Comparison of Antimicrobial Treatments Applied via Conventional or Handheld Electrostatic Spray To Reduce Shiga Toxin–Producing Escherichia coli on Chilled Beef Outside Rounds

2019 ◽  
Vol 82 (5) ◽  
pp. 862-868
Author(s):  
JESSICA C. HUDSON ◽  
TAMRA N. TOLEN ◽  
KATIE R. KIRSCH ◽  
GARY ACUFF ◽  
T. MATTHEW TAYLOR ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Shiga Toxin ◽  
Peracetic Acid ◽  
Tap Water ◽  
Cetylpyridinium Chloride ◽  
Tissue Samples ◽  
Significant Difference ◽  
Antimicrobial Interventions ◽  
Antimicrobial Treatments ◽  
Electrostatic Spray

ABSTRACT The purpose of this study was to compare the efficacy of different antimicrobial interventions applied via either conventional spray (CS) or handheld electrostatic spray (ESS) to reduce Shiga toxin–producing Escherichia coli (STEC) on fresh beef surfaces. Hot-boned outside rounds (ORs) were inoculated within 1 h after harvest with a cocktail of eight isolates consisting of 8 O157 and non-O157 serogroups of STEC (STEC8). ORs were hung on sterile meat hooks at 4°C for 36 h to simulate a contaminated full carcass side in the chiller. ORs were then treated with lactic acid (LA; 4.5%, w/v), 3.0% lauric arginate ester (LAE), 0.8% cetylpyridinium chloride, 200 mg/L peracetic acid, 3 mg/L chlorine dioxide, 5 mg/L ClO2, or tap water by using CS or ESS. Temperatures of LA and peracetic acid were set at 55 and 42°C before spraying, whereas all other solutions were applied at room temperature (25°C). Pretreatment and posttreatment STEC8-inoculated beef tissue samples were aseptically collected to evaluate the efficacy of interventions by application method (CS or ESS). LA applied with CS achieved the greatest reduction in STEC8 numbers (3.3 log CFU/cm2) compared with all other treatments: 0.2 log CFU/cm2 (tap water) to 2.3 log CFU/cm2 (LAE). Only for LA did a significant difference arise in mean STEC8 reductions between CS and ESS applications (3.2 versus 1.7 log CFU/cm2, respectively). Among the treatments applied with ESS, LAE produced the greatest reduction of STEC8. Antimicrobial interventions applied via conventional wand or cabinet-applied technologies can reduce the O157 and non-O157 STEC on fresh beef carcass surfaces, reducing transmission to beef consumers. HIGHLIGHTS

Validation of commonly used antimicrobial interventions on bob veal carcasses for reducing Shiga toxin producing Escherichia coli surrogate populations

2021 ◽  
Author(s):  
Chevise L. Thomas ◽  
Harshavardhan Thippareddi ◽  
Sanjay Kumar ◽  
Macc Rigdon ◽  
Robert W. Mckee ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Lactic Acid ◽  
Shiga Toxin ◽  
Hot Water ◽  
Peroxyacetic Acid ◽  
E Coli ◽  
Translocation Experiment ◽  
Low Levels ◽  
Antimicrobial Interventions ◽  
Antimicrobial Treatments

