scholarly journals Influence of Microwave Pre-Treatment on the Digestion and Higienisation of Waste Activated Sludge/Wpływ Dezintegracji Mikrofalowej Na Proces Fermentacji Oraz Higienizacji Nadmiernych Osadów Ściekowych

2014 ◽  
Vol 21 (3) ◽  
pp. 447-464 ◽  
Author(s):  
Jolanta Bohdziewicz ◽  
Mariusz Kuglarz ◽  
Klaudiusz Grűbel
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Treatment Effectiveness ◽  
Biogas Production ◽  
Salmonella Spp ◽  
Biogas Yield ◽  
Treatment Conditions ◽  
Higher Power ◽  
Pre Treatment ◽  
Treatment Step

Abstract The article presents the results of determining the most appropriate conditions of microwave sludge pre-treatment (500-1200 W), prior to its anaerobic digestion in a continuous mode. The assessment of the pre-treatment conditions (microwave power, sludge temperature after pre-treatment) was based on: the release of organic (COD, protein) and inorganic (NH4+, PO43-) substances into liquid, the quantity of methane produced, sludge higienisation and the susceptibility of the pre-treated sludge to dewatering. The power of the microwaves applied did not play significant role on the pre-treatment effectiveness. Taking into account the fact that sludge pre-treatment by microwave irradiation requires the delivery of energy, the pre-treatment by microwaves of higher power (1200 W) and resulting in sludge temperature of 70°C was recommended for further experiments. Sludge pre-treatment by means of microwave irradiation as a pre-treatment step influenced the effectiveness of the subsequent anaerobic digestion, conducted in continuous conditions, in a positive way. The largest amount of biogas was obtained for HRT in the range of 15-20 days. As compared to the sludge which did not undergo pre-treatment, daily biogas production and biogas yield increased by 18-41% and 13-35% respectively. The combination of microwave pre-treatment and mesophilic anaerobic digestion ensured the elimination of pathogens (Salmonella spp., Escherichia coli).

scholarly journals Opportunity of Biogas Production from Solid Organic Wastes through Anaerobic Digestion

2018 ◽  
Vol 65 ◽  
pp. 05025 ◽  
Author(s):  
Sagor Kumar Pramanik ◽  
Fatihah Binti Suja ◽  
Biplob Kumar Pramanik ◽  
Shahrom Bindi Md Zain
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Nutrient Balance ◽  
Organic Wastes ◽  
Organic Loading Rate ◽  
Biogas Yield ◽  
Carbon And Nitrogen ◽  
Potential Risks ◽  
Nitrogen Ratio ◽  
Pre Treatment

Solid organic wastes create potential risks to environmental pollution and human health due to the uncontrolled discharge of huge quantities of hazardous wastes from numerous sources. Now-a-days, anaerobic digestion (AD) is considered as a verified and effective alternative compared to other techniques for treating solid organic waste. The paper reviewed the biological process and parameters involved in the AD along with the factors could enhance the AD process. Hydrolysis is considered as a rate-limiting phase in the complex AD process. The performance and stability of AD process is highly influenced by various operating parameters like temperature, pH, carbon and nitrogen ratio, retention time, and organic loading rate. Different pre-treatment (e.g. mechanical, chemical and biological) could enhance the AD process and the biogas yield. Co-digestion can also be used to provide suitable nutrient balance inside the digester. Challenges of the anaerobic digestion for biogas production are also discussed.

Sludge electrooxidation as pre-treatment for anaerobic digestion

2016 ◽  
Vol 75 (4) ◽  
pp. 775-781 ◽  
Author(s):  
J. A. Barrios ◽  
U. Duran ◽  
A. Cano ◽  
M. Cisneros-Ortiz ◽  
S. Hernández
Keyword(s):  
Anaerobic Digestion ◽  
Volatile Fatty Acids ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Wastewater Sludge ◽  
Boron Doped Diamond ◽  
Boron Doped ◽  
Treatment Conditions ◽  
Volatile Solids ◽  
Pre Treatment

Anaerobic digestion of wastewater sludge is the preferred method for sludge treatment as it produces energy in the form of biogas as well as a stabilised product that may be land applied. Different pre-treatments have been proposed to solubilise organic matter and increase biogas production. Sludge electrooxidation with boron-doped diamond electrodes was used as pre-treatment for waste activated sludge (WAS) and its effect on physicochemical properties and biomethane potential (BMP) was evaluated. WAS with 2 and 3% total solids (TS) achieved 2.1 and 2.8% solubilisation, respectively, with higher solids requiring more energy. After pre-treatment, biodegradable chemical oxygen demand values were close to the maximum theoretical BMP, which makes sludge suitable for energy production. Anaerobic digestion reduced volatile solids (VS) by more than 30% in pre-treated sludge with a food to microorganism ratio of 0.15 g VSfed g−1 VSbiomass. Volatile fatty acids were lower than those for sludge without pre-treatment. Best pre-treatment conditions were 3% TS and 28.6 mA cm−2.

