scholarly journals A Comparative Study of Biogas Production from Cattle Slaughterhouse Wastewater Using Conventional and Modified Upflow Anaerobic Sludge Blanket (UASB) Reactors

2019 ◽  
Vol 17 (1) ◽  
pp. 283 ◽  
Author(s):  
Mohammed Ali Musa ◽  
Syazwani Idrus ◽  
Mohd Razif Harun ◽  
Tuan Farhana Tuan Mohd Marzuki ◽  
Abdul Malek Abdul Wahab
Keyword(s):  
Loading Condition ◽  
Biogas Production ◽  
Bacterial Species ◽  
High Strength ◽  
Upflow Anaerobic Sludge Blanket ◽  
Synthetic Wastewater ◽  
Anaerobic Sludge ◽  
Slaughterhouse Wastewater ◽  
Anaerobic Sludge Blanket ◽  
Uasb Reactors

Cattle slaughterhouses generate wastewater that is rich in organic contaminant and nutrients, which is considered as high strength wastewater with a high potential for energy recovery. Work was undertaken to evaluate the efficiency of the 12 L laboratory scale conventional and a modified upflow anaerobic sludge blanket (UASB) reactors (conventional, R1 and modified, R2), for treatment of cattle slaughterhouse wastewater (CSWW) under mesophilic condition (35 ± 1 °C). Both reactors were acclimated with synthetic wastewater for 30 days, then continuous study with real CSWW proceeds. The reactors were subjected to the same loading condition of OLR, starting from 1.75, 3, 5 10, 14, and 16 g L−1d−1, corresponding to 3.5, 6, 10, 20, 28, and 32 g COD/L at constant hydraulic retention time (HRT) of 24 h. The performance of the R1 reactor drastically dropped at OLR 10 g L−1d−1, and this significantly affected the subsequent stages. The steady-state performance of the R2 reactor under the same loading condition as the R1 reactor revealed a high COD removal efficiency of 94% and biogas and methane productions were 27 L/d and 89%. The SMP was 0.21 LCH4/gCOD added, whereas the NH3-N alkalinity ratio stood at 651 mg/L and 0.2. SEM showed that the R2 reactor was dominated by Methanosarcina bacterial species, while the R1 reactor revealed a disturb sludge with insufficient microbial biomass.

Toxicity of Sodium and Potassium Ions on Performance of UASB System

2014 ◽  
Vol 953-954 ◽  
pp. 1105-1108 ◽  
Author(s):  
Seni Karnchanawong ◽  
Kraiwet Kabtum
Keyword(s):  
Biogas Production ◽  
Cod Removal ◽  
Upflow Anaerobic Sludge Blanket ◽  
Synthetic Wastewater ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
Working Volume ◽  
Anaerobic Sludge Blanket ◽  
Uasb Reactors ◽  
Sodium And Potassium

The objective of this study was to investigate the toxicity of Na+and K+ions on performance of upflow anaerobic sludge blanket (UASB) system. Three laboratory-scale UASB reactors, 15.8 - l working volume, were employed with 1 reactor operated as control. They were loaded at organic loading rate (OLR) of 5 kg COD/(m3-d), treating synthetic wastewater with COD concentration ~ 5000 mg/l. Na+and K+ions were added in the range of 1010 - 7180 and 41 - 7320 mg/l, respectively. No toxicity was observed at influent Na+and K+concentrations up to 3340 and 2750 mg/l, respectively. Slight inhibitions on COD removal were founded at Na+and K+concentrations of 4610 and 3920 mg/l, respectively, but moderate effect on biogas production had occurred. When Na+and K+concentrations were increased to 7180 and 7320 mg/l, respectively, strong inhibitions were observed with COD removal dropped to 45.5 and 48.8 %, respectively. Ratios of biogas productions, as compared to the control reactor, were dropped to 0.31 and 0.32, respectively. Increasing cation concentrations had more detrimental effect on biogas production than COD removal.

scholarly journals Performance Comparison of Conventional and Modified Upflow Anaerobic Sludge Blanket (UASB) Reactors Treating High-Strength Cattle Slaughterhouse Wastewater

