Reduction of Escherichia coli O157:H7 on Produce by Use of Electrolyzed Water under Simulated Food Service Operation Conditions

2009 ◽  
Vol 72 (9) ◽  
pp. 1854-1861 ◽  
Author(s):  
PHILIPUS PANGLOLI ◽  
YEN-CON HUNG ◽  
LARRY R. BEUCHAT ◽  
C. HAROLD KING ◽  
ZHI-HUI ZHAO
Keyword(s):  
Escherichia Coli ◽  
Foodborne Pathogens ◽  
Fruits And Vegetables ◽  
Tap Water ◽  
Food Service ◽  
Escherichia Coli O157 ◽  
Electrolyzed Water ◽  
E Coli ◽  
Operation Conditions ◽  
Iceberg Lettuce

Treatment of fresh fruits and vegetables with electrolyzed water (EW) has been shown to kill or reduce foodborne pathogens. We evaluated the efficacy of EW in killing Escherichia coli O157:H7 on iceberg lettuce, cabbage, lemons, and tomatoes by using washing and/or chilling treatments simulating those followed in some food service kitchens. Greatest reduction levels on lettuce were achieved by sequentially washing with 14-A (amperage) acidic EW (AcEW) for 15 or 30 s followed by chilling in 16-A AcEW for 15 min. This procedure reduced the pathogen by 2.8 and 3.0 log CFU per leaf, respectively, whereas washing and chilling with tap water reduced the pathogen by 1.9 and 2.4 log CFU per leaf. Washing cabbage leaves for 15 or 30 s with tap water or 14-A AcEW reduced the pathogen by 2.0 and 3.0 log CFU per leaf and 2.5 to 3.0 log CFU per leaf, respectively. The pathogen was reduced by 4.7 log CFU per lemon by washing with 14-A AcEW and 4.1 and 4.5 log CFU per lemon by washing with tap water for 15 or 30 s. A reduction of 5.3 log CFU per lemon was achieved by washing with 14-A alkaline EW for 15 s prior to washing with 14-A AcEW for 15 s. Washing tomatoes with tap water or 14-A AcEW for 15 s reduced the pathogen by 6.4 and 7.9 log CFU per tomato, respectively. Application of AcEW using procedures mimicking food service operations should help minimize cross-contamination and reduce the risk of E. coli O157:H7 being present on produce at the time of consumption.

Survival and Recovery of Escherichia coli O157:H7, Salmonella, and Listeria monocytogenes on Lettuce and Parsley as Affected by Method of Inoculation, Time between Inoculation and Analysis, and Treatment with Chlorinated Water

2004 ◽  
Vol 67 (6) ◽  
pp. 1092-1103 ◽  
Author(s):  
MEGAN M. LANG ◽  
LINDA J. HARRIS ◽  
LARRY R. BEUCHAT
Keyword(s):  
Escherichia Coli ◽  
Listeria Monocytogenes ◽  
Foodborne Pathogens ◽  
Escherichia Coli O157 ◽  
Water Control ◽  
Drying Time ◽  
E Coli ◽  
Iceberg Lettuce ◽  
Spray Inoculation ◽  
Number Of Cells

