Inactivation of Escherichia coli O157:H7 on Orange Fruit Surfaces and in Juice Using Photocatalysis and High Hydrostatic Pressure

2015 ◽  
Vol 78 (6) ◽  
pp. 1098-1105 ◽  
Author(s):  
SUNGYUL YOO ◽  
KASHIF GHAFOOR ◽  
JEONG UN KIM ◽  
SANGHUN KIM ◽  
BORA JUNG ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Hydrostatic Pressure ◽  
Orange Juice ◽  
High Hydrostatic Pressure ◽  
Tap Water ◽  
Microbial Inactivation ◽  
Inactivation Kinetics ◽  
Escherichia Coli O157 ◽  
Biphasic Model ◽  
E Coli

Nonpasteurized orange juice is manufactured by squeezing juice from fruit without peel removal. Fruit surfaces may carry pathogenic microorganisms that can contaminate squeezed juice. Titanium dioxide–UVC photocatalysis (TUVP), a nonthermal technique capable of microbial inactivation via generation of hydroxyl radicals, was used to decontaminate orange surfaces. Levels of spot-inoculated Escherichia coli O157:H7 (initial level of 7.0 log CFU/cm2) on oranges (12 cm2) were reduced by 4.3 log CFU/ml when treated with TUVP (17.2 mW/cm2). Reductions of 1.5, 3.9, and 3.6 log CFU/ml were achieved using tap water, chlorine (200 ppm), and UVC alone (23.7 mW/cm2), respectively. E. coli O157:H7 in juice from TUVP (17.2 mW/cm2)–treated oranges was reduced by 1.7 log CFU/ml. After orange juice was treated with high hydrostatic pressure (HHP) at 400 MPa for 1 min without any prior fruit surface disinfection, the level of E. coli O157:H7 was reduced by 2.4 log CFU/ml. However, the E. coli O157:H7 level in juice was reduced by 4.7 log CFU/ml (to lower than the detection limit) when TUVP treatment of oranges was followed by HHP treatment of juice, indicating a synergistic inactivation effect. The inactivation kinetics of E. coli O157:H7 on orange surfaces followed a biphasic model. HHP treatment did not affect the pH, °Brix, or color of juice. However, the ascorbic acid concentration and pectinmethylesterase activity were reduced by 35.1 and 34.7%, respectively.

Note: Ultra High Hydrostatic Pressure Inactivation of Escherichia Coli in Milk, and Orange and Peach Juices

2003 ◽  
Vol 9 (6) ◽  
pp. 403-407 ◽  
Author(s):  
C. Dogan ◽  
O. Erkmen
Keyword(s):  
Escherichia Coli ◽  
Hydrostatic Pressure ◽  
Cell Growth ◽  
Orange Juice ◽  
High Hydrostatic Pressure ◽  
Raw Milk ◽  
Aerobic Bacteria ◽  
Bacterial Cells ◽  
E Coli ◽  
Peach Juice

Inactivation of Escherichia coli by high hydrostatic pressure (UHHP) was determined in broth, milk and orange and peach juices inoculated with the bacteria. HHP ranged from 200 to 700 MPa at 25 C and different treatment times. No cell growth occurred in broth after 60, 25, 15, 10 and 7 min at 300, 400, 500, 600 and 700 MPa, respectively. Reduction of aerobic bacteria in milk and peach juice were 3.08 and 6.07 log units after 15 min at 400 MPa, respectively, while all bacterial cells were inactivated in orange juice. Sterilisation of raw milk contaminated with E. coli occurred at 600 MPa for 30 min, while peach and orange juices needed 12 and 10 min, respectively. The injury of cells in broth at 300 MPa ranged from 8.8 to 100% depending on magnitude of pressure and treated time. In general, inactivation of aerobic bacteria and E. coli was enhanced significantly (P<0.01) by increasing the pressure.

scholarly journals Inactivation of Escherichia coli O157:H7 by High Hydrostatic Pressure Combined with Gas Packaging

2019 ◽  
Vol 7 (6) ◽  
pp. 154 ◽  
Author(s):  
Bing Zhou ◽  
Luyao Zhang ◽  
Xiao Wang ◽  
Peng Dong ◽  
Xiaosong Hu ◽  
...  
Keyword(s):  
Electron Microscopy ◽  
Escherichia Coli ◽  
Hydrostatic Pressure ◽  
High Hydrostatic Pressure ◽  
Cellular Structure ◽  
Combined Treatment ◽  
Physiological Saline ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Significant Difference