Water ◽  
2019 ◽  
Vol 11 (4) ◽  
pp. 806 ◽  
Author(s):  
Mohammed Ali Musa ◽  
Syazwani Idrus ◽  
Hasfalina Che Man ◽  
Nik Norsyahariati Nik Daud
Keyword(s):  
Oxygen Demand ◽  
High Strength ◽  
Performance Comparison ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
Slaughterhouse Wastewater ◽  
Anaerobic Sludge Blanket ◽  
Uasb Reactors

Cattle slaughterhouse wastewater (CSWW) with an average chemical oxygen demand (COD) and biochemical oxygen demand of 32,000 mg/L and 17,000 mg/L, respectively, can cause a severe environmental hazard if discharged untreated. Conventional upflow anaerobic sludge blanket (UASB) reactor is used in the treatment of slaughterhouse wastewater to meet the discharge standard limit of wastewater discharge set by the Department of Environment Malaysia (DOE). However, at higher loading rates the conventional systems are characterized by slow-growing microorganism resulting in long startup period, surface scum formation, and sludge washout. In this work, the performance of two laboratory scale (12 L) conventional (R1) and modified (R2) UASB reactors treating CSWW at mesophilic (36 ± 1 °C) condition were investigated. Both reactors were subjected to increasing organic loading rate (OLR) from 1.75 to 32 g L−1 day−1. The average COD, BOD5, and TSS removal efficiencies were ˃90%, at an OLR between 1.75 to 5 g L−1 day−1. The study revealed that R1 drastically reduced to 50, 53, and 43% with increasing OLR until 16 g L−1 day−1, whereas R2 maintained 76, 77, and 88% respectively, under the same OLR. Sign of reactor instability was very much pronounced in R1, showing poorly active Methanosaeta spp., whereas R2 showed a predominantly active Methanosarcina spp.

Herbal pharmaceutical wastewater treatment by a pilot scale upflow anaerobic sludge blanket (UASB) reactor

2009 ◽  
Vol 59 (11) ◽  
pp. 2265-2272 ◽  
Author(s):  
S. Satyanarayan ◽  
A. Karambe ◽  
A. P. Vanerkar
Keyword(s):  
Biogas Production ◽  
Oxygen Demand ◽  
High Strength ◽  
Cost Effective ◽  
Pilot Scale ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Reactor Performance ◽  
Anaerobic Sludge Blanket

Herbal pharmaceutical industry has grown tremendously in the last few decades. As such, literature on the treatment of this wastewater is scarce. Water pollution control problems in the developing countries need to be solved through application of cost effective aerobic/anaerobic biological systems. One such system—the upflow anaerobic sludge blanket (UASB) process which is known to be cost effective and where by-product recovery was also feasible was applied for treatment of a high strength wastewater for a period of six months in a pilot scale upflow anaerobic sludge blanket (UASB) reactor with a capacity of 27.44 m3. Studies were carried out at various organic loading rates varying between 6.26 and 10.33 kg COD/m3/day and hydraulic retention time (HRT) fluctuating between 33 and 43 hours. This resulted in chemical oxygen demand (COD), biochemical oxygen demand (BOD) and suspended solids (SS) removal in the range of 86.2%–91.6%, 90.0%–95.2% and 62.6%–68.0% respectively. The biogas production varied between 0.32–0.47 m3/kg COD added. Sludge from different heights of UASB reactor was collected and subjected to scanning electron microscopy (SEM). The results indicated good granulation with efficient UASB reactor performance.

