scholarly journals A steam rising model of steam-assisted gravity drainage production for heavy oil reservoirs

2019 ◽  
Vol 38 (4) ◽  
pp. 801-818
Author(s):  
Ren-Shi Nie ◽  
Yi-Min Wang ◽  
Yi-Li Kang ◽  
Yong-Lu Jia

The steam chamber rising process is an essential feature of steam-assisted gravity drainage. The development of a steam chamber and its production capabilities have been the focus of various studies. In this paper, a new analytical model is proposed that mimics the steam chamber development and predicts the oil production rate during the steam chamber rising stage. The steam chamber was assumed to have a circular geometry relative to a plane. The model includes determining the relation between the steam chamber development and the production capability. The daily oil production, steam oil ratio, and rising height of the steam chamber curves influenced by different model parameters were drawn. In addition, the curve sensitivities to different model parameters were thoroughly considered. The findings are as follows: The daily oil production increases with the steam injection rate, the steam quality, and the degree of utilization of a horizontal well. In addition, the steam oil ratio decreases with the steam quality and the degree of utilization of a horizontal well. Finally, the rising height of the steam chamber increases with the steam injection rate and steam quality, but decreases with the horizontal well length. The steam chamber rising rate, the location of the steam chamber interface, the rising time, and the daily oil production at a certain steam injection rate were also predicted. An example application showed that the proposed model is able to predict the oil production rate and describe the steam chamber development during the steam chamber rising stage.

SPE Journal ◽  
2017 ◽  
Vol 23 (01) ◽  
pp. 117-127 ◽  
Author(s):  
Zeinab Zargar ◽  
S. M. Farouq Ali

Summary Steam-assisted gravity drainage (SAGD) is a widely tested method for producing bitumen from oil sands (tar sands). Several analytical treatments of the basic process have been reported. In a typical model, the focus is on bitumen drainage ahead of an advancing heat front. In a few cases, a steady expression for bitumen-drainage rate is obtained. This has been modified by several investigators to include other effects. In all cases, the bitumen rate is obtained with no recourse to the steam-injection rate, which is worked out after the fact. The treatment of time dependence, in a few models, is tenuous, building it in partly by use of experimental data. In this work, the SAGD process is considered to develop during two stages: steam-chamber rise (or unsteady stage) and sideways-expansion (or steady stage). The sideways-expansion phase is modeled by two different approaches: constant volumetric displacement (CVD) and constant heat injection (CHI). In the transient-steam-chamber-rise stage of SAGD, initially there is no heat ahead of the rising front, but as the front rises with time, heat accumulates ahead of the front. In the sideways-spreading stage, there is a dynamic equilibrium situation. The accumulated heat ahead of the front plays a crucial role in this phase of SAGD modeling to find the advancing-front velocity. There is a reciprocal relation between the advancing-front velocity and the amount of stored heat ahead of the front. Higher front velocity leads to lower heat accumulation ahead of the front for mobilizing oil ahead and making it drain. By considering the equilibrium situation for thermal-recovery methods with a dominant-gravity-drainage driving force, the advancing-front velocity is responsible for heat accumulation ahead of the front, and, in turn, this heated oil drains away and is responsible for advancing the front. Therefore, the key point in the modeling is to determine the advancing-front movement that satisfies heat and mass balances over the system under equilibrium. In the CVD model, we postulate that the front movement is such that the steam-chamber growth is constant; that is, the oil-production rate is constant over time. In this work, it is shown that to obtain a constant oil-production rate from a mass balance, the injected heat has to be increased to compensate for the heat loss to the overburden and the growing accumulated heat ahead of the front caused by interface extension and decreasing front velocity. In the CHI model, heat is injected at a constant rate into the system, which provides heat for the growing steam-chamber size, increasing heat loss to the overburden, and heat flow by conduction ahead of the front. In this model, we are computing the front velocity that satisfies heat balance and mass balance for a constant heat-injection rate. Decreasing steam-chamber velocity with time from this model leads to decreasing oil-production rate. The modeling of the SAGD process in this work is different from that in previous works because it is believed that the steam-chamber velocity is the key point in SAGD modeling. In the CVD model, a constant maximum steam-chamber velocity is derived that gives a constant oil-production rate with a better agreement with field data. In the CHI approach, steam-chamber velocity, and hence the oil-production rate, is decreasing with time (strongly affected by increasing heat loss to the overburden).