The inactivation of Escherichia coli O157:H7 (E. coli) in physiological saline and lotus roots by high hydrostatic pressure (HHP) in combination with CO2 or N2 was studied. Changes in the morphology, cellular structure, and membrane permeability of the cells in physiological saline after treatments were investigated using scanning electron microscopy, transmission electron microscopy, and flow cytometry, respectively. It was shown that after HHP treatments at 150–550 MPa, CO2-packed E. coli cells had higher inactivation than the N2-packed and vacuum-packed cells, and no significant difference was observed in the latter two groups. Further, both the morphology and intracellular structure of CO2-packed E.coli cells were strongly destroyed by high hydrostatic pressure. However, serious damage to the intracellular structures occurred in only the N2-packed E. coli cells. During HHP treatments, the presence of CO2 caused more disruptions in the membrane of E. coli cells than in the N2-packed and vacuum-packed cells. These results indicate that the combined treatment of HHP and CO2 had a strong synergistic bactericidal effect, whereas N2 did not have synergistic effects with HHP. Although these two combined treatments had different effects on the inactivation of E. coli cells, the inactivation mechanisms might be similar. During both treatments, E. coli cells were inactivated by cell damage induced to the cellular structure through the membrane components and the extracellular morphology, unlike the independent HHP treatment.

Effects of Water Source, Dilution, Storage, and Bacterial and Fecal Loads on the Efficacy of Electrolyzed Oxidizing Water for the Control of Escherichia coli O157:H7

2004 ◽  
Vol 67 (7) ◽  
pp. 1377-1383 ◽  
Author(s):  
S. M. L. STEVENSON ◽  
S. R. COOK ◽  
S. J. BACH ◽  
T. A. McALLISTER
Keyword(s):  
Escherichia Coli ◽  
Bactericidal Activity ◽  
Storage Temperature ◽  
Uv Light ◽  
Tap Water ◽  
Organic Matter Content ◽  
Water Source ◽  
Deionized Water ◽  
Escherichia Coli O157 ◽  
E Coli

To evaluate the potential of using electrolyzed oxidizing (EO) water for controlling Escherichia coli O157:H7 in water for livestock, the effects of water source, electrolyte concentration, dilution, storage conditions, and bacterial or fecal load on the oxidative reduction potential (ORP) and bactericidal activity of EO water were investigated. Anode and combined (7:3 anode:cathode, vol/vol) EO waters reduced the pH and increased the ORP of deionized water, whereas cathode EO water increased pH and lowered ORP. Minimum concentrations (vol/vol) of anode and combined EO waters required to kill 104 CFU/ml planktonic suspensions of E. coli O157:H7 strain H4420 were 0.5 and 2.0%, respectively. Cathode EO water did not inhibit H4420 at concentrations up to 16% (vol/vol). Higher concentrations of anode or combined EO water were required to elevate the ORP of irrigation or chlorinated tap water compared with that of deionized water. Addition of feces to EO water products (0.5% anode or 2.0% combined, vol/vol) significantly reduced (P &lt; 0.001) their ORP values to &lt;700 mV in all water types. A relationship between ORP and bactericidal activity of EO water was observed. The dilute EO waters retained the capacity to eliminate a 104 CFU/ml inoculation of E. coli O157:H7 H4420 for at least 70 h regardless of exposure to UV light or storage temperature (4 versus 24°C). At 95 h and beyond, UV exposure reduced ORP, significantly more so (P &lt; 0.05) in open than in closed containers. Bactericidal activity of EO products (anode or combined) was lost in samples in which ORP value had fallen to ≤848 mV. When stored in the dark, the diluted EO waters retained an ORP of &gt;848 mV and bactericidal efficacy for at least 125 h; with refrigeration (4°C), these conditions were retained for at least 180 h. Results suggest that EO water may be an effective means by which to control E. coli O157:H7 in livestock water with low organic matter content.

