Design and Testing of a Mini-Plant for Conversion of Organic Waste to Biogas

2011 ◽  
Vol 367 ◽  
pp. 537-544
Author(s):  
Patrick Ebunilo ◽  
David Otiede
Keyword(s):  
Anaerobic Digestion ◽  
Ambient Temperature ◽  
Conversion Efficiency ◽  
Organic Waste ◽  
Temperature Range ◽  
Design And Testing ◽  
Good Percentage ◽  
Blue Flame

An experimental organic waste to biogas conversion mini-plant that works by anaerobic digestion has been designed, fabricated and tested. The demonstration involved the use of primarily, a biodigester and few other components. The organic waste was made into slurry and digested anaerobically for 14 days at an ambient temperature range of 28 to 32°C. The flame of biogas generated burnt with smokeless blue flame, indicating the presence of a colourless odourless gas called methane. The biodigester achieved a conversion efficiency of 64 percent. This equipment can be used to meet a good percentage of the fuel needs in Nigeria.

The performance and microbial diversity of temperature-phased hyperthermophilic and thermophilic anaerobic digestion system fed with organic waste

2008 ◽  
Vol 57 (2) ◽  
pp. 283-289 ◽  
Author(s):  
M. Y. Lee ◽  
J. H. Cheon ◽  
T. Hidaka ◽  
H. Tsuno
Keyword(s):  
Anaerobic Digestion ◽  
Microbial Diversity ◽  
Conversion Efficiency ◽  
Methane Conversion ◽  
Organic Waste ◽  
Effect Of Temperature ◽  
High Concentration ◽  
Thermophilic Anaerobic Digestion ◽  
In Series ◽  
Increasing Temperature

The objective of this study was to evaluate the performances and microbial diversities for development of the effective hyperthermophilic digester system that consists of a hyperthermophilic reactor and hyperthermophilic or thermophilic reactor in series. Lab-scale reactors were operated continuously fed with artificial kitchen garbage. The effect of temperature on the acidification step was firstly investigated. Results indicated that 20.8% of COD solubilization was achieved at 70°C, with 12.6% at 80°C. The average protein solubilization reached 31% at 80°C. Methane conversion efficiency following the acidification was around 85% on average at 55°C, but decreased with increasing temperature and methane gas was not produced over 73°C. As well, bacteria affiliated with the methanogens dominated the population below 65°C, while those affiliated with acidogens were predominant over 73°C. These results indicated that the hyperthermophilic process has considerable benefits to treat wastewater or waste containing high concentration of protein.

Highly-efficient Anaerobic Digestion of Refractory Organic Waste Using Subcritical Water Hydrolysis as Pretreatment Process

2012 ◽  
Vol 48 (1) ◽  
pp. 23-27
Author(s):  
TOMONAO MIYASHIRO ◽  
QINGHONG WANG ◽  
YINGNAN YANG ◽  
KAZUYA SHIMIZU ◽  
NORIO SUGIURA ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Organic Waste ◽  
Subcritical Water ◽  
Highly Efficient ◽  
Water Hydrolysis ◽  
Subcritical Water Hydrolysis

Perspective Biomass Carrier for Anaerobic Processing Systems of Organic Waste AIC

2020 ◽  
Vol 67 (1) ◽  
pp. 148-155
Author(s):  
Anatoliy V. Fedotov ◽  
Viktor S. Grigoriev ◽  
Dmitriy A. Kovalev ◽  
Andrey A. Kovalev
Keyword(s):  
Wastewater Treatment ◽  
Anaerobic Digestion ◽  
Specific Surface ◽  
Organic Waste ◽  
Porous Ceramic ◽  
Experimental Studies ◽  
Ceramic Materials ◽  
Porous Ceramics ◽  
Developed Surface ◽  
Highly Porous