Ruminants are natural reservoirs of Shiga toxin producing Escherichia coli (STEC), and the STEC can be easily transferred to carcasses during the conversion of animals to meat. Three experiments were conducted to validate the efficacy of lactic acid (4%; LA), peroxyacetic acid (300 ppm; PAA), and hot water (80˚C; HW) for their individual or combined abilities to reduce STEC surrogates on bob veal carcasses pre- and post-chill and through fabrication. In experiment 1, hot carcasses (n=9) were inoculated with a 5-strain cocktail (ca. 8 log CFU/mL) containing rifampicin-resistant surrogate Escherichia coli ( E. coli ; BAA-1427, BAA-1428, BAA-1429, BAA-1430, and BAA-1431) and then treated with HW, LA, or PAA. Carcasses were then chilled (0±1°C; 24 h), split in half, and each side was treated with either LA or PAA. In experiment 2, hot carcasses (n=3) were inoculated and chilled (24 h). After 24 h, the carcasses were split, and each side was treated with either LA or PAA. For experiment 3, carcasses (n=3) were chilled for 24 h, split, inoculated, and treated with either LA or PAA. After chilling, carcasses from all three experiments were fabricated to subprimals and the cut surfaces were sampled to determine the translocation. Experiment 1 showed that LA+LA was the most effective ( P ≤ 0.05) treatment for reducing surrogate E. coli on veal. In experiments 2 and 3, LA and PAA were similar ( P > 0.05) in their abilities to reduce E. coli on chilled veal carcasses. In experiments 1 and 2, all antimicrobial treatments resulted in undetectable levels (< 0.2 log CFU/cm 2 ) of surrogate E. coli on cut surfaces after fabrication, while low levels (1.7 and 1.0 log CFU/cm 2 for LA and PAA, respectively) were observed in experiment 3. Of the antimicrobial interventions utilized, lactic acid was more effective for reducing STEC surrogate populations on veal carcasses, pre- and/or post-chill.

Antimicrobial Interventions for O157:H7 and Non-O157 Shiga Toxin–Producing Escherichia coli on Beef Subprimal and Mechanically Tenderized Steaks

2015 ◽  
Vol 78 (3) ◽  
pp. 511-517 ◽  
Author(s):  
YEN-TE LIAO ◽  
J. CHANCE BROOKS ◽  
JENNIFER N. MARTIN ◽  
ALEJANDRO ECHEVERRY ◽  
GUY H. LONERAGAN ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Shiga Toxin ◽  
E Coli ◽  
Intervention Treatment ◽  
Hypobromous Acid ◽  
Emerging Risk ◽  
Antimicrobial Interventions ◽  
High Level ◽  
Antimicrobial Treatments ◽  
Vacuum Storage

Non-O157 Shiga toxin–producing Escherichia coli (STEC) is an emerging risk for food safety. Although numerous postharvest antimicrobial interventions have been effectively used to control E. coli O157:H7 during beef harvesting, research regarding their effectiveness against non-O157 STEC is scarce. The objectives of this study were (i) to evaluate effects of the spray treatments—ambient water, 5% lactic acid (LA), 200 ppm of hypobromous acid (HA), and 200 ppm of peroxyacetic acid (PA)—on the reduction of O157:H7 or non-O157 STEC (O26, O103, O111, and O145) with high (106 log CFU/50 cm2) or low (102 log CFU/50 cm2) levels on beef subprimals after vacuum storage for 14 days and (ii) to evaluate the association of the antimicrobial treatments and cooking (50 or 70°C) on the reduction of the pathogens in blade-tenderized steaks. The treatment effects were only observed (P = 0.012) on samples taken immediately after spray intervention treatment following inoculation with a high level of O157:H7. The LA and PA treatments significantly reduced low-inoculated non-O157 STEC after spray intervention; further, the LA and HA treatments resulted in significant reductions of non-O157 STEC on the low-inoculated samples after storage. Although cooking effectively reduced the detection of pathogens in internal steak samples, internalized E. coli O157:H7 and non-O157 STEC were able to survive in steaks cooked to a medium degree of doneness (70°C). This study indicated that the reduction on surface populations was not sufficient enough to eliminate the pathogen's detection following vacuum storage, mechanical tenderization, and cooking. Nevertheless, the findings of this study emphasize the necessity for a multihurdle approach and further investigations of factors that may influence thermal tolerance of internalized pathogenic STEC.

scholarly journals Effect of Exposure Time and Organic Matter on Efficacy of Antimicrobial Compounds against Shiga Toxin–Producing Escherichia coli and Salmonella

