scholarly journals Production of Polyhydroxyalkanoates in Unsterilized Hyper-Saline Medium by Halophiles Using Waste Silkworm Excrement as Carbon Source

Molecules ◽  
2021 ◽  
Vol 26 (23) ◽  
pp. 7122
Author(s):  
Shuangfeng Cai ◽  
Yaran Wu ◽  
Yanan Li ◽  
Shuying Yang ◽  
Zhi Liu ◽  
...  
Keyword(s):  
Carbon Source ◽  
Sole Carbon Source ◽  
Carbon Sources ◽  
Nile Red ◽  
Fermentation Medium ◽  
Pha Production ◽  
The Cost ◽  
Haloarcula Hispanica ◽  
Saline Medium ◽  
Nile Red Staining

The chlorophyll ethanol-extracted silkworm excrement was hardly biologically reused or fermented by most microorganisms. However, partial extremely environmental halophiles were reported to be able to utilize a variety of inexpensive carbon sources to accumulate polyhydroxyalkanoates. In this study, by using the nile red staining and gas chromatography assays, two endogenous haloarchaea strains: Haloarcula hispanica A85 and Natrinema altunense A112 of silkworm excrement were shown to accumulate poly(3-hydroxybutyrate) up to 0.23 g/L and 0.08 g/L, respectively, when using the silkworm excrement as the sole carbon source. The PHA production of two haloarchaea showed no significant decreases in the silkworm excrement medium without being sterilized compared to that of the sterilized medium. Meanwhile, the CFU experiments revealed that there were more than 60% target PHAs producing haloarchaea cells at the time of the highest PHAs production, and the addition of 0.5% glucose into the open fermentation medium can largely increase both the ratio of target haloarchaea cells (to nearly 100%) and the production of PHAs. In conclusion, our study demonstrated the feasibility of using endogenous haloarchaea to utilize waste silkworm excrement, effectively. The introduce of halophiles could provide a potential way for open fermentation to further lower the cost of the production of PHAs.

scholarly journals Isolation and Characterization of a Mutant of the Marine Bacterium Alcanivorax borkumensis SK2 Defective in Lipid Biosynthesis

2010 ◽  
Vol 76 (9) ◽  
pp. 2884-2894 ◽  
Author(s):  
Efraín Manilla-Pérez ◽  
Alvin Brian Lange ◽  
Stephan Hetzler ◽  
Marc Wältermann ◽  
Rainer Kalscheuer ◽  
...  
Keyword(s):  
Carbon Source ◽  
Sole Carbon Source ◽  
Marine Bacterium ◽  
Neutral Lipids ◽  
Nile Red ◽  
Dry Weight ◽  
Wax Ester ◽  
Gene Encoding ◽  
Isolation And Characterization ◽  
Key Enzyme

ABSTRACT In many microorganisms, the key enzyme responsible for catalyzing the last step in triacylglycerol (TAG) and wax ester (WE) biosynthesis is an unspecific acyltransferase which is also referred to as wax ester synthase/acyl coenzyme A (acyl-CoA):diacylglycerol acyltransferase (WS/DGAT; AtfA). The importance and function of two AtfA homologues (AtfA1 and AtfA2) in the biosynthesis of TAGs and WEs in the hydrocarbon-degrading marine bacterium Alcanivorax borkumensis SK2 have been described recently. However, after the disruption of both the AtfA1 and AtfA2 genes, reduced but substantial accumulation of TAGs was still observed, indicating the existence of an alternative TAG biosynthesis pathway. In this study, transposon-induced mutagenesis was applied to an atfA1 atfA2 double mutant to screen for A. borkumensis mutants totally defective in biosynthesis of neutral lipids in order to identify additional enzymes involved in the biosynthesis of these lipids. At the same time, we have searched for a totally TAG-negative mutant in order to study the function of TAGs in A. borkumensis. Thirteen fluorescence-negative mutants were identified on Nile red ONR7a agar plates and analyzed for their abilities to synthesize lipids. Among these, mutant 2 M131 was no longer able to synthesize and accumulate TAGs if pyruvate was used as the sole carbon source. The transposon insertion was localized in a gene encoding a putative cytochrome c family protein (ABO_1185). Growth and TAG accumulation experiments showed that the disruption of this gene resulted in the absence of TAGs in 2 M131 but that growth was not affected. In cells of A. borkumensis SK2 grown on pyruvate as the sole carbon source, TAGs represented about 11% of the dry weight of the cells, while in the mutant 2 M131, TAGs were not detected by thin-layer and gas chromatography analyses. Starvation and lipid mobilization experiments revealed that the lipids play an important role in the survival of the cells. The function of neutral lipids in A. borkumensis SK2 is discussed.