The use of upflow anaerobic sludge blanket reactors in the treatment of poultry slaughterhouse wastewater

2001 ◽  
Vol 44 (4) ◽  
pp. 83-88 ◽  
Author(s):  
V. Del Nery ◽  
M. H.Z. Damianovic ◽  
F. G. Barros
Keyword(s):  
Loading Rate ◽  
Upflow Anaerobic Sludge Blanket ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
Dissolved Air Flotation ◽  
Slaughterhouse Wastewater ◽  
Cod Reduction ◽  
Start Up ◽  
Anaerobic Sludge Blanket ◽  
Uasb Reactors

This work studied the performance of the dissolved air flotation (DAF) system and the start-up and the operation of two 450 m3 UASB reactors in a poultry slaughterhouse in Sorocaba, Brazil. The DAF presented reduction efficiency of grease and fats, suspended solids and COD 50% higher. The reactors were seeded with non-adapted sludge. The average COD of the reactor influent was 2,695mg/L; and the initial organic loading rate (OLR) and the initial sludge loading rate at the start-up were 0.51 kg COD/m3.day and 0.04 kg COD/kg VTS.day, respectively. The start-up period was 144 days. During this time the reactor flow rate and OLR were gradually increased. At the reactor start-up, the maximum OLR value was 2.1 kg COD/m3.day, the COD reduction was higher than 80%, and the concentration of volatile fatsty acids (VFA) was below 100mg/L. The COD reductions, considering the reactor effluent raw COD and soluble COD were similar throughout the period studied in both reactors. The reactor effluent raw COD was approximately 10% higher than the soluble COD until the 225th day of operation. From the 225th day of operation this value increased 20%-30% due to the sludge washout. The effluent soluble COD reduction, the effluent VFA concentration and the operational stability attested the good performance of UASB reactors in poultry slaughterhouse wastewater treatment.

A modular diagnosis system based on fuzzy logic for UASB reactors treating sewage

2016 ◽  
Vol 74 (2) ◽  
pp. 309-317 ◽  
Author(s):  
R. M. Borges ◽  
A. Mattedi ◽  
C. J. Munaro ◽  
R. Franci Gonçalves
Keyword(s):  
Fuzzy Logic ◽  
Biogas Production ◽  
Fuzzy Model ◽  
Organic Content ◽  
Upflow Anaerobic Sludge Blanket ◽  
Organic Load ◽  
Anaerobic Sludge ◽  
Diagnosis System ◽  
Anaerobic Sludge Blanket ◽  
Uasb Reactors

A modular diagnosis system (MDS), based on the framework of fuzzy logic, is proposed for upflow anaerobic sludge blanket (UASB) reactors treating sewage. In module 1, turbidity and rainfall information are used to estimate the influent organic content. In module 2, a dynamic fuzzy model is used to estimate the current biogas production from on-line measured variables, such as daily average temperature and the previous biogas flow rate, as well as the organic load. Finally, in module 3, all the information above and the residual value between the measured and estimated biogas production are used to provide diagnostic information about the operation status of the plant. The MDS was validated through its application to two pilot UASB reactors and the results showed that the tool can provide useful diagnoses to avoid plant failures.

Removal of chlorinated phenols in upflow anaerobic sludge blanket reactors

1998 ◽  
Vol 38 (8-9) ◽  
pp. 359-367 ◽  
Author(s):  
Ronald L. Droste ◽  
Kevin J. Kennedy ◽  
Jingua Lu ◽  
Mercedes Lentz
Keyword(s):  
Acetic Acid ◽  
Upflow Anaerobic Sludge Blanket ◽  
Synthetic Wastewater ◽  
Anaerobic Sludge ◽  
Chlorinated Phenols ◽  
Reactor Performance ◽  
Chlorine Atoms ◽  
Toxic Agents ◽  
Anaerobic Sludge Blanket ◽  
Uasb Reactors

The dechlorination of chlorophenol (CP) compounds was investigated using upflow anaerobic sludge blanket reactors. A total of five trichlorophenols (TCPs) and a single dichlorophenol (DCP) were individually treated: 2,3,4-TCP; 2,3,5-TCP; 2,3,6-TCP; 2,4,5-TCP; 2,4,6-TCP; and 3,5-DCP. Synthetic wastewater composed of sucrose and acetic acid provided an alternate, readily biodegradable carbon source. Each chlorinated compound was concurrently fed to separate reactors. The parameters that were quantified include biogas composition, acetic acid concentration, COD, and VSS. The degree to which CPs were sorbed to the granular biomass in actively dechlorinating UASB reactors was found to be insignificant. CP compounds were able to be metabolized to mineral end products to a large extent at loadings where reactor performance was not impaired. Ortho chlorine atoms were most readily removed from CPs. CPs containing chlorine atoms in the para position were the most toxic agents with 2,4,5-TCP being the most toxic compound. Toxicity was reversible.