2016 ◽  
Vol 79 (4) ◽  
pp. 561-568 ◽  
Author(s):  
NORASAK KALCHAYANAND ◽  
MOHAMMAD KOOHMARAIE ◽  
TOMMY L. WHEELER
Keyword(s):  
Escherichia Coli ◽  
Organic Matter ◽  
Lactic Acid ◽  
Exposure Time ◽  
Shiga Toxin ◽  
Peracetic Acid ◽  
Antimicrobial Compounds ◽  
Number Of Factors ◽  
Hypobromous Acid ◽  
Processing Plants

ABSTRACT Several antimicrobial compounds are in commercial meat processing plants for pathogen control on beef carcasses. However, the efficacy of the method used is influenced by a number of factors, such as spray pressure, temperature, type of chemical and concentration, exposure time, method of application, equipment design, and the stage in the process that the method is applied. The objective of this study was to evaluate effectiveness of time of exposure of various antimicrobial compounds against nine strains of Shiga toxin–producing Escherichia coli (STEC) and four strains of Salmonella in aqueous antimicrobial solutions with and without organic matter. Non-O157 STEC, STEC O157:H7, and Salmonella were exposed to the following aqueous antimicrobial solutions with or without beef purge for 15, 30, 60, 120, 300, 600, and 1,800 s: (i) 2.5% lactic acid, (ii) 4.0% lactic acid, (iii) 2.5% Beefxide, (iv) 1% Aftec 3000, (v) 200 ppm of peracetic acid, (vi) 300 ppm of hypobromous acid, and (vii) water as a control. In general, increasing exposure time to antimicrobial compounds significantly (P ≤ 0.05) increased the effectiveness against pathogens tested. In aqueous antimicrobial solutions without organic matter, both peracetic acid and hypobromous acid were the most effective in inactivating populations of STEC and Salmonella, providing at least 5.0-log reductions with exposure for 15 s. However, in antimicrobials containing organic matter, 4.0% lactic acid was the most effective compound in reducing levels of STEC and Salmonella, providing 2- to 3-log reductions with exposure for 15 s. The results of this study indicated that organic matter and exposure time influenced the efficacy of antimicrobial compounds against pathogens, especially with oxidizer compounds. These factors should be considered when choosing an antimicrobial compound for an intervention.

Simultaneous Enrichment of Shiga Toxin–Producing Escherichia coli O157 and O26 and Salmonella in Food Samples Using Universal Preenrichment Broth

2009 ◽  
Vol 72 (10) ◽  
pp. 2065-2070 ◽  
Author(s):  
MASASHI KANKI ◽  
KAZUKO SETO ◽  
JUNKO SAKATA ◽  
TETSUYA HARADA ◽  
YUKO KUMEDA
Keyword(s):  
Escherichia Coli ◽  
Shiga Toxin ◽  
Food Samples ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Significant Difference ◽  
Peptone Water ◽  
Radish Sprouts ◽  
Pork Samples ◽  
Better Than

Universal preenrichment broth (UPB) was compared with modified Escherichia coli broth with novobiocin (mEC+n) for enrichment of Shiga toxin–producing E. coli O157 and O26, and with buffered peptone water (BPW) for preenrichment of Salmonella enterica. Ten strains each of the three pathogens were inoculated into beef and radish sprouts following thermal, freezing, or no treatment. With regard to O157 and O26, UPB incubated at 42°C recovered significantly more cells from inoculated beef than UPB at 35°C and from radish sprout samples than UPB at 35°C and mEC+n. With regard to Salmonella, UPB incubated at 42°C was as effective as UPB at 35°C and BPW at recovering cells from beef and radish sprout samples. No significant difference was noted between the effectiveness of UPB at 42°C and UPB at 35°C or BPW in the recovery of Salmonella from 205 naturally contaminated poultry samples. By using UPB at 42°C, one O157:H7 strain was isolated from the mixed offal of 53 beef samples, 6 cattle offal samples, and 50 pork samples all contaminated naturally, with no pathogen inoculation. The present study found that UPB incubated at 42°C was as effective as, or better than, mEC+n for enrichment of O157 and O26 and comparable to BPW for preenrichment of Salmonella. These findings suggest that a great deal of labor, time, samples, and space may be saved if O157, O26, and Salmonella are enriched simultaneously with UPB at 42°C.

