scholarly journals Pretreatment of Cottage Cheese to Enhance Biogas Production

2014 ◽  
Vol 2014 ◽  
pp. 1-6 ◽  
Author(s):  
Vidhya Prabhudessai ◽  
Bhakti Salgaonkar ◽  
Judith Braganca ◽  
Srikanth Mutnuri
Keyword(s):  
Food Waste ◽  
Methane Production ◽  
Hydraulic Retention Time ◽  
Biogas Production ◽  
Methane Yield ◽  
Cottage Cheese ◽  
Thermal Pretreatment ◽  
Enzyme Systems ◽  
Protease Enzyme ◽  
Single Enzyme

This study evaluated the possibility of pretreating selected solid fraction of an anaerobic digester treating food waste to lower the hydraulic retention time and increase the methane production. The study investigated the effect of different pretreatments (thermal, chemical, thermochemical and enzymatic) for enhanced methane production from cottage cheese. The most effective pretreatments were thermal and enzymatic. Highest solubilisation of COD was observed in thermal pretreatment, followed by thermochemical. In single enzyme systems, lipase at low concentration gave significantly higher methane yield than for the experiments without enzyme additions. The highest lipase dosages decreased methane yield from cottage cheese. However, in case of protease enzyme an increase in concentration of the enzyme showed higher methane yield. In the case of mixed enzyme systems, pretreatment at 1 : 2 ratio of lipase : protease showed higher methane production in comparison with 1 : 1 and 2 : 1 ratios. Methane production potentials for different pretreatments were as follows: thermal 357 mL/g VS, chemical 293 mL/g VS, and thermochemical 441 mL/g VS. The average methane yield from single enzyme systems was 335 mL/g VS for lipase and 328 mL/g VS for protease. Methane potentials for mixed enzyme ratios were 330, 360, and 339 mL/g VS for 1 : 1, 1 : 2, and 2 : 1 lipase : protease, respectively.

Study on Solid-State Anaerobic Co-Digestion with Distiller’s Grains and Food Waste for Methane Production

2012 ◽  
Vol 485 ◽  
pp. 306-309
Author(s):  
Li Hong Wang ◽  
Qun Hui Wang ◽  
Wei Wei Cai
Keyword(s):  
Anaerobic Digestion ◽  
Solid State ◽  
Synergistic Effect ◽  
Food Waste ◽  
Methane Production ◽  
Waste Treatment ◽  
Biogas Production ◽  
Methane Yield ◽  
Kitchen Waste ◽  
Distiller's Grains

Solid-state anaerobic digestion (SSAD) of distiller’s grains (DG) and kitchen waste (KW) for biogas was investigated. Six DG to KW ratios of 10/1, 8/1, 6/1, 4/1, 1/0, and 0/1 was used. The results showed that in 48 digestion days the co-digestion with DG to KW ratio of 8:1 obtained the highest methane yield of 159.74mL/gTS, TS and VS reductions of 58.7% and 71.8%, hemicellulase, cellulose and lignin reductions of 46.7%, 45.4% and 4.0%. Compared to mono-digestions of DG or KW, co-digestion of DG and FW had a good synergistic effect. It indicated that SSAD of cellulosic-based waste and food waste could be one of the options for efficient biogas production and waste treatment

scholarly journals Pretreatment of Animal Manure Biomass to Improve Biogas Production: A Review

Energies ◽  
2020 ◽  
Vol 13 (14) ◽  
pp. 3573 ◽  
Author(s):  
Meneses-Quelal Orlando ◽  
Velázquez-Martí Borja
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Biogas Production ◽  
Poultry Manure ◽  
Animal Manure ◽  
Methane Yield ◽  
Operational Parameters ◽  
Advantages And Disadvantages ◽  
Physical Chemical ◽  
Chemical Pretreatments

