scholarly journals Enhanced biodegradability of dairy sludge by microwave assisted alkaline and acidic pre-treatments

2019 ◽  
Vol 7 (1-2) ◽  
pp. 92-97
Author(s):  
Sándor Beszédes ◽  
Zoltán Jákói ◽  
Balázs Lemmer ◽  
Cecilia Hodúr
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Biogas Production ◽  
Treatment Method ◽  
Acidic Condition ◽  
Alkaline Condition ◽  
Thermal Methods ◽  
Microwave Assisted ◽  
Pre Treatment ◽  
Aerobic Biodegradability

Considering the rapid, volumetric and selective heating effects of microwaves the microwave assisted chemical methods could provide appropriate alternatives for conventional thermal methods in sludge processing. Microwave irradiation alone is suitable to accelerate the hydrolysis stage of anaerobic decomposition of sludge resulted in accelerated biogas production rate and in higher biogas yield. Alkaline pre-treatments increase the organic matter solubility and suitable for disintegration of sludge particles. In some study are concluded that acidic conditions help the disintegration of waste activated sludge and assist in the solubilisation of carbohydrates and proteins which led to increased higher biogas production, as well. Beside the promising results related to effects of microwave pre-treatments on anaerobic digestion of sludge there are very few reports on the investigation of combined acidic/alkali-microwave pre-treatment method for food industry originated sludge. Hence, our study focused on the examination of the effects of combined microwave-alkali and microwave-acidic pre-treatment on aerobic and anaerobic biodegradability of sludge produced in dairy industry Our experimental results verified, that microwave irradiation with alkaline dosage improve the solubility of organic matters in the pH range of 8-12. But enhancement of disintegration was not correlated linearly with biodegradability. During pre-treatment stage, applying pH over 10, the aerobic biodegradability show decreasing tendency. Applying of acidic condition during microwave irradiation resulted in lower disintegration degree than obtained for microwave-alkaline sludge pre-treatment method. But with microwave assisted acidic pre-treatments a higher aerobic biodegradability could be achieved than with alkaline dosage. In microwave pre-treatments acidic condition was preferable to increase the shorter aerobic biodegradability; the alkaline condition was favourable to intensify the anaerobic digestion process.

scholarly journals Influence of Microwave Pre-Treatment on the Digestion and Higienisation of Waste Activated Sludge/Wpływ Dezintegracji Mikrofalowej Na Proces Fermentacji Oraz Higienizacji Nadmiernych Osadów Ściekowych

2014 ◽  
Vol 21 (3) ◽  
pp. 447-464 ◽  
Author(s):  
Jolanta Bohdziewicz ◽  
Mariusz Kuglarz ◽  
Klaudiusz Grűbel
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Treatment Effectiveness ◽  
Biogas Production ◽  
Salmonella Spp ◽  
Biogas Yield ◽  
Treatment Conditions ◽  
Higher Power ◽  
Pre Treatment ◽  
Treatment Step

Abstract The article presents the results of determining the most appropriate conditions of microwave sludge pre-treatment (500-1200 W), prior to its anaerobic digestion in a continuous mode. The assessment of the pre-treatment conditions (microwave power, sludge temperature after pre-treatment) was based on: the release of organic (COD, protein) and inorganic (NH4+, PO43-) substances into liquid, the quantity of methane produced, sludge higienisation and the susceptibility of the pre-treated sludge to dewatering. The power of the microwaves applied did not play significant role on the pre-treatment effectiveness. Taking into account the fact that sludge pre-treatment by microwave irradiation requires the delivery of energy, the pre-treatment by microwaves of higher power (1200 W) and resulting in sludge temperature of 70°C was recommended for further experiments. Sludge pre-treatment by means of microwave irradiation as a pre-treatment step influenced the effectiveness of the subsequent anaerobic digestion, conducted in continuous conditions, in a positive way. The largest amount of biogas was obtained for HRT in the range of 15-20 days. As compared to the sludge which did not undergo pre-treatment, daily biogas production and biogas yield increased by 18-41% and 13-35% respectively. The combination of microwave pre-treatment and mesophilic anaerobic digestion ensured the elimination of pathogens (Salmonella spp., Escherichia coli).

