Flow Behavior and Microstructural Evolution of a 7039 Aluminum Alloy during Hot Deformation

2011 ◽  
Vol 239-242 ◽  
pp. 2395-2398 ◽  
Author(s):  
Hui Zhong Li ◽  
Xiao Peng Liang ◽  
Min Song ◽  
Min Zeng

The flow behavior of a 7039 aluminum alloy and the corresponding microstructural evolution during hot deformation were studied by Gleeble-1500 thermal simulation tests, EBSD and TEM observations with temperatures ranging from 300 °C to 500 °C under strain rates from 0.01 s-1 to 10 s-1. It has been shown that the flow stress increases with the decrease in the deformation temperature and increase in the strain rate. The degree of dynamic recrystallization (DRX) increases with the increase in the deformation temperature and strain rate in 7039 aluminum alloy. The complete dynamic recrystallization occurs at 500 °C with a strain rate of 10 s-1.

2020 ◽  
Vol 2020 ◽  
pp. 1-14
Author(s):  
Qiang Fu ◽  
Wuhua Yuan ◽  
Wei Xiang

In the present work, the hot deformation behavior of TB18 titanium alloy was investigated by isothermal hot compression tests with temperatures from 650 to 880°C and strain rates from 0.001 to 10 s−1. The flow curves after friction and temperature correction show that the peak stress decreased with the temperature increase and the strain rate decrease. Three typical characteristics of flow behavior indicate the dynamic softening behavior during hot deformation. At a strain rate of 0.001∼0.01 s−1, the flow stress continues to decrease as the strain rate increases after the flow stress reaches the peak stress; the flow softening mechanism is dynamic recovery and dynamic recrystallization at a lower temperature and dynamic recrystallization at a higher temperature. The discontinuous yielding phenomenon could be seen at a strain rate of 1 s−1, dynamic recrystallization took place in the β single-phase zone, and flow localization bands were observed in the α + β two-phase zone. At a higher strain rate of 10 s−1, the flow instabilities were referred to as the occurrence of flow localization by adiabatic heat. Constitutive equation considering the compensation of strain was also established, and the results show high accuracy to predict the flow stress with the correlation coefficient of 99.2% and the AARE of 6.1%, respectively.


2016 ◽  
Vol 684 ◽  
pp. 35-41 ◽  
Author(s):  
S.V. Rushchits ◽  
E.V. Aryshensky ◽  
S.M. Sosedkov ◽  
A.M. Akhmed'yanov

The deformation behavior of 1565ch alloy under the plane-strain conditions in the temperature range of 350–490 оС and strain rates range of 0,1–10 s-1 is studied. The expression for steady flow stress as the functions of temperature of deformation and strain rate is obtained. It is established that 1565ch alloy with zirconium addition shows higher strain resistance and less tendency to dynamic and static recrystallization than AMg6.


2016 ◽  
Vol 877 ◽  
pp. 575-580
Author(s):  
Li Zhen Yan ◽  
Yong An Zhang ◽  
Bai Qing Xiong ◽  
Zhi Hui Li ◽  
Xi Wu Li ◽  
...  

The hot deformation behavior of an Al-0.92Mg-0.78Si-0.20Cu-0.60Zn alloy was studied by isothermal compression in the temperature range from 350 to 500 oC with strain rates of 0.01-10s-1 on Gleeble-1500 thermo-mechanical simulator. The microstructural evolution during hot deformation was investigated by electron back-scatter diffraction (EBSD). The results show that the strain rate and deformation temperature have significant influence on flow behavior, and the flow stress increases with increasing strain rate and decreasing deformation temperature. Processing map at the strain of 0.7 is obtained and exhibits three peak efficiency domains (380-420 oC at 0.01s-1, 480-500 oC at 0.01s-1 and 450-500 oC at 0.1-0.32s-1). According to the processing map and microstructure observation, the optimized processing condition of hot deformation for the alloy is at 450-500 oC and strain rate of 0.1-0.32s-1. The homogenized ingot is hot rolled at 480 oC with a strain rate of 0.1s-1 based on optimized deformation parameters. The fraction of high-angle grain boundary is 35.2%, which is in accord with microstructure after hot deformed at 500 oC with a strain rate of 0.1s-1.