The objective of this research is to present a review of the current technologies and pretreatments used in the fermentation of cow, pig and poultry manure. Pretreatment techniques were classified into physical, chemical, physicochemical, and biological groups. Various aspects of these different pretreatment approaches are discussed in this review. The advantages and disadvantages of its applicability are highlighted since the effects of pretreatments are complex and generally depend on the characteristics of the animal manure and the operational parameters. Biological pretreatments were shown to improve methane production from animal manure by 74%, chemical pretreatments by 45%, heat pretreatments by 41% and physical pretreatments by 30%. In general, pretreatments improve anaerobic digestion of the lignocellulosic content of animal manure and, therefore, increase methane yield.

scholarly journals Evaluation on the Methane Production Potential of Wood Waste Pretreated with NaOH and Co-Digested with Pig Manure

Catalysts ◽  
2019 ◽  
Vol 9 (6) ◽  
pp. 539 ◽  
Author(s):  
Renfei Li ◽  
Wenbing Tan ◽  
Xinyu Zhao ◽  
Qiuling Dang ◽  
Qidao Song ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Lignocellulosic Biomass ◽  
Methane Production ◽  
Biogas Production ◽  
Untreated Wood ◽  
Wood Waste ◽  
Methane Yield ◽  
Pig Manure ◽  
Naoh Pretreatment ◽  
Digestion Technique

Wood waste generated during the tree felling and processing is a rich, green, and renewable lignocellulosic biomass. However, an effective method to apply wood waste in anaerobic digestion is lacking. The high carbon to nitrogen (C/N) ratio and rich lignin content of wood waste are the major limiting factors for high biogas production. NaOH pre-treatment for lignocellulosic biomass is a promising approach to weaken the adverse effect of complex crystalline cellulosic structure on biogas production in anaerobic digestion, and the synergistic integration of lignocellulosic biomass with low C/N ratio biomass in anaerobic digestion is a logical option to balance the excessive C/N ratio. Here, we assessed the improvement of methane production of wood waste in anaerobic digestion by NaOH pretreatment, co-digestion technique, and their combination. The results showed that the methane yield of the single digestion of wood waste was increased by 38.5% after NaOH pretreatment compared with the untreated wood waste. The methane production of the co-digestion of wood waste and pig manure was higher than that of the single digestion of wood waste and had nonsignificant difference with the single-digestion of pig manure. The methane yield of the co-digestion of wood waste pretreated with NaOH and pig manure was increased by 75.8% than that of the untreated wood waste. The findings indicated that wood waste as a sustainable biomass source has considerable potential to achieve high biogas production in anaerobic digestion.

scholarly journals Optimisation of C:N Ratio for Co-Digested Processed Industrial Food Waste and Sewage Sludge Using the BMP Test

2011 ◽  
Vol 9 (1) ◽  
Author(s):  
Zuhaib Siddiqui ◽  
N.J. Horan ◽  
Kofi Anaman
Keyword(s):  
Sewage Sludge ◽  
Food Waste ◽  
Biogas Production ◽  
C:N Ratio ◽  
Methane Yield ◽  
Biochemical Methane Potential ◽  
Volatile Solids ◽  
Methane Potential ◽  
Biomethane Production ◽  
Bmp Test

Biomethane production from processed industrial food waste (IFW) in admixture with sewage sludge (primary and waste activated sludge: PS and WAS) was evaluated at a range of C:N ratios using a standard biochemical methane potential (BMP) test. IFW alone had a C:N of 30 whereas for WAS it was 5.4 and thus the C:N ratio of the blends fell in that range. Increasing the IFW content in mix improves the methane potential by increasing both the cumulative biogas production and the rate of methane production. Optimum methane yield 239 mL/g VSremoved occurred at a C:N ratio of 15 which was achieved with a blend containing 11 percent (w/w) IFW. As the fraction of IFW in the blend increased, volatile solids (VS) destruction was increased and this led to a reduction in methane yield and amount of production. The highest destruction of volatile solids of 93 percent was achieved at C:N of 20 followed by C:N 30 and 15. A shortened BMP test is adequate for evaluating optimum admixtures.