Alkali pre-treatment of Sorghum Moench for biogas production

2013 ◽  
Vol 67 (9) ◽  
Author(s):  
Karina Michalska ◽  
Stanisław Ledakowicz
Keyword(s):  
Anaerobic Digestion ◽  
Chemical Oxygen Demand ◽  
Volatile Fatty Acids ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Total Phenolic ◽  
Methane Generation ◽  
Pre Treatment ◽  
Alkali Hydrolysis ◽  
Almost All

AbstractThis work studies the influence of the alkali pre-treatment of Sorghum Moench — a representative of energy crops used in biogas production. Solutions containing various concentrations of sodium hydroxide were used to achieve the highest degradation of lignocellulosic structures. The results obtained after chemical pre-treatment indicate that the use of NaOH leads to the removal of almost all lignin (over 99 % in the case of 5 mass % NaOH) from the biomass, which is a prerequisite for efficient anaerobic digestion. Several parameters, such as chemical oxygen demand, total organic carbon, total phenolic content, volatile fatty acids, and general nitrogen were determined in the hydrolysates thus obtained in order to define the most favourable conditions. The best results were obtained for the Sorghum treated with 5 mass % NaOH at 121°C for 30 min The hydrolysate thus achieved consisted of high total phenolic compounds concentration (ca. 4.7 g L−1) and chemical oxygen demand value (ca. 45 g L−1). Although single alkali hydrolysis causes total degradation of glucose, a combined chemical and enzymatic pre-treatment of Sorghum leads to the release of large amounts of this monosaccharide into the supernatant. This indicates that alkali pre-treatment does not lead to complete cellulose destruction. The high degradation of lignin structure in the first step of the pre-treatment rendered the remainder of the biomass available for enzymatic action. A comparison of the efficiency of biogas production from untreated Sorghum and Sorghum treated with the use of NaOH and enzymes shows that chemical hydrolysis improves the anaerobic digestion effectiveness and the combined pre-treatment could have great potential for methane generation.

scholarly journals Opportunity of Biogas Production from Solid Organic Wastes through Anaerobic Digestion

2018 ◽  
Vol 65 ◽  
pp. 05025 ◽  
Author(s):  
Sagor Kumar Pramanik ◽  
Fatihah Binti Suja ◽  
Biplob Kumar Pramanik ◽  
Shahrom Bindi Md Zain
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Nutrient Balance ◽  
Organic Wastes ◽  
Organic Loading Rate ◽  
Biogas Yield ◽  
Carbon And Nitrogen ◽  
Potential Risks ◽  
Nitrogen Ratio ◽  
Pre Treatment

Solid organic wastes create potential risks to environmental pollution and human health due to the uncontrolled discharge of huge quantities of hazardous wastes from numerous sources. Now-a-days, anaerobic digestion (AD) is considered as a verified and effective alternative compared to other techniques for treating solid organic waste. The paper reviewed the biological process and parameters involved in the AD along with the factors could enhance the AD process. Hydrolysis is considered as a rate-limiting phase in the complex AD process. The performance and stability of AD process is highly influenced by various operating parameters like temperature, pH, carbon and nitrogen ratio, retention time, and organic loading rate. Different pre-treatment (e.g. mechanical, chemical and biological) could enhance the AD process and the biogas yield. Co-digestion can also be used to provide suitable nutrient balance inside the digester. Challenges of the anaerobic digestion for biogas production are also discussed.