scholarly journals Enhanced biodegradability of dairy sludge by microwave assisted alkaline and acidic pre-treatments

2019 ◽  
Vol 7 (1-2) ◽  
pp. 92-97
Author(s):  
Sándor Beszédes ◽  
Zoltán Jákói ◽  
Balázs Lemmer ◽  
Cecilia Hodúr
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Biogas Production ◽  
Treatment Method ◽  
Acidic Condition ◽  
Alkaline Condition ◽  
Thermal Methods ◽  
Microwave Assisted ◽  
Pre Treatment ◽  
Aerobic Biodegradability

Considering the rapid, volumetric and selective heating effects of microwaves the microwave assisted chemical methods could provide appropriate alternatives for conventional thermal methods in sludge processing. Microwave irradiation alone is suitable to accelerate the hydrolysis stage of anaerobic decomposition of sludge resulted in accelerated biogas production rate and in higher biogas yield. Alkaline pre-treatments increase the organic matter solubility and suitable for disintegration of sludge particles. In some study are concluded that acidic conditions help the disintegration of waste activated sludge and assist in the solubilisation of carbohydrates and proteins which led to increased higher biogas production, as well. Beside the promising results related to effects of microwave pre-treatments on anaerobic digestion of sludge there are very few reports on the investigation of combined acidic/alkali-microwave pre-treatment method for food industry originated sludge. Hence, our study focused on the examination of the effects of combined microwave-alkali and microwave-acidic pre-treatment on aerobic and anaerobic biodegradability of sludge produced in dairy industry Our experimental results verified, that microwave irradiation with alkaline dosage improve the solubility of organic matters in the pH range of 8-12. But enhancement of disintegration was not correlated linearly with biodegradability. During pre-treatment stage, applying pH over 10, the aerobic biodegradability show decreasing tendency. Applying of acidic condition during microwave irradiation resulted in lower disintegration degree than obtained for microwave-alkaline sludge pre-treatment method. But with microwave assisted acidic pre-treatments a higher aerobic biodegradability could be achieved than with alkaline dosage. In microwave pre-treatments acidic condition was preferable to increase the shorter aerobic biodegradability; the alkaline condition was favourable to intensify the anaerobic digestion process.

scholarly journals APLIKASI THERMAL PRE-TREATMENT LIMBAH TANAMAN JAGUNG (Zea mays) SEBAGAI CO·SUBSTRAT PADA PROSES ANAEROBIK DIGESTI UNTUK PRODUKSI BIOGAS

2016 ◽  
Vol 36 (01) ◽  
pp. 79
Author(s):  
Darwin Darwin ◽  
Yusmanizar Yusmanizar ◽  
Muhammad Ilham ◽  
Afrizal Fazil ◽  
Satria Purwanto ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Corn Stover ◽  
Biogas Production ◽  
Lag Phase ◽  
Total Production ◽  
Biogas Yield ◽  
Anaerobic Digestion Process ◽  
Digestion Process ◽  
Volatile Solids ◽  
Pre Treatment

