scholarly journals BIOGAS FROM CASSAVA PEELS WASTE

Detritus ◽  
2020 ◽  
pp. 100-108
Author(s):  
Felix Aibuedefe Aisien ◽  
Eki Tina Aisien
Keyword(s):  
Anaerobic Digestion ◽  
Sodium Hydroxide ◽  
Biogas Production ◽  
Cow Dung ◽  
Retention Period ◽  
Buffer Solutions ◽  
Volatile Solids ◽  
Agricultural Applications ◽  
Cassava Peels ◽  
Official Methods Of Analysis

The increasing growth of cassava agro-industries in Nigeria has led to the enormous generation of cassava peels waste. The feasibility of generating biogas and biofertilizer for both domestic and agricultural applications from cassava peels waste inoculated with cow dung was investigated. Fresh and stale cassava peels were used in the study. Three pretreatment chemicals such as sodium hydroxide (NaOH), calcium hydroxide (Ca(OH)2 and ammonium chloride (NH4Cl) buffer solutions were used in pretreating the cassava peels and cow dung slurry. Six batch anaerobic biodigesters of 10-litre capacity each were used in this study for 40 days retention period. The pH, temperature, and volumes of biogas and methane produced were monitored and recorded daily. The fertilizer qualities (total solids, volatile solids, % phosphorus, % nitrogen, etc.) of the digester slurry and the digester sludge after 40 days digestion were determined using official methods of analysis of Association of Official Analytical Chemists (AOAC). The results showed that the amount of biogas generated is 2540 cm3/day. The stale cassava peels and cow dung slurry and the use of NH4Cl pretreatment chemical gave the best biogas production and methane yield of 104,961cm3 and 62.3% respectively. The digester sludge from the anaerobic digestion of cassava peels and cow dung showed and demonstrated good biofertilizer qualities.

scholarly journals Evaluation of Biogas through Chemically Treated Cottonseed Hull in Anaerobic Digestion with/without Cow Dung: An Experimental Study

2021 ◽  
Author(s):  
Venkateshkumar R ◽  
Shanmugam S ◽  
Veerappan AR
Keyword(s):  
Anaerobic Digestion ◽  
Sodium Hydroxide ◽  
Calcium Hydroxide ◽  
Biogas Production ◽  
Cow Dung ◽  
Batch Reactors ◽  
Biogas Yield ◽  
Cottonseed Hull ◽  
Pre Treatment ◽  
Feedstock Material

Abstract Cow dung is generally used as the feedstock material for the anaerobic digestion to produce biogas. A selection of alternate biomass material is needed to reduce the consumption or to eliminate the use of cow dung. Recently, cottonseed hull has been considered as the primary substrate to produce biogas. In this paper, the effect of biogas production on anaerobic co-digestion of cow dung with pre-treated cottonseed hull using different concentrations of sulfuric acid, hydrochloric acid, hydrogen peroxide, and acetic acid is investigated. Sodium hydroxide and calcium hydroxide are used at different concentrations for pre-treatment of cottonseed hull. The enhancement of biogas production from the batch reactors at mesophilic temperature (35 ± 2 ℃) is observed for mono- and co-digestion of cow dung with treated cottonseed hull. Maximum biogas yield is achieved for the treated cottonseed hull at 6% sodium hydroxide during mono digestion and at 6% calcium hydroxide during co-digestion.

scholarly journals Effect of co-digestion of food waste and cow dung on biogas yield

2020 ◽  
Vol 181 ◽  
pp. 01005
Author(s):  
Makhura Emmanuel Pax ◽  
Edison Muzenda ◽  
Tumeletso Lekgoba
Keyword(s):  
Anaerobic Digestion ◽  
Moisture Content ◽  
Food Waste ◽  
Biogas Production ◽  
Cow Dung ◽  
Mixing Ratio ◽  
Total Solids ◽  
Biogas Yield ◽  
Volatile Solids ◽  
Thermophilic Conditions

