An improved method for canning 3-fold concentrated whole milk

1970 ◽  
Vol 37 (3) ◽  
pp. 505-511 ◽  
Author(s):  
P. W. Board ◽  
J. T. Mullett
Keyword(s):  
Raw Milk ◽  
Improved Method ◽  
Organoleptic Properties ◽  
Total Solids ◽  
Whole Milk

SummaryA method is described for canning and sterilizing concentrated whole milk containing 36·5% total solids. The product had acceptable organoleptic properties and did not form sediment or undergo age-thickening during storage. The method involved initially increasing the pH of the raw milk and forewarming. The product was not homogenized nor were polyphosphates added.

scholarly journals Mixing sweet cream buttermilk with whole milk to produce cream cheese

2015 ◽  
Vol 54 (2) ◽  
pp. 73-78 ◽  
Author(s):  
Masoud Bahrami ◽  
Dariush Ahmadi ◽  
Faranak Beigmohammadi ◽  
Fakhrisadat Hosseini
Keyword(s):  
Statistical Analysis ◽  
Chemical Composition ◽  
Membrane Protein ◽  
Milk Fat ◽  
Dry Matter ◽  
Skim Milk ◽  
Organoleptic Properties ◽  
Cream Cheese ◽  
Total Solids ◽  
Whole Milk

Abstract Buttermilk is an important by-product of the manufacture of butter. Sweet-cream buttermilk (SCBM) is similar in composition to skim milk, except for its high phospholipid and milk fat globular membrane protein content. The main objective of this investigation was to produce optimum quality cream cheese by replacing whole milk with different proportions of SCBM (5, 10, 15, 20, 25, 30, 35, 40, 45, and 50%). Statistical analysis showed that there were significant differences (p < 0.05) between the chemical and organoleptic properties of the samples. As the percentage of SCBM increased, the chemical composition of total solids, fat, protein, fat in dry matter (FDM) and ash of cheese milk decreased significantly, leading to a softer, moister curd. Samples prepared with more than 25% SCBM were not acceptable to the taste panel. The cream cheeses prepared using 25% and 30% SCBM had the highest yields. Total solids and FDM were strong predictors of cheese yield (r2 ≈ 0.589). The results also showed that the best range for replacement using SCBM is 20–25%.

scholarly journals Uses of milk in sweetmeat shops and consumer preferences to milk products at Mymensingh municipality in Bangladesh

2016 ◽  
Vol 2 (2) ◽  
pp. 266-273
Author(s):  
ABM Kawsar Ahmed ◽  
Md Rezwanul Habib ◽  
Samia Afrin ◽  
Mohammad Ashiqul Islam ◽  
Md Harun Ur Rashid
Keyword(s):  
Data Analysis ◽  
Shelf Life ◽  
Distribution Pattern ◽  
Statistical Methods ◽  
Consumer Preferences ◽  
Raw Milk ◽  
Milk Products ◽  
Whole Milk ◽  
Significant Difference ◽  
Research Findings

The work has been designed to investigate the utilization of milk for consumption of fluid milk and milk products, their distribution pattern, pricing, shelf life and consumer’s preference of Mymensingh municipality in Bangladesh. The study was based on milk and milk products and data were collected from the selected sweetmeat shops by direct interview, of which 20 samples were collected from sweetmeat shops and 7 from goalas. Both tabular and statistical methods were used for collected data analysis. Shopkeepers of different sweetmeat shops received raw milk from farmers (52.6%) and goalas (47.4%) and the highest amount of whole milk was required in per unit production of rasomalai (21%) and ghee (18%) whereas the lowest amount in chomchom (9%). Milk products prices were not remained same throughout the year in this municipality due to fluctuation of raw milk availability and their price. Eid, Puja festivals and other educational activities results that may increase milk products selling especially rasogolla and kalojam. Research findings also showed non-significant difference in case of pricing, distribution pattern, shelf life and selling of milk and milk products following sweetmeats.Asian J. Med. Biol. Res. June 2016, 2(2): 266-273

Comparison of Two Methods for Determination of Total Solids Content of Milk: Collaborative Study

