scholarly journals Studies on drying characteristics and techno-economic analysis of sprouted moth beans (Vigna aconitifolia) in solar tunnel dryer

2019 ◽  
Author(s):  
C. M Badgujar ◽  
O. S. Karpe ◽  
S. R. Kalbande
Keyword(s):  
Moisture Content ◽  
Economic Analysis ◽  
Initial Moisture Content ◽  
Cost Benefit ◽  
Maximum Temperature ◽  
Drying Time ◽  
Sun Drying ◽  
Tunnel Dryer ◽  
Present Worth ◽  
Drying Efficiency

A commercial solar tunnel dryer (STD) was evaluated for drying of sprouted moth beans and also its techno-economic analysis was carried out. The maximum temperature 58ºC was recorded at 13:00h in STD during the drying process i.e. 41.0% (34.2ºC) higher than the maximum ambient temperature at the same time. A total drying time of 13:50h were required in STD to reduce the initial moisture content from 177.7% dry basis (d.b) to a final moisture content of 16.6% (d.b). However, the open sun drying took 16.5 drying hours to obtain desired moisture content. The net present worth and cost-benefit ratio of dryer was Rs.5,83,910.68/- and 1.19, respectively. However, the payback period for STD was 15 month 8 days. The cost economics of dried products were proved better for STD than open sun drying method. STD samples were found to be of good quality in terms of color, taste and aroma as compared to open sun dried (OSD) with an overall drying efficiency of STD was 19.7%. Therefore, the evaluated solar tunnel dryer were recommended for the drying of sprouted moth beans.

Pengeringan Biji Kakao dengan Pengering Surya Tipe Terowong Berpenggerak Sel Fotovoltaik di Manokwari

Agrotek ◽  
2018 ◽  
Vol 2 (6) ◽  
Author(s):  
Wilson Palelingan Aman
Keyword(s):  
Moisture Content ◽  
Performance Test ◽  
Initial Moisture Content ◽  
Maximum Temperature ◽  
Photovoltaic Module ◽  
Cocoa Beans ◽  
Drying Time ◽  
Tunnel Dryer ◽  
Heat Collector ◽  
New Construction

<em>A research about cocoa beans drying used solar tunnel dryer with photovoltaic module driven have conducted in Manokwari. Solar tunnel dryer used in this research adapted from type Hohenheim with photovoltaic module and integrated air heat collector has been installed at the Department of Agricultural Technology, Papua State University Manokwari to dried cocoa beans. The objectives of this research were to design solar tunnel dryer and evaluate it�s performance in dryed cocoa beans. The result obtained was a new construction of solar tunnel dryer for cocoa beans with dimensions 6 m of length and 0,9 m of wide. The dryer completed with photovoltaic module to drive the blowers of hot drying air. �Performance test of the dryer showed that drying of 10 kg of cocoa beans with initial moisture content about 70% wet basis needed 13 hours of drying time to achieved final moisture content about 7,17% wet basis. The drying time achieved was faster compared than traditional solar drying that needed 20 hours of drying time. The maximum temperature achieved in drying chamber was 60 <sup>o</sup>C.</em>

scholarly journals Cherry Tomato Drying: Sun versus Convective Oven

Horticulturae ◽  
2021 ◽  
Vol 7 (3) ◽  
pp. 40
Author(s):  
Vincenzo Alfeo ◽  
Diego Planeta ◽  
Salvatore Velotto ◽  
Rosa Palmeri ◽  
Aldo Todaro
Keyword(s):  
Moisture Content ◽  
Initial Moisture Content ◽  
Drying Process ◽  
Drying Time ◽  
Oven Drying ◽  
Sun Drying ◽  
Different Temperatures ◽  
Final Water Content ◽  
Drying Curves ◽  
Drying Conditions

Solar drying and convective oven drying of cherry tomatoes (Solanum lycopersicum) were compared. The changes in the chemical parameters of tomatoes and principal drying parameters were recorded during the drying process. Drying curves were fitted to several mathematical models, and the effects of air temperature during drying were evaluated by multiple regression analyses, comparing to previously reported models. Models for drying conditions indicated a final water content of 30% (semidry products) and 15% (dry products) was achieved, comparing sun-drying and convective oven drying at three different temperatures. After 26–28 h of sun drying, the tomato tissue had reached a moisture content of 15%. However, less drying time, about 10–11 h, was needed when starting with an initial moisture content of 92%. The tomato tissue had high ORAC and polyphenol content values after convective oven drying at 60 °C. The dried tomato samples had a satisfactory taste, color and antioxidant values.