2017 ◽  
Vol 898 ◽  
pp. 137-143
Author(s):  
Lin Xiang ◽  
Bin Tang ◽  
Hong Chao Kou ◽  
Jie Shao ◽  
Jin Shan Li

Isothermal compression tests were conducted to investigate the effect of hot deformation parameters on flow behavior and microstructure of Ti-6Al-4V-0.2O alloy. The experimental results show that the strain rate and height reduction have little effect on the volume fraction of primary α at a deformation temperature of 860 ̊C. At a deformation temperature of 940 ̊C, the volume fraction of primary α at a high strain rate (10s-1) is about 10% less than that at low strain rates (0.01s-1~1s-1). It may be one of the reasons for the significantly discontinuous yielding phenomenon. Another reason is that the dislocation density decreased suddenly due to the dynamic recovery. With the increasing strain rate and the decreasing deformation temperature, the volume fraction of irregular secondary α increases and lamellar secondary α decreases. And with height reduction increasing, the irregular secondary α increases firstly and then tends to be steady because of dynamic recovery and recrystallization.


2018 ◽  
Vol 777 ◽  
pp. 402-407
Author(s):  
Gui Qing Chen ◽  
Gao Sheng Fu ◽  
Xiao Dong Lin ◽  
Jun De Wang ◽  
Chao Zeng Cheng ◽  
...  

3003 aluminum melt was treated with efficient purification, and it was deformed by isothermal compression in the range of deformation temperature 300-500 °C at strain rate 0.0l-10.0 s-1 with Gleeble-1500 thermal simulator. The results show that efficient purification treatment can significantly reduce the impurities, and make inclusion size smaller, uniform distribution. Room temperature mechanical properties were significantly improved. At the same strain rate, the flow stress of 3003 aluminum alloy decreases with the increase of deformation temperature. The flow stress increases with the increase of strain rate under the same deformation temperature. Two kinds of 3003 aluminum alloys with different purification treatments both have dynamic recrystallization characteristics. Especially when the strain rate reaches 10.0 s-1, the rheological curve appears sawtooth fluctuation and the alloy may have discontinuous dynamic recrystallization.


2007 ◽  
Vol 546-549 ◽  
pp. 749-754 ◽  
Author(s):  
Hui Zhong Li ◽  
Xin Ming Zhang ◽  
Min Gan Chen ◽  
Ying Liu ◽  
Hui Gao

The deformation behavior of 2519 aluminum alloy was studied by isothermal compression by Gleeble-1500 simulator in the temperature range from 300 to 450°C under the strain rates of 0.01~10s-1. The results showed that the flow stress was controlled by strain rate and deformation temperature. The flow stress increased with strain rate and decreased with deformation temperature. The flow stress of 2519 aluminum alloy increased with strain and to the constant values at three strain rates of 0.01 s-1,0.1 s-1and1 s-1, indicating the dynamic recovery to occur. The flow stress decreased after a peak value with increase of strain at strain rate 10s-1 and deformation temperature higher than 350°C, showing partly dynamic recrystallization. The flow stress of 2519 aluminum alloy during high temperature deformation can be represented by Zener-Hollomon parameter.


2015 ◽  
Vol 816 ◽  
pp. 810-817
Author(s):  
Yong Biao Yang ◽  
Zhi Min Zhang ◽  
Xing Zhang

The hot deformation behaviors of Aluminum alloy C919 were studied in the present investigation. The hot compression tests for C919 were carried out in the temperature range of 350°C~470°C and strain rates range of 0.001s-1~1s-1 using GLEEBLE-1500 thermal simulate testing machine. Optical microscopy (OM) was used for the microstructure characterization. The experimental results showed that the flow stress of C919 aluminum alloy decreased with increasing temperature and decreasing strain rates and the flow stress curves tended to increase at a strain rate of 1s-1 with increasing strain, while the flow stresses kept with increasing strain at lower strain rate. The alloys were more prone to dynamic recrystallization with decreasing strain rates during hot deformation. The hot compression behavior of C919 aluminum alloy can be described as hyperbolic sine function corrected Arrhenius relation. The processing maps for the alloy were built at a strain of 0.6. The instability deformation domain occurred at temperatures range from 350°C and 380°C and at a strain rate of 0.1-1s-1. Based on the processing maps and microstructure observations, the optimum hot-working parameters were determined to be at a temperature of 470°C in the strain rate range from 0.1-0.01s−1 for the C919 aluminum alloy.


