Anaerobic Digestion of Animal Manure and Influence of Organic Loading Rate and Temperature on Process Performance, Microbiology, and Methane Emission From Digestates

Biogas production from manure is of particular value in regard of lowering greenhouse gas emissions and enhancing nutrient re-circulation. However, the relatively low energy content and the characteristics of manure often result in low degradation efficiency, and the development of operating strategies is required to improve the biogas yield and the economic benefits. In this study, the potential to enhance the performance of two full-scale biogas plants operating with cattle manure, in mono-digestion or combined with poultry manure, was investigated. Four continuously fed laboratory-scale reactors were operated in sets of two, in which the temperature in one reactor in each set was increased from 37–42°C to 52°C. The potential to increase the capacity was thereafter assessed by increasing the organic loading rate (OLR), from ca 3 to 5 kg volatile solids (VS)/ m3 and day. The processes were evaluated with both chemical and microbiological parameters, and in addition, the residual methane potential (RMP) was measured to evaluate the risk of increased methane emissions from the digestate. The results showed that both processes could be changed from mesophilic to themophilic temperature without major problems and with a similar shift in the microbial community profile to a typical thermophilic community, e.g., an increase in the relative abundance of the phylum Firmicutes. However, the temperature increase in the reactor co-digesting cattle and poultry manure caused a slight accumulation of fatty acids (2 g/l) and reduced the specific methane production, most likely due to ammonia inhibition (0.4–0.7 g NH3/l). Still, during operation at higher OLR, thermophilic as compared to mesophilic temperature slightly increased the methane yield and specific methane production, in both investigated processes. However, the higher OLR decreased the overall degree of degradation in all processes, and this showed a positive correlation with increased RMP values. Chemical analyses suggested that high RMP values (40–98 Nml gVS−1) were related to the degradation of cellulose, hemicellulose, and volatile fatty acid enriched in the digestate. Conclusively, increased temperature and load can increase the methane yield from manure but can result in less efficient degradation and increased risks for methane emissions during storage and handling of the digestate.

Specific Methane Yield of Wetland Biomass in Dry and Wet Fermentation Technologies

Our study evaluated the specific methane yield (SMY) of selected wetland species subjected to wet and dry anaerobic digestion: Carex elata All. (CE), a mixture (~50/50) of Carex elata All. and Carex acutiformis L. (CA), Phragmites australis (Cav.) Trin. ex Steud. (PA), Typha latifolia L. (TL) and Phalaris arundinacea L. (PAr). Plants were harvested in late September, and therefore, the study material was characterised by high lignin content. The highest lignin content (36.40 ± 1.04% TS) was observed in TL, while the lowest (16.03 ± 1.54% TS) was found in CA. PAr was characterised by the highest hemicellulose content (37.55 ± 1.04% TS), while the lowest (19.22 ± 1.22% TS) was observed in TL. Cellulose content was comparable in almost all plant species studied and ranged from 25.32 ± 1.48% TS to 29.37 ± 0.87% TS, except in PAr (16.90 ± 1.29% TS). The methane production potential differed significantly among species and anaerobic digestion (AD) technologies. The lowest SMY was observed for CE (121 ± 28 NL kgVS−1) with dry fermentation (D–F) technology, while the SMY of CA was the highest for both technologies, 275 ± 3 NL kgVS–1 with wet fermentation (W–F) technology and 228 ± 1 NL kgVS–1 with D–F technology. The results revealed that paludi-biomass could be used as a substrate in both AD technologies; however, biogas production was more effective for W–F. Nonetheless, the higher methane content in the biogas and the lower energy consumption of technological processes for D–F suggest that the final amount of energy remains similar for both technologies. The yield is critical in energy production by the AD of wetland plants; therefore, a promising source of feedstock for biogas production could be biomass from rewetted and previously drained areas, which are usually more productive than natural habitats.