To speed up the wastewater treatment under aerobic conditions and to optimize the processes of anaerobic wastewater treatment in digesters, immobilization technologies of microorganisms and enzymes on solid carriers are used. Ceramic carriers based on aluminosilicates and alumina are one of the promising inorganic biomass carriers. (Research purpose) To study the structure of porous ceramic biomass carriers for anaerobic processing of organic waste and evaluate the prospects for their use. (Materials and methods) The substrate for anaerobic digestion was a mixture of sediments of the primary and secondary sewage sumps of the Lyubertsy treatment facilities. K-65 cattle feed was used to ensure the constancy of the composition of organic substances in substrates as a cosubstrate. The authors used the method of low-temperature nitrogen adsorption of Bruner-Emmett-Teller to study the pore structure and specific surface of solid carriers on a specific surface analyzer Quntachrome Autosorb-1. (Results and discussion) The main characteristics (specific surface, volume of micro- and mesopores, predominant pore radius, water absorption and others) of chamotte foam lightweight and highly porous corundum ceramics were determined. It was revealed that ceramic materials with a developed surface and electrically conductive material provided an increase in biogas yield by 3.8-3.9 percent with an increase in methane content by an average of 5 percent. (Conclusions) The results of anaerobic digestion showed a positive effect of both a conductive carrier and highly porous ceramic materials on the process of anaerobic bioconversion of organic waste into biogas. It is advisable to expand experimental studies on the use of a conductive carrier with a developed surface based on highly porous ceramics.

scholarly journals Biochar promotes methane production during anaerobic digestion of organic waste

2021 ◽  
Author(s):  
Leilei Xiao ◽  
Eric Lichtfouse ◽  
P. Senthil Kumar ◽  
Quan Wang ◽  
Fanghua Liu
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Organic Waste

scholarly journals Sugarcane Bagasse as a Co-Substrate with Oil-Refinery Biological Sludge for Biogas Production Using Batch Mesophilic Anaerobic Co-Digestion Technology: Effect of Carbon/Nitrogen Ratio

Water ◽  
2021 ◽  
Vol 13 (5) ◽  
pp. 590
Author(s):  
Aiban Abdulhakim Saeed Ghaleb ◽  
Shamsul Rahman Mohamed Kutty ◽  
Gasim Hayder Ahmed Salih ◽  
Ahmad Hussaini Jagaba ◽  
Azmatullah Noor ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Sugarcane Bagasse ◽  
Organic Waste ◽  
Wastewater Treatment Plants ◽  
Biogas Production ◽  
Raw Materials ◽  
Oil Refinery ◽  
Methane Yield ◽  
Oil Refineries ◽  
Biological Sludge

Man-made organic waste leads to the rapid proliferation of pollution around the globe. Effective bio-waste management can help to reduce the adverse effects of organic waste while contributing to the circular economy at the same time. The toxic oily-biological sludge generated from oil refineries’ wastewater treatment plants is a potential source for biogas energy recovery via anaerobic digestion. However, the oily-biological sludge’s carbon/nitrogen (C/N) ratio is lower than the ideal 20–30 ratio required by anaerobic digestion technology for biogas production. Sugarcane bagasse can be digested as a high C/N co-substrate while the oily-biological sludge acts as a substrate and inoculum to improve biogas production. In this study, the best C/N with co-substrate volatile solids (VS)/inoculum VS ratios for the co-digestion process of mixtures were determined empirically through batch experiments at temperatures of 35–37 °C, pH (6–8) and 60 rpm mixing. The raw materials were pre-treated mechanically and thermo-chemically to further enhance the digestibility. The best condition for the sugarcane bagasse delignification process was 1% (w/v) sodium hydroxide, 1:10 solid-liquid ratio, at 100 °C, and 150 rpm for 1 h. The results from a 33-day batch anaerobic digestion experiment indicate that the production of biogas and methane yield were concurrent with the increasing C/N and co-substrate VS/inoculum VS ratios. The total biogas yields from C/N 20.0 with co-substrate VS/inoculum VS 0.06 and C/N 30.0 with co-substrate VS/inoculum VS 0.18 ratios were 2777.0 and 9268.0 mL, respectively, including a methane yield of 980.0 and 3009.3 mL, respectively. The biogas and methane yield from C/N 30.0 were higher than the biogas and methane yields from C/N 20.0 by 70.04 and 67.44%, respectively. The highest biogas and methane yields corresponded with the highest C/N with co-substrate VS/inoculum VS ratios (30.0 and 0.18), being 200.6 mL/g VSremoved and 65.1 mL CH4/g VSremoved, respectively.