scholarly journals Development and performance evaluation of a solar tunnel date dryer in Oman

2012 ◽  
Vol 17 ◽  
pp. 21
Author(s):  
Mohammad Ali Basunia ◽  
Hamid H. Al-Handali ◽  
Mohammed Issa Al-Belushi ◽  
Mohammad Shafiur Rahman ◽  
Osman Maghoub
Keyword(s):  
Moisture Content ◽  
Initial Moisture Content ◽  
Average Moisture Content ◽  
Air Velocity ◽  
Sun Drying ◽  
Tunnel Dryer ◽  
Moisture Content Level ◽  
Collector Region ◽  
And Performance

Taking into consideration the date harvesting and landholding capacities of the marginalized rural farmers in Oman, a 12 meter long and 2 meter wide tunnel was designed and constructed to dry about 180-200 kg of freshly harvested dates per batch. Half of the tunnel base was used as a flat plate air heating solar collector and the other half as a dryer. The drying air was forced from the collector region (South side) to the drying region (North side) of the half circled tunnel where the product is to be dried. The drying temperature could be easily raised by some 5-30 oC above the ambient temperature inside the tunnel at an air velocity of approximately 0.5 m/sec. The test was conducted with 190.2 kg freshly harvested dates with initial moisture content of 32.8% (wet-basis) to analyze the performance of the dryer. The dates were dried to a final average moisture content of 18.6% (wet-basis) within two days (20 hours). The results indicated that the drying was faster in a solar tunnel dryer than the natural open air sun drying. It was possible to reach the moisture content level for safe storage within less than two days (20 hrs) with a solar tunnel dryer and 5-7 days in open air natural sun drying. The improvement in the quality of dates in terms of color and brightness was distinctly recognized. 

scholarly journals Effect of Pads and Thickness of Paddy on Moisture Removal under Sun Drying

2021 ◽  
Author(s):  
A. Narmilan ◽  
G. Niroash ◽  
M.I.M. Mowjood ◽  
A.T.A. Akram
Keyword(s):  
Sri Lanka ◽  
Moisture Content ◽  
Removal Rate ◽  
Initial Moisture Content ◽  
Storage Period ◽  
Moisture Removal ◽  
Drying Time ◽  
Sun Drying ◽  
Regular Time ◽  
Paddy Farmers

Background: Sun drying is a popular post-harvest operation to maintain rice quality during the storage period. Farmers use different pads and thicknesses for sun drying of paddy in Ampara district, Sri Lanka. A study was conducted to evaluate the suitability and effectiveness of the drying pad and thickness as practiced by local paddy farmers during the sun drying process.Methods: The grain with an initial moisture content of 28% (dry basis) was sun dried with four types of drying pads and five levels of thickness of grain. This experiment was conducted between 8.30 am and 4.30 pm at the South Eastern University of Sri Lanka in August 2020. The moisture contents of the grain were measured at regular time intervals.Result: It was found that the duration of drying of paddy from 28% to 13% moisture content on a dry basis was 300 to 540 minutes depending upon the drying pad and thickness. The tarpaulin is reasonable at shallow thickness with less time to reach the necessary moisture level than other drying pads. Black polythene and fertilizer bag can be utilized for sun drying of paddy at 4 cm thickness with 130 minutes. It was found that with an increase in the thickness of paddy from 0.5 cm to 4 cm, the drying time increases. A statistically significant interaction was obtained between drying pads and thickness level on moisture removal of paddy. Therefore, the moisture removal rate differs with the drying pad and thickness of the paddy under open sun drying.