SPE Journal ◽  
2019 ◽  
Vol 24 (02) ◽  
pp. 492-510 ◽  
Author(s):  
Mohsen Keshavarz ◽  
Thomas G. Harding ◽  
Zhangxin Chen

Summary The majority of the models in the literature for the steam-assisted-gravity-drainage (SAGD) process solve the problem of conductive heat transfer ahead of a moving hot interface using a quasisteady-state assumption and extend the solution to the base of the steam chamber where the interface is not moving. This approach, as discussed by Butler (1985) and Reis (1992), results in inaccurate or sometimes infeasible estimations of the oil-production rate, steam/oil ratio (SOR), and steam-chamber shape. In this work, a new approach for the analytical treatment of SAGD is proposed in which the problem of heat transfer is directly solved for a stationary source of heat at the base of the steam chamber, where the oil production occurs. The distribution of heat along the interface is then estimated depending on the geometry of the steam chamber. This methodology is more representative of the heat-transfer characteristics of SAGD and resolves the challenges of those earlier models. In addition, it allows for the extension of the formulations to the early stages of the process when the side interfaces of the chamber are almost stationary, without loss of the solution continuity. The model requires the overall shape of the steam chamber as an input. It then estimates the movement of chamber interfaces using the movement of the uppermost interface point and by satisfying the global material-balance requirements. Oil-production rate and steam demand are estimated by Darcy's law and energy-balance calculations, respectively. The result is a model that is applicable to the entire lifetime of a typical SAGD project and provides more-representative estimations of in-situ heat distribution, bitumen-production rate, and SOR. With the improved knowledge obtained on the fundamentals of heat transfer in SAGD, the reason for the discrepancies between the various earlier models will be clarified. Results of the analytical models developed in this work show reasonable agreement with fine-scale numerical simulation, which indicates that the primary physics are properly captured. In the final section of the paper, the application of the developed models to two field case studies will be demonstrated.


2021 ◽  
Author(s):  
Zeinab Zargar ◽  
S. M. Farouq Ali

Abstract Steam-Assisted Gravity Drainage (SAGD) is a remarkably successful process for the tar sands (oil sands). Two closely spaced parallel horizontal wells, injector above the producer, form a SAGD well pair. Steam is injected to provide heat to the reservoir oil and mobilize it. The low viscosity oil drains down to the producer under the gravity effect. Parallel well pairs 1000 m long are utilized in the process, spaced 100 m apart horizontally almost in all projects. In this work, an analytical model for the SAGD process is introduced by coupling heat and fluid flow and constitutive equations. A moving boundary, counter-current flow approach is used for the steam chamber rise and subsequent sideways expansion. The model is unique because it assumes the steam injection rate is constant and it permits modeling of the late phase of SAGD when adjacent well pair interference occurs. This leads to a reduction in heat loss to the overburden and a decline in oil production rate. This study examines the question of optimal well pair spacing in relation to the formation thickness and in-place oil. The effect of other variables on SAGD performance is investigated. A case study was performed using Christina Lake oil sand properties to show how the project performance varies under different senerios involving well pair spacing, reservoir thickness, steam injection rate, and steam quality. Results show that, in evaluating a SAGD pad performance, as the spacing is increased, the cumulative oil production decreases, with a simultanous increase in the cumulative steam-oil ratio at the same steam injection rate. However, a smaller portion of injected heat is lost to the overburden. It is concluded that a smaller well spacing requires more wells to deplete the whole pad area. On the other hand, a larger pattern well spacing affects oil recovery and heat consumption. Different conclusions are derived for the same pattern well spacing value using a single well pair model and pattern well pair configuration. Results also show that SAGD well pair spacing can be increased with an increase in formation thickness. The computational procedure is simple and makes it possible to examine a series of options for well spacing for a given set of conditions. This study presents for the first time an analytical relation between SAGD pattern well pair spacing and oil recovery.


SPE Journal ◽  
2011 ◽  
Vol 16 (03) ◽  
pp. 494-502 ◽  
Author(s):  
Z.. Wu ◽  
S.. Vasantharajan ◽  
M.. El-Mandouh ◽  
P.V.. V. Suryanarayana

Summary In this paper, we present a new, semianalytical gravity-drainage model to predict the oil production of a cyclic-steam-stimulated horizontal well. The underlying assumption is that the cyclic steam injection creates a cylindrical steam chamber in the upper area of the well. Condensed water and heated oil in the chamber are driven by gravity and pressure drawdown toward the well. The heat loss during the soak period and during oil production is estimated under the assumption of vertical and radial conduction. The average temperature change in the chamber during the cycle is calculated using a semianalytical expression. Nonlinear, second-order ordinary differential equations are derived to describe the pressure distribution caused by the two-phase flow in the wellbore. A simple iteration scheme is proposed to solve these equations. The influx of heated oil and condensed water into the horizontal wellbore is calculated under the assumption of steady-state radial flow. The solution from the semianalytical formulation is compared against the results from a commercial thermal simulator for an example problem. It is shown that the model results are in good agreement with those obtained from reservoir simulation. Sensitivity studies for optimization of wellbore length, gravity drainage, bottomhole pressure, and steam-injection rate are conducted with the model. Results indicate that the proposed model can be used in the optimization of individual-well performance in cyclic-steam-injection heavy-oil development. The semianalytical thermal model presented in this work can offer an attractive alternative to numerical simulation for planning heavy-oil field development.