This paper aims at finding the effect of co-digestion of cow dung and food waste on total biogas yield. Biogas production was improved through co-digestion of cow dung and food waste (FW) containing a small fraction of inoculum under mesophilic temperature (37ºC) over a retention time of 24 days. Co-digestion ratios of 1:1, 2:1 and 3:1 for cowdung/foodwaste were used for the study on anaerobic digestion on the co digested matter. Tests were carried out starting with the preparation of substrates, substrate characterization to determine the moisture content (MC), total solids (TS), volatile solids (VS) and ultimately batch anaerobic digestion experiments under thermophilic conditions (370C). The moisture content, volatile solids and total solids for food waste were 78, 22 and 90.7% respectively while the characteristics for cow dung were 67.2, 32.8 and 96.0 % respectively. From the study, a mixing ratio of cow dung: food waste of 1:2 was found to be the optimum substrate mixture for biogas production at 25595.7 Nml. The accumulated gas volumes of 18756.6, 14042.5, 13940.8 and 13839.1 Nml were recorded for cow dung: food waste ratios of 2:1, 1:1, 1:3 and 3:1 respectively. For a co-digestion containing more of the food waste than cow dung, a higher volume of biogas is produce.

scholarly journals Biochemical Methane Potential of Cork Boiling Wastewater at Different Inoculum to Substrate Ratios

2021 ◽  
Vol 11 (7) ◽  
pp. 3064
Author(s):  
Roberta Mota-Panizio ◽  
Manuel Jesús Hermoso-Orzáez ◽  
Luis Carmo-Calado ◽  
Gonçalo Lourinho ◽  
Paulo Sérgio Duque de Brito
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Treatment Plant ◽  
Organic Substrates ◽  
Biochemical Methane Potential ◽  
Volatile Solids ◽  
Working Volume ◽  
Methane Potential ◽  
Bmp Test ◽  
Cork Industry

The present study evaluates the digestion of cork boiling wastewater (CBW) through a biochemical methane potential (BMP) test. BMP assays were carried out with a working volume of 600 mL at a constant mesophilic temperature (35 °C). The experiment bottles contained CBW and inoculum (digested sludge from a wastewater treatment plant (WWTP)), with a ratio of inoculum/substrate (Ino/CBW) of 1:1 and 2:1 on the basis of volatile solids (VSs); the codigestion with food waste (FW) had a ratio of 2/0.7:0.3 (Ino/CBW:FW) and the codigestion with cow manure (CM) had a ratio of 2/0.5:0.5 (Ino/CBW:CM). Biogas and methane production was proportional to the inoculum substrate ratio (ISR) used. BMP tests have proved to be valuable for inferring the adequacy of anaerobic digestion to treat wastewater from the cork industry. The results indicate that the biomethane potential of CBWs for Ino/CBW ratios 1:1 and 2:1 is very low compared to other organic substrates. For the codigestion tests, the test with the Ino/CBW:CM ratio of 2/0.7:0.3 showed better biomethane yields, being in the expected values. This demonstrated that it is possible to perform the anaerobic digestion (AD) of CBW using a cosubstrate to increase biogas production and biomethane and to improve the quality of the final digestate.

scholarly journals Trace Element Supplementation and Enzyme Addition to Enhance Biogas Production by Anaerobic Digestion of Chicken Litter

Energies ◽  
2020 ◽  
Vol 13 (13) ◽  
pp. 3477
Author(s):  
Navodita Bhatnagar ◽  
David Ryan ◽  
Richard Murphy ◽  
Anne-Marie Enright
Keyword(s):  
Anaerobic Digestion ◽  
Trace Element ◽  
Biogas Production ◽  
Positive Control ◽  
Negative Control ◽  
Enzyme Treatment ◽  
Small Scale ◽  
Volatile Solids ◽  
Chicken Litter ◽  
Set Up