Thermal pre-treatment was given on corn stover in the purpose of breaking the lignin content; thus, it may help anaerobic microorganisms to convert polymer including cellulose and hemicelluloses into biogas. This study aimed to investigate the effects of thermal pre-treatment on corn stover in anaerobic digestion process related to the production of biogas as well as digestion process efficiency. This research was carried out by utilizing batch reactors where the temperature was maintained at mesophilic conditions above room temperature (33 ± 2 oC). Based on the result, it was known that thermal pre-treatment given on the corn stover may enhance anaerobic digestion process for biogas production at the first 10 days. This condition reduced the time of lag phase during anaerobic digestion. The biogas production of corn stover given thermal pre-treatment was slow at 26 days where their average total production were 12,412.5 mL,12,310 mL at 15 and 25 minutes thermal pre-treatment, respectively while biogas production of non pre-treated corn stover was 12,557 mL. The highest daily biogas production was accomplished by corn stover that was given thermal pre-treatment at 25 minutes (915 mL). Corn stover given with 15 minutes thermal pre-treatment also generated higher daily biogas production at day 9 (772.5 mL) compared with corn stover that was not pre-treated (405 mL). This research also revealed that corn stover given thermal pre-treatment reached higher biogas yield compared with non pre-treated corn stover where their biogas yield were 670.39, 690.65 mL/g volatile solids added at 15 and 25 minutes thermal pre- treatment respectively, and 456.37 mL/g volatile solids added of non pre-treated corn stover.Keywords: Thermal pre-treatment, corn stover, anaerobic digestion, biogas ABSTRAKThermal pre-treatment diberikan pada limbah tanaman jagung dengan tujuan untuk memecahkan kandungan lignin yang terdapat pada limbah tanaman jagung sehingga memudahkan mikroorganisme anaerobik untuk mengkonversi polimer yang berupa selulosa dan hemiselulosa menjadi biogas. Tujuan dari penelitian ini adalah untuk melakukan kajian mengenai penerapan thermal pre-treatment pada limbah tanaman jagung terhadap proses anaerobik digesi yang meliputi efisiensi proses digesi dan produksi biogas yang dihasilkan. Penelitian ini dilakukan dengan menggunakan reaktor tipe batch yang suhunya dipertahankan pada kondisi mesophilic atau di atas rata-rata suhu kamar (33 ± 2 oC). Hasil penelitian diperoleh bahwa thermal pre-treatment yang diberikan pada limbah tanaman jagung mampu mempercepat proses produksi biogas pada 10 hari pertama sehingga dapat mengurangi lag-phase pada proses anaerobik digesi. Limbah tanaman jagung yang diberikan thermal pre-treatment mengalami perlambatan produksi biogas pada hari ke 26 dengan rata-rata total produksi 12.412,5 mL untuk limbah tanaman jagung yang diberikan thermal pre- treatment selama 15 menit, dan 12.310 mL untuk limbah tanaman jagung yang diberikan thermal pre-treatment selama 25 menit, sedangkan limbah tanaman jagung yang tidak diberikan pre-treatment menghasilkan produksi biogas sebesar 12.557 mL pada hari ke 26. Produksi biogas harian tertinggi terjadi pada substrat yang diberikan thermal pre-treatment 25 menit, dengan produksi biogas tertinggi pada hari ke 9 dengan rata-rata produksi sebesar 915 mL. Substrat yang diberikan thermal pre-treatment 15 menit juga memproduksi biogas jauh lebih tinggi (772,5 mL) pada hari ke 9 jika dibandingkan dengan substrat tanpa diberikan pre-treatment yang hanya memproduksi biogas sebesar 405 mL. Data hasil penelitian menunjukkan bahwa limbah tanaman jagung yang diberikan thermal pre-treatment memperoleh biogas yield lebih tinggi dari pada yang tidak diberikan pre-treatment dimana 670,39 mL/g volatile solids untuk thermal pre- treatment 15 menit, 690,65 mL/g volatile solids untuk thermal pre-treatment 25 menit dan 456,37 mL/g volatile solids untuk limbah tanaman jagung yang tidak diberikan pre-treatment.Kata kunci: Thermal pre-treatment, limbah tanaman jagung, anaerobik digesi, biogas

scholarly journals Evaluation of Biogas through Chemically Treated Cottonseed Hull in Anaerobic Digestion with/without Cow Dung: An Experimental Study

2021 ◽  
Author(s):  
Venkateshkumar R ◽  
Shanmugam S ◽  
Veerappan AR
Keyword(s):  
Anaerobic Digestion ◽  
Sodium Hydroxide ◽  
Calcium Hydroxide ◽  
Biogas Production ◽  
Cow Dung ◽  
Batch Reactors ◽  
Biogas Yield ◽  
Cottonseed Hull ◽  
Pre Treatment ◽  
Feedstock Material

Abstract Cow dung is generally used as the feedstock material for the anaerobic digestion to produce biogas. A selection of alternate biomass material is needed to reduce the consumption or to eliminate the use of cow dung. Recently, cottonseed hull has been considered as the primary substrate to produce biogas. In this paper, the effect of biogas production on anaerobic co-digestion of cow dung with pre-treated cottonseed hull using different concentrations of sulfuric acid, hydrochloric acid, hydrogen peroxide, and acetic acid is investigated. Sodium hydroxide and calcium hydroxide are used at different concentrations for pre-treatment of cottonseed hull. The enhancement of biogas production from the batch reactors at mesophilic temperature (35 ± 2 ℃) is observed for mono- and co-digestion of cow dung with treated cottonseed hull. Maximum biogas yield is achieved for the treated cottonseed hull at 6% sodium hydroxide during mono digestion and at 6% calcium hydroxide during co-digestion.