Thermal and Starvation Stress Response of Escherichia coli O157:H7 Isolates Selected from Agricultural Environments

2016 ◽  
Vol 79 (10) ◽  
pp. 1673-1679 ◽  
Author(s):  
ACHYUT ADHIKARI ◽  
ANDY BARY ◽  
CRAIG COGGER ◽  
CALEB JAMES ◽  
GÜLHAN ÜNLÜ ◽  
...  
Keyword(s):  
Escherichia Coli ◽  
Heat Stress ◽  
Stress Response ◽  
Weibull Model ◽  
Stress Conditions ◽  
Inactivation Kinetics ◽  
Escherichia Coli O157 ◽  
Starvation Stress ◽  
E Coli ◽  
Response To Stress

ABSTRACT Pathogens exposed to agricultural production environments are subject to multiple stresses that may alter their survival under subsequent stress conditions. The objective of this study was to examine heat and starvation stress response of Escherichia coli O157:H7 strains isolated from agricultural matrices. Seven E. coli O157:H7 isolates from different agricultural matrices—soil, compost, irrigation water, and sheep manure—were selected, and two ATCC strains were used as controls. The E. coli O157:H7 isolates were exposed to heat stress (56°C in 0.1% peptone water for up to 1 h) and starvation (in phosphate-buffered saline at 37°C for 15 days), and their survival was examined. GInaFiT freeware tool was used to perform regression analyses of the surviving populations. The Weibull model was identified as the most appropriate model for response of the isolates to heat stress, whereas the biphasic survival curves during starvation were fitted using the double Weibull model, indicating the adaptation to starvation or a resistant subpopulation. The inactivation time during heating to achieve the first decimal reduction time (δ) calculated with the Weibull parameters was the highest (45 min) for a compost isolate (Comp60A) and the lowest (28 min) for ATCC strain 43895. Two of the nine isolates (ATCC 43895 and a manure isolate) had β &lt; 1, indicating that surviving populations adapted to heat stress, and six strains demonstrated downward concavity (β &gt; 1), indicating decreasing heat resistance over time. The ATCC strains displayed the longest δ2 (&gt;1,250 h) in response to starvation stress, compared with from 328 to 812 h for the environmental strains. The considerable variation in inactivation kinetics of E. coli O157:H7 highlights the importance of evaluating response to stress conditions among individual strains of a specific pathogen. Environmental isolates did not exhibit more robust response to stress conditions in this study compared with ATCC strains.

Transfer of Escherichia coli O157:H7 to Romaine Lettuce due to Contact Water from Melting Ice

2008 ◽  
Vol 71 (2) ◽  
pp. 252-256 ◽  
Author(s):  
JIN KYUNG KIM ◽  
MARK A. HARRISON
Keyword(s):  
Escherichia Coli ◽  
Tap Water ◽  
Sampling Site ◽  
Contaminated Water ◽  
Escherichia Coli O157 ◽  
Romaine Lettuce ◽  
E Coli ◽  
Ice Melt ◽  
Leaf Surfaces ◽  
Shipping Containers

Ice can be used to chill romaine lettuce and maintain relative humidity during transportation. Escherichia coli O157:H7 may contaminate water used for ice. The objective of this study was to determine the potential for E. coli O157:H7 contamination of romaine lettuce from either ice contaminated with the pathogen or by transfer from lettuce surfaces via melting ice. In experiment 1, lettuce was spot inoculated with E. coli O157:H7 and chilled with ice prepared from uncontaminated tap water. In experiment 2, water inoculated with this pathogen was frozen and used to ice lettuce. Three heads of lettuce were stacked in each container and stored at 4 or 20°C. After the ice melted, E. coli O157:H7 attachment to and recovery from the lettuce leaves were determined. For experiment 1, the population of E. coli O157:H7 attached to inoculated sites averaged 3.8 and 5.5 CFU/cm2 at 4 and 20°C, respectively. Most of the uninoculated sites became contaminated with the pathogen due to ice melt. For experiment 2, 3.5 to 3.8 log CFU E. coli O157:H7 per cm2 was attached to the top leaf on the first head. After rinsing with chlorinated water (200 μg/ml), E. coli O157:H7 remained on the surface of the top head (1.8 to 2.0 log CFU/cm2). There was no difference in numbers of E. coli O157:H7 recovered from each sampling site at 4 and 20°C. Results show that E. coli O157:H7 can be transferred onto other produce layers in shipping containers from melted ice made of contaminated water and from contaminated to uncontaminated leaf surfaces.

scholarly journals Alicyclobacillus acidoterrestris Strain Variability in the Inactivation Kinetics of Spores in Orange Juice by Temperature-Assisted High Hydrostatic Pressure

2020 ◽  
Vol 10 (21) ◽  
pp. 7542
Author(s):  
Patra Sourri ◽  
Anthoula A. Argyri ◽  
Efstathios Z. Panagou ◽  
George-John E. Nychas ◽  
Chrysoula C. Tassou
Keyword(s):  
High Pressure ◽  
Hydrostatic Pressure ◽  
Orange Juice ◽  
High Hydrostatic Pressure ◽  
Reference Strain ◽  
Wild Type Strain ◽  
Weibull Model ◽  
Inactivation Kinetics ◽  
High Pressure Level ◽  
Kinetics Of