Food as a Vehicle for Transmission of Shiga Toxin–Producing Escherichia coli

2007 ◽  
Vol 70 (10) ◽  
pp. 2426-2449 ◽  
Author(s):  
MARILYN C. ERICKSON ◽  
MICHAEL P. DOYLE
Keyword(s):  
Escherichia Coli ◽  
Shiga Toxin ◽  
Cetylpyridinium Chloride ◽  
The United States ◽  
Influential Factors ◽  
Sodium Chlorite ◽  
Processing Plant ◽  
E Coli ◽  
Wide Range ◽  
Alfalfa Sprouts

Contaminated food continues to be the principal vehicle for transmission of Escherichia coli O157:H7 and other Shiga toxin–producing E. coli (STEC) to humans. A large number of foods, including those associated with outbreaks (alfalfa sprouts, fresh produce, beef, and unpasteurized juices), have been the focus of intensive research studies in the past few years (2003 to 2006) to assess the prevalence and identify effective intervention and inactivation treatments for these pathogens. Recent analyses of retail foods in the United States revealed E. coli O157:H7 was present in 1.5% of alfalfa sprouts and 0.17% of ground beef but not in some other foods examined. Differences in virulence patterns (presence of both stx1 and stx2 genes versus one stx gene) have been observed among isolates from beef samples obtained at the processing plant compared with retail outlets. Research has continued to examine survival and growth of STEC in foods, with several models being developed to predict the behavior of the pathogen under a wide range of environmental conditions. In an effort to develop effective strategies to minimize contamination, several influential factors are being addressed, including elucidating the underlying mechanism for attachment and penetration of STEC into foods and determining the role of handling practices and processing operations on cross-contamination between foods. Reports of some alternative nonthermal processing treatments (high pressure, pulsed-electric field, ionizing radiation, UV radiation, and ultrasound) indicate potential for inactivating STEC with minimal alteration to sensory and nutrient characteristics. Antimicrobials (e.g., organic acids, oxidizing agents, cetylpyridinium chloride, bacteriocins, acidified sodium chlorite, natural extracts) have varying degrees of efficacy as preservatives or sanitizing agents on produce, meat, and unpasteurized juices. Multiple-hurdle or sequential intervention treatments have the greatest potential to minimize transmission of STEC in foods.

Validation of a Sequential Hide-On Bob Veal Carcass Antimicrobial Intervention Composed of a Hot Water Wash and Lactic Acid Spray in Combination with Scalding To Control Shiga Toxin–Producing Escherichia coli Surrogates†

2018 ◽  
Vol 81 (5) ◽  
pp. 762-768
Author(s):  
JOSHUA D. HASTY ◽  
JOHN A. HENSON ◽  
GARY R. ACUFF ◽  
DENNIS E. BURSON ◽  
JOHN B. LUCHANSKY ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Lactic Acid ◽  
Ambient Temperature ◽  
Shiga Toxin ◽  
Hot Water ◽  
E Coli ◽  
Chemical Agents ◽  
Antimicrobial Interventions ◽  
Antimicrobial Intervention ◽  
Additional Reduction