Full-stream and part-stream ultrasound treatment effect on sludge anaerobic digestion

2010 ◽  
Vol 61 (6) ◽  
pp. 1363-1372 ◽  
Author(s):  
S. I. Pérez-Elvira ◽  
L. C. Ferreira ◽  
A. Donoso-Bravo ◽  
M. Fdz-Polanco ◽  
F. Fdz-Polanco
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Full Scale ◽  
Optimum Process ◽  
Capillary Suction ◽  
Biogas Yield ◽  
Batch Tests ◽  
Secondary Sludge ◽  
Pre Treatment ◽  
The Relationship

The use of ultrasound as pre-treatment to improve anaerobic digestion of secondary sludge has been established as a promising technology. There are great differences between lab scale and full-scale devices, regarding the relationship between the disintegration achieved and the energy supplied. Based on economic aspects, most of the full-scale plants use partial-stream instead of the full-stream sonication, which affects biogas production and digestate dewatering characteristics. A laboratory scale operation combining ultrasound and anaerobic digestion (batch tests) has been performed, determining the relationship between the ratio of sonicated sludge fed and the methane production, SCOD removal and capillary suction time after 20-day anaerobic biodegradation, in order to check the possible benefits of part-stream versus full-stream sonication. Additional incubation was also evaluated, searching for an optimum process combining ultrasound and 24-h incubation pretreatment. Results showed that by sonicating fresh WAS at 25,700 kJ/kg TS biogas yield increased linearly with the percentage of sonicated WAS in the substrate, from 248 (control reactor) to 349 mL CH4/g VS (41% increase in full-stream sonication). By incubation (24 h, 55°C), 325 mL CH4/g VS were obtained (31% increase), but the digestion of the soluble compounds generated during incubation of sonicated sludge appeared to be less degradable compared to those solubilised by ultrasound or incubation alone, which showed no benefit in combining both treatments. Post-digestion dewatering deteriorated for both part-stream and full-stream sonication, and CST values were constant (74% higher than the control digestate) from 30% to 100% sonicated sludge.

scholarly journals Enhanced Biogas Production from Anaerobic Codigestion of Lignocellulosic Waste for Efficient Bioenergy Utilization in Heating and Combustion Engine

2020 ◽  
pp. 11-21
Author(s):  
Uduak U. Ndubuisi-Nnaji ◽  
Utibe A. Ofon ◽  
Ata O. Inyang-Enin ◽  
Georgina N. Ananso
Keyword(s):  
Anaerobic Digestion ◽  
Production Efficiency ◽  
Combustion Engine ◽  
Biogas Production ◽  
Removal Rates ◽  
Biogas Yield ◽  
Coconut Husk ◽  
Vs Removal ◽  
Pre Treatment ◽  
Banana Stem

Anaerobic digestion (AD) of lignocellulosic agro-waste such as coconut husk fibre, pineapple floret and banana stem was studied using standard protocols. A combination of physical, chemical and biological Pre-treatment was performed to facilitate the anaerobic digestion process. The experiment was carried out using laboratory-scale batch bioreactors maintained at 44.5 ± 2ºC and retention time of 25 days. Biogas production, pH, total and volatile solids concentrations (TS, VS) were also measured. With a general increase in pH after Pre-treatment of all substrates, biogas yield was significantly improved by 83.1% in all codigestion assays when compared to control (untreated substrates) with highest TS and VS removal rates of 77.7% and 87.2% respectively. In terms process performance, Pre-treatment of single substrate did not significantly improve AD of single substrates (coconut husk fibre/pineapple floret) and biogas production was inhibited in pre-treated banana stem. However, the highest biogas production with corresponding TS and VS removal rates of 78.3% and 92.9% respectively were obtained from untreated banana stem. Codigestion significantly enhanced biogas production that can be utilized for heating and knowledge of appropriate Pre-treatment choice is recommended to improve bioenergy production efficiency during anaerobic digestion.