The effects of method for applying inoculum and of drying time after inoculation on survival and recovery of foodborne pathogens on iceberg lettuce and parsley were studied. Five-strain mixtures of Escherichia coli O157:H7, Salmonella, or Listeria monocytogenes were applied to lettuce and parsley by dip, spot, or spray inoculation methods. Inocula were dried for 2 h at 22°C or for 2 h at 22°C and then 22 h at 4°C before being treated with water (control) or chlorine (200 μg/ml). Significantly higher populations (CFU per lettuce or parsley sample) of E. coli O157:H7 and Salmonella (α = 0.05) were recovered from dip-inoculated produce than from spot- or spray-inoculated produce. This difference was attributed to larger numbers of cells adhering to lettuce and parsley subjected to dip inoculation. Populations of E. coli O157:H7 and Salmonella recovered from lettuce inoculated by spot and spray methods were not significantly different, but populations recovered from spot-inoculated parsley were significantly higher than those recovered from spray-inoculated parsley, even though the number of cells applied was the same. Significantly different numbers of L. monocytogenes were recovered from inoculated lettuce (dip > spray > spot); populations recovered from dip-inoculated parsley were significantly higher than those recovered from spot- or spray-inoculated parsley, which were not significantly different from each other. Populations of pathogens recovered from lettuce and parsley after drying inoculum for 2 h at 22°C were significantly higher than or equal to populations recovered after drying for 2 h at 22°C and then for 22 h at 4°C. Significant differences (water > chlorine) were observed in populations of all pathogens recovered from treated lettuce and parsley, regardless of inoculation method and drying time. It is recommended that spot inoculation with a drying time of 2 h at 22°C followed by 22 h at 4°C be used to determine the efficacy of chlorine and other sanitizers in killing foodborne pathogens on lettuce and parsley.

Survival and Dissemination of Escherichia coli O157:H7 on Physically and Biologically Damaged Lettuce Plants

2008 ◽  
Vol 71 (12) ◽  
pp. 2384-2388 ◽  
Author(s):  
DANIEL ARUSCAVAGE ◽  
SALLY A. MILLER ◽  
MELANIE L. LEWIS IVEY ◽  
KEN LEE ◽  
JEFFREY T. LeJEUNE
Keyword(s):  
Escherichia Coli ◽  
Foodborne Pathogens ◽  
Xanthomonas Campestris ◽  
Fruits And Vegetables ◽  
Traumatic Injury ◽  
Central Vein ◽  
Escherichia Coli O157 ◽  
Physical Damage ◽  
E Coli ◽  
Direct Inoculation

The ecology of the vegetable leaf surface is important to the survival of enteric pathogens. Understanding changes in ecological parameters during the preharvest stages of production can lead to development of approaches to minimize the hazard of contamination of fresh fruits and vegetables with foodborne pathogens. In this study, survival levels of Escherichia coli O157 over a 10-day period were compared among traumatically injured, phytopathogen-damaged, and healthy lettuce plants. Leaves from lettuce plants cracked along the central vein, plants infected with Xanthomonas campestris pv. vitians, and healthy plants were inoculated with E. coli O157:H7. The presence of E. coli O157:H7 populations on inoculated leaves and non-inoculated leaves of these same plants was determined for 10 days. The density of E. coli O157:H7 decreased over time on the inoculated leaves regardless of the treatment. The population of E. coli O157:H7 remained higher on traumatically injured leaves than on healthy plants (P < 0.001). E. coli O157:H7 was detected on leaves other than the direct inoculation site of the enteric pathogen in all three treatments groups. Preharvest damage, especially that caused by traumatic injury, impacted the survivability of E. coli O157:H7. Maintaining healthy plants and minimizing physical damage around the time of harvest might improve the safety of fresh produce.

Tracking an Escherichia coli O157:H7–Contaminated Batch of Leafy Greens through a Pilot-Scale Fresh-Cut Processing Line

2014 ◽  
Vol 77 (9) ◽  
pp. 1487-1494 ◽  
Author(s):  
ANNEMARIE L. BUCHHOLZ ◽  
GORDON R. DAVIDSON ◽  
BRADLEY P. MARKS ◽  
EWEN C. D. TODD ◽  
ELLIOT T. RYSER
Keyword(s):  
Escherichia Coli ◽  
Membrane Filtration ◽  
Fluorescent Protein ◽  
Pilot Scale ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Leafy Greens ◽  
Iceberg Lettuce ◽  
Processing Line ◽  
Fresh Cut