ABSTRACT Scalding of hide-on bob veal carcasses with or without standard scalding chemical agents typically used for hogs, followed by an 82.2°C hot water wash and lactic acid spray (applied at ambient temperature) before chilling, was evaluated to determine its effectiveness in reducing Shiga toxin–producing Escherichia coli surrogate populations. A five-strain cocktail of rifampin-resistant, nonpathogenic E. coli surrogates was used to inoculate hides of veal carcasses immediately after exsanguination (target inoculation level of 7.0 log CFU/100 cm2). For carcasses receiving no scalding treatments, spraying with 82.2°C water as a final wash resulted in a 4.5-log CFU/100 cm2 surrogate reduction, and an additional 1.2-log CFU/100 cm2 reduction was achieved by spraying with 4.5% lactic acid before chilling. Scalding hide-on carcasses in 60°C water (no chemicals added) for 4 min in a traditional hog scalding tank resulted in a 2.1-log CFU/100 cm2 reduction in surrogate levels, and a subsequent preevisceration 82.2°C water wash provided an additional 2.9-log CFU/100 cm2 reduction. Spraying a 4.5% solution of lactic acid onto scalded, hide-on carcasses (after the 82.2°C water wash) resulted in a minimal additional reduction of 0.4 log CFU/100 cm2. Incorporation of scalding chemicals into the scald water resulted in a 4.1-log CFU/100 cm2 reduction (1.9 log CFU/100 cm2 greater than scalding without chemicals) in the surrogate population, and the first 82.2°C wash provided an additional 2.5-log CFU/100 cm2 reduction. Application of antimicrobial interventions did not affect the carcass temperature decline during chilling, the pH decline, or the color characteristics of the ribeye or the flank of the bob veal carcasses.

Improving the Enrichment and Plating Methods for Rapid Detection of Non-O157 Shiga Toxin–Producing Escherichia coli in Dairy Compost

2016 ◽  
Vol 79 (3) ◽  
pp. 413-420 ◽  
Author(s):  
HONGYE WANG ◽  
ZHAO CHEN ◽  
XIUPING JIANG
Keyword(s):  
Escherichia Coli ◽  
Shiga Toxin ◽  
Cell Concentration ◽  
Culture Method ◽  
Single Step ◽  
Potassium Tellurite ◽  
Selective Enrichment ◽  
Immunomagnetic Bead ◽  
Significant Difference ◽  
Low Levels

ABSTRACT A culture method to detect non-O157 Shiga toxin–producing Escherichia coli (STEC) was optimized in this study. The finished dairy compost with 30% moisture content was inoculated with a cocktail of six non-O157 STEC serovars at initial concentrations of 1 to 100 CFU/g. Afterward, non-O157 STEC cells in the inoculated dairy compost were enriched by four methods, followed by plating onto cefixime-tellurite sorbitol MacConkey agar supplemented with 5 mg/liter novobiocin (CTN-SMAC) and modified Rainbow agar containing 5 mg/liter novobiocin, 0.05 mg/liter cefixime trihydrate, and 0.15 mg/liter potassium tellurite (mRBA). Immunomagnetic bead separation (IMS) was used to compare the cell concentration of individual non-O157 STEC serotypes after enrichment. There was no significant difference (P > 0.05) between CTN-SMAC and mRBA for non-O157 STEC enumeration. The single-step selective enrichment recovered ca. 0.54 log CFU/g more cells (ca. 0.41 log CFU/g for compost-adapted cells) (P < 0.05) compared with the two-step enrichment. Furthermore, the duration of the process to detect non-O157 STEC from dairy compost by selective enrichment, followed by IMS, was optimized. Among six non-O157 STEC serotypes, serotypes O111, O45, and O145 reached the highest cell density after enrichment in dairy compost, and the cell populations reached 7.3, 7.4, and 7.8 log CFU/g within 16 h of incubation, respectively. In contrast, without an enrichment step, the IMS detection limit of individual non-O157 STEC serovars ranged from 3.15 to 4.15 log CFU/g in dairy compost. These results demonstrate that low levels of non-O157 STEC can be detected within 2 days from dairy compost by using a culture method with an optimized enrichment procedure followed by IMS.

Sign in / Sign up

Export Citation Format

Share Document