Effect of Ultrasonic Pretreatment for the Anaerobic Digestion of Sewage Sludge

2012 ◽  
Vol 531 ◽  
pp. 528-531 ◽  
Author(s):  
Na Wei
Keyword(s):  
Anaerobic Digestion ◽  
Sewage Sludge ◽  
Volatile Fatty Acids ◽  
Biogas Production ◽  
Oxygen Demand ◽  
High Concentration ◽  
Ultrasonic Pretreatment ◽  
Soluble Chemical Oxygen Demand ◽  
Pre Treatment ◽  
Settling Characteristics

Anaerobic digestion is an economic and environmentally friendly technology for treating the biomass material-sewage sludge, but has some limitations, such as the low efficient biogass production. In this paper ultrasound was proposed as pre-treatment for effective sludge anaerobic digestion. Sludge anaerobic digestion experiments with ultrasonic pretreatment was investigated. It can be seen that this treatment effectively leaded to the increase of soluble chemical oxygen demand(SCOD) and volatile fatty acids(VFA)concentration. High concentration of VFA leaded to a increase in biogas production. Besides, the SV of sludge was reduced and the settling characteristics of sludge was improved after ultrasonic pretreatment. It can be concluded that sludge anaerobic digestion with ultrasonic pretreatment is an effective method for biomass material transformation.

scholarly journals Enhancement anaerobic digestion and methane production from kitchen waste by thermal and thermo-chemical pretreatments in batch  leach bed reactor with down flow

2018 ◽  
Vol 64 (No. 3) ◽  
pp. 128-135 ◽  
Author(s):  
Radmard Seyed Abbas ◽  
Alizadeh Hossein Haji Agha ◽  
Seifi Rahman
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Methane Production ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Lag Phase ◽  
Kitchen Waste ◽  
Gompertz Equation ◽  
Chemical Pretreatments ◽  
Pretreatment Conditions

The effects of thermal (autoclave and microwave irradiation (MW)) and thermo-chemical (autoclave and microwave irradiation – assisted NaOH 5N) pretreatments on the chemical oxygen demand (COD) solubilisation, biogas and methane production of anaerobic digestion kitchen waste (KW) were investigated in this study. The modified Gompertz equation was fitted to accurately assess and compare the biogas and methane production from KW under the different pretreatment conditions and to attain representative simulations and predictions. In present study, COD solubilisation was demonstrated as an effective effect of pretreatment. Thermo-chemical pretreatments could improve biogas and methane production yields from KW. A comprehensive evaluation indicated that the thermo-chemical pretreatments (microwave irradiation and autoclave- assisted NaOH 5N, respectively) provided the best conditions to increase biogas and methane production from KW. The most effective enhancement of biogas and methane production (68.37 and 36.92 l, respectively) was observed from MW pretreated KW along with NaOH 5N, with the shortest lag phase of 1.79  day, the max. rate of 2.38 l·day<sup>–1</sup> and ultimate biogas production of 69.8 l as the modified Gompertz equation predicted.

Sludge electrooxidation as pre-treatment for anaerobic digestion

2016 ◽  
Vol 75 (4) ◽  
pp. 775-781 ◽  
Author(s):  
J. A. Barrios ◽  
U. Duran ◽  
A. Cano ◽  
M. Cisneros-Ortiz ◽  
S. Hernández
Keyword(s):  
Anaerobic Digestion ◽  
Volatile Fatty Acids ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Wastewater Sludge ◽  
Boron Doped Diamond ◽  
Boron Doped ◽  
Treatment Conditions ◽  
Volatile Solids ◽  
Pre Treatment

Anaerobic digestion of wastewater sludge is the preferred method for sludge treatment as it produces energy in the form of biogas as well as a stabilised product that may be land applied. Different pre-treatments have been proposed to solubilise organic matter and increase biogas production. Sludge electrooxidation with boron-doped diamond electrodes was used as pre-treatment for waste activated sludge (WAS) and its effect on physicochemical properties and biomethane potential (BMP) was evaluated. WAS with 2 and 3% total solids (TS) achieved 2.1 and 2.8% solubilisation, respectively, with higher solids requiring more energy. After pre-treatment, biodegradable chemical oxygen demand values were close to the maximum theoretical BMP, which makes sludge suitable for energy production. Anaerobic digestion reduced volatile solids (VS) by more than 30% in pre-treated sludge with a food to microorganism ratio of 0.15 g VSfed g−1 VSbiomass. Volatile fatty acids were lower than those for sludge without pre-treatment. Best pre-treatment conditions were 3% TS and 28.6 mA cm−2.