Cross-contamination of fresh-cut leafy greens with residual Escherichia coli O157:H7–contaminated product during commercial processing was likely a contributing factor in several recent multistate outbreaks. Consequently, radicchio was used as a visual marker to track the spread of the contaminated product to iceberg lettuce in a pilot-scale processing line that included a commercial shredder, step conveyor, flume tank, shaker table, and centrifugal dryer. Uninoculated iceberg lettuce (45 kg) was processed, followed by 9.1 kg of radicchio (dip inoculated to contain a four-strain, green fluorescent protein–labeled nontoxigenic E. coli O157:H7 cocktail at 106 CFU/g) and 907 kg (2,000 lb) of uninoculated iceberg lettuce. After collecting the lettuce and radicchio in about 40 bags (~22.7 kg per bag) along with water and equipment surface samples, all visible shreds of radicchio were retrieved from the bags of shredded product, the equipment, and the floor. E. coli O157:H7 populations were quantified in the lettuce, water, and equipment samples by direct plating with or without prior membrane filtration on Trypticase soy agar containing 0.6% yeast extract and 100 ppm of ampicillin. Based on triplicate experiments, the weight of radicchio in the shredded lettuce averaged 614.9 g (93.6%), 6.9 g (1.3%), 5.0 g (0.8%), and 2.8 g (0.5%) for bags 1 to 10, 11 to 20, 21 to 30, and 31 to 40, respectively, with mean E. coli O157:H7 populations of 1.7, 1.2, 1.1, and 1.1 log CFU/g in radicchio-free lettuce. After processing, more radicchio remained on the conveyor (9.8 g; P < 0.05), compared with the shredder (8.3 g), flume tank (3.5 g), and shaker table (0.1 g), with similar E. coli O157:H7 populations (P > 0.05) recovered from all equipment surfaces after processing. These findings clearly demonstrate both the potential for the continuous spread of contaminated lettuce to multiple batches of product during processing and the need for improved equipment designs that minimize the buildup of residual product during processing.

Effects of Water Source, Dilution, Storage, and Bacterial and Fecal Loads on the Efficacy of Electrolyzed Oxidizing Water for the Control of Escherichia coli O157:H7

2004 ◽  
Vol 67 (7) ◽  
pp. 1377-1383 ◽  
Author(s):  
S. M. L. STEVENSON ◽  
S. R. COOK ◽  
S. J. BACH ◽  
T. A. McALLISTER
Keyword(s):  
Escherichia Coli ◽  
Bactericidal Activity ◽  
Storage Temperature ◽  
Uv Light ◽  
Tap Water ◽  
Organic Matter Content ◽  
Water Source ◽  
Deionized Water ◽  
Escherichia Coli O157 ◽  
E Coli

To evaluate the potential of using electrolyzed oxidizing (EO) water for controlling Escherichia coli O157:H7 in water for livestock, the effects of water source, electrolyte concentration, dilution, storage conditions, and bacterial or fecal load on the oxidative reduction potential (ORP) and bactericidal activity of EO water were investigated. Anode and combined (7:3 anode:cathode, vol/vol) EO waters reduced the pH and increased the ORP of deionized water, whereas cathode EO water increased pH and lowered ORP. Minimum concentrations (vol/vol) of anode and combined EO waters required to kill 104 CFU/ml planktonic suspensions of E. coli O157:H7 strain H4420 were 0.5 and 2.0%, respectively. Cathode EO water did not inhibit H4420 at concentrations up to 16% (vol/vol). Higher concentrations of anode or combined EO water were required to elevate the ORP of irrigation or chlorinated tap water compared with that of deionized water. Addition of feces to EO water products (0.5% anode or 2.0% combined, vol/vol) significantly reduced (P < 0.001) their ORP values to <700 mV in all water types. A relationship between ORP and bactericidal activity of EO water was observed. The dilute EO waters retained the capacity to eliminate a 104 CFU/ml inoculation of E. coli O157:H7 H4420 for at least 70 h regardless of exposure to UV light or storage temperature (4 versus 24°C). At 95 h and beyond, UV exposure reduced ORP, significantly more so (P < 0.05) in open than in closed containers. Bactericidal activity of EO products (anode or combined) was lost in samples in which ORP value had fallen to ≤848 mV. When stored in the dark, the diluted EO waters retained an ORP of >848 mV and bactericidal efficacy for at least 125 h; with refrigeration (4°C), these conditions were retained for at least 180 h. Results suggest that EO water may be an effective means by which to control E. coli O157:H7 in livestock water with low organic matter content.

