 10 min and then assessed for pathogen survivors by direct plating. The lowest concentration that decreased all three pathogens by >5 log was 15×. After a 3-min exposure to the 15× concentration, populations of E. coli O157:H7, Salmonella Typhimurium DT104, and L. monocytogenes decreased by >5.45, >5.62, and >6.92 log, respectively, with no sublethal injury and no significant loss in seed germination rate or final sprout yield. The components of this 15× concentration (treatment A) were assessed independently and in various combinations to optimize antimicrobial activity. With inoculated seeds, treatment C (15,000 ppm of Emery 658, 15,000 ppm of lactic acid, and 7,500 ppm of glycerol monolaurate) decreased Salmonella Typhimurium, E. coli O157:H7, and L. monocytogenes by 6.23 and 5.57 log, 4.77 and 6.29 log, and 3.86 and 4.21 log after 3 and 5 min of exposure, respectively. Treatment D (15,000 ppm of Emery 658 and 15,000 ppm of lactic acid) reduced Salmonella Typhimurium by >6.90 log regardless of exposure time and E. coli O157:H7 and L. monocytogenes by 4.60 and >5.18 log and 3.55 and 3.14 log after 3 and 5 min, respectively. No significant differences (P > 0.05) were found between treatments A, C, and D. Overall, treatment D, which contained Emery 658 and lactic acid as active ingredients, reduced E. coli O157:H7, Salmonella Typhimurium, and L. monocytogenes populations by 3.55 to >6.90 log and may provide a viable alternative to the recommended 20,000 ppm of chlorine for sanitizing alfalfa seeds.

Sign in / Sign up

Export Citation Format

Share Document