1989 ◽  
Vol 72 (5) ◽  
pp. 712-718 ◽  
Author(s):  
Jenny L Clark ◽  
David M Barbano ◽  
Chapman E Dunham
Keyword(s):  
Collaborative Study ◽  
Raw Milk ◽  
Preliminary Evaluation ◽  
Oven Method ◽  
Total Solids ◽  
Relative Standard ◽  
Aoac Method ◽  
Standard Deviations ◽  
Forced Air ◽  
Solids Content

Abstract Ten laboratories analyzed 9 pairs of blind duplicate raw milk samples for total solids. A direct forced air oven method (4 h at 100°C) and a modification of the AOAC predry method (16.032) were used. Preliminary evaluation of the modified AOAC method indicated that blank determinations were necessary. Total solids content ranged from 12.0 to 14.6%. Average repeatability standard deviations (sr) of the direct forced air oven and modified AOAC methods were 0.019 and 0.017, respectively. Average reproducibility standard deviations (SR) of the direct forced air oven and the modified AOAC methods were 0.042 and 0.047, respectively. Average repeatability relative standard deviations (RSDr) for the direct forced air oven and the modified AOAC methods were 0.149 and 0.136%, respectively; average reproducibility relative standard deviations (RSDR) were 0.327 and 0.370%, respectively. Mean repeatability values (r) and reproducibility values (R) were 0,054 and 0.118 for the direct forced air oven method and 0.049 and 6.133 for the modified AOAC method, respectively. The mean test result of the direct forced air oven method (12.7293%) was comparable to that for the modified AOAC method (12.7273%). The modification of AOAC method 16.032 and the direct forced air oven method have been approved interim official first action.

Thermal Resistance of Listeria monocytogenes Scott A in Ultrafiltered Milk as Related to the Effect of Different Milk Components

2010 ◽  
Vol 73 (11) ◽  
pp. 2110-2115 ◽  
Author(s):  
KINGA SZLACHTA ◽  
SUSANNE E. KELLER ◽  
ARLETTE SHAZER ◽  
STUART CHIRTEL
Keyword(s):  
Listeria Monocytogenes ◽  
Thermal Resistance ◽  
Milk Fat ◽  
Milk Powder ◽  
Skim Milk ◽  
Skim Milk Powder ◽  
Single Measure ◽  
Total Solids ◽  
Whole Milk ◽  
Milk Components

Pasteurization parameters for grade A milk are well established and set by regulation. However, as solids levels increase, an increased amount of heat is required to destroy any pathogens present. This effect is not well characterized. In this work, the effect of increased dairy solids levels on the thermal resistance of Listeria monocytogenes was examined through the use of ultrafiltered (UF) milk, reconstituted milk powder, and the milk components lactose and caseinate. From the results obtained, lactose and caseinate did not appear to affect thermal resistance. In addition, the level of milk fat, up to 10% of the total solids in UF whole milk, did not result in statistically significant changes to thermal resistance when compared with UF skim milk. Reconstituted skim milk powder at 27% total solids (D62-value = 1.16 ± 0.2 [SD] min, z = 5.7) did result in increased thermal resistance, as compared with reconstituted skim milk powder at 17.5% (D62-value = 0.86 ± 0.02 min, z = 5.57) and UF whole milk at 27% total solids (D62-value = 0.66 ± 0.07 min, z = 5.16). However, that increase appeared to be due to the increase in salt levels, not to increases in caseinate, fat, or lactose. Consequently, total solids, as a single measure, could not be used to predict increased thermal resistance of L. monocytogenes in concentrated milk.

Fluorometric Analysis of Alkaline Phosphatase in Fluid Dairy Products

1990 ◽  
Vol 53 (7) ◽  
pp. 588-591 ◽  
Author(s):  
RICHARD M. ROCCO
Keyword(s):  
Alkaline Phosphatase ◽  
Dairy Products ◽  
Raw Milk ◽  
Test Sample ◽  
Reaction Rates ◽  
Product Formation ◽  
Test Time ◽  
Whole Milk ◽  
Repeated Analysis ◽  
Total Test Time

A new quantitative assay has been developed for measuring residual alkaline phosphatase (ALP) activity in a wide variety of dairy products including whole milk, low fat and skim milks, chocolate milk, and creams. ALP in the test sample hydrolyzes a nonfluorescent substrate, FluorophosR, to a highly fluorescent product. Product formation is monitored continuously during a short incubation period and enzyme activity is calculated from the rate of fluorescence increase. Total test time is 3 min. Reaction rates are linear up to 0.5% raw milk (equivalent to 5 μg phenol/ml/15 min) with a detection limit of 0.006% raw milk. Within and between run precision of the fluorometric method was assessed by repeated analysis of a pasteurized milk sample containing added mixed herd raw milk. The within run (N=10) mean was 190.4 mU/L, standard deviation (SD) 3.2, and a coefficient of variance (CV) of 1.7%. The procedure provides a rapid, sensitive, precise, and easy-to-use ALP assay, applicable to a wide variety of dairy products.