scholarly journals Studies on poly-3-hydroxyoctanoate biosynthesis by a consortium of microorganisms

2016 ◽  
Vol 27 (1) ◽  
pp. 44-47 ◽  
Author(s):  
Mihaela Carmen Eremia ◽  
Irina Lupescu ◽  
Mariana Vladu ◽  
Maria Petrescu ◽  
Gabriela Savoiu ◽  
...  
Keyword(s):  
Bacillus Subtilis ◽  
Carbon Source ◽  
Pseudomonas Putida ◽  
Sole Carbon Source ◽  
Bacterial Biomass ◽  
Fermentation Medium ◽  
Energy Reserve ◽  
Bacterial Strains ◽  
Sodium Octanoate ◽  
Intracellular Energy

Abstract Polyhydroxyalcanoates (PHAs) are specifically produced by a wide variety of bacteria, as an intracellular energy reserve in the form of homo- and copolymers of [R]-β-hydroxyalkanoic acids, depending on the C source used for microorganism growth, when the cells are grown under stressing conditions. In this paper we present microbiological accumulation of poly-3-hydroxyoctanoate (PHO) by using a consortium of bacterial strains, Pseudomonas putida and Bacillus subtilis, in a rate of 3:1, grown on a fermentation medium based on sodium octanoate as the sole carbon source. The experiments performed in the above mentioned conditions led to the following results: from 18.70 g sodium octanoate (7.72 g/L in the fermentation medium) used up during the bioprocess, 3.93-3.96 g/L dry bacterial biomass and 1.834 - 1.884 g/L PHA, containing 85.83 - 86.8% PHO, were obtained.

scholarly journals Comparative metabolomics of Phialemonium curvatum as an omnipotent fungus cultivated on crude palm oil versus glucose

2020 ◽  
Vol 19 (1) ◽  
Author(s):  
Arief Izzairy Zamani ◽  
Susann Barig ◽  
Sarah Ibrahim ◽  
Hirzun Mohd. Yusof ◽  
Julia Ibrahim ◽  
...  
Keyword(s):  
Carbon Source ◽  
Organic Acids ◽  
Vegetable Oil ◽  
Carbon Metabolism ◽  
Sole Carbon Source ◽  
Carbon Sources ◽  
Tca Cycle ◽  
Central Carbon Metabolism ◽  
Targeted Metabolomics ◽  
Central Carbon

Abstract Background Sugars and triglycerides are common carbon sources for microorganisms. Nonetheless, a systematic comparative interpretation of metabolic changes upon vegetable oil or glucose as sole carbon source is still lacking. Selected fungi that can grow in acidic mineral salt media (MSM) with vegetable oil had been identified recently. Hence, this study aimed to investigate the overall metabolite changes of an omnipotent fungus and to reveal changes at central carbon metabolism corresponding to both carbon sources. Results Targeted and non-targeted metabolomics for both polar and semi-polar metabolites of Phialemonium curvatum AWO2 (DSM 23903) cultivated in MSM with palm oil (MSM-P) or glucose (MSM-G) as carbon sources were obtained. Targeted metabolomics on central carbon metabolism of tricarboxylic acid (TCA) cycle and glyoxylate cycle were analysed using LC–MS/MS-TripleQ and GC–MS, while untargeted metabolite profiling was performed using LC–MS/MS-QTOF followed by multivariate analysis. Targeted metabolomics analysis showed that glyoxylate pathway and TCA cycle were recruited at central carbon metabolism for triglyceride and glucose catabolism, respectively. Significant differences in organic acids concentration of about 4- to 8-fold were observed for citric acid, succinic acid, malic acid, and oxaloacetic acid. Correlation of organic acids concentration and key enzymes involved in the central carbon metabolism was further determined by enzymatic assays. On the other hand, the untargeted profiling revealed seven metabolites undergoing significant changes between MSM-P and MSM-G cultures. Conclusions Overall, this study has provided insights on the understanding on the effect of triglycerides and sugar as carbon source in fungi global metabolic pathway, which might become important for future optimization of carbon flux engineering in fungi to improve organic acids production when vegetable oil is applied as the sole carbon source.

scholarly journals Host engineering for improved valerolactam production in Pseudomonas putida