scholarly journals Growth of Salmonella and Other Foodborne Pathogens on Inoculated Inshell Pistachios during Simulated Delays between Hulling and Drying

2019 ◽  
Vol 82 (5) ◽  
pp. 815-825 ◽  
Author(s):  
MAHTA MOUSSAVI ◽  
VANESSA LIEBERMAN ◽  
CHRIS THEOFEL ◽  
JAVAD BAROUEI ◽  
LINDA J. HARRIS
Keyword(s):  
Escherichia Coli ◽  
Relative Humidity ◽  
Foodborne Pathogens ◽  
Lag Time ◽  
Escherichia Coli O157 ◽  
Contributing Factors ◽  
Shell Surface ◽  
E Coli ◽  
Significant Growth ◽  
Lower Maximum

ABSTRACT During harvest, pistachios are hulled, separated in water into floater and sinker streams (in large part on the basis of nut density), and then dried before storage. Higher prevalence and levels of Salmonella were previously observed in floater pistachios, but contributing factors are unclear. To examine the behavior of pathogens on hulled pistachios during simulated drying delays, floater and sinker pistachios collected from commercial processors were inoculated at 1 or 3 log CFU/g with cocktails of Salmonella and in some cases Escherichia coli O157:H7 or Listeria monocytogenes and incubated for up to 30 h at 37°C and 90% relative humidity. Populations were measured by plating onto tryptic soy agar and appropriate selective agars. In most cases, no significant growth (P > 0.05) of Salmonella was observed in the first 3 h after inoculation in hulled floaters and sinkers. Growth of Salmonella was greater on floater pistachios than on corresponding sinkers and on floater pistachios with ≥25% hull adhering to the shell surface than on corresponding floaters with <25% adhering hull. Maximum Salmonella populations (2 to 7 log CFU/g) were ∼2-log higher on floaters than on corresponding sinkers. The growth of E. coli O157:H7 and Salmonella on hulled pistachios was similar, but a longer lag time (approximately 11 h) and significantly lower maximum populations (4 versus 5 to 6 log CFU/g; P < 0.05) were predicted for L. monocytogenes. Significant growth of pathogens on hulled pistachios is possible when delays between hulling and drying are longer than 3 h, and pathogen growth is enhanced in the presence of adhering hull material.

Transfer of Escherichia coli O157:H7 to Romaine Lettuce due to Contact Water from Melting Ice

2008 ◽  
Vol 71 (2) ◽  
pp. 252-256 ◽  
Author(s):  
JIN KYUNG KIM ◽  
MARK A. HARRISON
Keyword(s):  
Escherichia Coli ◽  
Tap Water ◽  
Sampling Site ◽  
Contaminated Water ◽  
Escherichia Coli O157 ◽  
Romaine Lettuce ◽  
E Coli ◽  
Ice Melt ◽  
Leaf Surfaces ◽  
Shipping Containers