2013 ◽  
Vol 712-715 ◽  
pp. 658-661 ◽  
Author(s):  
Dong Xu Wen ◽  
Y.C. Lin ◽  
Ming Song Chen

In order to study the workability and optimize hot forming processing parameters for GH4169 superalloy, the hot deformation behaviors are investigated. The results show that the flow stress strongly depends on the strain rate, deformation temperature and strain. With the increase of strain rates and the decrease of deformation temperature, the flow stress increases. The flow stress exhibits an initial increase with the strain until a peak stress value, showing a obvious work hardening. After the peak stress, increasing strain results in the decrease of stress, indicating a dynamic flow softening. A revised constitutive equation incorporating the effects of temperature, strain rate and work-hardening rate of the material is established by compensation of strain. A good agreement between the measured and predicted results shows that the established model can give an accurate prediction of the flow behavior of GH4169 superalloy.


Author(s):  
B. F. Luan ◽  
R. S. Qiu ◽  
Z. Zhou ◽  
K. L. Murty ◽  
J. Zhou ◽  
...  

Hot deformation characteristics of forged and β-quenched Zr-1.0Sn-0.3Nb-0.3Fe-0.1Cr (N18 alloy) in the temperature range 625–950°C and in the strain rate range 0.005–5 s−1 have been studied by uniaxial compression testing of Gleeble 3500. For this study, the approach of processing maps has been adopted and their interpretation done using the Dynamic Materials Model (DMM). Based on a series of true stress-true strain curves on various temperatures and strain rates, the flow stress has been summarized and both the strain rate sensitivity index (m) and deformation activation energy (Q) have been calculated by the constitutive equations that flow stress and the relationship of Z parameter and flow stress have been established subsequently. Furthermore, the efficiency of power dissipation (⬜) given by [2m/(m+1)] and improved by Murty has been plotted as a function of temperature and strain rate to obtain different processing maps at different true strain rates ranging from 0.1–0.7. Subsequently, the microstructures of the specimens after compression testing were characterized by electron channeling contrast (ECC) imaging techniques used an FEI Nova 400 field emission gun scanning electron microscopy (FEG-SEM). The results showed that: (i) The hyperbolic sine constitutive equation can describe the flow stress behavior of zirconium alloy, and the deformation activation energy and flow stress equation were calculated under the different temperature stages which insists that the deformation mechanism is not dynamic recovery. (ii) The hot processing maps and its validation were analyzed, which indicated that the DMM theory was reliable and could be adopted as useful tool for optimizing hot workability of Zr. The optimum parameters for extrusion and hammer forging were revealed on the processing maps of 830–950°C, 0.048–2.141 s−1 and 916–950°C, 2.465–5 s−1. (iii) The microstructure of the ingot exhibits a typical lamellar Widmanstatten structure. Under the different strain rates, the grains formed by dynamic recrystallization existed normally in the central zone of the compression samples while the no uniformity of grain size increased with the increasing of strain rate. Meanwhile, due to the dynamic recrystallization as a thermal activation process, the grains size and uniformity increased with the increasing of temperature. In brief, microstructure analysis showed that continuous dynamic recrystallization and geometric dynamic recrystallization operated concurrently during the isothermal compressive deformation.


Metals ◽  
2020 ◽  
Vol 10 (6) ◽  
pp. 782 ◽  
Author(s):  
Qiang Liang ◽  
Xin Liu ◽  
Ping Li ◽  
Xianming Zhang

The flow behavior of a new kind of high-strength nickel brass used as automobile synchronizer rings was investigated by hot compression tests with a Gleeble-3500 isothermal simulator at strain rates ranging from 0.01 to 10 s−1 and a wide deformation temperature range of 873–1073K at intervals of 50 K. The experimental results show that flow stress increases with increasing strain rate and decreasing deformation temperature, and discontinuous yielding appeared in the flow stress curves at higher strain rates. A modified Arrhenius constitutive model considering the compensation of strain was established to describe the flow behavior of this alloy. A processing map was also constructed with strain of 0.3, 0.6, and 0.9 based on the obtained experimental flow stress–strain data. In addition, the optical microstructure evolution and its connection with the processing map of compressed specimens are discussed. The predominant deformation mechanism of Cu-Ni-Al brass is dynamic recovery when the deformation temperature is lower than 973 K and dynamic recrystallization when the deformation temperature is higher than 973 K according to optical observation. The processing map provides the optimal hot working temperature and strain rate, which is beneficial in choosing technical parameters for this high-strength alloy.


Sign in / Sign up

Export Citation Format

Share Document