SPE Journal ◽  
2016 ◽  
Vol 21 (02) ◽  
pp. 353-363 ◽  
Author(s):  
Mahdie Mojarad ◽  
Hassan Dehghanpour

Summary Recently, different models were proposed to describe two- and three-phase flow at the edge of a steam chamber developed during a steam-assisted-gravity-drainage (SAGD) process. However, 2D-scaled SAGD experiments and recent micromodel visualizations demonstrate that steam condensate is primarily in the form of microbubbles dispersed in the oil phase (water-in-oil emulsion). Therefore, the challenging question is: Can the multiphase Darcy equation be used to describe the transport of water as a discontinuous phase? Furthermore, the physical impact of water as a continuous phase or as microbubbles on oil flow can be different. Water microbubbles increase the apparent oil viscosity, whereas a continuous water phase decreases the oil relative permeability. Investigating the impact of these two phenomena on oil mobility at the steam-chamber edge and on overall oil-production rate during an SAGD process requires development of relevant mathematical models, which is the focus of this paper. In this paper, we develop an analytical model for lateral expansion of the steam chamber that accounts for formation and transport of water-in-oil emulsion. It is assumed that emulsion is generated as a result of condensation of steam, which penetrates into the heated bitumen. The emulsion concentration decreases from a maximum value at the chamber interface to zero far from the interface. The oil viscosity is affected by both temperature gradient caused by heat conduction and microbubble concentration gradient resulting from emulsification. We conduct a sensitivity analysis with the measured data from scaled SAGD experiments. The sensitivity analysis shows that, by increasing the value of m (temperature viscosity parameter), the effect of emulsification on oil-flow rate decreases. It also shows that the effect of temperature on oil mobility is much stronger than that of emulsion. We also compare the model predictions with field production data from several SAGD operations. Butler's model overestimates oil-production rate caused by the single-phase assumption, whereas the proposed model presents more-accurate oil-flow rate, supporting the fact that one should include emulsification effect in the SAGD analysis.


SPE Journal ◽  
2016 ◽  
Vol 22 (01) ◽  
pp. 327-338 ◽  
Author(s):  
Yang Yang ◽  
Shijun Huang ◽  
Yang Liu ◽  
Qianlan Song ◽  
Shaolei Wei ◽  
...  

Summary The technology of steam-assisted gravity drainage (SAGD) with a dual horizontal well pair has been widely adopted in thermal recovery for heavy oil in recent years. However, the close distance between injector and producer makes it easy to cause steam breakthrough, which means lower thermal efficiency as well as higher investment. It is generally acknowledged that there is a vapor-liquid interface between the injector and producer. A suitable liquid level is desired to prevent steam from being produced directly; otherwise, an overly high liquid level would influence oil productivity or even submerge the injector. The existence of a liquid level generates a temperature difference (i.e., subcool) between two wells. Subcool has widely been used to characterize the liquid level in research, yet it is inaccurate. Further studies are still needed on how to maintain a suitable and stable liquid level in SAGD development. In addition to the heat-loss model and geometric features of the steam chamber (SC), mass conservation, energy conservation, and gravity-drainage theory are used to develop a multistage mathematical model for liquid-level characterization during the SAGD process. The new model is validated against both field data and simulation results. On the basis of this model, an optimal production/injection ratio (PIR) at different times could be calculated to maintain a stable liquid level above the producer, avoiding steam channeling accordingly. Besides, the model can also be used to predict optimal steam-injection rate under constant-pressure injection. Other SAGD dynamic performance predictions, such as SC expansion speed, could also be derived from this model. In addition, recommendations for liquid-level adjustment are offered on the basis of field conditions.