scholarly journals Effect of Hydraulic Retention Time on the Treatment of Real Cattle Slaughterhouse Wastewater and Biogas Production from HUASB Reactor

Water ◽  
2020 ◽  
Vol 12 (2) ◽  
pp. 490
Author(s):  
Mohammed Ali Musa ◽  
Syazwani Idrus
Keyword(s):  
Retention Time ◽  
Suspended Solids ◽  
Hydraulic Retention Time ◽  
Biogas Production ◽  
Nitrogen Concentration ◽  
Upflow Anaerobic Sludge Blanket ◽  
Synthetic Wastewater ◽  
Growth Surface ◽  
Anaerobic Sludge ◽  
Slaughterhouse Wastewater

Anaerobic digestion technology provides an alternative route for sustainable management of organic waste. In this study, the performance of the hybrid upflow anaerobic sludge blanket (HUASB) reactor consisting of synthetic grass media as attached growth surface was investigated for the treatment of cattle slaughterhouse wastewater under mesophilic (35 ± 1 °C) condition. After acclimatization with synthetic wastewater, the reactor was loaded up to OLR 10 g L−1d−1, corresponding to 20 g COD/L at a varying hydraulic retention time (HRT) of 24, 30, 36, 42, and 48 h. The system attained a maximum COD removal efficiency of 97% total suspended solids (TSS), volatile suspended solids (VSS), fats, oil, and grease (FOG), color removal, and turbidity were found as 97%, 284 mg/L, 79%, 78%, and 91% respectively. The biogas production after 48 h was found as 38 L/d, with about 85% methane and specific methane production of 0.24 LCH4/gCODadded. The ratio of alkalinity was 0.22, while ammonia nitrogen concentration reached a maximum of 839 mg/L at a steady state. Scanning electron microscopic (SEM) analysis revealed a predominance of Methanosarcina bacteria with the coccoidal shape at the end of the performance study. Therefore, the results of the experiment showed that increasing HRT significantly affects the performance of the system.

Biomass Acclimatization to Sequentially Varying Substrates in an Upflow Anaerobic Sludge Blanket (UASB) Bioreactor

2006 ◽  
Vol 41 (4) ◽  
pp. 437-448 ◽  
Author(s):  
Yee Ying Jennifer Tan ◽  
Mohd. Ali Hashim ◽  
K.B. Ramachandran
Keyword(s):  
Loading Rate ◽  
Biogas Production ◽  
Domestic Wastewater ◽  
High Strength ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Start Up ◽  
Time Required ◽  
Volumetric Loading ◽  
Anaerobic Sludge Blanket

Abstract In this study, an upflow anaerobic sludge blanket (UASB) bioreactor was sequentially subjected to high-strength synthetic, low-strength synthetic and domestic wastewaters. From COD removal data, supported by volumetric loading rate, hydraulic retention time, pH and qualitative biogas production data, it was observed that the biomass in the bioreactor took about twice the time required to acclimatize to a change in substrate characteristics or composition compared to a much more drastic quantitative change, i.e., more than 95% difference, in substrate concentration. As the initial experiment coincided with the bioreactor start-up, it could also be concluded that the feeding regime did not shorten the overall start-up time of a UASB bioreactor meant to treat domestic wastewater, but its eventual success was probably more assured.

