Start up of Thermophilic UASB (Upflow Anaerobic Sludge Blanket) Reactors Using Micro-Carrier and Mesophilic Granular Sludge

1992 ◽  
Vol 26 (3-4) ◽  
pp. 877-886 ◽  
Author(s):  
T. Ohtsuki ◽  
M. Watanabe ◽  
Y. Miyaji
Keyword(s):  
High Performance ◽  
Ph Dependence ◽  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Phase System ◽  
Two Phase ◽  
Start Up ◽  
Initial Seed

Two start-up methods of thermophilic UASB reactor were investigated for fast start-ups; one utilized micro-carrier as an initial support material and the other used intact mesophilic UASB granules as an initial seed. With both methods thermophilic granules having high activity were obtained in less than 3 months, even with acidified wastewater. Maximum sludge load for VFA substrate and sugar substrate were 3.2 and 0.9 kgCOD/kgVSS/day, respectively. Pre-acidogenesis was indispensable for high-performance treatment of sugar-containing substrate. It was proven that with a two-phase system sludge load could be raised to 3.0 kgCOD/kgVSS/day for sugar containing wastewaters. Some features of obtained sludge were examined, including maximum substrate utilizing activities, temperature dependence, pH dependence, and activity deterioration under lower loading conditions.

Removal of COD from Piggery Wastewater Using a Lab-Scale UASB Reactor

2012 ◽  
Vol 534 ◽  
pp. 221-224
Author(s):  
Fei Yan ◽  
Jin Long Zuo ◽  
Tian Lei Qiu ◽  
Xu Ming Wang
Keyword(s):  
Granular Sludge ◽  
Cod Removal ◽  
Upflow Anaerobic Sludge Blanket ◽  
Synthetic Wastewater ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Volume Loading ◽  
Piggery Wastewater ◽  
Start Up ◽  
Anaerobic Sludge Blanket

It took 55 days to start up a lab-scale upflow anaerobic sludge blanket (UASB) reactor at ambient temperature 27-28 oC by using the synthetic wastewater, and piggery wastewater was used as the influent after the reactor start-up. From day 120 onwards, COD removal efficiency maintained in the range of 85% to 95% with 6.79-9.66 kg COD/ (m3•d) of volume loading, and the effluent COD concentration ranged between 400 mg/L and 600 mg/L. Granular sludge formation was observed in the reactor after 40-day operation, and the sludge diameter reached 2-4 mm in the 120 day-old reactor. The pH changes in the influent had little influence on COD removal from piggery wastewater using the UASB reactor.

A hybrid two-phase system for anaerobic digestion of food waste

2002 ◽  
Vol 45 (12) ◽  
pp. 159-165 ◽  
Author(s):  
J.Y. Wang ◽  
H.L. Xu ◽  
J.H. Tay
Keyword(s):  
Anaerobic Digestion ◽  
Food Waste ◽  
Batch Reactor ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Phase System ◽  
Bioreactor Landfills ◽  
Two Phase ◽  
Methanogenic Phase

A hybrid two-phase system, consisting of a solid waste reactor as the acidification reactor and a wastewater reactor, i.e. an upflow anaerobic sludge blanket (UASB) reactor, as the methanogenic reactor, for anaerobic digestion of food waste was investigated. After the pre-acidification stage, COD and total VFA removals in the methanogenic phase were in the ranges of 74-93% and 77-100%, respectively, while leachate COD and total VFA concentrations in the acidification phase decreased by 95% and 97-99%, respectively. Some 99% of the total CH4 generated was from the methanogenic phase with the CH4 content of 68-70%. About 77-79% of TOC, 57-60% of volatile solids and 79-80% of total COD were removed. The results of this laboratory-scale study show that the hybrid two-phase anaerobic batch reactor system is suitable for effective conversion of food waste into CH4 and CO2. The hybrid two-phase system can be further developed into an effective and efficient way to enhance waste stabilization in operating bioreactor landfills.

High-Rate Anaerobic Treatment of Industrial Wastewaters

1991 ◽  
Vol 24 (1) ◽  
pp. 69-74 ◽  
Author(s):  
J. Rintala
Keyword(s):  
Granular Sludge ◽  
Anaerobic Treatment ◽  
High Rate ◽  
Upflow Anaerobic Sludge Blanket ◽  
Synthetic Wastewater ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Industrial Wastewaters ◽  
Start Up ◽  
Uasb Reactors

Anaerobic mesophilic treatment of synthetic (a mixture of acetate and methanol) and thermomechanical pulping (TMP) wastewater was studied in laboratory-scale upflow anaerobic sludge blanket (UASB) reactors and filters with emphasis on the process start-up. The reactors were inoculated with nongranular sludge. The start-up of mesophilic and thermophilic processes inoculated with mesophilic granular sludge was investigated in UASB reactors fed with diluted vinasse. The start-up proceeded faster in the filters than in the UASB reactors with TMP and synthetic wastewater. Loading rates of over 15 kgCODm−3d−1 with 50-60 % COD removal efficiencies were achieved in 10 days in the mesophilic and in 50 days in the thermophilic UASB reactor treating vinasse. The results show that high-rate anaerobic treatment can be applied to different types of industrial wastewaters under varying conditions.