Ice can be used to chill romaine lettuce and maintain relative humidity during transportation. Escherichia coli O157:H7 may contaminate water used for ice. The objective of this study was to determine the potential for E. coli O157:H7 contamination of romaine lettuce from either ice contaminated with the pathogen or by transfer from lettuce surfaces via melting ice. In experiment 1, lettuce was spot inoculated with E. coli O157:H7 and chilled with ice prepared from uncontaminated tap water. In experiment 2, water inoculated with this pathogen was frozen and used to ice lettuce. Three heads of lettuce were stacked in each container and stored at 4 or 20°C. After the ice melted, E. coli O157:H7 attachment to and recovery from the lettuce leaves were determined. For experiment 1, the population of E. coli O157:H7 attached to inoculated sites averaged 3.8 and 5.5 CFU/cm2 at 4 and 20°C, respectively. Most of the uninoculated sites became contaminated with the pathogen due to ice melt. For experiment 2, 3.5 to 3.8 log CFU E. coli O157:H7 per cm2 was attached to the top leaf on the first head. After rinsing with chlorinated water (200 μg/ml), E. coli O157:H7 remained on the surface of the top head (1.8 to 2.0 log CFU/cm2). There was no difference in numbers of E. coli O157:H7 recovered from each sampling site at 4 and 20°C. Results show that E. coli O157:H7 can be transferred onto other produce layers in shipping containers from melted ice made of contaminated water and from contaminated to uncontaminated leaf surfaces.

Influence of Curli Expression by Escherichia coli O157:H7 on the Cell's Overall Hydrophobicity, Charge, and Ability To Attach to Lettuce

2007 ◽  
Vol 70 (6) ◽  
pp. 1339-1345 ◽  
Author(s):  
RENEE R. BOYER ◽  
SUSAN S. SUMNER ◽  
ROBERT C. WILLIAMS ◽  
MERLE D. PIERSON ◽  
DAVID L. POPHAM ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Surface Charge ◽  
Extracellular Proteins ◽  
Escherichia Coli O157 ◽  
Fruit And Vegetable ◽  
E Coli ◽  
Iceberg Lettuce ◽  
Escherichia Coli Cells ◽  
Abiotic Surfaces ◽  
Plant Surfaces

Curli fibers are produced by some Escherichia coli cells in response to environmental stimuli. These extracellular proteins enhance the cell's ability to form biofilms on various abiotic surfaces. E. coli O157:H7 cells readily attach to a variety of fruit and vegetable surfaces. It is not known whether the expression of curli influences the cell's ability to attach to produce surfaces. In this study, the effect of curli expression on the cell's overall hydrophobicity, charge, and ability to attach to cut and whole iceberg lettuce surfaces was examined. All strains, regardless of curli expression, attached preferentially to the cut edges of lettuce (P < 0.05). The curli-producing cells of E. coli O157:H7 strain E0018 attached in significantly greater numbers to both cut and whole lettuce pieces than did the non–curli-producing E0018 cells (P < 0.05); however, no significant attachment differences were observed between the curli-producing and non–curli-producing cells of E. coli O157:H7 strains 43894 and 43895. All curli-producing E. coli O157:H7 strains were significantly more hydrophobic (P < 0.01); however, no association between the cells' hydrophobic characteristics and lettuce attachment was observed. Overall surface charge of the cells did not differ among strains or curli phenotypes. Results indicate that overall hydrophobicity and cell charge in E. coli O157:H7 strains do not influence attachment to iceberg lettuce surfaces. The presence of curli may not have any influence on attachment of E. coli O157:H7 cells to produce items. Additional factors may influence the attachment of E. coli O157:H7 to plant surfaces and should be further examined.

Inactivation of Escherichia coli O157:H7 and Salmonella and Native Microbiota on Fresh Strawberries by Antimicrobial Washing and Coating

2018 ◽  
Vol 81 (8) ◽  
pp. 1227-1235 ◽  
Author(s):  
MINGMING GUO ◽  
TONY Z. JIN ◽  
JOSHUA B. GURTLER ◽  
XUETONG FAN ◽  
MADHAV P. YADAV
Keyword(s):  
Escherichia Coli ◽  
Foodborne Pathogens ◽  
Allyl Isothiocyanate ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Native Microflora ◽  
Pathogen Populations ◽  
Antimicrobial Treatments ◽  
Antimicrobial Effectiveness