Anaerobic digestion (AD) of chicken litter (CL) is a viable alternative to disposal. However, methane yields from this primarily organic waste are quite low when mono-digested. This paper discusses the effect of an enzyme cocktail, trace element (TE) supplementation and selenium (Se) addition in small-scale batch biomethane potential (BMP) assays to enhance the AD of CL. Eleven different assays were set up in triplicate including assays containing only inoculum (blank), only CL (negative control) and cellulose and inoculum (positive control). The results indicate that both enzyme treatment and trace element supplementation enhanced the biogas and methane yield. The highest specific biogas and methane yields were noted for 1% enzyme-treated CL of 835.2 L/kg volatile solids (VS) and 460.8 L/kg VS, respectively. Usually, mono-digestion of CL is low due to high nitrogen content and the presence of recalcitrant lignocellulosic material from the bedding material. Enzyme treatment performed better than the addition of the TE mix and Se.

Application of the IWA Anaerobic Digestion Model (ADM1) for simulating full-scale anaerobic sewage sludge digestion

2005 ◽  
Vol 52 (1-2) ◽  
pp. 487-492 ◽  
Author(s):  
Y. Shang ◽  
B.R. Johnson ◽  
R. Sieger
Keyword(s):  
Wastewater Treatment ◽  
Steady State ◽  
Anaerobic Digestion ◽  
Biogas Production ◽  
Treatment Plant ◽  
Biochemical Parameter ◽  
Full Scale ◽  
Anaerobic Digesters ◽  
Biogas Yield ◽  
Volatile Solids

A steady-state implementation of the IWA Anaerobic Digestion Model No. 1 (ADM1) has been applied to the anaerobic digesters in two wastewater treatment plants. The two plants have a wastewater treatment capacity of 76,000 and 820,000 m3/day, respectively, with approximately 12 and 205 dry metric tons sludge fed to digesters per day. The main purpose of this study is to compare the ADM1 model results with full-scale anaerobic digestion performance. For both plants, the prediction of the steady-state ADM1 implementation using the suggested physico-chemical and biochemical parameter values was able to reflect the results from the actual digester operations to a reasonable degree of accuracy on all parameters. The predicted total solids (TS) and volatile solids (VS) concentration in the digested biosolids, as well as the digester volatile solids destruction (VSD), biogas production and biogas yield are within 10% of the actual digester data. This study demonstrated that the ADM1 is a powerful tool for predicting the steady-state behaviour of anaerobic digesters treating sewage sludges. In addition, it showed that the use of a whole wastewater treatment plant simulator for fractionating the digester influent into the ADM1 input parameters was successful.

Sludge electrooxidation as pre-treatment for anaerobic digestion

2016 ◽  
Vol 75 (4) ◽  
pp. 775-781 ◽  
Author(s):  
J. A. Barrios ◽  
U. Duran ◽  
A. Cano ◽  
M. Cisneros-Ortiz ◽  
S. Hernández
Keyword(s):  
Anaerobic Digestion ◽  
Volatile Fatty Acids ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Wastewater Sludge ◽  
Boron Doped Diamond ◽  
Boron Doped ◽  
Treatment Conditions ◽  
Volatile Solids ◽  
Pre Treatment

Anaerobic digestion of wastewater sludge is the preferred method for sludge treatment as it produces energy in the form of biogas as well as a stabilised product that may be land applied. Different pre-treatments have been proposed to solubilise organic matter and increase biogas production. Sludge electrooxidation with boron-doped diamond electrodes was used as pre-treatment for waste activated sludge (WAS) and its effect on physicochemical properties and biomethane potential (BMP) was evaluated. WAS with 2 and 3% total solids (TS) achieved 2.1 and 2.8% solubilisation, respectively, with higher solids requiring more energy. After pre-treatment, biodegradable chemical oxygen demand values were close to the maximum theoretical BMP, which makes sludge suitable for energy production. Anaerobic digestion reduced volatile solids (VS) by more than 30% in pre-treated sludge with a food to microorganism ratio of 0.15 g VSfed g−1 VSbiomass. Volatile fatty acids were lower than those for sludge without pre-treatment. Best pre-treatment conditions were 3% TS and 28.6 mA cm−2.