Treatment of textile dyes in two-phase and single-phase anaerobic bio-treatment systems

2008 ◽  
Vol 57 (6) ◽  
pp. 863-868 ◽  
Author(s):  
D. Bhattacharyya ◽  
K. S. Singh
Keyword(s):  
Single Phase ◽  
Granular Sludge ◽  
Anaerobic Treatment ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Phase System ◽  
Two Phase ◽  
Anaerobic Reactors ◽  
Anaerobic Sludge Blanket

This research integrates two different concepts of anaerobic biotechnology- two-phase anaerobic treatment and anaerobic granular sludge bed technology, in treatment of colored wastewaters from textile industries. Four anaerobic reactors based on upflow anaerobic sludge blanket (UASB) technology were used as acid reactors and an expanded granular sludge bed (EGSB) reactor was used as a methane reactor. A conventional single-phase anaerobic reactor, working on EGSB technology was run in parallel to compare the performances of the two systems. Reactors were operated at different hydraulic retention times. The results from the study, which span over a period of 400 days, indicated that the two-phase system produces a higher quality of effluent in terms of color, COD and suspended solids than single-phase anaerobic treatment when operated under similar conditions. Alkalinity requirement of two-phase system was also observed to be lower than that of single-phase system which is important regarding design consideration.

scholarly journals Microbial Diversity Dynamics in a Methanogenic-Sulfidogenic UASB Reactor

2021 ◽  
Vol 18 (3) ◽  
pp. 1305
Author(s):  
E. Fernández-Palacios ◽  
Xudong Zhou ◽  
Mabel Mora ◽  
David Gabriel
Keyword(s):  
Paper Industry ◽  
Chemical Species ◽  
Methanogenic Archaea ◽  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Rrna Gene ◽  
Sulfate Reducing ◽  
Long Run

In this study, the long-term performance and microbial dynamics of an Upflow Anaerobic Sludge Blanket (UASB) reactor targeting sulfate reduction in a SOx emissions treatment system were assessed using crude glycerol as organic carbon source and electron donor under constant S and C loading rates. The reactor was inoculated with granular sludge obtained from a pulp and paper industry and fed at a constant inlet sulfate concentration of 250 mg S-SO42−L−1 and a constant C/S ratio of 1.5 ± 0.3 g Cg−1 S for over 500 days. Apart from the regular analysis of chemical species, Illumina analyses of the 16S rRNA gene were used to study the dynamics of the bacterial community along with the whole operation. The reactor was sampled along the operation to monitor its diversity and the changes in targeted species to gain insight into the performance of the sulfidogenic UASB. Moreover, studies on the stratification of the sludge bed were performed by sampling at different reactor heights. Shifts in the UASB performance correlated well with the main shifts in microbial communities of interest. A progressive loss of the methanogenic capacity towards a fully sulfidogenic UASB was explained by a progressive wash-out of methanogenic Archaea, which were outcompeted by sulfate-reducing bacteria. Desulfovibrio was found as the main sulfate-reducing genus in the reactor along time. A progressive reduction in the sulfidogenic capacity of the UASB was found in the long run due to the accumulation of a slime-like substance in the UASB.

Acid Endurance and Sorption of Zn2+ of Anaerobic Granular Sludge Acclimated by Flue Gas Pretreatment Wastewater

2013 ◽  
Vol 634-638 ◽  
pp. 182-186
Author(s):  
Juan Wang ◽  
Qin Zhong
Keyword(s):  
Flue Gas ◽  
Ph Value ◽  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Anaerobic Granular Sludge ◽  
Methanogenic Activity ◽  
Activity Inhibition ◽  
Anaerobic Sludge Blanket

With the aim to use anaerobic granular sludge, the methanogenic activity inhibition and recovery of anaerobic granular sludge from an industrial anaerobic reactor (s1) were investigated by measuring the methane volume at low pH. A lab-scale upflow anaerobic sludge blanket (UASB) reactor was inoculated with s1.s1 was used to remove Zn2+ in wastewater. The results show that activity of s1 is similar when the pH value is 6.5 to 7.0. The methane volume is obviously decreased when the pH value is 6.0. The activity is completely inhibited when the pH value is 4.5. The activity is fully recovered when the pH is above 6.5 and hardly recovers when the pH fell to 4.5. The main Zn2+ removal mechanism is chemical adsorption.