Digestion of sludge and organic waste in the sustainability concept for Malmö, Sweden

2004 ◽  
Vol 49 (10) ◽  
pp. 163-169 ◽  
Author(s):  
J. la Cour Jansen ◽  
C. Gruvberger ◽  
N. Hanner ◽  
H. Aspegren ◽  
 Svärd
Keyword(s):  
Anaerobic Digestion ◽  
Organic Waste ◽  
Biogas Production ◽  
Treatment Plant ◽  
Pilot Scale ◽  
Anaerobic Treatment ◽  
Household Waste ◽  
Biogas Yield ◽  
Different Types ◽  
Pre Treatment

Anaerobic digestion of sludge has been part of the treatment plant in Malmö for many years and several projects on optimisation of the digestion process have been undertaken in full scale as well as in pilot scale. In order to facilitate a more sustainable solution in the future for waste management, solid waste organic waste is sorted out from households for anaerobic treatment in a newly built city district. The system for treatment of the waste is integrated in a centralised solution located at the existing wastewater treatment plant. A new extension of the digester capacity enables separate as well as co-digestion of sludge together with urban organic waste from households, industry, restaurants, big kitchens, food stores, supermarkets, green markets etc. for biogas production and production of fertiliser. Collection and pre-treatment of different types of waste are in progress together with examination of biogas potential for different types of organic waste. Collection of household waste as well as anaerobic digestion in laboratory and pilot scale has been performed during the last year. It is demonstrated that organic household waste can be digested separately or in combination with sludge. In the latter case a higher biogas yield is found than should be expected from digestion of the two materials separately. Household waste from a system based on collection of organic waste from grinders could be digested at mesophilic conditions whereas digestion failed at thermophilic conditions.

scholarly journals Biogas potential of organic waste onboard cruise ships — a yet untapped energy source

2021 ◽  
Author(s):  
Kai Schumüller ◽  
Dirk Weichgrebe ◽  
Stephan Köster
Keyword(s):  
Energy Source ◽  
Anaerobic Digestion ◽  
Sewage Sludge ◽  
Food Waste ◽  
Energy Demand ◽  
Organic Waste ◽  
Biogas Production ◽  
Biogas Yield ◽  
Cruise Ships ◽  
Detailed Presentation

AbstractTo tap the organic waste generated onboard cruise ships is a very promising approach to reduce their adverse impact on the maritime environment. Biogas produced by means of onboard anaerobic digestion offers a complementary energy source for ships’ operation. This report comprises a detailed presentation of the results gained from comprehensive investigations on the gas yield from onboard substrates such as food waste, sewage sludge and screening solids. Each person onboard generates a total average of about 9 kg of organic waste per day. The performed analyses of substrates and anaerobic digestion tests revealed an accumulated methane yield of around 159 L per person per day. The anaerobic co-digestion of sewage sludge and food waste (50:50 VS) emerged as particularly effective and led to an increased biogas yield by 24%, compared to the mono-fermentation. In the best case, onboard biogas production can provide an energetic output of 82 W/P, on average covering 3.3 to 4.1% of the total energy demand of a cruise ship.

Alkali pre-treatment of Sorghum Moench for biogas production

2013 ◽  
Vol 67 (9) ◽  
Author(s):  
Karina Michalska ◽  
Stanisław Ledakowicz
Keyword(s):  
Anaerobic Digestion ◽  
Chemical Oxygen Demand ◽  
Volatile Fatty Acids ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Total Phenolic ◽  
Methane Generation ◽  
Pre Treatment ◽  
Alkali Hydrolysis ◽  
Almost All

AbstractThis work studies the influence of the alkali pre-treatment of Sorghum Moench — a representative of energy crops used in biogas production. Solutions containing various concentrations of sodium hydroxide were used to achieve the highest degradation of lignocellulosic structures. The results obtained after chemical pre-treatment indicate that the use of NaOH leads to the removal of almost all lignin (over 99 % in the case of 5 mass % NaOH) from the biomass, which is a prerequisite for efficient anaerobic digestion. Several parameters, such as chemical oxygen demand, total organic carbon, total phenolic content, volatile fatty acids, and general nitrogen were determined in the hydrolysates thus obtained in order to define the most favourable conditions. The best results were obtained for the Sorghum treated with 5 mass % NaOH at 121°C for 30 min The hydrolysate thus achieved consisted of high total phenolic compounds concentration (ca. 4.7 g L−1) and chemical oxygen demand value (ca. 45 g L−1). Although single alkali hydrolysis causes total degradation of glucose, a combined chemical and enzymatic pre-treatment of Sorghum leads to the release of large amounts of this monosaccharide into the supernatant. This indicates that alkali pre-treatment does not lead to complete cellulose destruction. The high degradation of lignin structure in the first step of the pre-treatment rendered the remainder of the biomass available for enzymatic action. A comparison of the efficiency of biogas production from untreated Sorghum and Sorghum treated with the use of NaOH and enzymes shows that chemical hydrolysis improves the anaerobic digestion effectiveness and the combined pre-treatment could have great potential for methane generation.

Sign in / Sign up

Export Citation Format

Share Document