Thin-Layer Mathematical Modeling of Turmeric in Indirect Natural Conventional Solar Dryer

2020 ◽  
Vol 142 (4) ◽  
Author(s):  
Masnaji R. Nukulwar ◽  
Vinod B. Tungikar
Keyword(s):  
Mathematical Modeling ◽  
Moisture Content ◽  
Thin Layer ◽  
Air Velocity ◽  
Drying Time ◽  
Sun Drying ◽  
Solar Dryer ◽  
Air Temperatures ◽  
Drying Efficiency ◽  
Kinetics Of

Abstract The objective of this study is to find an optimized thin-layer mathematical model suitable for drying kinetics of turmeric. Turmeric has a high moisture content which necessitates effective drying. A 10 kg, sample batch, of turmeric was dried in a solar dryer. Drying air temperatures and air velocity were observed in the range of 55 °C–68 °C and 0.7 m/s–1.4 m/s, respectively, in the drying experiments. It is seen that the moisture content of the turmeric is reduced from 77% to 11.93% in 22 h when compared with open sun drying, which required 60 h for the same reduction in the moisture content. Scheffler dish was used to generate steam for the dryer. Seven thin-layer mathematical models, cited in the literature, had been used for the study. These models were applied for different trays placed in the dryer. The result of the research and experimentation showed that the Page model fits best for drying in the steam-based dryer and open sun drying. Experimental results showed 63.33% saving in drying time, and the drying efficiency was found as 29.85%. Uncertainty in the drying efficiency was observed as 0.67%. Experimental investigation and the findings from the mathematical modeling are presented in this paper.

scholarly journals Performance Evaluation of Solar Tunnel Dryer for Drying of Garlic.

2017 ◽  
Vol 5 (2) ◽  
pp. 212-218 ◽  
Author(s):  
Arjoo Arjoo ◽  
Yadvika Yadvika ◽  
Y.K. Yadaadav
Keyword(s):  
Performance Evaluation ◽  
Moisture Content ◽  
Thermal Efficiency ◽  
Initial Moisture Content ◽  
Drying Process ◽  
Tunnel Drier ◽  
Drying Time ◽  
Tunnel Dryer ◽  
Safe Level ◽  
And Performance

This paper presents dying efficiency and performance of the solar tunnel dryer for drying of garlic. The dryer is a tunnel like semi-cylindrical in shape, poly house made up of UV-stabilized polyethylene sheet. The capacity is large enough that it can be used to dry 400 kg of garlic under controlled environmental conditions. The temperature inside the dryer was always higher than the ambient and the variation varied from 8-30 ºC. Initial moisture content of garlic was reduced from 66 % (w.b.) to about 9 % (w.b.) in 9 days which is considered to be a safe level. During the drying process the average thermal efficiency of the drier was estimated to be about 13.45 %. Drying time was considerably reduced with the use of a solar tunnel drier and pressing of the sample. Also, the final dried garlic was found to be good in terms of quality and sensory evaluation shows that it is highly acceptable.

scholarly journals Comparative Study between Modified Solar Dryer and Open Sun Drying for Drying of Onion Slices

2021 ◽  
pp. 23-29
Author(s):  
P. Sivamma ◽  
E. Mounika ◽  
K. Carolin Rathinakumari ◽  
G. Senthil Kumaran ◽  
B. Bindu
Keyword(s):  
Solar Energy ◽  
Moisture Content ◽  
Temperature Difference ◽  
Initial Moisture Content ◽  
Ambient Condition ◽  
Maximum Temperature ◽  
Maximum Temperature Difference ◽  
Sun Drying ◽  
Solar Dryer ◽  
Solar Greenhouse

Solar greenhouse drying is a method of removing moisture from the food material in which drying medium is solar energy which is easily available and low in cost for farmers. The solar energy is decreases in the monsoon months in comparison to non-monsoon months. The decrease in the solar energy results in lower temperatures in the solar greenhouse dryer. The aluminium foil which has 88% reflectivity, reflects the radiation inside solar greenhouse dryer and heats the air inside dryer and maintains heat for longer times.Aluminium foil was applied on eastern, western and southern walls of the dryer and the parameters viz; temperature and relative humidity were recorded in both modified solar greenhouse dryer, solar greenhouse dryer and ambient conditions. Assessment of temperature in ambient condition, solar greenhouse dryer with and without modification showed the maximum temperature difference between solar greenhouse dryer without modification and ambient condition was about 11.5°C whereas 17.5°C maximum temperature difference between modified solar greenhouse dryer and ambient condition. The dryer was able to reduce moisture content of onion from initial moisture content of 679 per cent dry basis to 5.7 per cent in 31 h of drying whereas the traditional sun drying was able to reduce moisture content of onion from initial moisture content of 679 per cent dry basis to 29 per cent in 31 h of drying time. The results showed a considerable advantage of solar dryer over the traditional open sun drying method in term of drying rate and less risk for spoilage.