2019 ◽  
Author(s):  
Mitchell G. Thompson ◽  
Luis E. Valencia ◽  
Jacquelyn M. Blake-Hedges ◽  
Pablo Cruz-Morales ◽  
Alexandria E. Velasquez ◽  
...  
Keyword(s):  
Metabolic Engineering ◽  
Carbon Source ◽  
Pseudomonas Putida ◽  
Aromatic Compounds ◽  
Sole Carbon Source ◽  
Carbon Sources ◽  
Shotgun Proteomics ◽  
Rich Media ◽  
Amide Hydrolase

ABSTRACTPseudomonas putida is a promising bacterial chassis for metabolic engineering given its ability to metabolize a wide array of carbon sources, especially aromatic compounds derived from lignin. However, this omnivorous metabolism can also be a hindrance when it can naturally metabolize products produced from engineered pathways. Herein we show that P. putida is able to use valerolactam as a sole carbon source, as well as degrade caprolactam. Lactams represent important nylon precursors, and are produced in quantities exceeding one million tons per year[1]. To better understand this metabolism we use a combination of Random Barcode Transposon Sequencing (RB-TnSeq) and shotgun proteomics to identify the oplBA locus as the likely responsible amide hydrolase that initiates valerolactam catabolism. Deletion of the oplBA genes prevented P. putida from growing on valerolactam, prevented the degradation of valerolactam in rich media, and dramatically reduced caprolactam degradation under the same conditions. Deletion of oplBA, as well as pathways that compete for precursors L-lysine or 5-aminovalerate, increased the titer of valerolactam from undetectable after 48 hours of production to ~90 mg/L. This work may serve as a template to rapidly eliminate undesirable metabolism in non-model hosts in future metabolic engineering efforts.

Saccharomyces cerevisiae glucose signalling regulator Mth1p regulates the organellar Na+/H+ exchanger Nhx1p

2010 ◽  
Vol 432 (2) ◽  
pp. 343-352 ◽  
Author(s):  
Keiji Mitsui ◽  
Masafumi Matsushita ◽  
Hiroshi Kanazawa
Keyword(s):  
Saccharomyces Cerevisiae ◽  
Carbon Source ◽  
Sole Carbon Source ◽  
Glucose Sensor ◽  
Ph Regulation ◽  
Gene Knockout ◽  
Carbon Sources ◽  
Acidic Ph ◽  
In Cells

Organelle-localized NHEs (Na+/H+ exchangers) are found in cells from yeast to humans and contribute to organellar pH regulation by exporting H+ from the lumen to the cytosol coupled to an H+ gradient established by vacuolar H+-ATPase. The mechanisms underlying the regulation of organellar NHEs are largely unknown. In the present study, a yeast two-hybrid assay identified Mth1p as a new binding protein for Nhx1p, an organellar NHE in Saccharomyces cerevisiae. It was shown by an in vitro pull-down assay that Mth1p bound to the hydrophilic C-terminal half of Nhx1p, especially to the central portion of this region. Mth1p is known to bind to the cytoplasmic domain of the glucose sensor Snf3p/Rgt2p and also functions as a negative transcriptional regulator. Mth1p was expressed in cells grown in a medium containing galactose, but was lost (possibly degraded) when cells were grown in medium containing glucose as the sole carbon source. Deletion of the MTH1 gene increased cell growth compared with the wild-type when cells were grown in a medium containing galactose and with hygromycin or at an acidic pH. This resistance to hygromycin or acidic conditions was not observed for cells grown with glucose as the sole carbon source. Gene knockout of NHX1 increased the sensitivity to hygromycin and acidic pH. The increased resistance to hygromycin was reproduced by truncation of the Mth1p-binding region in Nhx1p. These results implicate Mth1p as a novel regulator of Nhx1p that responds to specific extracellular carbon sources.