scholarly journals The Influence of Pressure-Swing Conditioning Pre-Treatment of Cattle Manure on Methane Production

2019 ◽  
Vol 7 (1) ◽  
pp. 6 ◽  
Author(s):  
Britt Schumacher ◽  
Timo Zerback ◽  
Harald Wedwitschka ◽  
Sören Weinrich ◽  
Josephine Hofmann ◽  
...  
Keyword(s):  
Methane Production ◽  
Fossil Fuels ◽  
Biogas Production ◽  
Cattle Manure ◽  
Methane Yield ◽  
Batch Tests ◽  
Pre Treatment ◽  
Pressure Swing ◽  
C 30 ◽  
Kinetic Calculations

Cattle manure is an agricultural residue, which could be used as source to produce methane in order to substitute fossil fuels. Nevertheless, in practice the handling of this slowly degradable substrate during anaerobic digestion is challenging. In this study, the influence of the pre-treatment of cattle manure with pressure-swing conditioning (PSC) on the methane production was investigated. Six variants of PSC (combinations of duration 5 min, 30 min, 60 min and temperature 160 °C, 190 °C) were examined with regards to methane yield in batch tests. PSC of cattle manure showed a significant increase up to 109% in the methane yield compared to the untreated sample. Kinetic calculations proved also an enhancement of the degradation speed. One PSC-variant (190 °C/30 min) and untreated cattle manure were chosen for comparative fermentation tests in continuously stirred tank reactors (CSTR) in lab-scale with duplicates. In the continuous test a biogas production of 428 mL/g volatile solids (VS) (54.2% methane) for untreated manure was observed and of 456 mL/g VS (53.7% methane) for PSC-cattle-manure (190 °C/30 min). Significant tests were conducted for methane yields of all fermentation tests. Furthermore, other parameters such as furfural were investigated and discussed.

scholarly journals EFFECT OF ORGANIC LOADING RATE ON THE PERFORMANCE OF ANAEROBIC CO-DIGESTION DIGESTER TREATING FOOD WASTE AND SLUDGE WASTE

2018 ◽  
Vol 56 (2A) ◽  
pp. 37-42
Author(s):  
Dinh Thi Nga
Keyword(s):  
Production Rate ◽  
Food Waste ◽  
Loading Rate ◽  
Biogas Production ◽  
Methane Yield ◽  
Organic Loading Rate ◽  
Organic Loading ◽  
Working Volume ◽  
Sludge Waste ◽  
Biogas Production Rate

This research was carried out to evaluate the effect of organic loading rate to the performance of anaerobic co-digestion digester treating organic fraction of food waste (FW) and sludge waste (SW) from wastewater treatment plant. The experiment was conducted in two runs: Run S50, substrate contained 50 % of FW and 50 % of SW in term of volatile solid (VS) concentration; Run S100 (control run) contained 100 % SW in the influent substrate. The experiment was performed in a 3L working volume reactor at ambient temperature with three levels of organic loading rate (OLR) as 2; 4; 6 kgVS/m3/day, the duration of experiment was 18 days for each level of OLR. As results, the average of biogas production rate (BPR) at OLR 2;4;6 kgVS/m3/day,in Run S50 and Run S100 was 390 – 520;  860 – 1220; 1140 - 2440 ml/day and 160 – 300; 560 – 640; 700 - 1400 ml/day, respectively. The maximum methane yield (mlCH4/gVSadded/day) of organic loading rate 2; 4; 6 kgVS/m3/day was 118.96; 326.49; 628.20 for Run S50 and; 58.28; 160.27; 255.54 for Run S100, respectively. In conclusion, Run S50 always produced higher biogas production rate and higher methane yield at all 3 OLR levels. The higer OLR could enhance BPR and methane yield but at OLR 6 kgVS/m3/day made unstable performance and high concentration of COD in the effluent. Therefore, in this experimental conditions it has better operation at OLR under 6 kgVS/m3/day for the stable performance of reactors.