An Indirect Passive Solar Dryer for Drying

2011 ◽  
Vol 367 ◽  
pp. 517-524
Author(s):  
A. F. Alonge ◽  
O. O. Oniya
Keyword(s):  
Moisture Content ◽  
Initial Moisture Content ◽  
Solar Drying ◽  
Drying Time ◽  
Sun Drying ◽  
Two Samples ◽  
Drying System ◽  
Average Size ◽  
Local Materials ◽  
Drying Chamber

A solar drying system designed on the principles of convective heat flow, constructed from local materials was employed in drying yam (Dioscorea Alata). A glass collector having an efficiency of about 0.63 was used along with an absorber for absorbing the heat energy. The drying chamber consisted of drying trays. A chimney fitted at the top centre of the drying chamber enhanced airflow. Air passing through the collector heated up and dried the foodstuff in the drying chamber. The latitude of Ilorin is 8.26oN and the collector angle could be varied . 56o C, 41o C and 71o C were obtained as the maximum attainable temperatures for the drying chamber, ambient and collector respectively. Two samples of yam chips, each weighing 1560g and having an average size of 1cm thick, were dried both inside the dryer and outside the dryer within its surrounding. The initial moisture content of the yam was 70.3% (wet basis) and its final moisture content was 9% (wet basis).The result was compared to natural sun drying. It was observed that the drying time was reduced from 52 hours for sun drying to 45 hours for solar drying. The total cost of the construction was 6, 105 Naira.

scholarly journals Performance Evaluation of an Inflatable Solar Dryer for Maize and the Effect on Product Quality Compared with Direct Sun Drying

2021 ◽  
Vol 11 (15) ◽  
pp. 7074
Author(s):  
Janvier Ntwali ◽  
Steffen Schock ◽  
Sebastian Romuli ◽  
Christine G. Kiria Chege ◽  
Noble Banadda ◽  
...  
Keyword(s):  
Performance Evaluation ◽  
Moisture Content ◽  
Product Quality ◽  
Postharvest Quality ◽  
Maximum Temperature ◽  
Drying Methods ◽  
Drying Time ◽  
Sun Drying ◽  
Solar Dryer ◽  
Adverse Weather

Maize is an important staple in Africa, which necessitates immediate drying to preserve the postharvest quality. The traditional drying of maize in the open sun is prone to adverse weather and extraneous contamination. In this study, the drying performance of an inflatable solar dryer (ISD) was compared to direct sun drying (DSD) in Gombe Town, Wakiso District (Uganda) by analysing the moisture content, yeasts, moulds, aflatoxin, and colour. The maximum temperature inside the ISD reached 63.7 °C and averaged 7 °C higher than the ambient temperature. Maize was dried using both methods to a moisture content below 14% after two days. In one of the received maize lots that was already heavily contaminated after harvest, drying with DSD and ISD reduced the aflatoxin content from 569.6 µg kg−1 to 345.5 µg kg−1 and 299.2 µg kg−1, respectively. Although the drying performance in terms of drying time and product quality regarding colour, yeast, and mould was similar for both drying methods, the advantage of ISD in reducing the risk of spoilage due to sudden rain is obvious. A strategy for the early detection of aflatoxins in maize is recommended to avoid contaminated maize in the food chain.

scholarly journals Karakteristik Pengeringan Biji Jagung (Zea Mays L.) Menggunakan Alat Pengering Surya Adriyarkara Termodifikasi

2018 ◽  
Vol 3 (2) ◽  
pp. 351-360
Author(s):  
Athul Fadhli ◽  
Diswandi Nurba ◽  
Raida Agustina
Keyword(s):  
Zea Mays ◽  
Relative Humidity ◽  
Moisture Content ◽  
Zea Mays L ◽  
Initial Moisture Content ◽  
Solar Irradiation ◽  
Air Velocity ◽  
Drying Time ◽  
Average Temperature ◽  
Average Relative Humidity