Fluorometric Determination of Alkaline Phosphatase in Fluid Dairy Products: Collaborative Study

1990 ◽  
Vol 73 (6) ◽  
pp. 842-849 ◽  
Author(s):  
Richard M Rocco
Keyword(s):  
Alkaline Phosphatase ◽  
Dairy Products ◽  
Collaborative Study ◽  
Skim Milk ◽  
Raw Milk ◽  
Chocolate Milk ◽  
Phenyl Phosphate ◽  
Whole Milk ◽  
Standard Deviations

Abstract Official methods for the measurement of alkaline phosphatase (ALP) in dairy products use either phenyl phosphate or phenolphthaleln monophosphate as substrate. Quantitation of results requires butanol extraction of the Indophenol (Scharer) or 3-h dialysis of the liberated phenolphthaleln (Rutgers). The Advanced Fluorophos® assay Is based on a self-indicating substrate which, when acted upon by ALP, loses a phosphate radical and becomes a highly fluorescent compound. The rate of fluorophore formation Is monitored for 3 mln In a fluorometer and the enzyme activity In mU/L Is calculated. Eight laboratories participated in a collaborative study to evaluate the Fluorophos® assay for determining ALP activity In whole milk, skim milk, chocolate milk, and cream (half and half). The comparative method was the AOAC quantitative phenyl phosphate method, 16.121-16.122 (14th Ed.). Mixed herd raw milk was added to pasteurized samples at 0.05, 0.1, and 0.2% (v/v). Method performance at 0.1% (v/v) added raw milk as measured by repeatability and reproducibility standard deviations (sr and sR) and relative standard deviations (RSDr and RSDR), respectively, were: whole milk, sr = 21.7%, sR = 34.6%, RSDr = 4.4%, RSDR = 7.0%; skim milk, sr = 19.2%, sR = 31.4%, RSDr = 3.8%, RSDR = 6.2%; chocolate milk, sr = 27.6%, sR = 45.8%, RSDr = 5.3%, RSDR = 8.8%. The method has been adopted official first action by AOAC for determination of alkaline phosphatase in whole milk, skim milk, and chocolate milk.

Detailed fatty acid profile of milk, cheese, ricotta and by products, from cows grazing summer highland pastures

2017 ◽  
Vol 84 (3) ◽  
pp. 329-338 ◽  
Author(s):  
Matteo Bergamaschi ◽  
Giovanni Bittante
Keyword(s):  
Fatty Acid ◽  
De Novo ◽  
Raw Milk ◽  
Two Dimensional ◽  
Bulk Milk ◽  
Whole Milk ◽  
Fresh Cheese ◽  
Skimmed Milk ◽  
Morning Milk ◽  
By Products

In this research two-dimensional GC was used to analyse, for the first time, the detailed fatty acid (FA) profiles of 11 dairy matrices: raw milk (evening whole, evening partially skimmed, morning whole, and vat milk), cream, fresh cheese, whey, ricotta, scotta, 6- and 12-month-ripened cheeses, obtained across artisanal cheese- and ricotta-making trials carried out during the summer period while cows were on highland pastures. Samples were collected during 7 cheese- and ricotta-making procedures carried out at 2-week intervals from bulk milk to study possible differences in the transfer and modification of FA. Compared with morning milk, evening milk had fewer de novo synthetised FA. The detailed FA profile of partially skimmed milk differed little from that of evening whole milk before skimming, but the cream obtained differed from partially skimmed milk and from fresh cheese in about half the FA, due mainly to higher contents of all de novo FA, and lower contents of n-3 and n-6 FA. Fresh cheese and whey had similar FA profiles. The ricotta manufacturing process affected the partition of FA between ricotta and scotta, the FA profile of the latter differing in terms of groups and individual FA from the former, whereas ricotta and fresh cheese had similar composition of FA. In general, there was an increase in medium-chain saturated FA, and a decrease in many polyunsaturated FA during the first 6 months of ripening, but not during the second 6 months. Two-dimensional GC yielded a very detailed and informative FA profile on all the 11 dairy products and by-products analysed.