scholarly journals Strategies to Optimize Microalgae Conversion to Biogas: Co-Digestion, Pretreatment and Hydraulic Retention Time

Molecules ◽  
2018 ◽  
Vol 23 (9) ◽  
pp. 2096 ◽  
Author(s):  
Maria Solé-Bundó ◽  
Humbert Salvadó ◽  
Fabiana Passos ◽  
Marianna Garfí ◽  
Ivet Ferrer
Keyword(s):  
Retention Time ◽  
Cell Walls ◽  
Hydraulic Retention Time ◽  
Microscopic Analysis ◽  
Fold Increase ◽  
Resistant Cell ◽  
Methane Yield ◽  
Thermal Pretreatment ◽  
Primary Sludge ◽  
Yield Increase

This study aims at optimizing the anaerobic digestion (AD) of biomass in microalgal-based wastewater treatment systems. It comprises the co-digestion of microalgae with primary sludge, the thermal pretreatment (75 °C for 10 h) of microalgae and the role of the hydraulic retention time (HRT) in anaerobic digesters. Initially, a batch test comparing different microalgae (untreated and pretreated) and primary sludge proportions showed how the co-digestion improved the AD kinetics. The highest methane yield was observed by adding 75% of primary sludge to pretreated microalgae (339 mL CH4/g VS). This condition was then investigated in mesophilic lab-scale reactors. The average methane yield was 0.46 L CH4/g VS, which represented a 2.9-fold increase compared to pretreated microalgae mono-digestion. Conversely, microalgae showed a low methane yield despite the thermal pretreatment (0.16 L CH4/g VS). Indeed, microscopic analysis confirmed the presence of microalgae species with resistant cell walls (i.e., Stigioclonium sp. and diatoms). In order to improve their anaerobic biodegradability, the HRT was increased from 20 to 30 days, which led to a 50% methane yield increase. Overall, microalgae AD was substantially improved by the co-digestion with primary sludge, even without pretreatment, and increasing the HRT enhanced the AD of microalgae with resistant cell walls.

scholarly journals Performance and Kinetic Model of a Single-Stage Anaerobic Digestion System Operated at Different Successive Operating Stages for the Treatment of Food Waste

Processes ◽  
2019 ◽  
Vol 7 (9) ◽  
pp. 600 ◽  
Author(s):  
Sagor Kumar Pramanik ◽  
Fatihah Binti Suja ◽  
Mojtaba Porhemmat ◽  
Biplob Kumar Pramanik
Keyword(s):  
Experimental Data ◽  
Anaerobic Digestion ◽  
Kinetic Model ◽  
Removal Efficiency ◽  
Food Waste ◽  
Biogas Production ◽  
Gompertz Model ◽  
Methane Yield ◽  
Biogas Yield ◽  
Modified Gompertz Model

A large quantity of food waste (FW) is generated annually across the world and results in environmental pollution and degradation. This study investigated the performance of a 160 L anaerobic biofilm single-stage reactor in treating FW. The reactor was operated at different hydraulic retention times (HRTs) of 124, 62, and 35 days under mesophilic conditions. The maximum biogas and methane yield achieved was 0.934 L/g VSadded and 0.607 L CH4/g VSadded, respectively, at an HRT of 124 days. When HRT decreased to 62 days, the volatile fatty acid (VFA) and ammonia accumulation increased rapidly whereas pH, methane yield, and biogas yield decreased continuously. The decline in biogas production was likely due to shock loading, which resulted in scum accumulation in the reactor. A negative correlation between biogas yield and volatile solid (VS) removal efficiency was also observed, owing to the floating scum carrying and urging the sludge toward the upper portion of the reactor. The highest VS (79%) and chemical oxygen demand (COD) removal efficiency (80%) were achieved at an HRT of 35 days. Three kinetic models—the first-order kinetic model, the modified Gompertz model, and the logistic function model—were used to fit the cumulative biogas production experimental data. The kinetic study showed that the modified Gompertz model had the best fit with the experimental data out of the three models. This study demonstrates that the stability and performance of the anaerobic digestion (AD) process, namely biogas production rate, methane yield, intermediate metabolism, and removal efficiency, were significantly affected by HRTs.