scholarly journals Biogas potential of organic waste onboard cruise ships — a yet untapped energy source

2021 ◽  
Author(s):  
Kai Schumüller ◽  
Dirk Weichgrebe ◽  
Stephan Köster
Keyword(s):  
Energy Source ◽  
Anaerobic Digestion ◽  
Sewage Sludge ◽  
Food Waste ◽  
Energy Demand ◽  
Organic Waste ◽  
Biogas Production ◽  
Biogas Yield ◽  
Cruise Ships ◽  
Detailed Presentation

AbstractTo tap the organic waste generated onboard cruise ships is a very promising approach to reduce their adverse impact on the maritime environment. Biogas produced by means of onboard anaerobic digestion offers a complementary energy source for ships’ operation. This report comprises a detailed presentation of the results gained from comprehensive investigations on the gas yield from onboard substrates such as food waste, sewage sludge and screening solids. Each person onboard generates a total average of about 9 kg of organic waste per day. The performed analyses of substrates and anaerobic digestion tests revealed an accumulated methane yield of around 159 L per person per day. The anaerobic co-digestion of sewage sludge and food waste (50:50 VS) emerged as particularly effective and led to an increased biogas yield by 24%, compared to the mono-fermentation. In the best case, onboard biogas production can provide an energetic output of 82 W/P, on average covering 3.3 to 4.1% of the total energy demand of a cruise ship.

scholarly journals Degradation of bioplastics in organic waste by mesophilic anaerobic digestion, composting and soil incubation

2021 ◽  
Vol 134 ◽  
pp. 67-77
Author(s):  
Mirko Cucina ◽  
Patrizia De Nisi ◽  
Luca Trombino ◽  
Fulvia Tambone ◽  
Fabrizio Adani
Keyword(s):  
Anaerobic Digestion ◽  
Organic Waste ◽  
Soil Incubation

PROSPECTS FOR OBTAINING GAS MOTOR FUEL FROM BIOGAS OF ANAEROBIC DIGESTION OF AGRICULTURAL WASTE

2021 ◽  
Vol 3 (144) ◽  
pp. 22-31
Author(s):  
Viktor S. Grigor’yev ◽  
◽  
Il’ya V. Romanov
Keyword(s):  
Anaerobic Digestion ◽  
Gas Hydrates ◽  
Process Model ◽  
Organic Waste ◽  
Agricultural Waste ◽  
Motor Fuel ◽  
Hydrate Formation ◽  
Research Purpose ◽  
Industrial Complex ◽  
Mixed Gas

The ability of gas hydrates to concentrate gas into a solid chelate structure and the properties of self-preservation of gas hydrates at negative temperatures allows us to consider the possibility of developing a method for the utilization of biogas, environmentally safe storage and transportation of biomethane. (Research purpose) The research purpose is in substantiation the technological possibilities of obtaining synthetic mixed gas hydrates of biogas components, their storage and transportation based on the analysis of the existing regularities of the formation of gas hydrates in time, temperature and external pressure. (Materials and methods) The article presents the accumulated results of studies of the process of obtaining artificial hydrates of natural gas and methane- containing gas mixtures at various initial static pressures and temperatures. The object of research to substantiate the parameters of artificial creation of gas hydrates is biogas obtained during anaerobic thermophilic fermentation of organic waste at an existing experimental biogas plant. Mixed feed SK-8 with a humidity of 90-92 percent was used as an organic substrate of constant composition. The composition of biogas was studied using the Optima-7 Biogas gas analyzer. (Results and discussion) The article presents a process model and a technical appearance of an installation for producing gas motor fuel from the biogas of anaerobic digestion of organic waste of the agro-industrial complex. The hydrate formation time depends on the increase in the interfacial surface and the movement of gas bubbles relative to the liquid, which can be regulated by acting on the hydrate formation zone (shock wave, electromagnetic, mechanical, chemical, temperature). (Conclusions) The research results can be used in modeling processes in two-phase media during the formation of gas hydrates and the creation of installations for their production.

Sign in / Sign up

Export Citation Format

Share Document