Ultrasound pre-treatment for anaerobic digestion improvement

2009 ◽  
Vol 60 (6) ◽  
pp. 1525-1532 ◽  
Author(s):  
S. Pérez-Elvira ◽  
M. Fdz-Polanco ◽  
F. I. Plaza ◽  
G. Garralón ◽  
F. Fdz-Polanco
Keyword(s):  
Anaerobic Digestion ◽  
Energy Balance ◽  
Specific Energy ◽  
Biogas Production ◽  
Pilot Scale ◽  
Laboratory Scale ◽  
Net Generation ◽  
Batch Reactors ◽  
Anaerobic Reactors ◽  
Pre Treatment

Prior research indicates that ultrasounds can be used in batch reactors as pre-treatment before anaerobic digestion, but the specific energy required at laboratory-scale is too high. This work evaluates both the continuous ultrasound device performance (efficiency and solubilisation) and the operation of anaerobic digesters continuously fed with sonicated sludge, and presents energy balance considerations. The results of sludge solubilisation after the sonication treatment indicate that, applying identical specific energy, it is better to increase the power than the residence time. Working with secondary sludge, batch biodegradability tests show that by applying 30 kWh/m3 of sludge, it is possible to increase biogas production by 42%. Data from continuous pilot-scale anaerobic reactors (V=100 L) indicate that operating with a conventional HRT = 20 d, a reactor fed with pre-treated sludge increases the volatile solids removal and the biogas production by 25 and 37% respectively. Operating with HRT = 15 d, the removal efficiency is similar to the obtained with a reactor fed with non-hydrolysed sludge at HTR = 20 d, although the specific biogas productivity per volume of reactor is higher for the pretreated sludge. Regarding the energy balance, although for laboratory-scale devices it is negative, full-scale suppliers state a net generation of 3–10 kW per kW of energy used.

scholarly journals Evaluation of acidogenic sludge from anaerobic reactors running at low solids retention times to reduce sludge generation and enhance biogas production

Water SA ◽  
2019 ◽  
Vol 45 (4 October) ◽  
Author(s):  
Wilza Da Silva Lopes ◽  
Ysa Helena Diniz Morais de Luna ◽  
Jose Tavares de Sousa ◽  
Wilton Silva Lopes ◽  
Valderi Duarte Leite
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Kinetic Constant ◽  
Oxygen Demand ◽  
Gas Production ◽  
Primary Sludge ◽  
Anaerobic Reactors ◽  
Solids Retention ◽  
Improved Performance ◽  
Pre Treatment

ABSTRACT   Sludges generated in the biological processing of sewage are complex mixtures, the constituents of which pose risks to public health and the environment. Anaerobic digestion is considered the most sustainable option for treating sludge because it offers the possibility of generating biogas. The aim of this study was to compare the quantities, properties, biodegradabilities and biochemical methane potentials (BMP) of primary sludge (PS) generated by a primary decanter with acidogenic sludges produced by upflow anaerobic (UA) reactors operating at solids retention times (SRTs) of 2, 4, 6 and 8 days (Samples S2, S4, S6 and S8, respectively). Sludges from both pre-treatments were submitted to alkaline solubilization in order to determine the efficiency of the process in disrupting extracellular complexes. Based on the levels of total solids (TS) present, the primary decanter was found to generate higher quantities of excess sludge (yield of 3.1 gTS∙d-1) than UA reactors operating at low SRTs (yields in the range 1.69 to 0.64 gTS∙d-1). The concentrations of dissolved materials in PS and Samples S2 and S8 were considerably higher after alkaline solubilization, with respective increases of 8, 14 and 28-fold in dissolved organic carbon, 12, 20 and 40-fold in chemical oxygen demand, 25, 31 and 59-fold in proteins, and 17, 21 and 63-fold in carbohydrates. In addition, the BMP value for S8 was some 13% higher than that recorded for PS while the kinetic constant for gas production by S8 was 1.8-fold greater than that of PS. It is concluded that a pre-treatment combining anaerobic digestion at low SRT and alkaline solubilisation would lead to improved performance in subsequent stages of anaerobic digestion and, consequently, increased efficiency in biogas production.

Sign in / Sign up

Export Citation Format

Share Document