Advanced Reactor Design, Operation and Economy

1986 ◽  
Vol 18 (12) ◽  
pp. 99-108 ◽  
Author(s):  
Gatze Lettinga ◽  
Look Hulshoff Pol
Keyword(s):  
Suspended Solids ◽  
Granular Sludge ◽  
High Rate ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Internal Circulation ◽  
Inlet System ◽  
Anaerobic Sludge Blanket ◽  
Feed Inlet

Of the high rate anaerobic wastewater treatment systems the UASB (Upflow Anaerobic Sludge Blanket) reactor has found the widest application. Therefore the attention with respect to design, operation and economy will be focussed on this reactor type. In designing a UASB reactor specific attention is needed for the GSS (Gas-Solids Separator) device and the feed inlet system. For soluble wastewater generally no phase separation is required. Only for wastewaters high in suspended solids pre-acidification in a separate acidification reactor can be beneficial. Increasing attention is given to the development of modified UASB systems, such as a combination of a sludge bed reactor and an anaerobic filter. Other possible modified UASB systems may be found in a FS (Floating Settling) UASB reactor, the EGSB (Expanded Granular Sludge Bed) reactor and the UASB IC (Internal Circulation) reactor. As many factors are involved in the costs of a UASB reactor, only some rough data on reactor costs are presented.

Start-up of a thermophilic upflow anaerobic sludge bed (UASB) reactor with mesophilic granular sludge

1992 ◽  
Vol 37 (1) ◽  
pp. 130-135 ◽  
Author(s):  
Jules B. van Lier ◽  
Katja C. F. Grolle ◽  
Alfons J. M. Stams ◽  
Everly Conway de Macario ◽  
Gatze Lettinga
Keyword(s):  
Granular Sludge ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Start Up

Impact of aluminum chloride on process performance and microbial community structure of granular sludge in an upflow anaerobic sludge blanket reactor for natural rubber processing wastewater treatment

2016 ◽  
Vol 74 (2) ◽  
pp. 500-507 ◽  
Author(s):  
Nguyen Thi Thanh ◽  
Takahiro Watari ◽  
Tran Phuong Thao ◽  
Masashi Hatamoto ◽  
Daisuke Tanikawa ◽  
...  
Keyword(s):  
Community Structure ◽  
Microbial Community ◽  
Natural Rubber ◽  
Microbial Community Structure ◽  
Aluminum Chloride ◽  
Granular Sludge ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Anaerobic Sludge Blanket

In this study, granular sludge formation was carried out using an aluminum chloride supplement in an upflow anaerobic sludge blanket (UASB) reactor treating natural rubber processing wastewater. Results show that during the first 75 days after the start-up of the UASB reactor with an organic loading rate (OLR) of 2.65 kg-COD·m−3·day−1, it performed stably with a removal of 90% of the total chemical oxygen demand (COD) and sludge still remained in small dispersed flocs. However, after aluminum chloride was added at a concentration of 300 mg·L−1 and the OLR range was increased up to 5.32 kg-COD·m−3·day−1, the total COD removal efficiency rose to 96.5 ± 2.6%, with a methane recovery rate of 84.9 ± 13.4%, and the flocs began to form granules. Massively parallel 16S rRNA gene sequencing of the sludge retained in the UASB reactor showed that total sequence reads of Methanosaeta sp. and Methanosarcina sp., reported to be the key organisms for granulation, increased after 311 days of operation. This indicates that the microbial community structure of the retained sludge in the UASB reactor at the end of the experiment gave a good account of itself in not only COD removal, but also granule formation.

A Modified UASB Process Treating Winery Wastewater

1990 ◽  
Vol 22 (9) ◽  
pp. 167-174 ◽  
Author(s):  
S. S. Cheng ◽  
J. J. Lay ◽  
Y. T. Wei ◽  
M. H. Wu ◽  
G. D. Roam ◽  
...  
Keyword(s):  
Gas Production ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Winery Wastewater ◽  
Start Up ◽  
Methane Potential ◽  
Bmp Test ◽  
Anaerobic Sludge Blanket ◽  
Different Characteristics

During the last two years,twenty-seven bioreactors of upflow anaerobic sludge blanket(UASB) process were constructed and operated well to treat 3,300 m3/day of winery wastewater in six winery plants in Taiwan. Each UASB reactor was installed with an internal filter and a side-armed sludge settler to separate gas-liquid-solid effectively in 127 m3 of reactor volume.These six plants established good performance of UASB process with different organic loadings depending on different characteristics of the winery wastewater. Start-up performance of the modified UASB process in four winery plants was investigated.Bioactivity of anaerobic sludge in each UASB was evaluated by means of Biochemical Methane Potential (BMP)test. Biokinetics of Monod and Haldane models were employed to interpret the different sludge characteristics in terms of gas production rate. Scanning electronic microscopy also showed different morphology of sludge granules in three UASB systems.

Sign in / Sign up

Export Citation Format

Share Document