Interactions between the bovine milk fat globule membrane and skim milk components on heating whole milk

1992 ◽  
Vol 59 (2) ◽  
pp. 187-195 ◽  
Author(s):  
Avis V. Houlihan ◽  
Philippa A. Goddard ◽  
Stephen M. Nottingham ◽  
Barry J. Kitchen ◽  
Colin J. Masters
Keyword(s):  
Milk Fat ◽  
Bovine Milk ◽  
Skim Milk ◽  
Milk Proteins ◽  
Raw Milk ◽  
Membrane Lipid ◽  
Milk Fat Globule Membrane ◽  
Whole Milk ◽  
Milk Fat Globule ◽  
Fat Globule

SummaryHeating raw milk at 80 °C for 2·5–20 min was found to result in compositional changes in the milk fat globule membrane (MFGM). The yield of protein material increased with the duration of heating, owing to incorporation of skim milk proteins, predominantly β-lactoglobulin, into the membrane. Lipid components of the MFGM were also affected, with losses of triacylglycerols on heating.

scholarly journals Compositional aspects and bacteriological quality of camel milk from Tunisian oasis

2021 ◽  
Author(s):  
Khaldi Zahran ◽  
Nafti Mounir ◽  
Jilani Tabarek
Keyword(s):  
Chemical Composition ◽  
Raw Milk ◽  
Fat Content ◽  
Physical Characteristics ◽  
Total Solids ◽  
Age Class ◽  
Quality Aspects ◽  
Mineral Concentrations ◽  
The Impact

Abstract This study was planned to investigate the raw milk characteristics and quality aspects and to evaluate the impact of nongenetic factors on physicochemical composition and microbial quality of milk from local Maghrebi camels (Camelus dromedarius) kept under a traditional system in oasis areas, southern west, Tunisia. Forty-nine individual milk samples were collected from lactating Negga over two periods of the year (winter and summer). Animals belonging to private flocks were between 5 and 17.5 years of age, with parity numbers ranging from first to sixth. Samples were analyzed for physical parameters, chemical composition, mineral concentrations, and microbiological features according to standard methods. The overall means of physical characteristics were 6.63 ± 0.22, 1030.63 ± 2.54, and 19.11 ± 4.08 for pH, density, and acidity, respectively. No significant association (P > 0.05) between physical characteristics and nongenetic factors has been observed. The average results of chemical composition for dry matter, protein, fat, casein, lactose, ash, and casein/protein ratio were 115.24±15.67g/L, 30.98±6.40 g/L, 32.84±4.88 g/L, 22.77±4.27 g/L, 37.21±4.64 g/L, 6.87±1.59 g/L, and 0.74±0.06 g/L respectively. Season, parity, and age were confirmed to impinge significantly on chemical components, except for lactose. The maximum contents of total solids, protein, casein, and fat content were observed during winter. The third lactation was characterized with the highest content of total solids, protein, casein, and lactose; while the highest fat content was recorded in the second lactation. Lactose content was stable throughout all the studied age classes (P > 0.05), whereas the other chemical constituents, showed an obvious superiority in the age class of 7≤ age ≤ 9 years. Season, parity, and age of the animal exerted a significant effect on all minerals. The highest levels of Ca, P, and K were recorded in the winter (P<0.01) whereas Na showed an opposite pattern and was higher in the summer (P<0.01). All major minerals were higher in milk from multiparous than primiparous camels, with maximum concentrations at the fourth lactation. The uppermost levels of mineral concentrations were recorded in the age class of 7≤ age ≤ 9 years. The lowest ones were those of animals over 12 years old. The microbial analysis of raw milk which is affected by season, parity, and age showed higher overall contamination levels in all studied bacterial counts. The highest levels were observed in winter, among the multiparous and oldest Negga. The results highlighted the complete absence of the two dangerous pathogens Salmonella and CSR in all analyzed samples.

Sign in / Sign up

Export Citation Format

Share Document