Abstrak. Jagung merupakan tanaman penghasil karbohidrat terpenting. Pengeringan jagung pipil menggunakan alat pengering merupakan proses untuk menghasilkan jagung pipil yang siap diolah untuk pembuatan tepung jagung dengan batas kadar air tertentu sehingga menghaslkan jagung pipil dengan kualitas yang baik. Tujuan penelitian ini adalah untuk mengkaji karakteristik pengeringan biji jagung menggunakan alat pengering surya Termodifikasi. Metode penelitian  menggunakan 3,15 kilogram jagung pipil dengan kadar air awal 22% untuk proses pengeringan. Parameter yang dianalisis terkait alat pengering kolektor surya yaitu temperatur, kelembaban relatif, kecepatan udara dan iradiasi surya, sedangkan parameter yang dianalisis terkait bahan yaitu kadar air, lama waktu pengeringan, laju pengeringan dan organoleptik. Prosedur penelitian terdiri dari pengujian kosong dan pengujian dengan menggunakan jagung pipil. Hasil penelitian menunjukkan bahwa temperatur rata-rata dalam rak pengering sebelum dilakukan modifikasi yaitu 44,4oC, temperatur rata-rata setelah dilakukan modifikasi yaitu 55,5oC dan temperatur rata-rata rak pengering pada pengeringan menggunakan jagung pipil yaitu 46,96oC. Kelembaban relatif rata-rata dalam rak pengering sebelum dilakukan modifikasi yaitu 40,1%, kelembaban relatif rata-rata dalam rak pengering setelah modifikasi yaitu 35,1% dan kelembaban relatif rata-rata pengeringan menggunakan jagung pipil yaitu 44,45%. Dari hasil pengukuran tersebut menunjukkan bahwa nilai temperatur dan kelembaban pada alat setelah modifikasi lebih baik dibandingkan sebelum alat dimodifikasi. Pengukuran temperatur dan kelembaban relatif terdiri dari 4 titik pengukuran yaitu rak 1A,1B dan rak 2A, 2B. Kecepatan udara rata-rata yang diukur konstan yaitu 0,7 m/s pada ruang pengering, sedangkan lingkungan 1,1 m/s. Total iradiasi surya selama pengeringan yaitu 1848,84 W/m2. Kadar air jagung pipil masing-masing rak yaitu rak 1A 14,29%, rak 1B 14,47%, rak 2A 13,91% dan rak 2B 14,1%. Hasil dari pengujian organoleptik, panelis agak menyukai jagung pipil yang dikeringkan menggunakan alat pengering tersebut.Characteristics of Seed Drying (Zea mays L.) Using a Modified Adriyarkara Solar DryerAbstract. Corn is the most important carbohydrate plant. Drying corn using a drying tool is a process to produce corn that are ready to be processed for making corn flour with a certain water content limit so as to produce corn with good quality. The purpose of this study was to examine the characteristics of drying of corn kernels using a modified solar dryer. The research method used 3,15 kilogram of corn milled with the initial moisture content of 22% for drying process. The parameters analyzed in relation to solar collector dryers are temperature, relative humidity, air velocity and solar irradiation, while the parameters analyzed are materials such as moisture content, drying time, drying rate and organoleptic. The research procedure consists of unloaded testing and testing using corn. The results showed that the average temperature in the dryer tray before modification was 44,4°C, the average temperature after modification was 55,5°C and the average temperature of the dryer tray on drying using corn was 46,96oC. The average relative humidity in the dryer tray before modification is 40,1%, the average relative humidity in the dryer tray after modification is 35,1% and the average relative humidity of drying using corn is 44,45%. From the measurement results show that the value of temperature and humidity in the tool after modification is better than before. Measurement of temperature and relative humidity consist of 4 point of measurement that is tray 1A, 1B and tray 2A, 2B. Average mean air velocity measured is 0,7 m/s at the dryer room, while the environment is 1,1 m/s. Total solar irradiation during drying is 1848,84 W/m2. Moisture level of corn each shelves tray 1A is 14,29%, tray 1B is 14.47%, tray 2A is 13,91% and tray 2B is 14,1%. As a result of organoleptic testing, panelists rather like dried corn using the dryer.

Sign in / Sign up

Export Citation Format

Share Document