Gordonia (nocardia) amarae foaming due to biosurfactant production

2002 ◽  
Vol 46 (1-2) ◽  
pp. 519-524 ◽  
Author(s):  
K.R. Pagilla ◽  
A. Sood ◽  
H. Kim
Keyword(s):  
Surface Tension ◽  
Carbon Source ◽  
Stationary Phase ◽  
Activated Sludge ◽  
Sole Carbon Source ◽  
Wastewater Treatment Plants ◽  
Carbon Sources ◽  
Biomass Concentration ◽  
Culture Broth ◽  
Biosurfactant Production

Gordonia amarae, a filamentous actinomycete, commonly found in foaming activated sludge wastewater treatment plants was investigated for its biosurfactant production capability. Soluble acetate and sparingly soluble hexadecane were used as carbon sources for G. amarae growth and biosurfactant production in laboratory scale batch reactors. The lowest surface tension (critical micelle concentration, CMC) of the cell-free culture broth was 55 dynes/cm when 1,900 mg/L acetate was used as the sole carbon source. The lowest surface tension was less than 40 dynes/cm when either 1% (v/v) hexadecane or a mixture of 1% (v/v) hexadecane and 0.5% (w/v) acetate was used as the carbon source. The maximum biomass concentration (the stationary phase) was achieved after 4 days when acetate was used along with hexadecane, whereas it took about 8 days to achieve the stationary phase with hexadecane alone. The maximum biosurfactant production was 3 × CMC with hexadecane as the sole carbon source, and it was 5 × CMC with the mixture of hexadecane and acetate. Longer term growth studies (∼ 35 days of culture growth) indicated that G. amarae produces biosurfactant in order to solubilize hexadecane, and that adding acetate improves its biosurfactant production by providing readily degradable substrate for initial biomass growth. This research confirms that the foaming problems in activated sludge containing G. amarae in the activated sludge are due to the biosurfactant production by G. amarae when hydrophobic substrates such as hexadecane are present.

scholarly journals What Is New in the Field of Industrial Wastes Conversion into Polyhydroxyalkanoates by Bacteria?

Polymers ◽  
2021 ◽  
Vol 13 (11) ◽  
pp. 1731
Author(s):  
Paulina Marciniak ◽  
Justyna Możejko-Ciesielska
Keyword(s):  
Food Industry ◽  
Scale Up ◽  
Carbon Sources ◽  
Food Service ◽  
Value Added ◽  
Industrial Wastes ◽  
Recent Developments ◽  
Tremendous Amount ◽  
Pha Production ◽  
The Cost

The rising global consumption and industrialization has resulted in increased food processing demand. Food industry generates a tremendous amount of waste which causes serious environmental issues. These problems have forced us to create strategies that will help to reduce the volume of waste and the contamination to the environment. Waste from food industries has great potential as substrates for value-added bioproducts. Among them, polyhydroxyalkanaotes (PHAs) have received considerable attention in recent years due to their comparable characteristics to common plastics. These biodegradable polyesters are produced by microorganisms during fermentation processes utilizing various carbon sources. Scale-up of PHA production is limited due to the cost of the carbon source metabolized by the microorganisms. Therefore, there is a growing need for the development of novel microbial processes using inexpensive carbon sources. Such substrates could be waste generated by the food industry and food service. The use of industrial waste streams for PHAs biosynthesis could transform PHA production into cheaper and more environmentally friendly bioprocess. This review collates in detail recent developments in the biosynthesis of various types of PHAs produced using waste derived from agrofood industries. Challenges associated with this production bioprocess were described, and new ways to overcome them were proposed.

scholarly journals Production of Polyhydroxyalkanoates (PHA) for Biomedical Application using Sugar Industry Waste and Native Micro Flora via Biphasic System.

2019 ◽  
Vol 7 (4.14) ◽  
pp. 7
Author(s):  
P Paulraj ◽  
S Periyavedi ◽  
K Sajna ◽  
P T Mohamed Javad ◽  
P Sajeesh ◽  
...  
Keyword(s):  
Carbon Source ◽  
Sole Carbon Source ◽  
Biomedical Application ◽  
Sugar Industry ◽  
Cellulolytic Activity ◽  
Bacterial Strains ◽  
Industry Waste ◽  
Research Production ◽  
System A ◽  
The Cost

Plastics are synthetic polymers that changed our daily life due to their applications. But it’s increasing environmental problems had made the researchers find the alternative way such as usage of biodegradable plastics like Polyhydroxyalkanoates (PHA) which has similar properties to the conventional plastic. In this research production and characterization of PHAs using sugar industry wastes as a sole carbon source was carried in order to reduce the cost of production of PHA. Isolation of heterotrophic native micro flora from soil sample contaminated with sugar effluent for amylolytic and cellulolytic activity with PHA production potentials was carried out.  Suitable conditions for PHA accumulation were optimized with 1X and 2X MSM with sugar effluent as a sole carbon source and bacteriostatic antibiotics as an inducer using bi-phasic system. A total of 14 different heterotrophic native bacterial strains were isolated, among them, 4 isolates showed starch hydrolytic property, 7 isolates showed cellulolytic activity and 7 were PHA producers. The strain with the highest PHA accumulation (99.99µg/mL of culture) in 2X MSM with sugar effluent within 6 hours was considered as a potential strain (53% of PHB CWD). The isolate was confirmed as Chryseobacterium Sp. using 16S rRNA sequencing. 