2007 ◽  
Vol 10 (01) ◽  
pp. 19-34 ◽  
Author(s):  
Ian Donald Gates ◽  
Joseph Kenny ◽  
Ivan Lazaro Hernandez-Hdez ◽  
Gary L. Bunio

Summary Steam-assisted gravity drainage (SAGD) is being operated by several operators in Athabasca and Cold Lake reservoirs in Central and Northern Alberta, Canada. In this process, steam, injected into a horizontal well, flows outward, then contacts and loses its latent heat to bitumen at the edge of a depletion chamber. As a consequence, the viscosity of bitumen falls, its mobility rises, and it flows under gravity toward a horizontal production well located several meters below and parallel to the injection well. Despite many pilots and commercial operations, it remains unclear how to optimally operate SAGD. This is especially the case in reservoirs with a top-gas zone in which pilot data are nearly nonexistent. In this study, a steam-chamber operating strategy is determined that leads to optimum oil recovery for a minimum cumulative steam-to-oil ratio (SOR) in a top-gas reservoir. These findings were established from extensive reservoir-simulation runs that were based on a detailed geostatistically generated static reservoir model. The strategy devised uses a high initial chamber injection rate and pressure prior to chamber contact with the top gas. Subsequent to breakthrough of the chamber into the gas-cap zone, the chamber injection rates are lowered to balance pressures with the top gas and avoid (or at least minimize) convective heat losses of steam to the top-gas zone. The results are also analyzed by examining the energetics of SAGD. Introduction A cross-section of the SAGD process is displayed in Fig. 1. Steam is injected into the formation through a horizontal well. In Fig. 1, the wells are portrayed as points that extend into the page. Around and above the injection well, a steam-depletion chamber grows. At the edge of the chamber, heated bitumen and (steam) condensate flow under the action of gravity to a production well typically placed between 5 and 10 m below and substantially parallel to the injection well. Usually, the production well is located several meters above the base of pay. In industrial practice (Singhal et al. 1998; Komery et al. 1999), injection and production well lengths are typically between 500 and 1000 m. Because the steam chamber operates at saturation conditions, the injection pressure controls the operating temperature of SAGD. SAGD has been piloted extensively in Athabasca and Cold Lake reservoirs in Alberta (Komery et al. 1999; Butler 1997; Kisman and Yeung 1995; Ito and Suzuki 1999; Ito et al. 2004; Edmunds and Chhina 2001; Suggett et al. 2000; Siu et al. 1991; AED 2004) and is being used as a commercial technology to recover bitumen in several Athabasca reservoirs (Yee and Stroich 2004). These pilots and commercial operations have demonstrated that SAGD is technically effective, but it has not been fully established whether its operating conditions are at optimum values. This is especially the case in reservoirs in contact with gas or water zones where the optimum operating strategy remains unclear. The variability of the cumulative injected-steam (expressed in cold water equivalents, or CWE) to produced-oil ratio (cSOR) shows that some SAGD well pairs operate fairly efficiently (with cSOR between 2 and 3), whereas others operate at much greater cSOR (up to 10 and higher) (Yee and Stroich 2004). Higher cSOR means that more steam is being used per unit volume bitumen produced. The higher the steam usage, the greater the amount of natural gas combusted, and the less economic the process. One key control variable in SAGD is the temperature difference between the injected steam and the produced fluids. This value, known as the subcool, is typically maintained in a form of steamtrap control between 15 and 30°C (Ito and Suzuki 1999). The subcool is being used as a surrogate variable instead of the height of liquid above the production well. The liquid pool above the production well prevents flow of injected steam directly from the injection well to the production well, thus promoting injected steam to the outer regions of the depletion chamber and enabling delivery of its latent heat to the bitumen. The value of the optimum steamtrap subcool temperature difference and how the operating pressure impacts the optimum subcool value remains unclear. It also remains unclear how the subcool should be controlled in heterogeneous reservoirs that have top gas.


SPE Journal ◽  
2016 ◽  
Vol 22 (03) ◽  
pp. 902-911 ◽  
Author(s):  
M.. Heidari ◽  
S. H. Hejazi ◽  
S. M. Farouq Ali

Summary Steam-assisted gravity drainage (SAGD) is one of the successful in-situ thermal-recovery methods for oil-sands production. In this paper, we provide a simple semianalytical model that can accurately analyze an SAGD project with variable properties. In particular, we investigate the effect of temperature-dependent properties such as thermal conductivity, heat capacity, and rock density on SAGD performance. The proposed model sequentially solves the transient nonlinear heat-transfer equation coupled with the continuity equation with Kirchhoff's transformation and the heat integral method (HIM). A criterion for timestep selection is defined on the basis of the Courant and Péclet numbers to guarantee the stability of the sequential technique. The results illustrate that the temperature-dependent physical properties affect temperature distributions ahead of steam chamber which consequently have a significant impact on the cumulative oil production and oil-production rate. Moreover, the results show that the temperature profile ahead of the steam chamber changes with time and space, and a 2D transient assumption for SAGD modeling is necessary. The semianalytical model runs in a small fraction of numerical-simulator runtime, yet it provides reasonable results. Thus, it has the potential to be used as a tool for quick SAGD evaluations.


Sign in / Sign up

Export Citation Format

Share Document