ABSTRACT Antimicrobial washing (AW), antimicrobial coating (AC), and a combination of washing followed by coating (AW+AC) were evaluated for their ability to inactivate artificially inoculated foodborne pathogens and native microbiota on strawberries stored at 4°C. Strawberries were inoculated with a six-strain composite of Escherichia coli O157:H7 and Salmonella; treated by AW, AC, or AW+AC; and stored at 4°C for 3 weeks. The washing solution contained 90 ppm of peracetic acid, and the coating solution consisted of chitosan (1%, w/v), allyl isothiocyanate (1%, v/v), and corn-bio fiber gum (5%, w/v). The effectiveness of the antimicrobial treatments against E. coli O157:H7 and Salmonella pathogens and native microflora on strawberries and their impact on fruit quality (appearance, weight loss, color, and firmness) were determined. By the end of storage, pathogen populations on strawberries were 2.5 (AW+AC), 2.9 (AC), 3.8 (AW), and 4.2 log CFU for the positive (untreated) control. AW+AC treatments also inactivated the greatest population of native microflora, followed by the AC treatment alone. AW+AC treatments showed additional antimicrobial effectiveness against these two pathogens and native microflora. Both AW+AC and AC treatments preserved the color, texture, and appearance of strawberries throughout storage. The coating treatments (AW+AC and AC alone) further reduced the loss of moisture throughout storage. The AW treatment was the least effective in reducing populations of pathogens and native microflora and in maintaining the quality of strawberries throughout storage. This study demonstrates a method to improve the microbiological safety, shelf life, and quality of strawberries.

Is There a Relation between the Microscopic Leaf Morphology and the Association of Salmonella and Escherichia coli O157:H7 with Iceberg Lettuce Leaves?

2016 ◽  
Vol 79 (10) ◽  
pp. 1784-1788 ◽  
Author(s):  
INGE VAN der LINDEN ◽  
MARKUS ERIKSSON ◽  
MIEKE UYTTENDAELE ◽  
FRANK DEVLIEGHERE
Keyword(s):  
Escherichia Coli ◽  
Stomatal Density ◽  
Fresh Produce ◽  
Morphological Structure ◽  
Bacterial Attachment ◽  
Escherichia Coli O157 ◽  
Stages Of Development ◽  
E Coli ◽  
Iceberg Lettuce ◽  
Morphological Differences

ABSTRACT To prevent contamination of fresh produce with enteric pathogens, more insight into mechanisms that may influence the association of these pathogens with fresh produce is needed. In this study, Escherichia coli O157:H7 and Salmonella were chosen as model pathogens, and fresh cut iceberg lettuce was chosen as a model fresh produce type. The morphological structure of iceberg lettuce leaves (stomatal density and length of cell margins per leaf area) was quantified by means of leaf peels and light microscopy of leaves at different stages of development (outer, middle, and inner leaves of the crop) on both leaf sides (abaxial and adxial) and in three leaf regions (top, center, and bottom). The morphology of the top region of the leaves was distinctly different from that of the center and base, with a significantly higher stomatal density (up to five times more stomata), different cell shape, and longer cell margins (two to three times longer). Morphological differences between the same regions of the leaves at different stages of development were smaller or nonsignificant. An attachment assay with two attenuated E. coli O157:H7 strains (84-24h11-GFP and BRMSID 188 GFP) and two Salmonella strains (serovars Thompson and Typhimurium) was performed on different regions of the middle leaves. Our results confirmed earlier reports that these pathogens have a higher affinity for the base of the lettuce leaf than the top. Differences of up to 2.12 log CFU/g were seen (E. coli O157:H7 86-24h11-GFP). Intermediate attachment occurred in the central region. The higher incidence of preferential bacterial attachment sites such as stomata and cell margins or grooves could not explain the differences observed in the association of the tested pathogens with different regions of iceberg lettuce leaves.

Sign in / Sign up

Export Citation Format

Share Document