The treatment of iron oxalate leach liquors in a UASB with sulfate reduction

1997 ◽  
Vol 36 (6-7) ◽  
pp. 383-390 ◽  
Author(s):  
J. E. Teer ◽  
D. J. Leak ◽  
A. W. L. Dudeney ◽  
A. Narayanan ◽  
D. C. Stuckey
Keyword(s):  
Bacterial Species ◽  
Upflow Anaerobic Sludge Blanket ◽  
Anaerobic Sludge ◽  
Desulfovibrio Vulgaris ◽  
Hydrogenotrophic Methanogenesis ◽  
Irreversible Effects ◽  
High Concentrations ◽  
A Minor ◽  
Anaerobic Sludge Blanket ◽  
Reducing Bacteria

The presence of small amounts of iron (>0.013% Fe) in sand creates problems in the manufacture of high quality glass. Removal by hot sulphuric acid is possible, but creates environmental problems, and is costly. Hence organic acids such as oxalic have been investigated since they are effective in removing iron, and can be degraded anaerobically. The aim of this work was to identify key intermediates in the anaerobic degradation of oxalate in an upflow anaerobic sludge blanket reactor (UASB) which was removing iron from solution in the sulphide form, and to determine the bacterial species involved. 2-bromoethanesulfonic acid (BES) and molybdenum were selected as suitable inhibitors for methanogenic and sulphate reducing bacteria (SRB) respectively. 40mM molybdenum was used to inhibit the SRB in a reactor with a 12hr HRT. Total SRB inhibition took place in 20 hrs, with a complete breakthrough of influent sulphate. The lack of an immediate oxalate breakthrough confirmed Desulfovibrio vulgaris subspecies oxamicus was not the predominant oxalate utilising species. Nevertheless, high concentrations of molybdenum were found to inhibit oxalate utilising bacteria in granular reactors but not in suspended population reactors; this observation was puzzling, and at present cannot be explained. Based on the intermediates identified, it was postulated that oxalate was degraded to formate by an oxalate utilising bacteria such as Oxalobacter formigenes, and the formate used by the SRBs to reduce sulphate. Acetate, as a minor intermediate, existed primarily as a source of cell carbon for oxalate utilising bacteria. Methanogenic inhibition identified that 62% of the CH4 in the reactor operated at 37°C originated from hydrogenotrophic methanogenesis, whilst this figure was 80% at 20°C. Possible irreversible effects were recorded with hydrogenotrophic methanogens.

scholarly journals Bioenergy recovery from cattle wastewater in an UASB-AF hybrid reactor

2017 ◽  
Vol 76 (9) ◽  
pp. 2268-2279 ◽  
Author(s):  
Henrique Vieira de Mendonça ◽  
Jean Pierre Henry Balbaud Ometto ◽  
Marcelo Henrique Otenio ◽  
Alberto José Delgado dos Reis ◽  
Isabel Paula Ramos Marques
Keyword(s):  
Biogas Production ◽  
Upflow Anaerobic Sludge Blanket ◽  
Hybrid Reactor ◽  
Anaerobic Sludge ◽  
The Novel ◽  
Organic Loading ◽  
Loading Rates ◽  
Volatile Solids ◽  
Anaerobic Sludge Blanket

Abstract New data on biogas production and treatment of cattle wastewater were registered using an upflow anaerobic sludge blanket-anaerobic filter (UASB-AF) hybrid reactor under mesophilic temperature conditions (37 °C). The reactor was operated in semi-continuous mode with hydraulic retention times of 6, 5, 3 and 2 days and organic loading rates of 3.8, 4.6, 7.0 and 10.8 kg CODt m−3 d−1. Biogas volumes of 0.6–0.8 m3 m−3 d−1 (3.8–4.6 kg CODt m−3 d−1) and 1.2–1.4 m3 m−3 d−1 (7.0–10.8 kg CODt m−3 d−1), with methane concentrations between 69 and 75%, were attained. The removal of organic matter with values of 60–81% (CODt) and 51–75% (CODs) allowed methane yields of 0.155–0.183 m3 CH4 kg−1 CODt and 0.401–0.513 m3 CH4 kg−1 CODs to be obtained. Volatile solids were removed in 34 to 69%, with corresponding methane yields of 0.27 to 0.42 m3 CH4 kg−1 VSremoved. The good performance of the novel hybrid reactor was demonstrated by biogas outputs higher than reported previously in the literature, along with the quality of the gas obtained in the various experimental phases. The hybrid reactor investigated in this study presents comparative advantages, particularly in relation to conventional complete mixture units, considering economic factors such as energy consumption, reactor volume and installation area.

Sign in / Sign up

Export Citation Format

Share Document