scholarly journals Multicriteria Decision Model and Thermal Pretreatment of Hotel Food Waste for Robust Output to Biogas: Case Study from City of Jaipur, India

2018 ◽  
Vol 2018 ◽  
pp. 1-13 ◽  
Author(s):  
Paras Gandhi ◽  
Kunwar Paritosh ◽  
Nidhi Pareek ◽  
Sanjay Mathur ◽  
Javier Lizasoain ◽  
...  
Keyword(s):  
Food Waste ◽  
Biogas Production ◽  
Linear Trend ◽  
Logistic Models ◽  
Multicriteria Decision Making ◽  
Thermal Pretreatment ◽  
Multicriteria Decision ◽  
Biogas Yield ◽  
Volatile Solids ◽  
Decision Making Model

The anaerobic batch test (45 days at 37°C) was performed to describe the effect of thermal pretreatment at moderate temperatures (60, 80, and 100°C) over durations of 10 and 20 minutes on the enhancement of biogas production using hotel food waste from city of Jaipur, India. The results showed that the total cumulative biogas production with thermal pretreatment (100°C, 10 minutes) was 41% higher than the control. Also, this alternative gets first rank using multicriteria decision making model, VIKOR. This outcome was obtained due to the enhancement of degradation of organic compounds such as protein and volatile solids that occurred in the linear trend. Modified Gompertz and Logistic models were used to study the effect of different pretreatment parameters on lag time and biogas yield. Scanning electron microscopy and Fourier transform infrared spectroscopy were also employed to investigate the effect of thermal pretreatment on the physiochemical properties of food waste.

Anaerobic Co-Digestion of Food Waste and Thermal Pretreated Waste Activated Sludge: Synergetic Effect and Energy Assessment

2021 ◽  
Author(s):  
Jian Zhang ◽  
Peng Gan ◽  
Ru-yi Wang ◽  
Tian Xie ◽  
Yang Liu ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Food Waste ◽  
Methane Production ◽  
Synergetic Effect ◽  
Gompertz Model ◽  
Waste Activated Sludge ◽  
Thermal Pretreatment ◽  
Energy Assessment ◽  
Modified Gompertz Model

Abstract Thermal pretreatment was an effective method to improve the anaerobic digestion of waste activated sludge. However its application in China was still hindered by the high energy demand. In order to balance the energy consumption of sludge thermal pretreatment integrated with anaerobic digestion, food waste was introduced as co-substrate to achieve an energy self-sustainable sludge treatment system. Anaerobic biodegradability test was performed using thermal pretreated sludge and food waste in order to clarify the kinetics and mechanism of co-digestion, especially the synergetic effect on specific methane yield. The prominent synergetic effect was an initial acceleration of cumulative methane production by 20.7- 23.8% observed during the first 15 days, and the cumulative methane production of feedstock can be calculated proportionately from its composition. Between the evaluated models, modified Gompertz model presented a better agreement of the experimental results and it was able to describe the synergetic effect, assessed by the relative deviation between theoretical estimation and the experimental results of co-digestion tests. This feature made modified Gompertz model a suitable tool for methane production prediction of mono- and co-digestion. Energy assessment shown that co-digestion with food waste was a sustainable solution to maintain the integration of thermal pretreatment and anaerobic digestion energy neutral or even positive. Besides, the performance of sludge dewatering was a crucial factor for the energy balance.

Sign in / Sign up

Export Citation Format

Share Document