In this work, the inactivation kinetics of Alicyclobacillus acidoterrestris spores by temperature-assisted high hydrostatic pressure was assessed by means of the Weibull model. Spores from two A. acidoterrestris strains (a wild-type strain and a reference strain) were inoculated in commercial orange juice and subjected to high pressure levels (500 and 600 MPa) combined with four temperature regimes (25, 45, 60 and 70 °C) for time up to 30 min. Results showed that for a given high-pressure level spore inactivation was higher as temperature progressively increased. Furthermore, the Weibull model consistently produced satisfactory fit to the inactivation data based on the values of the root mean squared error (RMSE < 0.54 log colony-forming units (CFU)/mL) and the coefficient of determination (R2 > 0.90 in most cases). The shape of inactivation curves was concave upward (p < 1) for all temperature/high pressure levels tested, indicating rapid inactivation of the sensitive cells of the bacterium whereas the remaining ones adapted to high hydrostatic pressure (HHP) treatment. The values of the shape (p) and scale (δ) parameters of the Weibull model were dependent on the applied temperature for a given high pressure level and they were further described in a secondary model using first-order fitting curves to provide predictions of the surviving spore population at 55 and 65 °C. Results revealed a systematic over-prediction for the wild-type strain regardless of temperature and high pressure applied, whereas for the reference strain under-prediction was evident after 3 log-cycles reduction of the surviving bacteria spores. Overall, the results obtained indicate that the effectiveness of high hydrostatic pressure against A. acidoterrestris spores is strain-dependent and also underline the need for temperature-assisted HPP for effective spore inactivation during orange juice processing.

Viability of Salmonella, Escherichia coli O157:H7, and Listeria monocytogenes in Yellow Fat Spreads as Affected by Storage Temperature

2003 ◽  
Vol 66 (4) ◽  
pp. 549-558 ◽  
Author(s):  
SARAH L. HOLLIDAY ◽  
LARRY R. BEUCHAT
Keyword(s):  
Escherichia Coli ◽  
Listeria Monocytogenes ◽  
Storage Temperature ◽  
Salt Content ◽  
Inactivation Kinetics ◽  
Escherichia Coli O157 ◽  
E Coli ◽  
Inhibition Of Growth ◽  
Time Required ◽  
Kinetics Of

A study was conducted to characterize the survival and inactivation kinetics of a five-serotype mixture of Salmonella (6.23 to 6.55 log10 CFU per 3.5-ml or 4-g sample), a five-strain mixture of Escherichia coli O157:H7 (5.36 to 6.14 log10 CFU per 3.5-ml or 4-g sample), and a six-strain mixture of Listeria monocytogenes (5.91 to 6.18 log10 CFU per 3.5-ml or 4-g sample) inoculated into seven yellow fat spreads (one margarine, one butter-margarine blend, and five dairy and nondairy spreads and toppings) after formulation and processing and stored at 4.4, 10, and 21°C for up to 94 days. Neither Salmonella nor E. coli O157:H7 grew in any of the test products. The time required for the elimination of each pathogen depended on the product and the storage temperature. Death was more rapid at 21°C than at 4.4 or 10°C. Depending on the product, the time required for the elimination of viable cells at 21°C ranged from 5 to 7 days to &gt;94 days for Salmonella, from 3 to 5 days to 28 to 42 days for E. coli O157:H7, and from 10 to 14 days to &gt;94 days for L. monocytogenes. Death was most rapid in a water-continuous spray product (pH 3.66, 4.12% salt) and least rapid in a butter-margarine blend (pH 6.66, 1.88% salt). E. coli O157:H7 died more rapidly than did Salmonella or L. monocytogenes regardless of storage temperature. Salmonella survived longer in high-fat (≥61%) products than in products with lower fat contents. The inhibition of growth is attributed to factors such as acidic pH, salt content, the presence of preservatives, emulsion characteristics, and nutrient deprivation. L. monocytogenes did not grow in six of the test products, but its population increased between 42 and 63 days in a butter-margarine blend stored at 10°C and between 3 and 7 days when the blend was stored at 21°C. On the basis of the experimental parameters examined in this study, traditional margarine and spreads not containing butter are not “potentially hazardous foods” in that they do not support the growth of Salmonella, E. coli O157:H7, or L. monocytogenes.

Sign in / Sign up

Export Citation Format

Share Document