Solid-State Anaerobic Digestion for Methane Production from Corn Stalks with Stack-Pretreated

2011 ◽  
Vol 697-698 ◽  
pp. 326-330 ◽  
Author(s):  
S.X. Zhou ◽  
Y.P. Dong ◽  
Y.L. Zhang
Keyword(s):  
Anaerobic Digestion ◽  
Solid State ◽  
Methane Production ◽  
Biogas Production ◽  
Cow Dung ◽  
Cow Manure ◽  
Pretreatment Method ◽  
Biogas Yield ◽  
Microbial Pretreatment ◽  
Microbial Strains

Microbial pretreatment was applied to enhance biogas production from corn stover through solid-state anaerobic digestion, but the price of microbial strains is high. The objective of this study was to find the effects on biogas production by the naturally microbial pretreatment method. The highest cumulative biogas yield for 60-day solid-state anaerobic digestion was obtained in B group (the pretreated corn straws with cow dung), which was 19.6% higher than that of the untreated samples. The D group（the pretreated corn straws with the sludge）cumulative biogas yield for 60-day solid-state anaerobic digestion was obtained, which was 18.87% higher than that of the untreted samples. The biogas of D group increased to the range of 55%～60% methane content, while B group with the range of 75%～80%.The results indicated that the pretreated corn straws mixing cow manure can improve both the biogas production yield and the content of methane in CH4。

scholarly journals Kinetic Study on Biogas Production from Cabbage (Brassica oleracea) Waste and Its Blend with Animal Manure Using Logistic Function Model

2021 ◽  
pp. 34-43
Author(s):  
Christian C. Opurum
Keyword(s):  
Anaerobic Digestion ◽  
Kinetic Parameters ◽  
Goodness Of Fit ◽  
Biogas Production ◽  
Logistic Function ◽  
Gas Production ◽  
Cow Dung ◽  
Function Model ◽  
Biogas Yield ◽  
Significant Difference

This research paper aimed to evaluate the kinetics of anaerobic digestion (AD) of mixtures of cabbage waste (CW) with (Poultry dropping (PD) and Cow dung (CD). The study was conducted in 10L bio-digesters for 35 days under mesophilic conditions (25 - 35OC). Logistic function equation was used to simulate the experimental data to test for its goodness of fit and kinetic parameters namely: maximum biogas potential (Pb), the maximum biogas production rate (Rm), and the lag phase duration (λ) were estimated in each treatment. Chemical analysis showed that individual substrates possess characteristics that could support microbial activities in biogas production. The biogas yield in terms of added  volatile solids (VS) in decreasing order was as follows: 0.022, 0.018, 0.017, 0.014, 0.014 and 0.013 dm3/g VS for CW/CD 2:1, CW/PD3:1, CW/CD 1:1, CW alone, CW/PD1:1 and  CW/PD 2:1, respectively. A significant difference (P ≤ 0.05) in biogas yield was recorded in CW/CD 2:1 with 7.19 dm3 (53.29% increase). The kinetic parameters (Pb, Rm, and λ) for CW/CD 2:1 was 7.01 dm3, 1.58 dm3.d, and 2.29 days, respectively. This was followed by CW/PD 3:1 (5.84 dm3); with 24.92% increase in gas production and CW/CD 1:1 (5.42 dm3) with 15.53% increase relative to CW alone, 4.69 dm3. The digesters fed with CW/PD 1:1 and CW/PD 2:1 exhibited inhibitory effects on biogas production, with 7.51 and 2.05% decrease in gas yield, respectively. The logistic function model demonstrated a strong relationship between the experimental and model-predicted data. The high correlation coefficient (R2) ranging between 0.978 - 0.993 is evident. The model proved to be a useful tool in predicting anaerobic digestion and biogas production process.

Sign in / Sign up

Export Citation Format

Share Document