The Influence of Different Carbon Sources for Polyhydroxyalkanoates Storage

2015 ◽  
Vol 1088 ◽  
pp. 587-590
Author(s):  
Yan Ping Zhang
Keyword(s):  
Carbon Source ◽  
Activated Sludge ◽  
Sodium Acetate ◽  
Carbon Sources ◽  
Dry Weight ◽  
Sodium Propionate ◽  
Cell Content ◽  
Pha Production

The influence of different carbon sources such as glucose, sodium acetate, sodium propionate and ethanol for polyhydroxyalkanoates (PHA) storage were studied in details. It was shown that both the cell content and composition of PHA synthesized by microorganisms in activated sludge were different when different carbon sources were used. PHB (polyhydroxybutyrate) was the main PHA if sodium acetate was used as carbon source, while PHV (polydroxyvalerate) become the main PHA when sodium propionate was used. Sodium acetate and sodium propionate as carbon source had higher PHA production, which reached to 40.89% and 40.96% sludge dry weight, respectively . When ethanol used as carbon source, PHA content was 25.69% sludge dry weight. The minimal PHA storage was 20.14% sludge dry weight when glucose was used.

scholarly journals Genetically Modified Strains of Ralstonia eutropha H16 with β-Ketothiolase Gene Deletions for Production of Copolyesters with Defined 3-Hydroxyvaleric Acid Contents

2012 ◽  
Vol 78 (15) ◽  
pp. 5375-5383 ◽  
Author(s):  
Nicole Lindenkamp ◽  
Elena Volodina ◽  
Alexander Steinbüchel
Keyword(s):  
Fatty Acids ◽  
Carbon Source ◽  
Sole Carbon Source ◽  
Ralstonia Eutropha ◽  
Carbon Sources ◽  
Production Capacity ◽  
Wild Type ◽  
Content Type ◽  
Storage Behavior ◽  
Copolymer Poly

ABSTRACTβ-Ketothiolases catalyze the first step of poly(3-hydroxybutyrate) [poly(3HB)] biosynthesis in bacteria by condensation of two acetyl coenzyme A (acetyl-CoA) molecules to acetoacetyl-CoA and also take part in the degradation of fatty acids. During growth on propionate or valerate,Ralstonia eutrophaH16 produces the copolymer poly(3-hydroxybutyrate-co-3-hydroxyvalerate) [poly(3HB-co-3HV)]. InR. eutropha, 15 β-ketothiolase homologues exist. The synthesis of 3-hydroxybutyryl-CoA (3HB-CoA) could be significantly reduced in an 8-fold mutant (Lindenkamp et al., Appl. Environ. Microbiol. 76:5373–5382, 2010). In this study, a 9-fold mutant deficient in nine β-ketothiolase gene homologues (phaA,bktB, H16_A1713, H16_B1771, H16_A1528, H16_B0381, H16_B1369, H16_A0170, andpcaF) was generated. In order to examine the polyhydroxyalkanoate production capacity when short- or long-chain and even- or odd-chain-length fatty acids were provided as carbon sources, the growth and storage behavior of several mutants from the previous study and the newly generated 9-fold mutant were analyzed. Propionate, valerate, octanoate, undecanoic acid, or oleate was chosen as the sole carbon source. On octanoate, no significant differences in growth or storage behavior were observed between wild-typeR. eutrophaand the mutants. In contrast, during the growth on oleate of a multiple mutant lackingphaA,bktB, and H16_A0170, diminished poly(3HB) accumulation occurred. Surprisingly, the amount of accumulated poly(3HB) in the multiple mutants grown on gluconate differed; it was much lower than that on oleate. The β-ketothiolase activity toward acetoacetyl-CoA in H16ΔphaAand all the multiple mutants remained 10-fold lower than the activity of the wild type, regardless of which carbon source, oleate or gluconate, was employed. During growth on valerate as a sole carbon source, the 9-fold mutant accumulated almost a poly(3-hydroxyvalerate) [poly(3HV)] homopolyester with 99 mol% 3HV constituents.

Sign in / Sign up

Export Citation Format

Share Document