Biomethane Production from Anaerobic Co-Digestion of Selected Organic Fraction of Municipal Solid Waste (OFMSW) with Sewage Sludge: Effect of the Inoculum to Substrate Ratio (ISR) and Mixture Composition on Process Performances

The aim of this study was to evaluate the effect of the inoculum to substrate ratio (ISR) and the mixture ratio between organic fraction of municipal solid waste (OFMSW) and sewage sludge (SS) on the methane production potential achievable from anaerobic co-digestion (AcoD). Biochemical Methane Potential (BMP) assays at mesophilic temperature were used to determine the best AcoD configuration for maximizing methane yield and production rate, as well as to address possible synergistic effects. The maximum methane yield was observed at ISR of 1 and 60% OFMSW :40% SS as co-digestion mixture, whereas the highest methane production rate was achieved at ISR of 2 with the same mixture ratio (207 mL/gVS/d). Synergistic effects were highlighted in the mixtures having OFMSW below 60%, determining an increase of approximately 40% in methane production than the OFMSW and SS digestion as a sole substrate. The experimental data demonstrated that co-digestion of OFMSW and SS resulted in an increase in the productivity of methane than anaerobic digestion using the sole substrates, producing higher yields or production rates while depending on the ISR and the mixture ratio.

Coupling of Anaerobic Digestion and Struvite Precipitation in the Same Reactor: Effect of Zeolite and Bischofite as Mg2+ Source

The aim of this research was to assess the simultaneous effect of zeolite and bischofite on estruvite production in an anaerobic digester treating pig slurry as substrate. Three ratios (5:1, 6:1 and 7:1) of Mg-P were used for evaluating the effect of only bischofite on anaerobic digestion. For assessing the simultaneous effect of zeolite and bischofite on anaerobic digestion, three mass ratios of zeolite:bischofite (1, 5 and 10%) were used. As results, bischofite as Mg+2 source served to decrease the total phosphorous (TP) concentration in the anaerobic digestion of pig manure without affecting the maximum methane production rate or methane yield of the system. An average 82.5% TP removal was found in the reactors with bischofite during the first 5 days of digestion. Nevertheless, bischofite increased the lag-phase of the system. The simultaneous presence of zeolite and bischofite (1% ratio with respect to bischofite) caused a TP removal of 65.6% and increased the methane yield by up to 19.9% compared to a system without zeolite or bischofite. Thus, it is feasible to use bischofite and zeolite as enhancers for the simultaneous production of biogas and struvite inside an anaerobic digester treating piggery wastewater.

Anaerobic Co-digestion of Press mud and Molasses-based Distillery Wastewater for Enhanced Biogas Production

With goals in determining the effect of diluting the distillery wastewater (DWW) and of varying the amount of DWW and press mud (PM), anaerobic co-digestion study was carried out at mesophilic condition in a 2-L Erlenmeyer flask, with a working volume of 800 mL for Batch 1 and 1500 mL for Batch 2 experiments. For Batch 1, two different ratios of DWW and tap water, with 2:3 and 3:2, were used to assess the effect of dilution on the methane yield, where same volumetric amount of PM was added. For Batch 2, following ratio of PM and DWW were used: a) 1:0, b) 1:1, c) 1:1, d) 2:1, and e) 1:2. All samples had the same amount of inoculum, except that Batch 1 samples had bagasse. The parameters that were assessed after 42 days of digestion were: pH, COD, BOD, TSS, VS, Cu, Ca, Mg, Mn, TOC, TN, and methane yield. For the effect of dilution, a significant difference in the methane yield between samples with higher and lower dilution ratio was seen, and in the first batch, the optimal dilution ratio of DWW and H2O, with 3:2 gave higher methane yield of 78.23% (v/v). Meanwhile, optimal volumetric ratio of DWW and PM from the Batch 2 experiments, with value of 1:2, gave the highest methane yield of 79.43% (v/v).

Influence of the Preliminary Storage on Methane Yield of Anaerobic Digestion of the Organic Fraction of Municipal Solid Waste

Anaerobic digestion (AD) is a suitable management option for the energy valorization of many wastes, including the organic fraction of municipal solid waste (OFMSW). However, in some cases, long storage after the separate collection of this waste is required for management reasons, especially when the amount of waste to be treated temporarily exceeds the capacity of available AD plants. This study evaluates the biochemical methane potential (BMP) of the OFMSW after preliminary storage of 2, 6, and 10 days, in order to assess whether they are still suitable for AD or not. Moreover, the accuracy of three kinetic models (first order, Gompertz, and logistic models) in estimating the methane yield of stored OFMSW is tested. The resulting methane yield was between about 500 and 650 NmL·gVS−1 and slightly increased with the increase of the storage time after collection. Overall, this study has demonstrated that storage of OFMSW, when the collected amount of solid waste exceeds the treatment capacity of AD plants, a storage time up to 10 days does not impact the methane yield of the process.